2010 Volkswagen Jetta Suspension Problems

Your diesel Jetta's DPF (Diesel Particulate Filter) warning light keeps coming back every 6 months despite multiple repairs, including replacement of the filter itself, glow plugs, thermostat, O2 sensor, and timing belt. Most recently, your turbocharger failed suddenly while driving, causing a loss of power and a loud noise, making the car undriveable and requiring over $3,000 in repairs. The recurring DPF issues and cascade of related component failures suggest an underlying problem that previous repairs haven't fully resolved, and fixing the turbo may require inspection of the fuel system, intake, and exhaust components to prevent further damage.

The contact owns a 2010 Volkswagen Jetta. The contact stated that while driving at various speeds, there was an abnormal knocking sound coming from underneath the vehicle. The vehicle was taken to an independent mechanic who diagnosed that the rear passenger’s side coil spring had fractured. Additionally, the front passenger’s and driver’s side coil springs were also fractured. The vehicle was not yet repaired. The cause of the failure was not determined. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was approximately 68,000.

COIL SPRINGS IN REAR BOTH BROKE NOW FRONT SPRING IS BROKEN. VERY DANGEROUS HAPPENED WHILE DRIVING STRIAT DOWN HIGHWAY

I HAVE RECENTLY NOTICED THAT THE 2015 - 2019 JETTA SPORTWAGEN BEEN IDENTIFIED WITH A REAR COIL SPRING BREAKING ISSUE AND A RECALL WILL BE ISSUED APRIL 19, 2019 - MY 2010 JETTA SPORTWAGEN HAS RECENTLY EXPERIENCED THE SAME ISSUE AND I BELIEVE THE RECALL SHOULD BE EXPANDED

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. WHILE DRIVING OVER A BUMP AT DIFFERENT SPEEDS, THE CONTACT HEARD AN ABNORMAL RATTLING NOISE COMING FROM THE VEHICLE. COMPASS MOTORS (200 DOLSON AVE, MIDDLETOWN, NY 10940, (844) 258-3818) INFORMED THE CONTACT TO CALL THE MANUFACTURER. UPON INSPECTING THE VEHICLE, THE CONTACT FOUND THAT ALL FOUR COIL SPRINGS WERE FRACTURED. THE REAR COIL SPRINGS WERE REPAIRED, BUT THE FRONT SPRINGS WERE STILL FRACTURED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.

WHILE WILL DRIVING 70 MPH ON I-96, LEFT FRONT STRUT/COIL/DAMPENER FAILED , THE COIL SPRING BECAME PARTIALLY OFFSET AND SEPARATED LATERALLY FROM THE REMAINING PORTION OF THE COIL. THE PORTION OF THE COIL OFFSET BEGAN RUBBING ON THE FRONT TIRE SIDEWALL. FORTUNATELY, I WAS LOCATED 5-7 MILES FROM HOME AND MY LOCAL VEHICLE REPAIR SHOP. A DANGEROUS AND POTENTIALLY VERY DANGEROUS DEVELOPMENT. SEE ATTACHED IMAGES..

FRONT COIL SPRINGS SNAPPED, FRONT OF VEHICLE DROPPED, DAMAGED TIRE,....SAFETY ISSUE, IMMEDIATELY HAD DEFECTIVE PARTS REPLACED

JANUARY 10,2017 HAD CAR TOWED TO DEALERSHIP. RIGHT REAR COIL SPRING BROKEN INTO 3 PIECES. LEFT REAR CRACKED. BOTH REPLACE UNDER EXTENDED WARRANTY W/$100.00 DEDUCT. CAR HAD 77,695 MILES. MARCH 13, 2017 CAR TOWED DUE TO LEFT FRONT COIL SPRING BROKEN COVERED UNDER EXTENDED WARRANTY W/$100. DEDUCT. I HAD THEM REPLACE THE RIGHT COIL SPRING AND THEY FOUND MOUNTING BRACKET BROKEN ALONG WITH BEARING. THIS WAS NOT COVERED UNDER EXTENDED WARRANTY, COSTING ME $532.01. MY COMPLAINT IS WHY WOULD THE SPRINGS BREAK LIKE THAT? I HAVE OWNED MANY CARS OVER THE YEARS AND I AM NOT ROUGH ON THEM. I AVOID POT HOLES AND MAN HOLE COVERS AS MUCH AS POSSIBLE, SO WHY HAVE 3 OUT OF 4 BROKEN AND THE BEARINGS AND MOUNT BREAK ON THE OTHER, ALL WITHIN 9 WEEKS OF EACH OTHER? THIS IS VERY COSTLY NOW AND I AM AN OLDER WOMAN AND I CAN'T AFFORD THESE REPAIRS. I AM NOT HAPPY WITH VW CAR.

SPRING FAILED ON PASS FRONT STRUT AT HIGHWAY SPEED, SMOOTH ROAD, CAUSING TIRE TO BLOW-OUT AND WHEEL BEARING TO FAIL. FAMILY IN CAR INCLUDING 6 WEEK OLD. BARELY COULD CONTROL CAR TO SAFE STOP. LUCKY. REPAIRS WILL RUN OVER $1500. DEALER INFORMED US THAT MANY VW AND AUDI CARS ARE EXPERIENCING THIS, THAT THEY ARE WORRIED AND HAVE INFORMED VW THEY HAVE A PROBLEM. HE SHOWED ME THREE OTHER FAILED SPRINGS. I KEPT MINE. IT HAS NO SIGNS OF CORROSION PRIOR TO FAILURE - METAL FATIGUE PROBABLY RELATED TO BAD METALLURGY, ACCORDING TO MY DAD WHO'S AN ENGINEER.CLASSIC SPIRAL FRACTURE. HAD TO HAVE CAR TOWED TO VW DEALER 150 MILES FROM HOME - RENT CAR FOR 2 WEEKS UNTIL REPAIRED.

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. WHILE MAKING A LEFT TURN, THERE WAS A LOUD SNAP THAT CAME FROM THE FRONT OF THE VEHICLE. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT DRIVER AND PASSENGER SIDE COIL SPRINGS FAILED AND NEEDED TO BE REPLACED. THE DRIVER SIDE COIL SPRINGS WERE REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000. UPDATED 06/29/16*LJ THE CONSUMER STATED THAT THE 4TH COIL SPRING NEEDS TO BE REPLACE. *TR

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 35 MPH, THE COIL SPRING DETACHED FROM THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 85,000.

TL* THE CONTACT OWNS A 2010 VOLKSWAGEN JETTA. THE CONTACT STATED THAT WHILE DRIVING 30 MPH MAKING A TURN, THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. AFTER INSPECTING THE VEHICLE, THE CONTACT NOTICED THAT THE FRONT DRIVER COIL SPRING FRACTURED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE DEALER AND MANUFACTURER WERE MADE AWARE OF THE FAILURE. THE CONTACT PERFORMED THE REPAIRS ON THE VEHICLE BY HIMSELF. THE FAILURE RECURRED ON THE FRONT PASSENGER COIL SPRING. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 50,000.

ONE OF THE REAR COIL SPRINGS BROKE WHILE DRIVING. *TR

MY 2010 VW TDI SPORTWAGON EATS UP THE INSIDE OF THE TIRES, VERY QUICKLY. I JUST PURCHASED MY FIFTH SET OF TIRES FOR A CAR WITH LESS THAN 70,000 MILES ON IT. I'VE HAD THE ALIGNMENT CHECKED THREE TIMES, AND IT CONTINUALLY SHOWS TO BE WITHIN SPECS. THE FIRST TWO TIMES, I HAD A VW DEALERSHIP CHECK THE ALIGNMENT, AND BOTH TIMES THEY TOLD ME THERE WAS NOTHING THEY COULD DO. I JUST HAD A PRIVATE MECHANIC CHECK THE ALIGNMENT, AND HE SAID I COULDN'T HAVE A MORE PERFECT ALIGNMENT, ACCORDING TO VW'S SPECS. THE LAST SET OF TIRES I PURCHASED WERE RATED FOR 55,000 MILES, BUT I ONLY GOT 15,000 OUT OF THEM BEFORE THE INSIDES WERE WORN DOWN INTO THE BELTS. THIS IS A VERY DANGEROUS SITUATION SINCE THE REST OF THE TIRE LOOKS NEW, AND UNLESS YOU GET THE CAR UP ON A LIFT, OR LAY DOWN ON THE GROUND TO DELIBERATELY LOOK AT THE INSIDE OF THE TIRES, YOU CANNOT SEE THE DAMAGE TAKING PLACE, AND PLACING THE OPERATOR IN A SITUATION WHERE A BLOW-OUT CAN OCCUR WITHOUT WARNING. PLUS, NOT TO MENTION THE EXTREMELY HIGH COST OF TIRE PURCHASES TO OPERATE THIS VEHICLE. *TR

VW HAS REPLACED CONTROL ARM BUSHINGS AND THE NEW BUSHINGS HAVE FAILED SHORTLY THEREAFTER. *TR