2001 Ford Explorer Transmission Problems

Your transmission is not working properly. This is a critical drivetrain issue that will prevent your vehicle from operating normally and needs immediate professional diagnosis and repair.

Your vehicle unexpectedly shifted into gear and drove itself down the road while parked, crossing an intersection and hitting a brick wall—even though the shift lever showed the car was still in Park. The vehicle was running unattended when this happened. This suggests a serious issue with the transmission or shift mechanism that needs immediate investigation.

Your 2001 Ford Explorer is leaking both antifreeze and transmission fluid, and you're noticing thick smoke coming from the engine. You've also found significant rust underneath the vehicle with a hole in the running boards that's nearly caused them to fall off — you can see the ground through the hole. The check engine light hasn't come on, so the problems may not have been automatically detected. Repairs will likely involve locating and sealing the fluid leaks, inspecting the cooling and transmission systems, and addressing the structural rust and running board damage.

Your car requires 3 to 5 attempts to start, even after replacing the gas pump, spark plugs, cables, and temperature sensor. Additionally, your overdrive off light is flashing and you're experiencing rough gear shifts, particularly between 2nd and 3rd gear. The starting issue may require fuel system diagnostics, while the transmission problem may need transmission fluid evaluation or internal transmission service.

Your vehicle stalled unexpectedly while driving at various speeds without any warning signs. You were able to restart it manually and it ran normally afterward, but an independent mechanic diagnosed the issue as a transmission malfunction. The stalling could happen again while you're driving, potentially putting you in an unsafe situation. A transmission repair or rebuild may be needed to prevent future stalling.

DRIVING AROUND 30 MPH ON A FLAT STRAIGHT PAVED ROAD WHEN IT SUDDENLY SHIFTED INTO 4 WHEEL LOW.

SWITCHED INTO 4 WHEEL DRIVE LOW WITHOUT A COMMAND WHILE DRIVING AROUND 30 MPH ON A DRY LEVEL PAVED ROAD.

I PURCHASED A 2001 FORD EXPLORER SPORT TRACT I DIDN'T GET TO TEST DRIVE IT BECAUSE THERE WERE OTHER VEHICAL SURROUNDING IT. WHEN I FINALLY GOT TO DRIVE MY TRUCK HOME I NOTICED THE TRANSMISSION HAD A SEVERE ISSUE. WHEN I TURNED A CORNER MY TIRES RUBBED BADLY ON SOME OTHER PART TO THE TRUCKS PARTS AND THE DRIVER SEAT HAS A MEDAL ROD THAT JABS ME IN THE BACK THAT'S COMING THRU THE FABRIC NOW MY BATTERY HAS LEAKED ACID EVERY WHERE IN THE BATTERY COMPARTMENT AND SURROUNDING AREAS.

THE FORD EXPLORER 2001 XLS 4.0L REAR WHEEL DRIVE TRANSMISSION IS DEFECTIVE IN SLIP 4 TO 5 GEAR IN 75000 MILES. *TR

I TOOK MY CAR TO ASTORIA FORD LATE LAST YEAR, BECAUSE IT WAS STALLING AND LOSING POWER. THE CHARGED ME ALMOST $1,000.00 AND THE PROBLEM PERSISTS. THE O/D ON OFF LIGHT WILL STOP AND START. WHEN IT COMES ON WHICH JUST STARTED TODAY, THE CAR IN ANY GEAR WHILE ONLY GO FORWARD. IN REVERSE AND NEUTRAL, ONLY FORWARD. AS A POLICE OFFICER THIS IS VERY DANGEROUS, AND I CANNOT DRIVE THE VEHICLE. MANY HAVE SUBMITTED COMPLAINTS ABOUT THIS TO FORD, THEY CALL IT A PHANTOM PROBLEM. I HOPE THIS PHANTOM PROBLEM DOES NOT OCCUR IN FRONT OF A DAY CARE. *TR

FOR THE SECOND TIME, THE VEHICLE'S TRANSMISSION FAILED, LEAVING THE VEHICLE COMPLETELY POWERLESS WHILE DRIVING. THE TRANSMISSION ALSO FAILED AT APPROXIMATELY 70,000 MILES IN 2006, AGAIN WHILE DRIVING THE VEHICLE IN TRAFFIC. IN BOTH CASES, I, AS THE DRIVER, WAS NEARLY INVOLVED IN ACCIDENTS WITH OTHER VEHICLES BECAUSE OF THE COMPLETE LOSS OF THE TRANSMISSION POWER TRAIN. THE VEHICLE ALSO GAVE NO WARNING OF THE FAILURE PRIOR TO THESE EVENTS. IT IS MY UNDERSTANDING THAT THIS HAS BEEN A LONG-STANDING DESIGN DEFECT WITH FORD EXPLORERS, WITH A HIGH NUMBER OF VEHICLES FROM THE EARLY 2000S SUFFERING SIMILAR TRANSMISSION FAILURES. THIS IS BOTH DANGEROUS AND, I BELIEVE, A DEFECT THAT COULD CAUSE INJURY AND/OR DEATH.. I ALSO WISH TO ADD THAT THIS VEHICLE, WHICH IS 4 WHEEL DRIVE AND INCLUDES A FACTORY INSTALLED TOWING PACKAGE, HAS ONLY OCCASIONALLY BEEN USED FOR TOWING A BOAT (2X PER YEAR) AND IS SELDOM USED IN ITS 4 WHEEL DRIVE CAPACITY (ONLY ON SNOW COVERED ROADS 2-3 TIMES PER YEAR). THE VEHICLE HAS BEEN WELL MAINTAINED. THE COST OF THE REPAIRS IN EACH CASE WAS OVER $2,000. *TR

AS WITH SO MANY EXPLORERS I HAVE READ ABOUT, MY O/D LIGHT COMES ON AND FLASHES. I LOSE ALL POWER DURING INITIAL ACCELERATION AND THEN THE TRUCK SHOOTS OFF LIKE A ROCKET. IF I TURN THE IGNITION OFF, THE LIGHT RESETS AND THE VEHICLE IS OK FOR A WHILE UNTIL THE LIGHT AS WITH SO MANY EXPLORERS I HAVE READ ABOUT, MY O/D LIGHT COMES ON AND FLASHES. I LOSE ALL POWER DURING INITIAL ACCELERATION AND THEN THE TRUCK SHOOTS OFF LIKE A ROCKET. IF I TURN THE IGNITION OFF, THE LIGHT RESETS AND THE VEHICLE IS OK FOR A WHILE UNTIL THE LIGHT COMES ON AGAIN. I HAD THE CODES READ AND IT CAME UP A SOLENOID PROBLEM. I HAD THEM REPLACED AND TEN MILES FROM THE LOT, THE LIGHT CAME ON AGAIN. I HAVE READ THAT THIS IS A KNOWN ISSUE FROM FORD, BUT THEY HAVE YET TO ACT ON THIS ISSUE. COMES ON AGAIN. I HAD THE CODES READ AND IT CAME UP A SOLENOID PROBLEM. I HAD THEM REPLACED AND TEN MILES FROM THE LOT, THE LIGHT CAME ON AGAIN. I HAVE READ THAT THIS IS A KNOWN ISSUE FROM FORD, BUT THEY HAVE YET TO ACT ON THIS ISSUE. I TOOK IT TO THE FORD SHOP AND THEY TOLD ME THAT THEY HAVE FIXED SEVERAL AND THEY GO RIGHT BACK OUT IT WAS A WASTE OF MY TIME.. DOES SOMEONE HAVE TO GET KILLED BEFORE U ALL FIX THIS IF U TRY TO TAKE OFF AND IT SLIPS AND WILL NOT GO U CAN AND WILL GET HIT. *TR

THIS HAS OCCURRED MULTIPLE TIMES SINCE I'VE HAD THE VEHICLE. I KNOW ENOUGH ABOUT VEHICLES TO KNOW THIS IS NOT NORMAL IN THE EARLY YEARS OF 125,000 MILES AND ROUTINE MAINTENANCE. WHEN I ACCELERATE FROM A STOPPED POSITION THE RPM'S GO UP TO ABOUT 3,000 OR SO BUT THE VEHICLE DOES NOT ACCELERATE. THE O/D LIGHT WILL FLASH AND THE VEHICLE, WHEN IT DOES ACCELERATE, IS "SLUGGISH". WHEN I PULL OVER AND TURN OFF THE VEHICLE, THEN TURN IT BACK ON, IT SEEMS TO RESET THE LIGHT SO THAT IT IS NO LONGER ILLUMINATED BUT EVENTUALLY THE ISSUE WITH THE LACK OF ACCELERATION COMES BACK WITHIN THE NEXT FEW MILES AND USUALLY IS A PROBLEM BETWEEN 1ST AND 2ND GEAR. IT HAPPENS LIKE CLOCK WORK WHEN I LEAVE A DRIVEWAY AND ENTER TRAFFIC WHICH PUTS ME IN FEAR OF BEING HIT BY AN ONCOMING VEHICLE. THIS IS DEFINITELY A POTENTIAL HAZARD AND IN AN ATTEMPT TO DIAGNOSE THE PROBLEM I HAVE COME ACROSS MULTIPLE ENTRIES ON "BLOGS" WITH SIMILAR SYMPTOMS THAT USUALLY BEGIN AROUND 120,000-150,000 MILES. IN MY OPINION, THE ISSUE CAUSING THE PROBLEM, AND THE POTENTIAL RISK TO MY LIFE AND OTHERS, SHOULD HAVE BEEN RECALLED YEARS PREVIOUS. THIS SEEMS TO BE TOO COMMON. VEHICLES, IN GENERAL, SHOULD NOT BE OPERATING LIKE THIS UNLESS THERE IS AN EXTREME LACK OF CARE IN REGARDS TO MAINTENANCE. ON ANOTHER NOTE... I'VE NOTICED THAT THE VARIOUS FAULTY PARTS THAT HAVE BEEN RECALLED ARE "QUICK FIXES" WHICH TRANSLATES TO ME AS "CHEAP FIXES". IF A COMPANY PRODUCES A PRODUCT THAT FAILS BEFORE IT'S TIME OR CAUSES DANGER TO IT'S CUSTOMERS, THEY SHOULD DEFINITELY ENSURE THAT THE PROBLEM BE REMEDIED. SO "MAN UP" FORD AND ADDRESS THE ISSUE- OR THE ALTERNATIVE IS TO QUIT PRODUCING GARBAGE. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WHEN I STARTED FROM A STOP LIGHT IT TOOK OFF FINE BUT SHIFTING FROM 1ST TO 2ND AND THEN INTO 3RD THE ENGINE RACED BUT WOULD NOT ACCELERATE. I PUSHED THE O/D OFF AND IT SEEMED TO FIX THE PROBLEM. THEN OVER THE NEXT FEW DAYS IT BECAME MORE FREQUENT TO THE POINT THAT I AM AFRAID TO PULL OUT INTO TRAFFIC. I WORRY THAT I WILL BE HIT BY NOT GAINING SPEED TO GET GOING. ALSO MERGING ON THE FREEWAY IS FRUSTRATING AND UNSAFE. THE O/D LIGHT FLASHES ON AND OFF ALL OF THE TIME NOW. THIS HAS HAPPENED OVER THE COARSE OF A WEEK. THIS IS AN AUTOMATIC TRANSMISSION 2WD. *TR

VEHICLE STARTED HAVING A CHATTER UNDER THE HOOD. PULLED OUT ON TO THE HIGHWAY AND THE TRANSMISSION STARTED SLIPPING AND WOULD NOT ENGAGE (VERY DANGEROUS, WAS IN THE MIDDLE OF THE HIGHWAY AND COULDN'T MOVE). TOOK TO A MECHANIC AND HE TOLD ME THE NOISE HAD SOMETHING TO DO WITH THE TENSIONERS OR SOMETHING TO THAT EFFECT ON THE TRANSMISSION. HE SAID THERE WAS A RECALL FOR THIS IN THE PAST BUT NOT SURE IF THE RECALL IS STILL IN EFFECT. THIS DANGEROUS PROBLEM NEEDS TO BE FIXED BEFORE SOMEONE GETS INJURED OR WORSE AND FORD WILL BE LIABLE. *TR

TL* THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, THE TRANSMISSION SLIPPED. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE SERVOS NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 77,000. THE VIN WAS UNAVAILABLE.

MY FORD EXPLORER SPORT TRAC WITH AN AUTOMATIC TRANSMISSION HAS A COMMON PROBLEM THAT HAS PLAGUED MANY EXPLORERS, SPORT TRAC'S, AND RANGERS. A YOUTUBE VIDEO EXPLAINS THE PROBLEM, "UPLOADED ON DEC 7, 2011 - FORD USED THE 5R55E IN MANY REAR AND 4 WHEEL DRIVE APPLICATIONS. IT IS A GOOD TRANSMISSION BUT IS SUSCEPTIBLE TO THE VALVE BODY GASKET "BLOWING OUT." THE SYMPTOM OF THIS IN OUR VEHICLE WAS THAT THE TRANSMISSION MISSED SECOND GEAR UNDER ACCELERATION BUT FOUND A HIGHER GEAR WHEN WE LET OFF THE GAS PEDAL." THIS HAPPENS TO ME DAILY, AND IS A TRAFFIC HAZARD AS THE VEHICLE IS UNABLE TO ACCELERATE AS IT SHOULD. FORD PUBLISHED A TSB(TECHNICAL SERVICE BULLETIN) ON 03-22-10 ACKNOWLEDGING THIS PROBLEM. IT IS A DANGEROUS OCCURRENCE IN MOST VEHICLES WHERE THE VALVE BODY SEPARATOR PLATE DOES NOT WORK AS IT SHOULD. WHEN I TOOK MY VEHICLE TO THE DEALER, THEY DID NOT ACKNOWLEDGE THE PROBLEM BUT WANTED TO CHARGE OVER $4,000 FOR A NEW TRANSMISSION. THIS IS CLEARLY A DESIGN FLAW AND SHOULD BE ADDRESSED TO ALL OWNERS. PLEASE CHECK ALL COMPLAINTS REGARDING FORD'S AUTOMATIC TRANSMISSIONS, THE 5R55E AND HELP US OWNERS GET A REASONABLY PRICED CORRECTION, BEFORE ACCIDENTS OCCUR. THANK YOU. *TR

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 45 MPH, THE TRANSMISSION FAILED TO RESPOND WITH AN UNUSUAL WHINING NOISE. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD AND THE ENGINE WAS TURNED OFF. UPON RESTARTING, THE VEHICLE RESUMED NORMALLY. THE FAILURE RECURRED ON A SEPARATE OCCASION. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE FAILURE MILEAGE WAS UNAVAILABLE.

TL* THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT WHILE DRIVING, THE TRANSMISSION EXHIBITED A LOUD SQUEAKING SOUND. THE VEHICLE THEN BECAME RESISTANT TO ACCELERATION ATTEMPTS AND WOULD NO LONGER MOVE. THE CONTACT STATED THAT THE ENGINE CONTINUED TO OPERATE BUT THE VEHICLE WOULD NOT SHIFT INTO DRIVER OR REVERSE. THE VEHICLE HAD NOT BEEN TAKEN TO A DEALER OR MECHANIC FOR DIAGNOSIS. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.

VEHICLE WAS IDLING IN DRIVEWAY WITH THE DRIVERS DOOR OPEN. TRANSMISSION WAS IN PARK. TRANSMISSION DROPPED INTO REVERSE, ROLLED BACKWARDS IN DRIVEWAY, CRASHING THROUGH TWO CHAINLINK GATES, THE DOOR WAS TORN BACK AGAINST THE FENDER, I TRIED TO REACH INTO THE TRUCK TO TURN IT OFF, AND WAS PINNED BETWEEN THE TRUCK, AND THE CHAIN LINK FENCE. EXPLORER CURRENTLY IN THE COLLISION SHOP, AND TRANSMISSION WILL BE REPAIRED WHEN THE BODYWORK IS DONE. *TR

TRANSMISSION FAILED WITHOUT WARNING. WOULD NOT CATCH 3RD GEAR AND THEN SOUNDED LIKE A TOOLBOX WAS SCATTERED UNDER THE CAR. CAR SUCCESSIVELY LOST ALL GEARS EXCEPT 1ST. REPAIR COST OVER $2800.00. *TR

TRANSMISSION SLIPS WHILE SHIFTING FROM 2-3 GEAR OR BETWEEN 30MPH-40MPH. O/D OFF LIGHT BLINKS ON/OFF SOMETIMES WHEN THIS OCCURS. *TR

TL* THE CONTACT OWNS A 2001 FORD EXPLORER. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE ENGINE EXHIBITED AN ABNORMAL INCREASE IN RPMS. THE VEHICLE THEN ACCELERATED ABNORMALLY AND THE CONTACT WAS INVOLVED IN A CRASH THAT INVOLVED FOUR ADDITIONAL VEHICLES. NO INJURIES WERE REPORTED AND A POLICE REPORT WAS FILED. THE VEHICLE WAS TOWED TO THE DEALER WHO DIAGNOSED THAT THE SERVO PLUG HAD POPPED OUT OF PLACE AND FRACTURED THE SIDE OF THE TRANSMISSION. THE DEALER ADVISED THAT THE TRANSMISSION WOULD NEED REPLACING. THE MANUFACTURER WAS CONTACTED WHO DID NOT OFFER ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 118,000. THE VIN WAS UNAVAILABLE.

THE GUY BEFORE ME (AND MANY BEFORE HIM) EXPERIENCED THE SAME ISSUES I AM CURRENTLY EXPERIENCING WITH MY 2001 FORD EXPLORER SPORT: O/D OFF LIGHT BEGINS FLASHING, FEELING LOSS OF POWER AND HARD SHIFTING, ESPECIALLY WHEN TRYING TO GO FROM A COMPLETE STOP. TURN OFF VEHICLE, THEN RESTART PROBLEM GOES AWAY. THIS HAPPENS RANDOMLY, BUT MORE OFTEN IN COLD WEATHER. NOTHING COMING UP ON DIAGNOSTIC. *TR

2001 FORD EXPLORER SPORT. O/D OFF LIGHT BEGINS FLASHING, FEELING LOSS OF POWER AND HARD SHIFTING, ESPECIALLY WHEN TRYING TO GO FROM A COMPLETE STOP. TURN OFF VEHICLE, THEN RESTART PROBLEM GOES AWAY. THIS HAPPENS RANDOMLY, BUT MORE OFTEN IN COLD WEATHER. NOTHING COMING UP ON DIAGNOSTIC. *TR

I OWN A 2001 FORD EXPLORER SPORT. RECENTLY, IT APPEARS THAT IF I AM GOING A STEADY SPEED OR LEAVING FROM A COMPLETE STOP, THE CAR GOES INTO OVER DRIVE. THIS HAPPENS TO ME A MIN. OF 5 TIMES A DAY. THE BUTTON DOES NOT WORK FOR THE OVER DRIVE, SO EACH TIME THIS HAPPENS, I HAVE TO PULL OVER AND TURN THE CAR OFF AND BACK ON AGAIN. SOMETIMES THE OD GOES ON MINUTES AFTER I TURN THE CAR OFF AND ON AGAIN. I HAVE NOT TAKEN IT TO GET FIXED BECAUSE THE MECHANICS HAVE TOLD ME IT IS SIGNS OF THE TRANSMISSION FAILING. I AM A COLLEGE STUDENT AND CAN NOT AFFORD TO PAY OUT OF POCKET 3,000 WHEN THE CAR IS ONLY WORTH 6,000 AT BEST. *TR

2001 FORD EXPLORER SPORT. O/D OFF LIGHT BEGAN FLASHING, FEELING LOSS OF POWER IN EARLY GEARS, ESPECIALLY WHEN TRYING TO GO FROM A COMPLETE STOP. TURN OFF VEHICLE, NO PROBLEMS UNTIL AFTER DRIVING AGAIN. NOTHING COMING UP ON DIAGNOSTIC. *TR

OD LIGHT IS FLASHING AND THE FIRST GEAR SHIFTS REAL HARD. I TOOK IT TO THE FORD SHOP AND THEY TOLD ME THAT THEY HAVE FIXED SEVERAL AND THEY GO RIGHT BACK OUT IT WAS A WASTE OF MY TIME.. DOES SOMEONE HAVE TO GET KILLED BEFORE U ALL FIX THIS IF U TRY TO TAKE OFF AND IT SLIPS AND WILL NOT GO U CAN AND WILL GET HIT. *TR

I HAVE A 2001 FORD EXPLORER AND AT FIRST THE TRUCK WOULD SLIP IN AND OUT OF GEARS SO I TOOK IT TO A CERTIFIED MECHANIC AND WAS TOLD I NEEDED A NEUTRAL SAFETY SWITCH. I HAD THAT REPLACED ABOUT A MONTH AGO. YESTERDAY, I WAS DRIVING AND THE TRUCK SLIPPED OUT OF DRIVE.... AND IT WOULD NOT ACCELERATE. I PULLED OVER AND ATTEMPTED TO RESTART THE VEHICLE AND THE O/D OFF LIGHT STARTED FLASHING. THIS TRUCK IS GOING TO COST ME OVER 2,000 DOLLARS TO FIX AND IT SEEMS AS IF I AM NOT THE ONLY ONE EXPERIENCING THE SAME PROBLEMS. PLEASE HELP! *TR

FORD EXPLORER O/D LIGHT FLASHING, TRANSMISSION SLIPPING. *TR

'O/D OFF' LIGHT IF BLINKING, ON AND OFF. WHILE LIGHT IS BLINKING THE CAR SEEMS TO BE SLUGGISH AND DOES NOT RESPOND TO THROTTLE PROPERLY. ROUGH SHIFTS WHILE DRIVING. *TR

TRANSMISSIONS IN EXPLORER SPORT TRACS 2001 ARE NOT VERY RELIABLE, I AM HAVING TO PUT A 2ND ONE IN WITH ONLY 126,000 MILES. FORD SHOULD ADDRESS THE ISSUE WITH ALL TRANSMISSIONS IN THE EXPLORER. I WILL NOT PURCHASE ANOTHER FORD, NOR WILL I TELL ANYBODY ELSE, MAYBE THEY SHOULD HAVE TAKEN A BAIL-OUT FROM THE GOVERNMENT TO FIX THERE CARS. *TR

MY 2001 FORD EXPLORERS TRANSMISSION IS HAVING SHIFTING PROBLEMS FOLLOWED BY IT'S OVERDRIVE LIGHT FLASHING. I TALKED TO SEVERAL FORD TRANSMISSION FRIENDS AND THEY ADVISED ME TO INSTALL A UPGRADE KIT IN THE VALVE BODY. THIS WAS DONE, FLUID AND FILTER CHANGED, TO NO AVAIL. THE LIGHT INTERMITTENTLY FLASHES AND THE TRANSMISSION SHIFTING WEIRD. AFTER READING SEVERAL POSTS ON SEVERAL SITES REGARDING THIS PROBLEM, I AM AT A LOSS AT WHAT TO DO. SEVERAL PEOPLE STATED THAT THEY WENT TO THE EXTENT OF REPLACING THE TRANSMISSIONS WITH NEW ONES AND THE LIGHT STILL FLASHING AND HAVING THE SAME PROBLEMS. MY EXPLORER HAS 60K MILES ON IT AND THIS PROBLEM STARTED AT ONLY 50K MILES, TO ME THIS IS A PROBLEM FORD SHOULD ACKNOWLEDGE, AND ALLOW SOME COMPENSATION TO IT'S LOYAL CUSTOMERS. *TR

I HAVE A 2001 FORD EXPLORER SPORT THAT THE 4X4 CONTROL MODULE CONSTANTLY MALFUNCTIONS. THIS IS A COMMON PROBLEM THAT IS WIDESPREAD AND COULD CAUSE MAJOR ACCIDENTS BY LOSING CONTROL OF THE VEHICLE DURING OPERATION IN THE WINTER MONTHS ON SNOW/ ICE. IF YOU RESEARCH THIS YOU'LL FIND THE PROBLEM EXISTED FROM WHEN THESE WERE NEW VEHICLES AND FORD HAS NO RESOLUTION TO FIX THIS PROBLEM OTHER THAN REPLACE IT WITH ANOTHER DEFECTIVE PART. FORD'S DIAGNOSTIC COMPUTER DOESN'T EVEN RECOGNIZE THERE IS A FAILURE IN THE SYSTEM CREATING AN EVEN LARGER DANGER SINCE HERE'S NO WAY TO TRACE THE PROBLEM WHEN TAKEN IN FOR SERVICE. THERE SHOULD BE A RECALL ISSUED IMMEDIATELY. FORD AND MOTOROLA HAVE DESIGNED AND INSTALLED A DEFECTIVE PART THAT CAN KILL PEOPLE IF NOT FIXED AND HAS PROBABLY CAUSED HUNDREDS OF ACCIDENTS ALREADY. THE FORD PART NUMBER IS 1L54-7H417-AC AND THE MOTOROLA MODEL NUMBER IS 01MP207C01 AND IT IS DESCRIBED AS THE 4X4 CONTROL MODULE. *TR

TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT THE OVERDRIVE LIGHT KEPT ILLUMINATING ON THE INSTRUMENT PANEL AND THE TRANSMISSION WAS SLIPPING. THE SHIFT SOLENOID WAS REPLACED, BUT BEGAN TO FAIL 4,000 MILES LATER. THE FORD MANUFACTURER WAS AWARE OF THE FAILURE, BUT COULD NOT ASSIST BECAUSE IT WAS NOT A SAFETY ISSUE. THE FAILURE MILEAGE WAS 58,000.

FORD PART # 1L24-7H473-AG VENDOR # M799G MOTOROLA MODEL # 01MU152B06 DATE CODE 01211 SERIAL # 21396939

TL*THE CONTACT OWNS A 2001 FORD EXPLORER. WHILE DRIVING 65 MPH, THE OVERDRIVE LIGHT BEGAN BLINKING ON AND OFF. THE CONTACT HAD TO STOP THE VEHICLE EVERYTIME THE BLINKING OCCURRED. THE TRANSMISSION SWITCHED FROM FIRST TO SECOND GEAR EACH TIME THE LIGHT ILLUMINATED. THE CURRENT MILEAGE WAS 96,491 AND FAILURE MILEAGE WAS 96,427.

CHECK ENGINE LIGHT CAME ON, WITHIN HOURS THE TRANSMISSION STARTED NOT CATCHING...WOULD REV BETWEEN 2-3K RPM OR AROUND 30 MPH BUT NOT ACCELERATE. THEN O/D LIGHT STARTED BLINKING. ALL OUT OF THE BLUE.

2001 FORD EXPLORER SPORT WITH AUTOMATIC TRANSMISSION, 105,000 MILES. "O/D OFF" LIGHT BLINKING AFTER DRIVING FOR A FEW MINUTES. ENGINE ALWAYS REVS HIGH BETWEEN GEAR SHIFTS, ESPECIALLY BETWEEN FIRST AND SECOND, EVEN BEFORE THE LIGHT STARTS BLINKING. CHANGED TRANSMISSION FLUID AND FILTER, BUT THAT DIDN'T HELP. ONLY OCCASIONALLY TOWED SMALL TRAILER, BUT MOSTLY JUST DAILY DRIVING. NUMEROUS BLOGS ON THIS SUBJECT, SO THE PROBLEM APPEARS TO BE WIDESPREAD! *TR

TL*THE CONTACT OWNS A 2001 FORD EXPLORER SPORT TRAC. WHEN THE TRANSMISSION INDICATOR LEVER IS PULLED TO CHANGE GEARS, IT GOES ONE SPACE TOO FAR. WHEN THE GEAR IS PLACED INTO NEUTRAL, THE VEHICLE DRIVES IN REVERSE. WHEN THE GEAR IS PLACED INTO DRIVE, THE VEHICLE OPERATES IN NEUTRAL. WHEN THE GEAR IS PLACED INTO REVERSE, THE VEHICLE REMAINS IN PARK. THE CURRENT MILEAGE WAS 34,231 AND FAILURE MILEAGE WAS 34,175. UPDATED 02-19-08 *BF THE CONSUMER STATED DISCONNECTED SPEED DEACTIVATION SWITCH PERTAINING TO RECALL 05S28. UPDATED 02/14/08 *TR

ON OCTOBER 10TH, FOLLOWING A COLD START, THE VEHICLE WAS SHIFTED FROM PARK INTO DRIVE WITH THE 4X4 MODE SELECTION SWITCH SET TO 2WD MODE. INSTEAD OF 2WD MODE, THE VEHICLE WAS IN 4X4 LOW MODE. THERE WAS NO SHIFT COMMAND TO GO INTO 4X4 LOW MODE AND IT WAS IMPOSSIBLE TO SWITCH OUT OF 4X4 LOW MODE. THE VEHICLE WAS DRIVEN TO A DEALERSHIP IN 4X4 LOW MODE. THE DEALERSHIP CLAIMED THAT THE TRANSFER CASE SHIFT MOTOR HAD SHORTED FORCING THE UNCOMMANDED SHIFT TO 4X4 LOW MODE. THE SHIFT MOTOR WAS REPLACED AND THE VEHICLE WAS RETURNED. THE OLD PART IS AVAILABLE. ON NOVEMBER 2ND, FOLLOWING A COLD START, THE VEHICLE WAS SHIFTED FROM PARK INTO DRIVE WITH THE 4X4 MODE SELECTION SWITCH SET TO 2WD MODE. AFTER DRIVING A DISTANCE LESS THAN 1 MILE AT A VEHICLE SPEED OF APPROXIMATELY 20MPH, A REPETITIVE CLICKING NOISE WAS OBSERVED FROM UNDER THE PASSENGER'S SIDE DASH. WHILE THE VEHICLE WAS IN MOTION AN UNCOMMANDED SHIFT TO 4X4 LOW MODE OCCURRED. AFTER COMING TO A STOP IT WAS DISCOVERED THAT IT WAS IMPOSSIBLE TO SWITCH OUT OF 4X4 LOW MODE. THE VEHICLE WAS DRIVEN TO THE DEALERSHIP IN 4X4 LOW MODE. THE MOST RECENT REPAIR PRIOR TO THIS ISSUE WAS RELATED TO A FORD RECALL INVOLVING THE SPEED CONTROL SYSTEM. *TR

01 FORD EXPLORER AUTOMATIC TRANS. I HAVE A PROBLEM WITH MY REAR END LIKE MANY OTHER PEOPLE DO. IT WHINES VERY LOUD AND ONLY HAS 80K MILES ON IT. MY MECHANIC SAID THAT IT COULD LOCK UP ANY MINUTE WHILE DRIVING. I CANNOT AFFORD THE REPAIR AS I AM A FULLTIME COLLEGE STUDENT. THERE ARE THOUSANDS OF PEOPLE WITH THE SAME PROBLEM FORD NEEDS TO BE ADDRESSED BEFORE ANYBODY DIES. *TR

AFTER COMING TO A COMPLETE STOP IN A LOCAL NEIGHBORHOOD ATTEMPTED TO SHIFT THE VEHICLE INTO PARK AS MY WIFE EXITED THE VEHICLE. THE SHIFT LEVER BROKE INSIDE THE STEERING COLUMN WITH THE TRANSMISSION IN REVERSE. I WAS ABLE TO MANUALLY SHIFT THE LINKAGE ON THE SIDE OF THE TRANSMISSION USING A PAIR OF PLIERS WHILE THE EMERGENCY BRAKE WAS SET, AND MY WIFE APPLIED THE BRAKES. THE VEHICLE WAS THEN DRIVEN TO THE LOCAL FORD DEALER, WHERE I WAS INFORMED THAT THE ENTIRE STEERING COLUMN WOULD NEED TO BE REPLACED AT A COST OF $1200.00. THIS VEHICLE WAS BOUGHT NEW IN 2001 AND HAS ONLY 58,000 MILES. IT HAS NOT BEEN ABUSED IN ANY MANNER. THERE WAS NO WARNING WHATSOEVER THAT THERE WAS ANY TYPE OF A PROBLEM. SURELY, THIS WAS A MANUFACTURING DEFECT THAT FORD WILL PROBABLY DENY.*AK

MY 2001 FORD EXPLORER SPORT TRAC HAS BEEN IDLING ROUGH AND DOES NOT SEEM TO SHIFT GEARS PROPERLY. WHILE DRIVING, THE OVERDRIVE LIGHT WILL RANDOMLY COME ON AND FLASH. ONCE THE OVERDRIVE LIGHT COMES ON, THE VEHICLE IS VERY SLUGGISH AND DOES NOT DRIVE PROPERLY AFTER THAT. I TOOK THE VEHICLE IN FOR SERVICE TO A LOCAL MECHANIC. THE MECHANIC TOLD ME THAT THERE HAS BEEN A RECALL OF SOME OF THE EXPLORER SPORT TRAC'S BY FORD AND TO CONTACT A DEALER FOR THE REPAIR. WHEN I CONTACTED THE DEALER, THEY TOLD ME THAT MY TRUCK WAS NOT COVERED UNDER THE RECALL BASED ON THE VIN NUMBER I PROVIDED THEM. EVEN THOUGH MY TRUCK IS OF THE SAME MAKE AND MODEL AND EXPERIENCING THE SAME PROBLEMS AS OTHER FORD EXPLORER SPORT TRACS. *JB

3RD GEAR TRANSMISSION PROBLEM WHICH CAUSES VEHICLE TO SHIFT ERRATICALLY. *JB

TRANSMISSION FAILURE WITH CONTINUOUS MAINTENANCE AND ONLY 66000 MILES. *NM

TRANSMISSION PROBLEMS STARTED IN EARLY 50,000 MILES RANGE. LONG LAG BETWEEN SHIFTING FROM 2ND TO 3RD WITH INCREASED RPM'S OF ENGINE. INTERMITTENTLY CAUSES OVERDRIVE LIGHT TO START BLINKING. DEALER NOR AAMCO COULD DETERMINE CAUSE. *NM

TRANSMISSION FAILURE. I HAVE A 2001 FORD EXPLORER SPORT 2WD. AT 109000 MILES ONE DAY I WAS DRIVING IT ON THE FREEWAY, AND I NOTICED THAT THE O/D LIGHT IS FLASHING. I TRIED TO TURN IT OFF, BUT IT WOULDN'T. I EXITED FROM THE FREEWAY AN I PARKED THE CAR AT THE NEARBY GAS STATION TRYING T O FIND OUT WHAT WAS THE PROBLEM. I TURNED THE ENGINE OFF FOR A FEW MINUTES,AND THEN I TURNED IT BACK ON,AND THE O/D LIGHT WENT OFF. I THOUGHT IT WAS FINISHED, BUT IT WASN'T. I STARTED DRIVING FOR ABOUT 10 MINUTES THE O/D LIGHT CAME BACK ON, AND THE TRANSMISSION SHIFTS HARDLY FROM ONE GEAR TO ANOTHER. THE NEXT DAY I TOOK THE CAR TO THE TRANSMISSION SHOP TO CHECK WHAT IS GOING WRONG. FROM MY HOUSE TO THE SHOP ABOUT 25 MINUTES DRIVE, THE O/D LIGHT STARTED FLASHING. AT THE TRANSMISSION SHOP THEY PULLED THE CODE (P0....) , AND THE INSPECTOR SAID THERE A MALFUNCTION INSIDE OF THE TRANSMISSION, SOMETHING RELATED TO THE TORQUE CONVERTER. TO FIX IT THEY GIVE ME AN ESTIMATE OF $2500 . AND I M NOT CURRENTLY UNDER WARRANTY. I'VE BEEN MAINTAINING THIS CAR AS MUCH AS I CAN. BUT IT IS SHOCKING TO SEE THE TRANSMISSION GOING AT THIS MILEAGE. FORD MUST RECALL THIS ISSUE. IF NOT THEY SHOULD TAKE CAR OF THE REPAIR COST. THIS IS REALLY A SHAME! MY CAR HAS BEEN REPAIRED YET, BECAUSE I CAN'T AFFORD THE COST OF THAT REPAIR. I'M HOPING THAT FORD WILL LOOK AT THE CASE. *JB

I HAVE A 2001 FORD EXPLORER SPORT, WHICH I WAS TOLD USES THE SAME FAULTY TRANSMISSION AS THE 2002 EXPLORER. LIKE MANY THE O/D LIGHT STARTED FLASHING AND NOW THE ESTIMATE IS AROUND $3000 FOR THE DEALER TO INSTALL A TRANSMISSION. ONLY HAVE 76,000 MILES. FORD KNOWS ABOUT THE PROBLEM AS THEY HAVE VARIOUS TECH BULLETINS. THEY ARE JUST TRYING TO AVOID THE COST OF A RECALL. THIS IS THE SECOND FORD I HAD FAIL AROUND THIS MILEAGE WITH TRANSMISSION PROBLEMS. THE DEALER COULD CARE LESS I NEVER THOUGHT I WOULD SAY THIS BUT I WILL NEVER BUY A FORD AGAIN! THEY NEED TO DO WHAT'S RIGHT HERE, DO A SEARCH ONLINE AND YOU WONT BELIEVE HOW MANY PEOPLE HAVE EXACTLY THE SAME ISSUE! *NM

MY 2001 FORD EXPLORER SPORT 4X4 MAKES A LOUD WHINING NOISE TOOK IT TO A TRANSMISSION SHOP. INFORMED ME THAT THEY WOULD HAVE TO PROBABLY HAVE TO REPLACE THE DRIVE SHAFT ESTIMATED COST WOULD BE AT LEAST 2000$ I HAVE ALWAYS BABIED MY FORD. HOW IN THE WORD COULD A DRIVE SHAFT GO BAD? I HAVE HAD CARS THAT WERE 15 YEARS OLD AND OVER 200,000 MILES ON THEM NEVER A PROBLEM. *JB

2002 2WD EXPLORER SPORT: PLEASE RELEASE TO FORD: HERE'S YOUR TECHNICAL SERVICE NOTICE: 03-25-4 DEC 03 A/T - 5R55W NO 3RD GEAR/SLIPPING 2-3 SHIFT/DTC'S SET MY TRANSMISSION DIED AT 65,000 MILES. EVERYONE WITH A FORD EXPLORER HAS ISSUES WITH THE TRANSMISSION SOMEWHERE BETWEEN 50-65,000 MILES WITH THE PROBLEM NOTED IN YOUR TSB ABOVE. REFUND MY SERVICE DEDUCTIBLE FOR A KNOWN FAILURE WITH YOUR BROKEN TRANSMISSION. *NM

DT*: THE CONTACT STATED WHEN THE VEHICLE WAS TRANSITIONING BETWEEN 1ST AND 2ND GEAR, THE VEHICLE SEEMED AS IF IT WAS IN NEUTRAL UNTIL THE ACCELERATOR PEDAL WAS RELEASED. WHEN THE VEHICLE WAS TAKEN TO THE DEALER, THEY DETERMINED THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED.

DT*: THE CONTACT STATED THE VEHICLE IS EQUIPPED WITH A BUTTON TO PUSH TO PLACE THE VEHICLE INTO OVERDRIVE. HOWEVER, IT GOES INTO OVERDRIVE ON ITS OWN CAUSING THE VEHICLE TO JERK BADLY. IT IS AN INTERMITTENT PROBLEM THAT OCCURS DURING COLD WEATHER. TO DISENGAGE THE OVERDRIVE, THE VEHICLE MUST BE TURNED OFF AND RESTARTED. THE DEALERSHIP WAS CONSULTED. DURING COLD WEATHER WHEN THE VEHICLE IS IN OVERDRIVE IT GOES OUT OF OVERDRIVE AND JERKS. THE VEHICLE, SPEED AND RPMS DROP, AND OVERDRIVE OFF LIGHT FLASHES. CONTACT HAD TO PULL OFF THE ROADWAY AND TURN VEHICLE OFF AND RESTART FOR VEHICLE TO START INOVERDRIVE AS NORMAL. CONTACT CAME CLOSE TO BEING REAR ENDED. THE VEHICLE WOULD REMAIN IN OVERDRIVE UNLESS THE CONTACT CLICKED BUTTON ON SHIFT COLUMN TO TAKE IT OUT OF OVERDRIVE OR IF IN OVERDRIVE TO RESUME BACK TO OVERDRIVE. TOOK VEHICLE TO DEALER, WHO CLAIMED THERE WAS NO RECALL, BUT DID ADVISE HAD SIMILAR PROBLEMS WITH OTHER CONSUMERS. CONTACTED FORD MOTOR COMPANY, AND WAS TOLD THERE WA SNO RECALL AND COULD NOT DO ANYTHING. *AK

2001 FORD EXPLORER SPORT TRAC - 4X2 MANUAL 18 OCT 2002 - VEHICLE STOPPED SHIFTING INTO GEAR CLUTCH FLUID RESERVOIR EMPTY - DEALER REPLACED CLUTCH MASTER CYLINDER ASSEMBLY. 02 NOV 2002 -VEHICLE STOPPED SHIFTING INTO GEAR CLUTCH FLUID RESERVOIR EMPTY - DEALER REPLACED CLUTCH SLAVE CYLINDER ASSEMBLY 11 JUN 2003-VEHICLE STOPPED SHIFTING INTO GEAR CLUTCH FLUID RESERVOIR EMPTY - DEALER REPLACED CLUTCH MASTER CYLINDER ASSEMBLY I BELIEVE IT ALSO OCCURRED IN 2004 BUT NO RECORD OF WORK PERFORMED. 26 DEC 2005-VEHICLE STOPPED SHIFTING INTO GEAR CLUTCH FLUID RESERVOIR EMPTY - DEALER REPLACED CLUTCH MASTER & SLAVE CYLINDER ASSEMBLY 29 DEC 2005 - VEHICLE STOPPED SHIFTING INTO GEAR REWORK FROM LAST REPAIR - AIR IN CLUTCH FLUID LINE. ALTHOUGH NO ACCIDENT OCCURRED, THE FAILURES PRESENT A VERY DANGEROUS SITUATION, PARTICULARLY WHEN TRYING TO ACCELERATE; MERGING INTO TRAFFIC, ENTERING INTERSTATE, ETC FORD IS AWARE OF THIS DANGEROUS SITUATION AND HAS NOT ADDRESSED IT ADEQUATELY. THERE ARE CURRENTLY FOUR TECHNICAL SERVICE BULLETINS (TSBS) ISSUED BY FORD RELATED TO THIS COMPLAINT. *JB

2001 FORD EXPLORER TRANSMISSION PROBLEM. TRANSMISSION SLIPPING WHEN SHIFTING BETWEEN 2ND AND 3RD. FORD UNWILLING TO ADMIT FAULT AND REPAIR PROBLEM. MANY OTHER VEHICLE OWNERS WITH SAME PROBLEM NOT CORRECTED YET. *JB

AT AROUND 55000 MILES I HAD TO REPLACE MY REAR AXLE AND I AM NOW AT 62000 AND MY O/D WILL START FLASHING AND MY 2001 EXPLORER WILL SHIFT HARD OR NOT SHIFT AT ALL. *NM

2001 FORD EXPLORER SPORT 4X4 HAS 2-3 SHIFT FAILURE CAUSING CAR ENGINE RPM TO RISE SEVERELY WITHOUT SHIFTING TRANSMISSION INTO 3RD GEAR. THIS FIRST HAPPENED WHILE GETTING ON THE HIGHWAY LEAVING ME HOPELESSLY IN THE RIGHT LANE AS TRAFFIC RAPIDLY APPROACHED FROM BEHIND, I WAS FORTUNATE TO BE ABLE TO GET ONTO THE SHOULDER. I HAVE COME TO FIND OUT TODAY THAT THIS HAS BEEN AND CONTINUES TO BE A WELL KNOWN PROBLEM BY FORD FOR YEARS WHICH HAS YET TO BE ADDRESSED! THERE IS EVEN A TECH SERVICE BULLETIN FOR THIS PROBLEM! BESIDES RIPPING OFF CONSUMERS FOR OUTRAGES RECURRING REPAIR COSTS, THIS IS A REAL SAFETY ISSUE. IS IT GOING TO TAKE SOMEONE GETTING SEVERELY HURT BEFORE SOMETHING IS DONE. *NM

DT: THE CONTACT OWNED A 2001 FORD EXPLORER SPORT. TRANSMISSION MALFUNCTION CAUSING THE THIRD GEAR TO SLIP. THIS HAPPENED FOR A DAY. THE VEHICLE WAS TAKEN TO A TRANSMISSION PLACE, IT BLEW A CODE AND THEY SAID IT WAS AN INTERNAL TRANSMISSION PROBLEM. THE OVERDRIVE INDICATOR STARTED FLASHING. AS SOON AS THAT LIGHT STARTED TO FLASH THE TRANSMISSION STARTED ACTING UP. *AK

OVERDRIVE TURNS OFF - FORD HAS ISSUED TECHNICAL SERVICE BULLETIN ((TSB) 03-22-10 IN OBVIOUS RECOGNITION OF NUMEROUS PROBLEMS ,BUT REFUSED TO PAY FOR THE REPAIRS. *AK

SPORT TRACK HAS 76,000 MILES AND SUDDENLY STARTED MAKING A ROARING SOUND IN THE REAR WHICH GETS LOUDER AS SPEED INCREASES. IT WAS LOOKED AT BY TWO COMPANIES, BOTH OF WHICH DIAGNOSED IT AS A REAR AXLE PROBLEM-POSSIBLY A DIFFERENTIAL BREAKAGE. THERE ARE SLITHERS OF METAL ON SOME OF THE AXLE PARTS. WHEN LUBRICATION WAS CHECKED FOAMING WAS DETECTED. I DON'T HAVE A CLUE WHAT THIS MEANS---BUT I WAS REFERRED TO THE DEALER OR FORD AS IT WAS TOO BIG A JOB FOR THE REPAIR SHOP. I WAS TOLD TO EXPECT A COSTLY REPAIR BILL! WE HAVE NOT TAKEN LONG TRIPS, HAULED/PULLED ANYTHING. I'VE FILED A COMPLAINT WITH FORD REGARDING THIS.*AK

MY 2001 FORD SPORT TRAC TRANSMISSION WARNING LIGHT CAME ON. AFTER TAKING IT TO DEALER I WAS INFORMED THAT I NEED A NEW TRANSMISSION. WITH ONLY 56,000 ON TRUNK. SINCE ITS OUT OF WARRANTY I WILL HAVE TO FOOT THE BILL OF $3600. THERE ARE THOUSANDS OF OTHER SPORT TRAC OWNERS GETTING STUCK WITH BAD TRANSMISSIONS. PLEASE MAKE FORD FIX THERE BAD TRANSMISSIONS. *JB

I HAVE A 2001 EXPLORER SPORT. IN LOWER SPEEDS, MY TRANSMISSION WOULD START MISSING. FORD AND ANOTHER REPAIR CENTER BOTH IDENTIFIED THE PROBLEM AS A DEFECTIVE MAIN BODY REPLACEMENT VALVE. THE REPAIR CENTER TOLD ME THERE IS A SERVICE BULLETIN IDENTIFYING THIS PROBLEM (ARTICLE #02-13-8). HOWEVER, THERE IS NOT AN OFFICIAL RECALL. FORD SAID I WOULD HAVE TO PAY FOR THE COMPLETE REPAIR. *JB

2001 EXPLORER SPORT REVERSE NOT ENGAGING, SLIPPING TRANSMISSION, O/D LIGHT FLASHING. TRANSMISSION NOT SHIFTING OR ACCELERATING CORRECTLY, RPMS SHOOT UP BUT NO ACCELERATION. TRIED TO ACCELERATE TO AVOID AN ACCIDENT BUT HAD NO ACCELERATION. LUCKILY STEERED OUT OF IT. FORD DOES NOT WANT TO ADMIT KNOWLEDGE AND WANTS ME TO PAY FOR IT.

MY 2001 SPORT TRAC 2WD TRANSMISSION HAD TO BE REBUILT BECAUSE OF DEFECTIVE VALVE BODY GASKETS. THE TRUCK WAS TO THE POINT THAT WHEN I PULLED OUT INTO TRAFFIC THE 2ND - 3RD SHIFT WAS SO DELAYED THAT YOU HAD TO REMOVE YOUR FOOT FROM THE GAS PEDAL TO LET THE TRUCK SHIFT. THIS COULD BE A SAFETY ISSUE IF YOU REALLY NEED TO ACCELERATE FAST TO GET OUT OF THE WAY. THIS TRUCK HAS BEEN PAMPERED AND ALL TRANS SERVICE WAS TAKEN CARE OF ON SCHED. I HAVE NEVER HAD ANY PROBLEMS WITH A FORD TRANS, BUT I REALLY THINK SOMEBODY DROPPED THE BALL ON THIS ONE. REMEMBER THAT MOTO, QUALITY IS JOB 1. THE REBUILD COST $1500. AND I DO HAVE THE OLD BANDS, AND CLUTCH PACK, WHICH IS WORN BADLY. *JB

TRAVELING IN THE SLOW LANE AND WENT TO PASS ANOTHER VEHICLE WHEN PRESSING ON THE GAS THE RPM JUST RACED BUT THE TRUCK DID NOT? TURNS OUT WITH ONLY 70,000 CAREFULLY AND PAMPERED MILES I NEED A NEW TRANSMISSION. HOW IS THIS POSSIBLE WITH ALL PROPER SERVICES AT SUGESTED MILAGE? $2000 IS A BIG EXPENSE AT SUCH LOW MILAGE- WARANTY OUT AT 60,000 SO FORD TOLD ME IM OUT OF LUCK- THEY DID NOT TAKE ANY BLAME IN FAULTY PARTS OR ENGINEERING! FORD HAS A VERY BAD REPUTATION AND NOW I KNOW WHY. *AK

ME AND MY FAMILY HAVE BEEN LONG TIME FORD CUSTOMERS. I MYSELF HAVE OWNED 3 FORDS AND MANY OTHERS IN MY FAMILY HAVE HAD SEVERAL FORD VEHICLES. MY GRANDFATHER WAS A LONG TIME FORD SALESMAN IN BUNKIE, LA. I CURRENTLY OWN A 2001 FORD EXPLORER SPORT TRAC WITH 46000 MILES. I RECENTLY EXPERIENCED TRANSMISSION PROBLEMS WITH THE 2 TO 3 GEAR SHIFT SLIPPING. WELL TO MAKE A LONG STORY SHORT I HAD TO GET A TRANSMISSION OVERHAUL TO THE TUNE OF $1,800. THIS VEHICLE ONLY HAS 46000 MILES AND HAS DONE VERY LITTLE LIGHT TOWING AND NO OFF ROADING ETC. I HAVE ALWAYS LOVED FORD QUALITY, BUT IT SEEMS HAS DROPPED THE BALL ON THIS TRANSMISSION. THERE ARE TECHNICAL SERVICE BULLETINS OUT ON THIS TRANNY AND I HAVE RESEARCHED AND DISCOVERED MANY OTHERS THAT HAVE THE SAME PROBLEM. IT SEEMS FORD KNOWS THIS IS A PROBLEM, AND I THINK THEY SHOULD DO SOMETHING ABOUT BEFORE THEY LOSE ANOTHER LONG TIME CUSTOMER LIKE MYSELF. NEEDLESS TO SAY I WILL BE PURCHASING A NEW CAR SOON, BUT PLAN TO TAKE MY BUSINESS TO OTHER BRANDS DEALERSHIPS. *JB

WHILE DRIVING AT APPROXIMATELY 55 MPH, THE VEHICLE VIBRATED AND HAD A BUMPY RIDE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHERE THE MECHANIC REPLACED THE DIFFERENTIAL AFTER HAVING THE VEHICLE FOR OVER A MONTH. *AK THE RIGHT FRONT AXLE WAS REPLACED. *SC *JB

WHILE APPLYING THE ACCELERATOR PEDAL VEHICLE SHOOK. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE ,AND DROVE IT TO DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT AXLE SHAFT NEEDED TO BE REPLACED. *AK

2001 EXPLORER SPORT-TRAC AUTOMATIC TRANSMISSION WENT BAD AT 49,600 MILES. TRANSMISSION MECHANIC SAID THAT THE 4R55E AND 5R55E TRANSMISSIONS ARE NOTORIOUS FOR HAVING FAULTY VALVE BODIES WHICH CAUSES THE CLUTCHES TO BURN UP. MY TRUCK HAS ALWAYS BEEN MAINTAINED PROPERLY. NEVER RACED OR TOWED HEAVY LOADS. JUST A DAILY COMMUTER VEHICLE. THERE IS NO REASON THIS TRANSMISSION SHOULD HAVE FAILED THIS EARLY.*AK

2001 FORD SPORT TRAC TRANSMISSION ELECTRONICS FAILED AT 45,000 MILES CAUSING ENTIRE TRANSMISSION REBUILD TO BE NECESSARY. FORD CUSTOMER SERVICE EXTREMELY UNHELPFUL, NOTHING THEY WOULD DO AND ALSO WOULD NOT PROVIDE SUPERVISOR TO SPEAK TO. *JB

TRANSMISSION FAILURE- NO WARNING-

SOME HOW WATER GOT IN THE REAR DIFFERENTIAL AND DAMAGED THE REAR OF THE VEHICLE. PLEASE PROVIDE FURTHER DETAILS. *PH *PH

FORD IS A COMPLETE RIP OFF AND SOLD ME A LEMON I WILL NEVER EVER BUY OR RECOMMEND A FORD IN MY LIFE ALL WE'VE HAD IS PROBLEMS... WE JUST BROUGHT OUR FORD EXPLORER TO MT. VERNON FORD IN NY AND THEY TOLD US THEY WILL CHECK OUT WHAT THE PROBLEM IS AND IF WE DECIDE FOR THEM NOT TO FIX IT THERE OUR CHARGE IS 85.00 DOLLARS AND IF WE FIX IT THERE THEY WILL PUT IT TOWARDS THE REPAIR AND TOLD US THE PROBLEM WE ARE HAVING IS FROM NOT MAINTAINING THE CAR HOW DARE THEY MAKE SUCH A STATEMENT I HAVE ALWAYS TAKEN CARE OF MY CARS I HAVE A NISSAN WITH 130,000 MILES I HAVEN'T EVEN CHANGED THE CLUTCH STILL ORIGINAL WELL WE DECIDED NOT TO HAVE THE REPAIRS DONE THERE AND WHEN WE GOT THERE THEY CHARGED UP OVER 130.00 DOLLARS I AM DISGUSTED AND I AM GOING TO REPORT FORD TO THE BBB AND EVERY COMPLAINT CENTER THAT I CAN... WE ONLY HAVE 50,000 MILES ON IT AND BEFORE 36,000 WE HAD TO PUT IN A NEW TRANSMISSION IT'S A LEMON A PIECE OF JUNK... WE'VE ALSO BROUGHT IT IN FOR THE PASSENGER SEAT BELT AND THEY STILL HAVEN'T FIXED IT AND I SWEAR TO GOD IF WE ARE INVOLVED IN AN ACCIDENT OR GET PULLED OVER BY THE POLICE SOMEONE IS GOING TO PAY FOR IT TRUST ME LAW SUIT AND ALL. *LA

THE TRANSMISSION ON THE 2001 SPORT TRAC WENT OUT, IT ONLY HAD 42,000 MILES ON IT. IT WAS ONE MONTH OVER THE 3 YEARS. THE CAR WAS SERVICE EVERY 3 THOUSAND MILES FOR OIL CHANGE, 31,000 THOUSAND FOR TRANSMISSION SERVICE. I TOOK MY RECEIPT INTO THE FORD AUTO IN ST. PETERSBURG. I AM NOT HAPPY TO HAVE THIS HAPPEN I DID EVERYTHING TO KEEP MY CAR IN TOP SHAPE. IT WAS NOT NEGLECTED IN ANY WAY. FORD AUTO SAID THEIR WAS NOT A THING THEY COULD DO. WHY NOT ? WHERE I HAD THE TRANSMISSION FIXED, BECAUSE IT WAS ON A WEEKEND WHEN IT WENT OUT, TOLD ME HE HAS HAD A LOT ON THE EXPLORER IN WITH THE SAME PROBLEM ONE OF THEM WAS AS LOW AS 37,000 MILES. THIS SEEMS TO BE A PROBLEM, YOU SHOULD EITHER FIX IT OR PAY TO HAVE THEM FIX. *LA

VECHILE HAS 16,000 MILES. THREE TIMES AFTER STARTING VEHICLE AND DRIVING TWO BLOCKS OVERDRIVE INDICATOR FLASHES BY ITSELF. THEN TRANSMISSION OVER REVS AND DOES NOT SHIFT PROPERLY. OWNERS MANUAL SAYS THAT HWEN OVERDRIVE KIGHT FLASHES TO CALL DEALER AND ARRANGE FOR SERVICE, AS THERE IS PROBLEM WITH TRANSMISSION. BROUGHT TO DEALER TWICE, AS THEY COULD NOT RE-ENACT PROBLEM, THEY RETURNED VECHILE TO US SAYING NOTHING WRONG WITH VECHILE. I HAVE CALLED FORD CORPORATE CUSTOMER SERVICE WHO CONTACTED DEALER, BURNS FORD. THEY NOW SAY TO TAKE IT TO ANOTHER DEALERSHIP FOR SERVICE. I AM AFRAID TO DRIVE THIS VEHICLE. *AK

PROBLEMS INVOLVING 2001 FORD EXPLORER. *MR (THE LETTER WAS WRITTEN IN SPANISH) THERE WAS A PROBLEM WITH THE FRONT DIFFERENTIAL. *SCC *JB

TRANSMISSION LEAKS WHILE DRIVING OR PARKING. DEALER NOTIFIED.*AK

I HAVE A 2000 FORD EXPLORER SPORT. MY 5 SPEED AUTOMATIC TRANSMISSION SLIPS WHILE SHIFTING FROM 2ND TO 3RD GEAR. MY VEHICLE HAS ONLY 55,000 MILES ON IT AND FROM THE NEW GROUPS I'VE BEEN FOLLOWING, I'M NOT ALONE. I UNDERSTAND THAT FORD HAS REDESIGNED THE VALVE BODY AND IS REFUSING TO REPLACE DEFECTIVE UNITS FREE OF CHARGE. *NLM

AT 31,059 MILES, THE VEHICLE HESITATED AT ACCELERATION AND LOSS POWER, ESPECIALLY AT SECOND GEAR. AT 42,000 THE CAR WAS BROUGHT BACK TO THE DEALERSHIP BECAUSE OF SAME PROBLEMS THAT EXPERIENCED AT 31,059 MILES. DEALERSHIP REPLACED THE D.P.F.E SENSOR. *TT

THE VEHICLE TRANSMISSION JUMPED INTO REVERSE, KNOCKED THE CONSUMER DOWN AND ROLLED OVER HIS LEG. *NLM

2001 V8 EXPLORER 36500 MILES, MY TRANSMISSON STARTED SLIPPING ALL OVER THE PLACE, LUCKILY I GOT THE EXTENDED WARRENTY. BUT THERE IS NO REASON FOR SUCH A YOUNG TRANSMISSION TO GO BAD

DURING THE MANUFACTURE OF THE REAR END BY FORD THEY PACK THE INAPPROPRIATE AMOUNT OF GREASE IN THE DIFFERENTIAL (WHEATHER TOO SMALL OR TOO MUCH) WHICH CAUSES THE BEARINGS TO RUB AND WEAR OUT QUICKLEY. IF THE PROBLEM IS NOT TAKEN CARE OF IT CAN RESULT IN A LOCKING OF THE REAR END THUS HENCE THE LIKELY HOOD OF ACCIDENT POTENTIAL. JUST IMAGINE OUR CHILDREN BEING AFFECTED. FORD REFUSES TO CAUSE THIS PROBLEM EVEN WHEN IT IS VERY CLEAR OF LIABLITY. THE DEALERS REFUSE TO FIX THE ISSUE WITHOUT A CHARGE AND UNWARRENTED EXTRA WORK AND CHARGE. DT

ENGINE TEMPERATURE GAUGE READING HOT WHEN VEHICLE IS NOT OVERHEATING. CHECK GAUGES TROUBLE LIGHT COMES ON. DEALER REPLACED BUT STILL MALFUNCTIONING TRANSMISSION SHIFTING HARD. VEHICLE WILL JERK/CLUNK EVERY TIME TRANMISSION SHIFTS. DEALER FLUSHED TRANSMISSION AND REPLACE FLUID. NO CHANGE IN TRANSMISSION FUNCTION. VEHCILE VIBRATES/SHAKES AT HIGHER SPEEDS. MAY BE THE DRIVESHAFT. DEALER ROTATED TIRES. VIRBRATION STILL EXISTS. REAR SEAT BOTTOMS DO NOT ANCHOR SECURELY. THE SEAT BOTTOMS FLIP UP WHEN EXITING THE VEHICLE. THE REAR WINDOW WIPER WAS NOT CLEARING THE COVERED AREA, LEAVING DIRT AND DEBRIS ON THE WINDOW OBSTRUCTING THE VIEW. DEALER ADJUSTED ARM PROBLEM IS RESOLVED. DT

CONSUMER STATED THAT THE VEHICLE ROLLS FORWARD WHEN PUT IN PARK. *YH

THE DEALERSHIP HAS BEEN GREAT. THE ORIGINAL TRANSMISSION WAS DEFECTIVE, THE SECOND TRANSMISSION WAS DEFECTIVE AND ALL OF THE FLUID WAS PUSHED OUT THE THIRD TRANSMISSION HAS BEEN MAKING SQUEAKING SOUNDS THAT CANNOT BE LOCATED.*AK

ON TWO SEPARATE OCCASIONS VEHICLE INADVERTENTLY JUMPED OUT OF FOUR WHEEL HIGH TO FOUR WHEEL LOW AND CAUSED LOSS OF CONTROL. THIS LED TO A ROLLOVER ACCIDENT. VEHICLE AT THE DEALER, CONSUMER SUFFERED INJURIES. *AK *YH

WHEN SHIFTING TO DRIVE WHILE AT A SLIGHT INCLINE VEHICLE WILL ROLL BACK UNTIL APPLYING BRAKE. VEHICLE TAKEN TO DEALER 5 TIMES, CANNOT REMEDY PROBLEM. *AK

THE REAR PINION BEARING FAILED. NLM

THE REAR PINION BEARING FAILED. NLM

PUTTING SUV IN PARK WHEN THE GEAR SHIFT INDICATOR BROKE AND RELOCATED TO THE 1ST GEAR POSITION. NOW STUCK ON 1ST GEAR AND THERE IS NO VISUAL WAY OF KNOWING WHAT GEAR THE SUV IS IN. FORD IS COVERING THE DEFECT THROUGH WARRANTY, BUT THIS IS A REAL SAFETY ISSUE. REPAIRS BEING PERFORMED AT ORR PERFORMANCE IN ATLANTA, TEXAS.*AK

CONSUMER STATES WHILE SHE WAS PUTTING ITEM IN HER VEHICLE, HER TWO YEAR OLD SON CRAWLED UP TO THE FRONT OF VEHICLE AND TURNED THE KEY TO THE SECOND TURN OF THE GEAR SHIFTER AND PULLED THE TRUCK INTO GEAR, THE SECOND TURN ON THE GEAR SHIFTER IS THE ONLY WAY THAT THE VEHICLE CAN BE PUT INTO GEAR WITHOUT APPLYING THE BRAKE, THE VEHICLE HIT ANOTHER VEHICLE, CONSUMER CONTACTED MANUFACTURER AND WAS TOLD THAT ALL OF THE VEHICLES ARE DESIGNED THE SAME WAY. *JB

VEHICLE WAS RUNNING, LEFT IN PARK, AND GEAR SLIPPED/VEHICLE ROLLED DOWN HILL. RESULTING IN $12000 DAMAGE. CONSUMER WAS NOT IN VEHICLE AT THE TIME. EMERGENCY BRAKE NOT USED. *AK THE VEHICLE WAS UNSAFE DUE TO UNKOWN DEFECTS. THE EXACT CAUSE OF THE ROLL OVER INCIDENT WAS NOT DETERMINED. *YH

CONSUMER STATES A STRANGE NOISE IS MADE WHEN PRESSING ON THE ACCELERATOR, DEALER STATED THE PROBLEM WAS THE FRONT AXLE AND THAT THERE WERE SCRAPS OF METAL BREAKING OFF THE AXLE, CONSUMER IS REQUESTING A NEW VEHICLE AND STATES THAT THE SCRAPS OF METAL COULD BE DAMAGING OTHER PARTS OF THE VEHICLE. *SLC

WHILE DRIVING 75MPH A LOUD BOOM NOISE WAS SUDDENLY HEARD. VEHICLE WAS THUMPING AND VIBRATING. STEERING WAS VERY SHAKY. MANAGED TO GET OFF HIGHWAY, AND STOPPED VEHICLE TO CHECK. THERE WASN'T ANY PROBLEM WITH TIRES BLOWING OUT. LIMPED INTO ROAD SERVICE. MECHANIC INFORMED OWNER THE C V JOINTS ATTACHED TO TRANSMISSION TRANSFER CASE HAD BLOWN. FRONT DRIVELINE WAS REMOVED & REPLACED, BUT VIBRATIONS STILL APPEARED. CONTACTED MANUFACTURER, AND INFORMED VEHICLE WAS A LEMON.*AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

TRUCK SEEMS TO SHUDDER OR SHAKE WHEN PUT IN REVERSE OR FROM NEUTRAL TO DRIVE. *CJ

WHEN GOING DOWN A STEEP GRADE NEITHER "DRIVE 1" OR "DRIVE 2" ENGAGED & DID NOT SLOW THE VEHICLE. NEITHER LOW GEARS WORKED WHEN THE VEHICLE WAS IN MOTION OR WHEN STARTED FROM A COMPLETE STOP. THE GAS GUAGE WILL START SHOWING 1/4 TANK OF GAS WHEN THERE IS AT LEAST 3/4 FULL TANK. THIS IS ACCOMPANIED BY A BURNING SMELL COMING FROM THE FRONT OF THE VEHICLE. WHEN THE VEHICLE IS STOPPED & RESTARTED THE GAS GUAGE OFTEN RETURNS TO THE PROPER LEVEL OF GAS IN THE TANK.