2016 Toyota Camry Body & Structure Problems

The metal torsion bar that holds your trunk open broke and fell on you while loading groceries. After a failed repair attempt, the trunk became heavy and unstable again within minutes, creating a safety hazard. You've found reports of the same problem affecting many 2016-2015 Camry models with no recall, and repairs from Toyota dealers and body shops haven't provided a lasting solution. The fix will likely require replacing the trunk torsion bars with new Toyota OEM parts, though you may need to investigate whether a design correction is available.

Roof and sunroof structures began making continuous loud "popping" noises, very startling and distracting to driver and passengers. Toyota is aware of the problem, it involves the structure of the sunroof mating to the structure of the vehicle roof. This defect has existed since at least the 2007 model year, and Toyota published official guides for Toyota dealer repair procedures. Toyota refused the procedure due to my vehicle being out of its 3 year/36,000 mile warranty, instead quoting around $1600 for the repair. The popping noises are very loud, similar to a rock hitting the windshield. This startles the driver and causes the driver to jump and lose focus. This is a very well-known defect and Toyota is hiding behind the fact that it usually begins after the warranty period is expired. Toyota should cover its repair.

After driving in highway about 1 hour, The driver side door HALF OPENED BY ITSELF. Car has ~60K miles, this incident is happening for the first time. Before driving door was closed as usual. The car speed was ~ 77 mph during the incident, It was windy day, road quality was ideal.

THE BLIZZARD PEARL PAINT IS PEELING AROUND THE REAR WINDSHIELD AND ALONG THE SIDES OF THE FRONT WINDSHIELD.

TRUNK OPENS BY ITSELF. THEN, TRUNK LATCH DOES NOT CLOSE ANYMORE. *TR

THERE IS RUST IN MY VEHICLES BODY AND THE CHASSIS IS BENT OUT OF SHAPE IN THE FRONT. I DIDNT REALIZE UNTIL I TOOK IT TO THE BODY SHOP. ALSO THE AC SYSTEM WILL NOT WORK NO ONE KNOWS HOW TO FIX IT I SPENT OVER $3000 TRYING TO FIX IT AT THE DEALERSHIP.

I PURCHASED A USED 2016 CAMRY HYBRID XLE IN OCTOBER 2016, BUT I WAS UNAWARE OF THE ISSUE WITH THIS PARTICULAR VEHICLE. WHENEVER THE VEHICLE IS ON AN UNEVEN SURFACE BETWEEN AXLES, IT PRODUCES A KNOCKING, POPPING, TICKING, OR SNAPPING NOISE FROM THE MOON ROOF AREA WHILE DRIVING. TOYOTA BUILT MANY DEFECTIVE VEHICLES WITH POOR SUNROOF FRAME INSTALLATION, AND THE CUSTOMER IS HAVING TO PAY THOUSANDS OF DOLLARS TO DRIVE A NEW SHITTY CAR THAT MAKES NOISES ALL THE TIME. IT IS RATHER UNPLEASANT TO DRIVE A VEHICLE THAT YOU SHOULD BE PROUD OF, AND THE NHTSA SHOULD MAKE TOYOTA RECALL ALL THESE VEHICLES TO TEACH THE MANUFACTURER A LESSON. I HAVE CONTACTED TOYOTA IN REGARDS TO THIS MATTER, AND SINCE MY VEHICLE WAS NOT UNDER WARRANTY, THEY SAID THAT IT WAS NOT THEIR PROBLEM. THERE IS A REPAIR PROCEDURE INCLUDED IN TSB 0151-13 HAS BEEN DEVELOPED TO ADDRESS THIS CONDITION. IT IS VERY UNFORTUNATE THAT THE CONSUMER HAS TO DEAL WITH CAR MANUFACTURER'S INADEQUACY, BECAUSE THEIR INSPECTION PROGRAM IS WORTHLESS. ALL THAT I WANT IS TO GET MY VEHICLE FIXED FREE OF CHARGE, AND ENJOY A NICE RIDE.

THE ORIGINAL EXTERIOR PAINT IS PEELING OFF ON MY VEHICLE. SMALL RUSTY SPOTS CAN BE SEEN ON THE BODY OF MY VEHICLE.

TL* THE CONTACT OWNS A 2016 TOYOTA CAMRY. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE FRONT BUMPER LOWERED AND PUNCTURED THE FRONT PASSENGER TIRE. THE FAILURE CAUSED A FLAT TIRE. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 26,000.

I WAS DRIVING ON THE FREEWAY WHEN THE SUNROOF SHATTERED. THE VEHICLE IS 1-1/2 YEARS OLD. THE OUTSIDE WEATHER WAS ABOUT 50 DEGREES AND I HAD THE HEAT ON. NOT SURE IF THE INSIDE/OUTSIDE TEMPERATURES CAUSED THIS, OR IF THE BODY HAD SETTLED OR CHANGED IN SOME WAY TO CREATE PRESSURE ON THE GLASS.

AT STOP SIGNS OR TRAFFIC LIGHTS, THE ENGINE WOULD REV CONSIDERABLY & THEN STOP. AS WE APPROACHED OUR DRIVEWAY, THE CAR LURCHED FORWARD, THEN STOPPED. WE GOT TO OUR GARAGE-ENTRY CONTROL BOX & THE CAR LURCHED FORWARD ON OUR PARKING DECK, GOING LESS THAN 5 MPH, & WE HIT A BRICK WALL. WE THEN PUT THE CAR IN REVERSE & IT LURCHED BACKWARDS SO WE STOPPED THE CAR, TURNED IT OFF & CALLED THE POLICE. MY HUSBAND, WHO WAS DRIVING, SUSTAINED CHEST INJURIES (BLACK & BLUE, INJURED STERNUM, MARK ON HIS COLLARBONE FROM THE SEAT BELT NOT RESTRAINING HIM SUFFICIENTLY, DIFFICULTY BREATHING/STANDING/DRESSING/WALKING - GENERAL PAIN & SUFFERING) WHICH WEREN'T VISIBLE TO THE EMTS AT THE TIME & HE DIDN'T NEED TO GO TO THE HOSPITAL ALTHOUGH HIS REGULAR DOCTOR ADVISED HIM TO SEE ANOTHER AT AN EMERGENCY CARE CENTER. I REFUSED HIM MOVING IT ELSEWHERE AS I DIDN'T WANT TO DO FURTHER DAMAGE TO THE CAR OR ANOTHER VEHICLE WHILE WE WAITED FOR THE POLICE. I, AS THE PASSENGER, WAS NOT AFFECTED AT ALL PHYSICALLY. THE CAR WAS TOWED TO OUR DEALERSHIP'S SERVICE CENTER WHERE IT'S BEEN SITTING SINCE 3/21/17 AWAITING A TOYOTA INSPECTION ON APRIL 21ST - WHY IT SHOULD TAKE SO LONG IS INCONCEIVABLE AS IT'S OUR ONLY CAR!