2017 Ford Explorer Other Problems

While driving on the interstate, the B pillar (the vertical support beam between your front and rear doors) detached from your vehicle and struck your passenger window, narrowly missing the car behind you. This could have caused a serious accident if it had hit the other vehicle or caused you to lose control.

Back up camera fails to operate at times when vehicle is in reverse. Potential for backing collision or fatality.

Engine block timing plate cover has a defect crack in it causing an oil leak and fire hazard.

Hello there’s. Since I got the recall letter I keep going and calling to the Central ford dealership to replace the windshield molding, they keep saying that the moldings aren’t available but I know that they have been replaced them. My left moldings is very loose, I’m afraid that it will fall causing an accident.

safety recall notice: 24S02/NHTSA Recall 24V031 exterior A pillar trim part that detaches while driving can create a road hazard for driver and other road users, increasing the risk of a crash. The passenger trim flew off and hit windshield and car while driving on freeway (I-15 near Calico, CA). Driver's side trim is loose and rubber is cracked holding it on.

Windshield trim on both sides is broken and some is missing. It is available for inspection if done soon, I’m afraid to drive it much as it is, so I need to get it repaired. I’m concerned it could fly off and hit another vehicle and cause an accident, or my windshield could come out.

The driver side exterior black glossed facia on the "A" frame broke off while I was driving on the freeway at 80 miles per hour (speed limit). I did not see where it went, and luckily there were no cars behind me, but in a different situation it could have caused serious accidents. Much like their existing recall to replace roof racks.

The windshield trim, A post, drivers side is loose and in jeopardy of falling off. I am going to have this repaired. But, should this come off during driving it could affect another driver.

Panels by windshield one flew off on interstate and other is loose I'm scared this going rip off and cause an accident I see all same models have same issue. Please recall asap. I need this fixed and is a manufacturing defect.

I have 3 broken motor mounts in my 2017 Ford Explorer that is causing loss of power in my vehicle. I see that the 2020-2021 Ford Explorer was recalled for the same issue. My mechanic has had several ford explorers in for the same issue.

We had a catastrophic failure of the passenger side rear toe link. Causing loss of control of the vehicle No injuries thankfully The dealership and the Ford motor declined to toe the vehicle for repair due to its age. So a new part was ordered through Ford and work was do e locally Less than 30 miles later we had the same catastrophic failure of the same part.

Initially the cars check engine light came on intermittently for about 3 days, then one day while driving the wrench light came on and the car immediately started decelerating - almost as if I was breaking hard, and would not accelerate over 30. After turning it on and off multiple times the light went away for days until my appointment with the mechanic, that same day it came back on.

While driving down the highway the back seat in folded down position caught fire and burned a 12 inch hole through top and bottom of seat. To our knowledge the seat heater was not on the indicator light was not on.

Purchased my 2017 ford explorer 2/12/2018, bought new from dealer, and now has 6029 miles on it. The windshield seal and roof rails have deteriorated and coming away from the SUV. But, the parts they quoted me was for four pillers that go on each side of windshield, nothing about a seal.

We were driving forward on the interstate when the car lost power, a wrench logo appeared on the dash display, then we coasted the car to a stop at the left side of the road. Then we smelled smoke, saw flames flickering up from the hood, vacated the vehicle and called 911 as the front of the car under the hood burst into flames. The car was quickly engulfed in flames.

Strong burning smell and exhaust like smell entering the cabin of the vehicle. The smell comes in through the air vents and in through the windows when they are rolled down. The vehicle smells like it is burning at times while other times it produces a strong sulfur smell.

While getting in the parked car in the driveway after closing driver side door , rear tailgate window exploded . Sounding like a gunshot.

Explorer has less than 11000 miles on it. Since the day I bought the car, under mild to heavy acceleration, smell of rotten eggs feels the cabin. After driving for 20-30 min my wife and two children under the age of 10 start to experience fatigue, headaches and nausea.

At approximately 6:20am edt on monday, 3/12/18 a carbon monoxide detector installed in my 2017 ford explorer platinum indicated the presence of carbon monoxide in the passenger cabin exceeding 100ppm. This alarm went off when I was 5 minutes in to my commute to work while stopped at a stoplight on a city street. I also began getting a severe headache at this time.

There is a burning smell/ strong odor of exhaust fumes entering the vehicle when driving . It seems to occur more often or become stronger when accelerating up hills or when accelerating onto the highway, but can occur when driving at any time. My wife, myself, family members and friends who have ridden in or driven the vehicle have smelled it.

My 2017 ford explorer xlt has exhaust smell coming through the vents throughout the vehicle. This is not a new car smell but rather exhaust odor and only is apparent when the AC system or fan system is in the on position. I purchased this vehicle on june 13, 2017 and was hospitalized on july 1, 2017 for three days.

Traveling down interstate and sunroof exploded, sounded like a shot gun blast. Glass shattered, panel was pulled upward and no damage to the curtain.

This a police patrol vehicle used as a k-9 unit. Deputies have been complaining of headaches after shift. Last night they had to be seen by ems.

Your vehicle is a retired police interceptor that still has police insignias and markings on it, which could be misused for impersonation or fraud. The vehicle has open recalls that need to be addressed. You may want to contact the seller and Ford to have the police markings removed and all recalls completed before using the vehicle.

Your Ford Explorer's roof rails were subject to a recall, but the repair didn't properly address the original problem. Ford has not been willing to correct the issue.

The windshield outer trim pillar molding has flown off my vehicle twice while driving on the highway. This last time it almost hit someone on a motorcycle. What is Ford going to do to fix this?

This pertains to the B-Pillar trim recall. It should be noted that not only does the trim fall off but if it is the trim with the entry keypad, that can cause a short circuit that effects other parts of the car operation. Recently this happened to this vehicle and a fuse blew under the drivers side dash fuse 11 5 amp fuse.

My parking pawl failed. Other 2017 explorers have the recall but mine doesn’t? Dealership says mines not effected but it broke?

The Roof trim piece flew off while driving and almost hit the car behind me. The other side looks loose as while. I know the A pillars have an open recall on them as while but they said those parts arent available.

The A pillar trim has detached from the windshield while I was driving on the highway, it almost hit the car behind me. There was no warning before it became detached. When calling to see if parts were available I was told that they had been on back order for a year and they had no idea when parts would be available

the transmission has gone out for a second time 3 years ago the transmission was replaced as part of fords customer satisfaction and after 3 years of driving the car started acting weird stalling or not wanting to go- now it will not start after taking to the ford dealership they informed me it was the same problem they had previously fixed, and it was no longer under warranty I would have to pay for a whole new transmission- to be honest I still owe money on this car and could not afford a repair of over 7000 -It was already fixed just 3 years ago how is the Transmisson faulty for a second time?

Driving down the highway and the roof rail flew off almost hitting the car behind me upon pulling over I discovered the roof rail flew off. I called the dealership and they told me that vehicle is over 150k miles and the recall was voided. I don’t remember seeing that.

For over a year the windshield of my car had a “rattle” or wind-like noise. I figured this was due to the weather stripping around the windshield degrading and falling off. I heard about the recall and the very next day I was driving down the interstate and the plastic piece (A-Pillar) flew off and the car behind me swerved to miss the piece.

Upon starting my vehicle it started smoking all of a sudden from the exhaust pipes. Turned off right away. Towed to Ford dealer where they then said it was the turbocharger that leaked to the engine I believe and to the catilac converter.

The side Window Molding and mounting panel broke off while driving. When it broke off it could have hit a person or vehicle causing significant injury or damage, luckily it just narrowly missed the vehicle in the lane next to us. As this broke off while we were driving on the freeway we were unable to stop and retrieve the piece.

I was driving the speed limit on the thruway and my passenger side windshield outer trim flew off of my vehicle! It almost hit the vehicle behind me and cause myself and the vehicle behind me to swerve as it happened so suddenly it was startling.

The windshield trim has fallen off twice, almost hitting the vehicles behind us. We are about to replace them a 3rd time.

I was driving in the highway and one of the roof racks went off flying and almost hit the car behind me. After I stopped I checked the other rack and it is also lose and coming off.

My father in law became concerned after we purchased our new 2017 ford explorer because someone he knows had severe health issues from carbon monoxide poisoning from her ford explorer. He urged us to purchase a co detector. I got online and read about some of the issues with the car and decided this was probably a good idea.

C0 detector went off on a 3hr drive on 08-18-17 with AC and air recirculation on. After opening the windows the detector stopped beeping. The detector is a glui cigarette-lighter powered device w/ two USB ports () and has been installed in the center console cigarette lighter (facing the second row seats) since mid may.

On january 27th, 2017, my wife and I leased a new 2017 ford explorer. Every time we operate the vehicle, we get extremely sick (some symptoms we experience are sore throat, running nose, headaches, and nausea that last hours after exiting the vehicle). This occurs about 10-15 minutes while driving/operating the vehicle.

When I drive the truck lost power and the gas pedal don't work for 25 sec. Go off and on again. This happened driving in the highway and in city streets.

I received recall 24V031 in Feb '24, A pillar defect. I took my vehicle to the Ford dealer and had it inspected in Aug of '24. It was satisfactory at that time.

When driving my car, you can hear wind noise like the windows are down and it's loud enough to where I can't hear my kids most of the time when they need something from the backseats. These two recalls have been in place since May 2025 and there is still no remedy to fix this almost a year later. I have not taken it to a dealership but plan to this Friday 02/27/26.

The passenger side silver cover came off the top rail of my 2017 Ford Explorer. This SOULD be covered by Ford Safety Recall 21S22. I was told by my local Ford dealer my mileage was over the mileage limit of 152,000.

Safety Recall Notice 24S02/NHTSA Recall 24V031 - Exterior A-pillar applique trim clip attachments may not be properly engaged due to improper assembly. Two-step solution is required: Ford dealer has to check to see if the clips are properly engaged or not, then, if not, must order the correct parts from Ford.

Since Ford issued the first recall notice for Recall 24S02, I have been contacting my local Ford dealerships every few months to check whether the replacement parts were available. Each time, I am told the parts are still not in stock. As of today, multiple pieces of my vehicle have flown off while I was driving.

To whom it may concern, I am writing to formally file a complaint with ford. I request immediate assistance regarding multiple open recalls on my 2017 Ford Explorer Platinum. Despite multiple attempts to have these recalls addressed by my local Ford dealership and others, they have refused to perform all the necessary repairs.

Exterior windshield A-pillar flew off on the highway and ford said the repair was suppose to be ready on the latter half of 2024. This repair is not being dealt with in a timely manor. Manufacturer Recall Number 24S0.

The rubber seal for the windshield wiper cowl is completely deteriorating. This is a known common problem as the ford dealership parts department stated. With this rubber seal deteriorating its possible for wind to get under the cowling and blow it off while driving down the road causing a hazard for surrounding drivers.

Windshield cowl grille damage (along with A-pillar molding trim damage) causing loose parts and wind with rattling sound. Cowl should also be included and replaced as part of recall.

in reference to NHTSA Recall No: 25V347 & Manufacturer Recall No:25S53. according to ford my VIN does not apply due to the dates within the recall. both of my B pillar outside trim have been separated from the vehicle, just like it states in the recall.

I am unable to renew my registration due to not being able to complete / repair the recalls. Dealer does not have the parts for the repair therefore my vehicle will not pass inspection for the renewal. This has caused many troubles and issues, I am being pulled over by police and constantly worried they might tow my vehicle for expired registration.

Over Memorial Day weekend 2025, the A-pillar exterior trim on my 2017 Ford Explorer detached and flew off while I was driving. This matches the Ford recall (NHTSA Recall No. 25V347, Ford Recall No.

Was making loud buzzing noises and cracking noise while driving. The whole bottom is now gone. This been going on about 1-2 years now, when this all started.

About 4 years ago it was a recall to the roof rail trim disconnection, which mine was totally fine but since it was a recall I took it to the dealer to be replace. Now while I was driving on the highway I saw the right trim flight away. I called the dealer that replaced to see what they can do since I feel this is a continue problem a defective part.

The windshield trim is unattaching piece by piece. There is been a recall issued in January 2024. The dealership still does not have parts to make the repair over a year later.

While driving a certain speed I hear noise in main windshield area

I am submitting this complaint regarding a recurring turbocharger issue in my 2017 Ford Explorer Sport (VIN: [XXX] ). In April 2024, I was forced to replace the turbocharger system at a cost of approximately $2,500. Despite the repair, my vehicle continues to have serious performance issues.

There has been a long standing recall on the pillars for over a year, however ford continuously does not have the parts in stock. I have been awaiting repair for over a year with no date in sight.

The windshield trim on my 2017 Ford exploer which is the actual recall on this vehicle blew off while traveling on a major highway slamming into my windshield and into the next lane just missing another vehicle causing them to swerve violently to avoid being hit by the windshield trim!

Engine coolant leak. Come to find out it is the internal water pump, which several mechanics stated is a "common motor design flaw" with these vehicles. The repair for this is $3500!

I have been trying to get my vehicle fixed for safety recall 24s02 for months and the dealer keeps telling me they do not have the parts. I cannot use my car to go on trip or on freeways because of the windshield noise and I am afraid of something coming off and causing a wreck.

The APIM (Accessory Prodical Interface Module) component failed. This controls the touch screen, navigation system, phone/bluetooth call acceptance and other application. So while driving I had no or inaccurate navigation.

Gaskets on windshield are broken and moving while driving. The windshield is leaking water inside the vehicle from rain water damaged sunroof function and carpet.

When it rains, water leaks from the lights, seatbelts and dome lights. The water collects on the passenger floorboard front and rear and collects in the spare tire well. The car is now starting to mold this winter.

The rubber windshield trim is detaching from the windshield, causing a loud rattling/vibrating noise inside the vehicle. This issue also allows debris to get between the windshield and the windshield frame, causing even further damage.

Car wouldn't start. All the water had run out due to coolent leak near water pump and in finding it they found leak near front engine mount. These are problems that other 2017 explorer owners have also complained about online.

The gasket/seal surrounding the windshield on the passenger side front windshield was breaking off in sections. I had the dealer look at it while it was in the shop for some other recall work since I had only noticed it the day or so before. I was told it was the Pillar Moulding was coming apart but it was not a covered item.

In 2019 the Front Passenger B Pillar came loose and flew off while driving, this has been repaired. In 2022 the windshield A pillar came loose and had been repaired by myself. Now in 2023 the Front Driver B Pillar is coming loose and is pending repair.

Windshield trim flew off on the freeway going 65mph causing damage to a vehicle behind me. This problem has been reported to my nearest ford dealership.

windshield molding is falling apart. Windshield cowl fell apart and had to be replaced. Now rest of molding falling apart, as well as interior door molding.

Windshield rubber trim has almost entirely come off. I'm concerned that the plastic trim is next. You can hear the air coming into the car through the gap and now during a heavy rainstorm on 95 I had water coming into the vehicle.

Black plastic surround trim pieces of windshield and side door pillar are coming unglued and flying off at cruise speeds on highway without any warning or indication that it is about to happen. This presents a startle-effect distraction to the driver, possibly leading to lose of control of vehicle and/or impact hazards to following vehicles and pedestrians.

This vehicle has many blind spots and the blind spot alert only works sometimes. The locks only work sometimes too. It consistently does not lock the passenger side door with the lock or the key fob.

Pillar molding keeps flying out while driving. I have replaced 3 times and the last ones have flown off while driving. Thank God another vehicle has not been hit.

My wife took her 2017 Ford Explorer XLT to South Carolina from Florida. Upon her return last night, on 5 Jun 23 she was driving through Georgia and she heard a vibration coming from the drivers side windshield and then all of a sudden it stopped. When she parked inside our garage she noticed the drivers side A Pillar moulding trim piece had departed the vehicle and was missing.

On March 22, 2023 at approximately 10:15 am CDT, while heading south on Interstate 310 in Kenner, Louisiana, the passenger side windshield molding flew off the car while traveling just over 60 MPH. I was coming out of a curve from exiting I-10W onto I-310. Not sure if it hit another vehicle as there were other vehicles in general area at the time, but did not see exactly where part landed.

Driver side A pillar windshield molding came flying off while driving on highway at 70 MPH on I95. It detached from vehichle and slammed into my windshield caused it to crack and caused multiple scratches.

The A-pillar trim is coming off on both sides. I currently have a recall for the roof rails for the same type problem (dealer is booked out) where they can also fly off while driving. I googled the A-pillar concern I am having and it seems to be wide spread.

While driving at normal highway speeds, the piece of black trim on the passengers side of windshield flew off. Thankfully I was alone on the road so it did not strike another passenger. I took the vehicle to Ford.

Side moldings on the windshield came off flying into oncoming traffic. Had them replaced and then had to go back in again to have them reattached cause they came lose again.

On December 19, 2022, while driving to work in the morning on Interstate 580 I heard some cracking noises coming from outside my vehicle then all of a sudden I see something fly off the right side of my windshield.

IN JANUARY 2021 I had a recall for the roof rails on my 2017 Ford Explorer - it took them a year to get the parts due to covid but they finally fixed the roof rails. About one month ago the roof rails started to pop back up - I made appointment at local Ford Dealership in Fuquay Varina, NC.

After having the fan replaced on my vehicle less than 200 miles put on it the AC compressor went out.

Window trim on the winshield flew off while driving. Apparently this is a common issue with explorers, as when I went to the Ford Dealership to inquire about replacement they knew exactly what I was talking about and that they have tons of people coming in about it and that they are shocked that it hasnt been a recall so far.

Water pump failed and coolant leaked into the engine

I received two letters about this recall and scheduled an appointment with a ford dealer. When I showed up for the appointment they said it would take them a few days to even look at the vehicle and if the recall was not valid I would be charged. This was at the Bell Ford dealer in Phoenix.

The contact owns a 2017 Ford Explorer. The contact stated that after his wife exited the vehicle from the front driver’s side door, while attempting to open the rear driver’s side door, the vehicle began to roll backwards and knocked her to the ground. The contact's wife was taken to the hospital to seek medical attention but was not injured.

2017 ford 62,000 miles got vehicle brand new. On the freeway water light appears low coolant high temperature. I take vehicle water pump needed to be replaced.

The front windshield passenger side trim. Plastic trim flew off the windshield while driving 65 miles an hour in Tennessee on Hwy 111 near cookeville. It flew off but I was able to retrieve it from the side of the road.

I have been trying to get the first repair done, now the second. (I also have another Ford vehicle that has a recall that I haven't been able to schedule. I am told parts are unavailable or the repairs can't be done for months.

Passenger side windshield trim flew off while at highway speeds without any warning of it being broken or in need of repair. Flew off into traffic behind me.

The contact owns a 2017 Ford Explorer. The contact stated that while driving approximately 30 MPH, the engine shield fractured and detached from underneath the vehicle. The vehicle was taken to the local dealer who replaced the engine shield and the failure was remedied.

One week ago, my family and I took a trip in a recently purchased explorer where we all experienced symptoms of poisoning. We are currently getting the vehicle services by the dealership. However, we are not confident that the fix will be corrected as it seems like there are more than one location where the leak can take place.

1st time I had my car washed through a drive through car wash the luggage racks on top of the explorer lifted up. Took the vehicle to ford dealership in el cajon ca (were the vehicle was purchased) and they wanted $500 to fix it. Did not give me a ticket with the problem listed on it.

The top rail of the roof rack of this car isn't attached to the vehicle very well at all. I just lost one while going down the freeway. After talking to the dealership - it sounds like this is a problem that ford is very much aware of.

The vehicle has completely shut down while in motion and while parked on multiple occasions. The vehicle has also had multiple instances where it accelerates on its own, the most notable being when it will apply full acceleration while in a corner. This has been reported to both the local dealership networks and ford corporate with no willingness to document the issues or investigate.

Tl* the contact owned a 2017 ford explorer. The contact stated while testing the vehicle with an electromagnetic reading device, he noticed a high level electromagnetic radiation. The vehicle was taken to lebanon ford located at (770 columbus ave, lebanon, oh 45036), were the dealer was made aware of the failure.

Exhaust and carbon monoxide coming into cabin of car. Ford said they fixed the issue with tsb17-0044, but that has not fixed the problem. My wife and I get dizziness and the kids complain of the smell and headaches.

Hankook ventus s1 noble 2 tires, size 255/50/r20/105h for ford explorer 2017 wore out upon inspection. Mileage was under 21, 000 and tire thread was really bad. Needed to be replaced.

My vechile when driving at 65-70 MPH still has fumes getting into to cabin. I have taken the vechile for this recall but the problem persist. I have to open the windows to refresh the cabin.

I purchased my 2017 ford explorer on feb 14 2019 used from a dealer in nc. A short time after purchasing the vehicle I began smelling exhaust in the cabin of the vehicle. The vehicle was looked over at my local dealer who said they could not find the problem and sinply reploaced the cabin air filter which was black when it was removed.

For 2 years passengers were getting physically ill when riding in vehicle. Known issue with carbon monoxide leak was brought to ford's attention in 2018. Car was repaired with ford's prescribed fix options.

While driving the vehicle after purchasing it, the front passenger door lock rattles. I've taken it to them 4 times before they supposedly replaced it but it still rattles. They did not replace it.

We have been smelling carbon monoxide in the cabin during heavy acceleration (merging onto highway for example); it is especially worse when the AC or heat is on. We had it "fixed" several months ago when ford offered a solution to plug gaps. The problem persists and has not improved.

I have a popping noise when I turn my vehicle to left. I have had an axle and rear differential replaced. It continues to make a popping noise.

I'm the owner of a 2017 ford explorer. At the time I write this complaint my SUV is for the fourth time at the dealer ship, for the same problem since a bought it in september 2017: exhaust fumes entering the cabin. 3 weeks already since I dropped it at planet ford.

Smell strong odor of exhaust emission, start of car and while driving 1 hour commute dizziness and headaches. I had it taken to dealer for reseal. Still same issue.

There is an exhaust smell in the cabin of the vehicle. It has been making me sick, nausea, headaches, and burning eyes. The exhaust is coming in through the heating and air system and is more noticeable when accelerating and when the air conditioner is on.

The lines to the rear cabin heating and cooling started leaking r134, so the whole car is losing air conditioning since it all ties together. The car is less than two years old, and is having problems like this, which should be quite embarrassing to an experienced auto maker like ford.

Carbon monoxide leak since new . My son will have headaches and be nauseous when we take longer car rides or hard acceleration.

Exhaust fumes leaking in to the cab of the SUV. Causes a rotten egg smell, and has left my son and I nauseous many times.

Carbon monoxide leak . My daughter will have headaches and be nauseous when we take longer car rides. I have also had this problem/reaction

Took explorer to the dealership. For the rotten eggs smell for the second time as well as another issue. They did not address the exhaust smell and when question a second time they stated it was driven and the could not smell it.

2017 ford explorer sport AWD had the courtesy service for the exhaust bulletin done. I don't know what they fixed because the car still smells of exhaust when I accelerate hard. Trying to merge onto the highway on ramps comes to mind.

Carbon monoxide leak into vehicle. Car has foul odor that permeates through the car when driving. Especially when accelerating to highway speeds.

Bought my 2017 ford explorer brand new and it had been fine until 3 months ago when we started to smell smoke inside of the cabin. It happens every time we turn on the car for the first time with the AC or regular air turned on blowing through the vents. In two minutes or so the smell is gone.

Taken back to dealer for rotten egg smell this will be the second time after all they did was inspect per the tech bulletin and reprogrammed AC unit,(still have smell while under medium acceleration ) also whistling coming from intake side of motor.

Exhaust leaking into cab of police package explorer vehicle. Spring of 2018, seals of my explorer were replaced. Sept 2018, I felt sick, pulled over and passed out while driving explorer.

After a hard acceleration, sulfur smell takes over the cabin of the vehicle. I've taken the vehicle into the dealership and they have performed the recall on the exhaust system. The smell is still in my vehicle.

When the vehicle is being accelerated, a strong odor of sulfur or "rotten eggs" consumes the cabin of the SUV. This has occurred when the air system is in all modes, including when turned off. It is apparent that exhaust fumes are entering the cabin when driving the vehicle and endangering all passengers.

Original tires that came with truck vertus s1noble2 255/50 r20 105 h are worn out after 15000 miles of normal driving..tread is at a minimum and tires look weak on side walls...starting to crack. Tires need to be replaced after only 15000 mi

Vehicle has been back and forth to sawgrass ford as there is a bad smell of sulphur/rotten eggs. Dealer conducted voluntary recall. Have been back several times since january 2018 with same issue.

Exhaust smell in cabin upon acceleration. My vehicle already had the ford recommended repair at the dealer which did nothing to solve the problem. It seems worse now than when it started.

My vehicle consistently has an exhaust smell while driving and registers co levels from 3-5 ppm in normal driving conditions. Under hard acceleration the co levels have register above 11 ppm. The smell and co levels are at their worst when the engine is under a lot of strain.

There was a coolant leak into the heater box which cause the heater core to fail and then it began filling the driver's side of the cabin with coolant fumes for two months. The vehicle should have never left courtesy ford here in portland or. It went back three times for this issue.

I have a 2017 ford explorer platinum which I purchased brand new on november 25, 2016. It took me a while to realize but every time I would drive the explorer, my eyes would get very heavy and I would develop a headache. I commute 42 miles each way for work and I cant count how many times I almost fell completely asleep.

Carbon monoxide / exhaust gases entering the passenger cabin while driving made all passengers ill, with extreme headaches and nausea. While driving home from vacation the cabin filled with exhaust fumes and was a problem for the next several hours.

I am an attorney filing this report on behalf of and at the request of my client, the vehicle's owner. The complaint is a noxious odor which fills the vehicle during its operation; after numerous repair attempts by ford, this concern has not been corrected.

Exhaust smell in passenger cabin light headed, nausea, flared up my migraines. Complete negligence on behalf of dealership to sell me vehicle and not share information regarding this health concern. In addition, they mention the 'recall' and fail to address it.

Exhaust smell in cabin seems coming from heating ducts took it to dealer did there so called fix but still smell exhaust makes me feel dizzy when driving it seams the smell comes and go the smell is bad and also makes eyes water

There is a smell of exhaust in the cabin at times driving. When the smell is present I get a severe headache and feel sick to my stomach. A few weeks ago, I went to the dealer to report the exhaust smell and they immediately took it in like they knew exactly what is happening.

I am currently pulled over in a parking lot. Dizzy, just vomited, blurry vision. I am standing beside my vehicle to get fresh air.

Strong smell of exhaust inside the cabin. Vehicle has been back to ford three times and has modifications completed but has not corrected the problem. It happens more at highway speed with the air on recirculate.

Scott peterson motors of sturgis completed the 17n03 service on this vehicle in order to repair the problem of exhaust odor in the cabin. However the intermittent exhaust odor is still present. Also turned on a co meter and got a reading of 114 ppm of co while driving.

Since I purchased the car I noticed a foul smell on the interior. It smells like rotten eggs. Now that it is winter and I am warming up my car prior to getting an it I noticed that that same smell permeates the exterior of the car as well.

There's exhaust fume in the cabin my wife has suffered severe headache after 60 mins of driving included my 20months old baby. My car has already been repaired once and is in the shop again because I left a co2 senors in back seat and has gone off multiple times. Ford is not being very helpful because I don't want the car anymore.

When applying just the slightest bit of pressure to the brake pedal at the same moment the brake lights come on a clanking or clicking noise happens. The noise sounds like it is coming from the front passenger side of the vehicle. The noise is also random and despite efforts to intentially duplicate noise, it appears to happen randomly.

Ford recall. I started feeling fatigued, nauseous and getting headaches over the past week after driving to and from work. I drove home from work on 12/6/2017 at night and was struggling to keep my eyes open and got sick.

Have the carbon monoxide smell inside my SUV. I took it to the dealership in oct. And was told parts were backordered to dec.

Exhaust leaking into cabin of vehicle: while driving I noticed after a period of 1 hour I get dizzy, headaches, and feel nauseated. When after arriving at my destination I felt very lethargic taking many hours before I felt relief. My wife noticed it driving on a two hour trip where her vision became doubled.

There's exhaust fume in the cabin after hard acceleration(RPM was around 5000). And my family suffered a severe headache after 90 minutes driving included my 12 months old baby. My car has already been repaired twice in ford, but it has not been resolved.

Originally filed complaint 10883479 and 10954630 on a 2015 ford explorer limited for exhaust odor in the cabin. After several TSB repairs the exhaust odor was still in the cabin. On june 20, 2017, I paid $4670.29 and ford replaced my 2015 with a similar 2017 ford explorer limited.

Smell of egg/sulfur in the cabin of the car after rapid acceleration. I had notified the dealership at my last oil change. They didn't seem concerned about it.

My wife and I purchased a 2017 ford explorer and she was complaining of burning eyes and nesuea I did think nothing of it until I saw a cbs report about the police interceptors so when I went to my local dealership and asked them about it they said not to worry because my explorer was not part of the recall please NHTSA make them take the explorers back and exchange it's not fair that we paid for a $34,000 vehicle that is not safe for us and the public thank you,

My parents bought this unit 8 months ago from tipton ford dealership in brownsville tx. Soon after that my mom starting complaining about tingling in her hands and had lost 8 pounds in 2 weeks. She was recently admitted in the hospital for 4 days with carbon monoxide level in her blood.

Exhaust fumes in cabin are extremely strong when driving 35 MPH or highway. I am lightheaded, dizzy,trouble breathing exasperated with copd and asthma. Dealer said they did not notice exhaust in cabin with co detector.

Exhaust fume leaks into passenger cabin - problem since purchasing this vehicle new this spring; anytime when accelerating to merge into highway traffic with recirculating AC on a burning oil or acrid odor leaks into the cabin. In an attempt to fix the problem the local ford dealer 'resealed" the undercarriage, however the problem persist.

Since buying my explorer I have noticed any time I accelerate I begin to notice an awful smell. If we do not roll windows down, everyone in the vehicle gets nauseous or dizzy. Today while accelerating on the interstate I had to quickly stop to throw up.

When driving vehicle I suffer from burning eyes, headache, nasea, feeling ill, vehicle was at dealer for co2 leak, vehicle was out of service for approximately 60 days, I picked it up, drove home approximately 30 minutes and became ill, same as before it was supposedly repaired.

Exhaust fumes in cabin of car. They say they fixed it but I still smell exhaust fumes. Carbon monoxide

When accelerating past 2,500 rpms, exhaust comes into the car. It smells and has since I bought it. The dealership said it would burn off, I'm now at over 5,000 miles and it still does it.

Exhaust leak into cabin of vehicle, noticed especially on acceleration on highway at speeds of 55mph and when driving up and down hills. Had to roll down window to get smell out of vehicle. Causing driver to get headaches, nausea and get very drowsy.

Gas odor leak inside the car while driving that caused me to have sxs of dizziness, nausea and vomiting. It happened in multiple occasions.

We have taken our explorer into a ford dealership twice now. When you accelerate on the highway there is a really bad exhaust smell in the cabin from time to time. They claim to fix it every time and then the problem occurs again.

When I accelerate with the air conditioning unit on, the smell of exhaust is entering my cabin. I have to roll down the windows to let the smell out. According to the dealership, there is nothing wrong with our vehicle.

While driving my 2017 explorer I get sick while driving. I get a headache and very nauseous and sometimes I get dizzy. I will drive other vehicles and I don't get sick with them.

The explorer is experiencing carbon monoxide leaks. The further back you sit in the SUV the more you are exposed to the carbon monoxide. We purchased a detector and after only 10 minutes on the interstate the level was 15ppm.

Smelled gasoline in cabin after driving car for 2 miles in morning. Air conditioner was on, temp was approx 75 degrees. Contacted dealer and they said that sometimes with new cars it is the result of the coating on the new parts.

I have had an issue with the exhaust smell in the vehicle from the initial trip I took with the vehicle. I have discussed with the dealer and they have acknowledged that there have been other complaints but ford has not recalled or come up with a fix for the problem. I am aware of other customers using the lemon law in florida to replace their vehicle.

Ford explorer sport 2017 smells of exhaust gas in the driver cabin. I bought the car in march 5, 2017 and took it to dealer 3/9/17 to complain about exhaust fumes smell when I drove on the freeway. They told me they tested it and could not smell anything.

Possible carbon dioxide leak. On a recent long trip I had trouble with headaches and lightheaded. It became worse when the air conditioner was on.

Exhaust smell and eyes burning when acceleration with air conditioner on .inside of vehicle took to ford dealer and they say they don't smell anything . This has been ongoing since it was brand new 50 miles on vehicle

Engine exhaust odor in the cabin intermittently, going up a hill or merging onto the freeway at about 3500 rpms, air conditioner is on and recirculation mode is on, seems to fail more in hotter weather. This 2017 model is a replacement from ford of our 2015 ford explorer that had the same problem!

6/29/2017 this happened to my 2017 ford explorer back window yesterday. Nothing hit it we weren't on the freeway. We were at a light at a complete stand still.

When I acellerate fast like getting onto a busy highway, a burnt or cotton smell enters the passenger compartment despite the a/c recirculation being engaged. Smell dissapates after a while but always happens under the previously mentioned conditions. Ford dealership has seen the vehicle twice for this issue and is seeing it again tomorrow for the same thing.

Every time it's parked facing down hill and it rains the sunroof/moonroof leaks. The water comes out of the upper console once you start driving.

We currently have 4-2017 explorers that were placed in service between january 11 and january 19, 2017. Mileages range from 700 to 3000 on the 4. After our driver reporting dizziness, headaches and nausea, the first vehicle was taken out of service on february 20, 2017.

Rotten egg fumes filling interior of vehicle. I have owned it for less than a month. I have taken to dealership.

While the engine is started the odor and ailments are much more present but there is still a presence of an odor inside the cabin and ailments still impact driver when vehicle is in the off position.

I have a 2017 ford explorer that has a exhaust leak that I smell when I enter the highway. I also smell this odor when I tow my wave runner. The odor is so strong that my son vomited while in the vehicle.

Recall was published 1/19/24 Manufacturer Recall Number 24S02 NHTSA Recall Number 24V031 It's been over two years and Ford is saying the replacement parts are still not available. This is unacceptable.

There is an odor in the passenger cabin. Seems unsafe

It is known that for the specific year make and model that the water pump goes out around 100,000 miles. This water pump was built as an internal water pump, which is not typical for most cars. in order to fix this part, the engine has to be taken out and lots of parts have to be disassembled Just to get to it.

A buzzing started coming from my front dash. My mechanic pointed out the molding/trim on the windshield is basically disintegrating because of cheap quality materials.

In my 2017 Ford Explorer, that backup camera is experiencing issues that sound related to the current recall on 2021-2024 Ford Explorers. The image is all distorted, the backup assist lines are not present, the screen will go black or grey with distortion.

Display screen/Navigation screen is flashing continuously. This is affecting the use of the back up camera which could potentially cause damage to vehicles or persons. This also is affecting thr use of hands free operation.

faulty front grill

Water pump has gone out, and is a known issue with the explorers, plus they have made these very difficult to to replace and require partial engine tear down.

Vehicle was inspected for 24S02 a-pillar recall in October. Nothing is updated or addressed if the a-pillars pass inspection. that closed the recall.

Manufacturer Recall Number24S02 NHTSA Recall Number24V031 Recall StatusRecall Incomplete, remedy not yet available

Delay in available parts. Both A-pillar trim parts have detached from vehicle. Passengers side 6/2024, Drivers side 12/24.

None of the door locks work, making it unsafe and dangerous for crime areas. I have contacted ford many times however they are unwilling to fix issues and it is a widespread issue with the year and model... It is an expensive issue to fix in all 4 doors

The A trim pillar piece described in NHTSA recall 24VO31 flew off at highway speed. The B pillar trim piece flew off striking the side of the car causing a dent.

The trim around my windshield fell off while driving. I called a local ford store, Ed Martin Ford in Anderson, Indiana and was told the current recall does not cover this.

Me levanté por la mañana para llevar Mis hijos ala escuela y ya estaba rayada la troca ..desconocido

Front windshield rubber trim is disintegrating, dry rotted and cracked throughout, separating from windshield, pieces about to fly off. Vibrates and makes sound when driving 55 MPH or more.

Driver side window button does not work. All others do. There is no reason this should not work on a car with so few miles 18,700 and less than 7 years old.

2017 Ford Explorer windshield trim is starting to come off. Pieces have flown off behind the vehicle.

Rubber front windshield trim is deteriorating in the sun. Pieces are braking off while driving & causes a whistling sound.

The passenger side exterior windshield pillar trim piece flew off while driving on I20 west of Dallas Tx. Could have hit the car behind me.

Windshield trim became detached while driving 70 MPH on the freeway.

While driving on the interstate at speed of around 65mph, plastic piece that is mounted between windshield and passenger side door detached and flew into following traffic

windshield trim coming off before 5 year mark. had part of the trim come off and go flying along making a bad sound at highway speeds. had a about a 1 feet chunk fly off and hit the car behind me on the interstate.

Both front plastic windshield covers have flown off on the highway traveling around at rate of 65. The passenger side detached and flew off in one piece and the driver side only half of it flew off after cracking in half.

The locks on my vehicle are going out one door at a time. Seems like a reoccurring problem for many Ford Explorer owners. No warnings given.

As I was driving 70mph on the interstate my driver’s side windshield pillar molding flew off.

Yesterday I was driving on the highway and the molding next to windshield driver's side of the car flew away. We heard a loud nose when we stopped, we saw that the molding was complete gone. It could have hit another vehicle or a person

Windy conditions here driving along highway and the windshield cover blew off and unsure if hit another car or not but this should not be blowing off a vehicle which I'll have to now replace in addition to a safety hazard to others driving

While driving down the highway the windshield trim molding flew off vehicle on the driver’s side. At a later date the passenger one also flew off while driving on the highway with a vehicle behind me. Luckily never hit it.

Passenger side A-Pillar Front Molding Outer Trim Shield detached from vehicle while driving.

The power liftgate on my Ford Explorer slammed down on me when I attempted to put groceries into my car in the store parking lot.

While driving on the freeway the passenger side windshield side panel flew off the car completely. It looks as though the clips that hold it on all failed. This seems to be a known issue with this model of car.

In October, 2022 I was traveling on interstate 75 in GA. Heard a strange sound in front of vehicle. When I stopped later, I noticed that the trim along the edge of my windshield was no longer there.

2 open recalls with no solution or date of resolution to be given.

Ford Explorer 2017 SYNC/APIM malfunction. Touch screen and controls stop responding almost right after system starts. Troubleshoots indicate to perform master reset, software update, battery replacement but no difference.

Smell in car when driving on freeway or using air conditioner. Burning eyes, nose running, sore throat, feeling sick.

the ribs that are on the roof of the car are loose

There seems to be an issue with exhaust entering the cabin of 2017 Ford Explorers. There is also a TSB out for this, but Ford refuses to do a recall. Exhaust should not enter the cabin of a vehicle.

After a heavy rain water accumulated inside the car front passenger floor and under the seat. After inspecting I could not determine where the water came in. I feel this is a safety concern due to the electrical wiring under the seat

When accelerating on to the highway or uphill, the inside cabin smells of fumes. I believe it is carbon monoxide. When the car is warming up in the morning, the cabin smells do fumes, I believe itnis carbon monoxide.

When vehicle is running and all windows are close, it has a carbon dioxide smell inside the vehicle and I had to roll down the windows to let the air out.

My family & I have felt dizzy. Light headed. Headaches, nausea & numbness of arms.

Cosmetic plastic paneling has twice come off my vehicle while driving on an interstate. The first time if was the silver plastic molding on the right side of the roof rack rails. The second time it was a black piece of molding just aft of the passenger window.

Strong sulphur smell enters cabin when accelerating. Not a one-time event.

Exhaust comes into cabin when AC is on

I was sitting in the drivers seat and dropped my belt clip for my cell phone between the drivers seat and the center console. I reached between the drivers seat and center console to retrieve my belt clip and as I brought my hand back up the bracket the seat is attached to sliced the side of my hand/thumb open.

Very strong odor of exhaust fumes inside cabin. I was using the car's automatic start feature and when I got in car to drive kids to school, you could smell exhaust throughout car. Just recently purchased car and noticed this issue on 2nd day of ownership.

Exhaust smell coming into the cabin of the vehicle. Smells like hot exhaust that is coming in through the front vents while driving down the highway. Smells very bad and can't be good for you.

I went out to my car this morning to go to work and found that the rear window of the vehicle had shattered. It seams like it may have originated from where the wiper goes through the rear glass. I know that it wasn't broken by anyone because I have security cameras.

Exhaust is coming inside the cabin causing me to have headache and some nausea,,driving different times ,,up hills and speeding up,

I have had issues with all the door locks in my vehicle. When trying to lock the door using the key fob non of the doors will lock with the exception of the driver side door. In order to lock and unlock the doors you must do so manually by pushing the lock down or pulling the lock up.

When accelerating the AC has a horrible smell and also when you first start the vehicle

I have had this happen twice over the last year. When I have accelerated quickly while in motion on a highway , the accelerator pedal will remain depressed down. The car will continue to accelerate with my foot off the gas pedal.

Getting bad headaches and feeling sleepy when driving my ford explorer don't like having my 7month old in the car.

When accelerating, vehicle cab fills with exhaust fumes; smell causes passengers to feel sick.

Since a week ago I am feeling a strong smell in the vehicle once I turn it on and when I turn on the air condition it increases alot. I have gotten strong headaches because of this odor and my preocupation is that I am with my children most of the time. I called for a check up and they gave me an appointment.

Got this vehicle brand new. Have smelled strong exhaust smell inside the vehicle when driving since I bought it and problem has continued to worsen.

Carbon monoxide presence in vehicle. Repeatedly took it to the shop still no fix, have a new transmission put in problem persists change the timing cover problem still persists. Experience this issue at first startup, while driving local street and freeways, problem is getting worse my kids are getting sick and constant headache

Takata recal my explorer cab is filling with exhaust fumes. Makes me dizzy light headed and nauseous paying for a vehicle I can't even drive.

I have a terrible exhaust odor that enters the cab of my car upon acceleration.

Family has been having neurological symptoms after smelling severe exhaust in the cab of our vehicle.

Recall has already been completed on my ford and now when the max AC is on and your going down the road or need to accelerate the max AC turns off and comes out of the defrost vents and blows hot air this is not right and it does occur in any other vehicle that I currently own or have owned in the past

My daughter frequently complains of headaches, dizziness and nausea when riding in the front passenger seat. This only happens to her when she is in the ford. On one occasion she was taken to the emergency room and started vomiting.

If you want to know what is going on with your ford explorer, go to fordexplorernightmare.com. Read the 2 key documents and leave your story.

Since the day we leased this vehicle, I always feel a bit groggy and nauseous when riding in the vehicle. No specific date to attach to this.

I have been dizzy since purchased the car in november 2017, blurred vision as well.

Headaches and nausea, blurred vision, driving an hour a day to work at highway speeds.

Vehicle is two months old. Since pickup vehicle has had a smell of rotten eggs. More recently, I've been getting a reverb sound (like one window is cracked) which I can feel is due to a poor seal on the drivers door.

Noxious exhaust fumes are pouring into the cabin of the vehicle whenever the heat or a/c is running and are particularly noticeable when the vehicle is in motion. Noxious fumes are detectable by human sense of smell, and the noxious fumes increase in volume as the vehicle increases in speed.

Exhaust fumed smell in car... Specifically when AC is running and backing up

I bought a 2017 ford explorer for my daughter to drive back and forth to college. She has been experiencing dizziness, headaches and nearly passed out after driving the vehicle. When I get in the vehicle and start it up, it smells like exhaust inside the vehicle.

Carbon monoxide emissions in air conditioning system

There's some burning odor in the cabin. My family suffered a severe headache after 2 hours driving included my 11 months old baby.

Having head aches and short of breath, chest pains, fatigue,dizziness. Hard time breathing. Possible carbon monoxide poisoning.

Exhaust is entering the vehicle and making myself and my 2.5 year old son sick. I immediately get a headache when driving and feel nauseous, extreme fatigue, body and muscle aches, memory issues, confusion, and I've been coughing up brown mucous which is linked to the inhalation of hazardous pollution and gases.

Car smells like rotten eggs from the outside of the vehicle. I noticed a slight odor in the trunk area, but it's mostly coming from underneath the vehicle.

Exhaust smell.....rotten eggs or sulfer smell while accelerating with the a/c on in recirculate so I know its not from outside vehicles

When accelerating vehicle over 45 MPH exhaust fumes inside vehicle apparently coming through AC vents

Exhaust fumes coming inside car when accelerating

Our 2017 ford explorer sport has a constant foul smell after acceleration. The smell overwhelms the passenger compartment and is similar to a sulfur or burning hair smell. Additionally, if the vehicle is stopped idle for any period of time, upon initial acceleration, a large cloud of white smoke comes from the tailpipes.

On 9/11/2017 driving on highway - windows up no AC on - got this overwhelming feeling that was going to pass out - pulled to right and open all windows - head cleared - this was in the morning only person in the car - no history of medical issues

I noticed when am driving my vehicle I get sleep and I have never felt this way until I started driving this vehicle I havebeen filling light headed and headaches when am driving this vehicle. Not been filling well at all

Occasional exhaust gases inside vehicle while idling.

Exhaust smell coming into cabin from the front vents on highway acceleration.

Exhaust smell comes into the cabin when car is accelerating. Seems worst when the AC is in re-circulation mode. You can smell the exhaust fumes right after the engine/transmission has downshifted to accelerate.

Carbon monoxide inside passenger cabin, when driving at normal speeds in highway. Had to pull over to vomit and wait a while to be able to continue. Has happened in various occasion but wires the last time.

Heavy smell in cabin when the AC is turned on. The smell is foul and worse when AC is turned on. Driver has had several episodes of nausea, dizziness and overall unwell feeling since purchasing in november 2016.

Exhaust smell coming into the vehicle when driving or sitting with the air conditioning on.

Smell of exhaust fumes inside vehicle when driving vehicle upon reaching speeds approximatey 45 MPH and above off and on since purchasing new vehicle

We heard about the possibility of carbon monoxide issues with the vehicle. Concerned if it could be the cause of our 9 year old daughter's complaints of headaches when in the vehicle.

Law enforcement vehicle receiving high carbon monoxide level readings (10+ parts per million) in passenger cabin upon hard acceleration (from complete stop to 100+ MPH) with the air conditioning system on with the recirculation function activated.

Exhaust odor appears within cabin after excessive acceleration onto highway

Law enforcement vehicle receiving high carbon monoxide level readings (10+ parts per million) in passenger cabin upon hard acceleration (from complete stop to 100+ MPH) with the air conditioning system on with the recirculation function activated.

Law enforcement vehicle receiving high carbon monoxide level readings (10+ parts per million) in passenger cabin upon hard acceleration (from complete stop to 100+ MPH) with the air conditioning system on with the recirculation function activated.

Law enforcement vehicle receiving high carbon monoxide level readings (10+ parts per million) in passenger cabin upon hard acceleration (from complete stop to 100+ MPH) with the air conditioning system on with the recirculation function activated.

Bought this ford explorer april 2017 , it was a program car with 12,000 miles . I noticed a smell inside the cabin when the air conditioner is on . Dealing with headaches for three months , took at trip out of state and my whole family complained with headaches the entire trip .

Strong exhaust smell in cabin under hard acceleration. Requires opening the windows to dissipate the smell. Concerned about prolonged exposure for child and family.

Exhaust odor smell, as soon as car speeds up above the 40 MPH, it starts smelling exhaust in the car. Smell is so strong that cause headache. This is poison carbon monoxide.

My explorer has the strong smell of exhaust fumes that come into the cabin while you are driving. It is making the passengers feel sick and getting headaches. It is presently at earnhardt ford being looked at.

Odor which makes me nausea and have a headache

Odors in the occupant compartment under heavy throttle situations-climbing steep grades or accelerating onto the freeway-or when the HVAC system is in recirculation mode.

Every time gas is pushed at full throttle there is a smell of eexhaust in the cabin of the car , this is a new car just purchased , my two kids vomited and don't wanna ride in it this is not a joke at all .

Exhaust fumes, and carbon monoxide filling up the interior of vehicle, symptoms of coughing violently, exasperation of asthma symptoms, lightheaded,nausea, while driving on highway, waiting at a red light car fills up with exhaust fumes. These condition happen everyday

While the vehicle is in motion, exhaust fumes come inside vehicle when the air conditioner is turned on. This happens when on a city street and a highway. The fault or problem that is created for unsafe conditions is the smell of exhaust fumes.

Vehicle in motion- carbon monoxide detector reading of 45 ppm (parts per million). Passengers complaining of headaches, nausea, lightheadedness which prompted the use of the meter.

Exhaust in cabin when inside air is engaged, your own exhaust! Happens when vehicle is accelerated and then as you level the speed out, the exhaust fills the vehicle. This consistently happens on city streets, highway, turning corners, etc.

Upon heavy acceleration, toxic emissions smells fill the cabin even with the AC on recirculate. This is causing headaches. This has happened consistantley since I bought my 2017 explorer in jan.

Exhaust in the cabin of vehicle when using acceleration had it in the 2013 exployer and now in the new 2017 exployer. The exhaust in very sickiening in the cab when driving, and ford does not have a solution. Ford will not pay to have anything done even under warranty.

Excessive exhaust sulphur odor in vehicle while stationary or moving, with rear air conditioning on or off

While driving exhaust fumes enter cabin while excelerating and when air conditioner is on

Driving home after buying my brand new 2017 ford explorer I started smelling car exhaust. I thought it was as coming from the truck in front of me. It was coming out of the air vents in front of my face and I had the air on recirculate.

Same exact problem with "rotten eggs" smell / exhaust fumes entering the cabin as found in the ford class action lawsuit concerning 2011-2015 ford explorer models. The smell / exhaust fumes come through the a/c vents in the front of the vehicle when the vehicle is under any moderate to heavy acceleration. This problem can be duplicated every single time.

Smells like rotten eggs when I have my a/c on at freeway speeds

Purchased this vehicle august 2016. Shortly there after starting suffering severe headaches. Visited my family doctor in november 2017 and was diagnosed with migraine headaches and prescribed medication.

After hard acceleration the cabin fills with exhaust smell and I get a head ache instantly when you roll the windows down and it clears out of the cabin. Your head ache goes away. The car is fine until you accelerate again.

Outside vehicle exhaust enters cab area when accelerating with air conditioner is on

Back up camera does not work on a brand new car.

2017 ford explorer sport-when my car is in acceleration there's an exhaust smell that consumes the cabin. This happens every time .

Full accessory power active error message - received this message when I started the car to drive out my driveway, the car was fully locked up had to turn off and re-start.