2022 Toyota Rav4 Body & Structure Problems

Your panoramic sunroof suddenly shattered with a loud noise while your car was stationary, with no apparent impact or collision. The dealer suggested something may have contacted the roof, but you believe this is a manufacturing defect. Repairs will likely involve complete sunroof replacement or structural assessment.

Your rear liftgate hinge appears to be bent, which may affect how the liftgate opens and closes. The cause isn't clear, but the hinge itself may be defective. The repair will likely involve replacing the bent hinge with a new one.

When it rains, the water goes inside the door. So I have lots of water in my door. Toyota didn’t properly seal the outside of the door.

The contact owns a 2022 Toyota Rav4. The contact stated that after heavy rainfall, there was a swishing sound coming from the passenger’s side rear door. The contact stated that when the vehicle was parked, the contact inspected the vehicle, and became aware of water build-up in the passenger’s side rear door. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was 9,512.

Every time it rains our Rav 4 gets water in the back doors. It sloshes around and you have to manually pull the seal back to drain. It happens every time. my understanding is this is a known issue.

Tailgate will not close when button on the back or by the driver's seat is pressed. After pressing the close button at tailgate or driver's seat with tailgate open, it will lower an inch then beep several times and lift open again. Toyota dealer claims this is a known issue and the solution is to "reset" the tailgate, which they would do for me. Resetting immediately failed, and the issue persisted. Toyota service department said, "there is a button on the hatch that will reset it. you will hold that button until it does a sequence of beeps (beeeeeeeeepp, beep beep beep) then let go an press it again like you would want to close it and you should be good to go! :)" (sic). This solution worked once and immediately failed the second time I attempted to close the tailgate. This is a daily issue that was replicated at the dealer but not fixed.

APPEARS TO BE A MANUFACTURING DEFECT. SIDE DOORS BACK AND FRONT FILL WITH WATER. WINDOWS ROLLED UP AND DOWN HAVE STREAKS OF WATER(WET ALL THE TIME). WATER POURS OUT OF DOOR FRAMES. SLOSHING OF WATER IN DOORS. CAR HAS NO MORE THAN 15,000 MILES ON IT. ALWAYS KEEP COVERED IN GARAGE. CAR DOES NOT ACCUMULATE DEBRIS OR LEAVES. HAVE TAKEN INTO TOYOTA PALO ALTO TWICE NOW. NO REAL HELP. CANNOT SEE WELL FROM WINDOWS - SAFETY ISSUE AS SIDE WINDOWS STAY STREAKED OBSCURING VIEW AND MOLD CONCERNS WITH WET INTERIOR DOORS.

Power lift-gate lowered on its own as I was putting groceries in the back compartment. My hands were nowhere near the button you press to lower the lift-gate. If I hadn't quickly ducked out of the way, I could have been seriously injured or killed. This has never happened before. Now I'm reluctant to use the back compartment for fear the lift-gate may lower on its own again. This incident happened this morning in a Target parking lot about 9:30 AM.

The contact owns a 2022 Toyota Rav4. The contact heard an abnormal sound coming from the driver's side rear door. The contact stated that the sound was a "sloshing" sound of water. The contact stated that when she had parked the vehicle on a road with an upgrade with the front of the vehicle facing up, she observed that water was leaking out from the bottom of the door. The contact stated that when it rained, the noise and water leak were more noticeable. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 26,000.

The contact owns a 2022 Toyota Rav4. The contact stated that while either driving at various speeds or coming to a stop, a moving water sound would emit from both the rear driver and passenger side doors. The contact had taken the vehicle to the dealer on multiple occasions to have the doors drained to prevent mold from developing inside the vehicle. The contact was also informed by the dealer that the failure was a result of the vehicle's design and that no other repairs could be made to address the failure. The manufacturer was not notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 12,000.

The contact owns a 2022 Toyota Rav4. The contact stated that while driving and coming to a stop, there was a sound of moving water coming from the rear driver's side and passenger's side doors. The contact stated that upon opening the doors, she was able to partially drain the water; however, water was still leaking inside the rear driver's side and passenger's side doors during rainy weather. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 42,000.

Rear passenger door does not drain and holds water. This is a potential mold issue which is a health problem. This will also cause the doors to rust.

The contact owns a 2022 Toyota Rav4. The contact stated that while rolling down the driver's side window, the window made an abnormal sound. The vehicle was taken to the dealer, who removed plastic debris and tightened unknown screws on the driver's side door; however, the failure recurred. The manufacturer was made aware of the failure and informed the contact that it was a common failure in similar vehicles. The failure mileage was approximately 600.