2008 Toyota Highlander Brakes Problems

Your brake actuator and booster pump failed, causing your brakes to become weak and unsafe. Warning lights for ABS, brakes, and vehicle stability control appeared, and diagnostic codes C1252, C1256, and C1391 confirmed the problem. A previous repair at a local shop didn't last, and the issue requires Toyota dealer service due to software requirements, making it expensive to fix properly.

Your brake actuator has failed, which means your car's automatic braking system isn't working properly. You'll need to apply much more force to the brake pedal to stop your vehicle, and it will take longer to come to a complete stop. The brake actuator will need to be replaced, which Toyota estimates at $3,145.

While driving at 40 mph and approaching a turn, your brakes felt spongy and didn't slow the car quickly enough. A yellow warning light and long beep appeared on your dashboard. A shop diagnosed the problem as a faulty brake booster pump and actuator assembly, which Toyota has recalled for your vehicle's year and model — though your car wasn't included in that recall. Fixing this will require replacing the brake booster pump and actuator assembly.

Your brake pedal lost all resistance and sank to the floor while driving, and your ABS warning lights came on simultaneously. You were able to safely pull over, but the car was not driveable. A repair shop determined that your brake actuator assembly and ABS skid module had failed and required replacement.

Your 2008 Highlander Hybrid's ABS actuator and brake booster assembly have failed, causing your ABS, VSC, brake warning, and parking brake lights to illuminate. Toyota issued a limited Customer Support Program in 2019 that covers repairs only until December 31, 2020 (primary coverage), which has already expired, leaving you responsible for the full repair cost of approximately $3,000 or more. The repair will require replacement of the brake actuator assembly and brake booster pump assembly.

Your brake system is malfunctioning and your vehicle's information center is warning you to take the car to the dealership immediately. Your brakes could potentially fail, and multiple warning lights are appearing on your dashboard. This is the same issue that was previously recalled and repaired on your vehicle, but it's happening again.

Your ABS (anti-lock brake system) has malfunctioned multiple times even after Toyota replaced it under a recall in 2019 and again in 2022. The same diagnostic code (C1391) is now appearing again as of October 2024, causing your brake system, ABS, and master warning lights to illuminate. Toyota has confirmed the issue but cannot explain why the replacement parts failed so quickly, which creates a potential safety concern with your braking system. The fix will likely involve Toyota replacing the brake actuator and accumulator components again.

Your Highlander's brakes are experiencing a problem that Toyota had a recall program for between 2008-2010, with a deadline that passed in 2020. You're now having the same issue, which your Toyota dealer confirmed is the same defect, but they're charging you over $3,000 to fix it. Since Toyota acknowledged this was a faulty part and offered a free replacement program, you believe the deadline shouldn't have expired and you shouldn't have to pay for Toyota's manufacturing defect.

Your brake system is showing repeated warning messages for ABS, brakes, and traction control, along with dashboard warning lights that come and go over several months. A diagnostic scan revealed low pressure in the brake accumulator, which is the component that stores hydraulic pressure for your braking system. The issue may require inspection and possible replacement of the brake accumulator or related hydraulic components.

Your ABS (anti-lock brake) system has been making noise since you bought the vehicle in 2018, but in November 2023 multiple warning lights appeared on your dashboard including "Check VSC System," "BRAKE Malfunction," and "Check ABS." The warnings told you to pull over and shut off the vehicle, though your brake pedal felt normal. You're concerned that Toyota may have known about this issue and that repair costs are preventing you from getting it fixed.

Your brake system warning light came on, so you took your car to a Toyota dealer for diagnosis. The dealer recommended new brake pads, rotor adjustment, and five new tires for about $6,000, which you felt was too expensive. Your car has been sitting unused since then, and the 12V battery has died without being replaced.

I checked by local car repair shop found out failure code C1391. Mean- Brake Actuator Assembly fault. Recall program ended already by 2020. But is not my mistake, i every time on time change oil, tire, brake pads and do State inspection. this is Part defect from beginning some cars failing low mileage some failing after. This is whole part failure only by Toyota Hybrid vehicles. This repair only done by Toyota dealership because of Toyota software to install. Repair cost about 3500$ and i can't afford this repair cost i have 3 children 6years, 3years, 10 month old. Dangerous to drive with kids. Toyota USA already denied my request. Sincerly, [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

The contact owns a 2008 Toyota Highlander. The contact stated while driving at an undisclosed speed, the ABS and stabili-trak warning lights were illuminated. The vehicle was taken to an independent mechanic to be diagnosed. The mechanic retrieved DTC: C1391, indicating that the brake actuator assembly was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the Extended Program had expired, and the contact was advised to call the NHTSA Hotline for assistance. The failure mileage was approximately 180,000.

All the lights relating to brakes and ABS flashed up on the dashboard. We continued home slowly. Upon investigation from a trusted mechanic it seems it is the brake actuator. From numerous reviews and complaints online this is a reoccurring issue with Toyota cars but recalls were only issued for 2006-2007 models even though the 2008 Highlander hybrids use the same part.

Needed to have hub and bearing and spindles replaced in front driver's side wheel (AWD). Repair shop completed repairs and aligned the vehicle. Computer needed to be reset after alignment. Shop followed reset instructions and vehicle then showed codes for the ABS system (ABS pump and actuator and skid control module). Repair shop cannot reset computer without replacing parts estimated cost is over $5,600. No work on brakes or ABS system was done. No errors or codes previously existed prior to replacement of bearing and hub. No codes existed until after the alignment was completed. ABS system no longer works. Repair was completed at an independent repair shop. Have appointment with dealership on 9/29 to see if code can be reset. These codes were an issue in 06-07 Highlander hybrids and Prius models and part of a recall.

ABS warning light at 118,000 7/8/2022 C1391 This is a known recall and problem on the earlier model Highlanders, as well as the second generation Highlanders, but not recalled as of today 8/19/22. It is a flawed ABS design and safety hazzard.

Brake system failed in hybrid and issue is well documented. Current lawsuits however not including this make/model.

Chief complaint ISSUES were as follow : " BRAKE MALFUNCTION STOP The vehicle in a safe plase immediately and contact Dealer." Warning lights were illuminated on the instrument cluster or information display: yellow master warning light, the red brake system warning light and buzzer, yellow ABS warning light, yellow SLIP indicator light. After carefull diagnosis, it was determined that the brake booster pump was turning on frequently or working constantly. Unusual squeaky noise can be heard when depressing the brake pedal. In addition, the ABS Diagnostic Trouble Codes were identical as the problem. From research it should be noted. Toyota has previously identified and issued safety recall for the same vehicle however stopped short of including the 2008 Toyota Highlander hybrid model with the aforementioned Vin number.

When I started my 2008 Highlander Hybrid on Valentine’s Day and drove 3 car lengths from my drive way, my dash screen notified me with “Check ABS, Check Brake System, and Check VSC System” all with “Have your car checked by a dealer”. I reversed the car and returned to my driveway. My husband called a friend mechanic shop owner who ran the diagnostic report that showed a C1391code. I remembered I received a notification letter regarding this issue and called the dealer. Service agent indicated that without Toyota doing the diagnostic run on my vehicle, they could not give me any quote on the price, but notified me that the letter I received had expired on December 31, 2020 or 10 years or 150,000 miles. My Highlander had this alert screen notification at 144,000 miles. I was told I would be responsible for repair charges. Feeling very frustrated, I called the Toyota corporate number and spoke to a female who then connected me with a supervisor. I explained my experience and the representative explained the notification letter had expired and was unlike a recall, which was indefinite. I emphasized to him that since Toyota knew this was a problem, how could they put an expiration date on the failed Brake Booster Actuator Pump Assembly that they clearly knew was a brake problem. Furthermore, Toyota, which I have been a loyal owner of five vehicles, had only allowed one year + for their accountability to the fixing the brake assembly parts. This meant it was a luck of the draw depending on miles driven for the brake assembly to fail during the little more than a year notification period for Toyota to be responsible for replacing the parts. I find this to be very unfair and unjust. I voiced my opinion to the 800 number a second time, & was told that if the NHTSA had determined it a recall, no expiration date. As a senior citizen who is on a fixed income, I believe Toyota should fix all Brake Booster Actuator Pumps that fail and NHTSA should demand a recall.

The Brake Actuator Assembly and Brake Booster Pump Assembly have failed on my 2008 Toyota Highlander Hybrid. As I understand, this is a common problem for my vehicle and Toyota has agreed to fix it if the mileage is under 150,000 miles (which mine is) AND the time since first use is less than 10 years (which is not the case.) For this safety issue, I think Toyota should be standing behind the safety of their vehicles and fix my brake pump. This is putting my family at risk. This issue has been confirmed by my local independent auto service company. The warning lights came on after the failure (brake, ABS, master warning, traction control).

The ABS ACTUATOR failed in my 2008 Toyota Highlander Hybrid. The screen inside the car flashed ABS // VSC // CHECK BRAKE SYSTEM. Vehicle is at 144,000 miles The component is out of stock nationwide and Toyota dealer has issued a warranty extension.

On November 26, 2021 my 2008 Highlander Hybrid started displaying Check ABS, Check VSC System, Check Brake System and Brake Malfunction, errors on the display screen. I could feel the the grinding noise and brake pedal seemed different than normal. The Brake Malfunction error was displayed with a warning to "Stop the vehicle in a safe place immediately, and contact a dealer". I bought a vehicle diagnosis code reader and it showed C1391 (Abnormal Leak in Accumulator Pressure). I received the same code late last year in 2020 and took my vehicle to dealer. They told me that I was not driving my vehicle due to pandemic and the 12V battery went bad. They removed the errors and I replaced the battery from Walmart. I did not see the error code again until now (after 1 year). I received a Customer Support Program Bulletin letter (POL19-06) from Toyota in 2019 or early 2020 which mentioned C1391 as a verification of problem in vehicle. I showed it to the dealership during my 2020 visit and they said my vehicle is not covered. I believed them since I did not see the error again after replacing the 12V battery. Now I am having the same problem again. The ABS error was displayed on 11/26/2021. I was able to read and reset the ABS error code C1391 on 11/30/2021. The ABS error showed up again on 12/2/2021 while I was driving the car with my family in it. I had to reset it to reach home safely. It ABS error came back ON again before reaching home. I am unable to get it fixed because the extended warranty provided by Toyota for this known safety issue expired on 12/31/2020 and now I am billed for the replacement parts and labor ($4000). Toyota should have opened a recall for this faulty ABS system or should not have an expiry date to this program. After searching the internet I am also surprised that this problem is not only with Highlander Hybrid but though out Toyota and Lexus product lines. I request you to please ask Toyota to open a recall on this life threatening issue.

On approx. August 13, 2021, my 2008 Toyota Highlander Hybrid vehicle began making grinding sounds when the brake is fully depressed while the transmission lever is set to "drive". On approx. August 20, 2021, my vehicle started showing 4 error messages on the display: Brake Malfunction, Check ABS, Check VSC System, and Check Brake System. The Brake Malfunction error was displayed with a warning to "Stop the vehicle in a safe place immediately, and contact a dealer". At the same time, these 5 warning lamps became illuminated: Brake System Warning Light and Warning Buzzer (Red), Brake System Warning Light (Yellow), Master Warning Light (Yellow), ABS Warning Light (Yellow), and SLIP Indicator (Yellow). A car repair technician obtained the following error codes from the vehicle in a diagnosis: C1241 (Low or High Power Supply Voltage), C1253 (Pump Motor Relay), and C1391 (Abnormal Leak in Accumulator). I was informed that the VSC (vehicle stability control) safety feature of the vehicle is disabled while the error codes and messages are present. Toyota previously issued a customer support bulletin (No. POL19-06) on June 6, 2019, titled "Customer Support Program ZKC: Certain 2008-2010 Model Year Highlander Hybrid Vehicles Coverage for Brake Actuator Assembly and Brake Booster Pump Assembly". In the bulletin, Toyota acknowledged that its 2008-2010 Highlander Hybrid models had "certain internal malfunctions of the Brake Actuator Assembly". Affected error codes include C1391, C1252, C1256, and C1253. Affected warning lamps consists of all 5 of the warning lamps that were illuminated in my vehicle. Affected parts include 04008-26448 (Actuator Assy, Brake w/ Fluid) and 04008-51148 (Pump Kit, Brake Booster w/ Accumulator). Instead of issuing a recall for this hazardous defect, Toyota opted to offer "Customer Support Program ZKC". The malfunction that manifested my vehicle is not eligible for this program. Toyota should issue a proper recall to address this safety hazard.

2008-2010 Toyota Highlander (hybrid, in my case) has an ongoing problem with the brake actuator and brake booster. In my case, within a year I will have had these items replaced twice. The cost to me will be about $3000. According to many website chats and blogs, this is a repeated repair even after having replaced it.

MAY 2021 UPDATE: 2008 HIGHLANDER HYBRID 184,XXXMI I OWN A 2008 HIGHLANDER HYBRID IN GREAT SHAPE, MINUS INTERNAL LEAKAGE IN MY BRAKE ACTUATOR ASSEMBLY. MY CAR THREW THE DEATH CODE [C1391] WHICH IS THE INDICATION THAT THIS IS THE ISSUE. THE SCREEN INSIDE THE CAR FLASHED ABS // VSC // CHECK BRAKE SYSTEM. THE CAR WAS PURCHASED NEW FROM A DEALERSHIP AND HAS BEEN IN THE FAMILY EVER SINCE. THE "RECALL" ON THE ACTUATOR IS NOT ACTUALLY A RECALL, IT IS A "WARRANTY EXTENSION."AFTER RECEIVING A QUOTE FOR REPLACEMENT OF $4200CAD, I CONTACTED TOYOTA ABOUT MY ISSUE. MY HIGHLANDER HAS 184,XXXMI AND IS A 2008 SO IT IS BEYOND THE MILAGE OF THE EXTENDED WARRANTY (150,000MI) AND BEYOND THE END DATE OF THE INFINITY MILEAGE REPLACEMENT (NEW WARRANTY ENDED DEC 2020, OF COURSE). I CALLED TOYOTA, MADE A CLAIM, AND 24HRS LATER I CALLED BACK IN AND WAS DIRECTED TO SPEAK WITH THE WARRANTY DEPARTMENT MANAGER. ALTHOUGH MY APPROACH WAS DIRECT, THOROUGH, AND CALM, HE REALLY DIDN'T SEEM TO CARE. HE DEFENDED TOYOTA STATING THAT THEY "ALREADY WERE BEING VERY GRACIOUS BY EXTENDING THE CLAIM TO BEGIN WITH" AND THAT "THERE IS NOTHING WE CAN DO." I FIND THE FACT THAT TOYOTA RECOGNIZES THEY HAVE USED A FAULTY PART IN THEIR HIGHLANDERS, AND DID NOT LIST IT AS A "RECALL" (SO YOU COULD GET IT SWAPPED OUT BEFORE IT CAUSED PROBLEMS) IS RIDICULOUS. I MISSED THE CUT-OFF BY 5MO AND HIS ONLY RECOMMENDATION WAS TO CALL MULTIPLE DEALERSHIPS AND "SHOP AROUND" FOR A CHEAPER PART. ESTIMATED REPAIR COST: $4,200CAD

ON MARCH 26, 2021 WHEN WE STARTED THE VEHICLE, THERE WERE SEVERAL INDICATORS AND MESSAGES THAT THERE WAS A PROBLEM WITH THE BRAKING SYSTEM AND THAT IT NEEDED TO BE SERVICED BY A TOYOTA DEALER IMMEDIATELY. UPON DOING SOME RESEARCH IT BECAME CLEAR THAT TOYOTA IS FULLY AWARE OF MALFUNCTIONS OF THE BRAKE ACTUATOR ASSEMBLY AND BRAKE BOOSTER PUMP ON THIS VEHICLE AND COMMUNICATED IT TO OWNERS IN A CUSTOMER SUPPORT PROGRAM NOTIFICATION-ZKC IN 2019. IN THAT VOLUNTARY COMMUNICATION, TOYOTA IDENTIFIED THE MALFUNCTIONS OF THE BRAKE SYSTEM COMPONENTS AND STATED THAT THE COST OF REPAIRS WAS COVERED THROUGH DECEMBER 31, 2020. HOWEVER, SINCE THIS PROBLEM DID NOT BECOME APPARENT UNTIL MARCH 26, 2021 TOYOTA DID NOT FULLY COVER THE COST OF REPAIRS. IT IS UNCLEAR WHY THIS KNOWN DEFECT AND MALFUNCTION HAVE NOT BEEN TREATED AS A RECALL. THERE ARE NUMEROUS CASES THAT HAVE BEEN DOCUMENTED ONLINE OF BRAKE FAILURE ON THIS VEHICLE AS A RESULT OF THE MALFUNCTIONS OF THE BRAKE ACTUATOR AND BOOSTER PUMP SOME WITH CATASTROPHIC CONSEQUENCES. NO ONE AT TOYOTA HAS BEEN ABLE TO EXPLAIN WHY REPAIRS ARE NOT COVERED AFTER DECEMBER 31, 2020 AND INDICATE THAT IT WAS APPARENTLY AN ARBITRARY DATE. MY ASSUMPTION IS THAT THIS WAS A DELIBERATE EFFORT BY TOYOTA TO LIMIT THEIR FINANCIAL EXPOSURE WITH NO REGARD FOR THE SAFETY OF DRIVERS AND PASSENGERS. HOPEFULLY THE NHTSA WILL INVESTIGATE THIS ISSUE AND REQUIRE TOYOTA TO NOTIFY ALL OWNERS OF THIS VEHICLE OF THE DEFECT AND POTENTIAL DANGER ASSOCIATED WITH BRAKING SYSTEM FAILURE AND HAVE TOYOTA RECALL THE VEHICLE AND MAKE THE APPROPRIATE REPAIRS. THE ESTIMATED COST FOR THE REPAIR IS $2,700.

THE ABS ON OUR 2008 TOYOTA HIGHLANDER HYBRID LIMITED WENT OUT SEVERAL DAYS BEFORE WE HAD PLANNED A LONG TRIP. WE HEARD A NOISE AND TOOK IT TO OUR MECHANIC, WHO DIAGNOSED IT. THANKFULLY WE WERE NOT HURT OR IN AN ACCIDENT.THE 2006 AND 2007 HIGHLANDERS HAVE RECALLS ON THEM FOR THIS PROBLEM. THE 2008 HAS THE SAME BRAKE COMPONENTS, PER OUR MECHANIC, BUT THERE IS NO RECALL ON THE 2008. WE WOULD LIKE TO KNOW WHY, AS IT USES THE SAME PARTS THAT ALREADY HAVE A RECALL ON THEM.

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

MY 2008 HIGHLANDER HYBRID CAME UP WITH THE FOLLOWING LIGHTS IN THE DASHBOARD AND INFORMATION DISPLAY: BRAKE SYSTEM MALFUNCTION, CHECK BRAKE SYSTEM, CHECK ABS AND CHECK VSC SYSTEM. THE BRAKES GOT HARD TO PRESS ALL THE SUDDEN AFTER THE LIGHTS CAME ON, I WAS LUCKY I WASN'T DRIVING THE CAR WHEN IT HAPPENED. I RECEIVED A LETTER FROM TOYOTA BACK IN 2019 STATING THERE WAS A PROBLEM WITH MY MODEL'S BRAKE ACTUATOR AND THAT IF MY VEHICLE HAD THESE SYMPTOMS, THEY WOULD REPAIR IT FOR FREE, BUT I HAD TO WAIT UNTIL THE PROBLEM PRESENTED ITSELF. THE PRIMARY COVERAGE FOR THIS WAS UNTIL DECEMBER 31ST, 2020 AND THE SECONDARY COVERAGE WAS UNTIL THE CAR HAD 10 YEARS OR 150,000 MILES ON IT. THEY TOLD ME I DON'T QUALIFY FOR EITHER COVERAGES SINCE THE WARRANTY EXTENSION WAS UNTIL 2020 AND MY CAR ALREADY HAS 12 YEARS (FIRST DATE OF USE MAY, 2009), EVEN THOUGH IT ONLY HAS 80,280 MILES ON IT. MY LOCAL DEALER'S ESTIMATE FOR THIS PROBLEM TOTALS $3,873.55 WHICH IS ABSOLUTELY RIDICULOUS FOR A PROBLEM THEY RECOGNIZED HAPPENS TO EVERY MODEL IN MY CATEGORY, AND A PROBLEM THEY WOULD'VE FIXED FOR FREE LESS THAN 4 MONTHS AGO. EVEN MY SERVICE ADVISOR TOLD ME TO BE CAREFUL AND NOT DRIVE THE CAR AS THIS IS A SAFETY ISSUE. THIS SHOULD'VE BEEN A RECALL, NOT A WARRANTY EXTENSION.

VEHICLE DRAINED THE NEW 12 VOLT BATTERY RECENTLY INSTALLED. I DELIVERED THE BATTERY TO THE VENDOR WHO CHARGED IT AND RAN AN ANALYSIS AND FOUND THAT THE BATTERY WAS IN PROPER WORKING ORDER. THEY INDICATED SOMETHING IN THE VEHICLE CAUSED THE DRAIN. UPON REPLACING THE FULLY CHARGED BATTERY THE VEHICLE DID NOT START. THERE WERE THREE WARNING MESSAGES: CHECK BRAKE SYSTEM, CHECK VSC SYSTEM, AND CHECK 4WD SYSTEM. THE BRAKING SYSTEM ISSUE SEEMS TO BE A COMMON ONE IN THIS MAKE, MODEL, AND YEAR AND I RECEIVED A CUSTOMER SUPPORT PROGRAM NOTIFICATION LETTER FROM THE MANUFACTURER INDICATING COVERAGE FOR THE BRAKE ACTUATOR ASSEMBLY WHICH CAUSES THESE WARNINGS. WHEN I HAD THIS CHECKED PRIOR TO THE COVERAGE EXPIRATION DATE OF DECEMBER 31, 2020, THE DEALERSHIP INDICATED THAT THIS WAS NOT THE ISSUE. THE COST TO REPAIR THIS ISSUE SEEMS PROHIBITIVE AT OVER $3,000.00.

THE CAR KEEPS LUNGING FORWARD AS THE BRAKE IS BEING PRESSED AT TIMES. THIS IS PARTICULARLY DANGEROUS IN SNOWY AND SLIPPERY CONDITIONS. I WAS FORCED ONTO ONCOMING TRAFFIC AS THE CAR LUNGED FORWARD WHEN I ATTEMPTED TO STOP AT A STOP. THE CAR BRAKE STOPPED WORKING BRIEFLY AND THE CAR INSTEAD JERK FORWARD. I CALLED TOYOTA ON 3/1/2021 WHO CLAIMED IT IS PART A CUSTOMER SUPPORT PROGRAM TO REPAIR AS OF DECEMBER 31, 2021 AND NOT CLASSIFIED AS A RECALL AND WILL THEY WILL NOT MAKE THE NECESSARY REPAIRS. THIS IS A DEFINITE RECALL AND SHOULD BE ADDRESSED ASAP. I WAS DRIVING ON A LOCAL ROAD, SNOWY CONDITIONS, AND ATTEMPTED TO STOP GOING DOWNHILL WHEN THE CAR JERKED FORWARD AS THE BRAKE WAS BEING APPLIED.

I HAVE TOYOTA HIGHLANDER HYBRID 2008. MY CAR IS MAKING NOISE UNDER THE HOOD WHENEVER I HIT THE BRAKE REGARDLESS OF IF THE CAR IS MOVING OR HALT. INITIALLY TOYOTA SERVICE GUYS SAID THAT THE SOUND IS EXPECTED AND NOTHING IS WRONG WITH MY CAR BUT DURING MY LAST VISIT TO THEM THEY MENTIONED MY ABS ACTUATOR AND MOTOR HAS GONE BAD AND NEEDS TO BE REPLACED. THE ESTIMATE COST TO FIX THE PROBLEM IS AROUND $3200. I HAVE READ ONLINE ABOUT THE SIMILAR CASES AND I REQUEST TOYOTA TO RECOGNIZE THE PROBLEM AND ISSUE A RECALL TO REPLACE THE PAT 'ABS ACTUATOR AND MOTOR'. PRIOR MODELS WERE RECALLED FOR THE SAME ISSUE AND ALTHOUGH 2008 USES THE SAME COMPONENTS , IT HAS NOT BEEN RE-CALLED.

RECENTLY ALL THE BRAKE LIGHTS CAME ON THE DASH AS I WAS DRIVING THE CAR. THE WARNING NOTE ON THE SCREEN SAID TO TAKE IT IMMEDIATELY TO THE DEALER TO FIX. AFTER THEIR DIAGNOSTIC THE DEALERSHIP FOUND THAT BOTH THE BRAKE BOOSTER PUMP AND ABS ACTUATOR NEEDED TO BE REPLACED AT A COST OF $3,064 INCLUDING THE 3-4 HOURS LABOR COST AFTER RESEARCHING THIS ISSUE APPARENTLY IT IS A VERY COMMON COMPLAINT WITH THESE VEHICLES.FOR SOMETHING AS SERIOUS AS THIS I'M SURPRISED THAT THERE HAS NEVER BEEN A RECALL ON THIS ISSUE. *TR

ABS FAILURE, WHICH SEEMS TO BE AN ISSUE WITH THIS MODEL BASED ON AN ONLINE SEARCH. PRIOR MODELS WERE RECALLED FOR THE SAME ISSUE, AND ALTHOUGH THE 2008 USES THE SAME COMPONENTS, IT HAS NOT BEEN RECALLED. THIS IS A SAFETY ISSUE GIVEN THAT THE BRAKES CAN FAIL. FIXING THE ISSUE BEFORE IT BECOMES A DISASTER COSTS $4000 +

I HAVE TOYOTA HIGHLANDER HYBRID 2008. MY CAR IS GIVING A SOUND UNDER THE HOOD WHENEVER I HIT THE BRAKE. NO MATTER THE CAR IS HALT OR MOVING. INITIALLY TOYOTA SERVICE GUYS SAID THAT THE SOUND IS EXPECTED AND NOTHING WRONG MY CAR. YESTERDAY THEY WERE TELLING THAT THE "ABS ACTUATOR" IS BAD AND HAS TO BE REPLACED NOW OR LATER. THE ESTIMATED COST TO FIX THE PROBLEM IS $3000. I HAVE READ ONLINE ABOUT THE SIMILAR CASES. I REQUEST TO TOYOTA TO RECOGNIZE THE ISSUE AND ISSUE A RECALL TO REPLACE THE PART "ABS ACTUATOR ASSY". THE ATTACHED URL DESCRIBE THE SIMILAR ISSUE AND AT YOU CAN HEAR THE SOUND IN THE YOUTUBE URL: HTTPS://WWW.YOUTUBE.COM/WATCH?V=WVFUMDZLE4Y&FEATURE=YOUTU.BE

TOYOTA JUST DENIED OUR CLAIM FOR THE REIMBURSEMENT FOR THE BRAKE ACTUATOR ASSEMBLY CUSTOMER SUPPORT PROGRAM (MALFUNCTION OF THE BREAK ACTUATOR ASSEMBLY IN 2008 HIGHLANDER HYBRID). SUPPOSEDLY THE REPAIR PERFORMED ON OUR VEHICLE "DOES NOT MEET THE CRITERIA FOR REIMBURSEMENT". INTERESTING. PROBLEM WITH OUR VEHICLE WAS EXACTLY WHAT THE CUSTOMER SUPPORT PROGRAM ZKC IS FOR. THEY HAVE BEEN PLAYING GAMES WITH US FOR ALMOST 3 MONTHS. WE SENT THEM THE COMPLETE DOCUMENTATION SEVERAL TIMES (THEY TRIED TO CLAIM SOMETHING WAS ALWAYS MISSING). NOTHING WAS MISSING. WE ARE THE ORIGINAL OWNERS OF THE VEHICLE AND HAVE KEPT EVERY RECEIPT, EVERY DMV DOCUMENT, EVERY CREDIT CARD STATEMENT... WE KEPT RE-SENDING THEM THE DOCUMENTS; SOME OF THEM AS MANY AS 4 TIMES. INTERESTING, WHEN I CALLED THEM, THEY HAD THE DOCUMENTS ON FILE. THEY JUST DO NOT WANT TO PAY; WAY TOO OBVIOUS. TOYOTA REPS ARE HORRIBLE ACTORS... WE ARE NOT GIVING UP. WE WILL BE CALLING AND E-MAILING THEM UNTIL THEY REIMBURSE US. IF THEY DO NOT, WE (AND OTHER PEOPLE IN OUR VERY EXTENDED FAMILY) WILL NOT BUY A TOYOTA VEHICLE AGAIN. SO SHORTSIGHTED BY TOYOTA: SAVE $3700 BUT LOSE SEVERAL CUSTOMERS... THE WARNING LIGHT CAME ON IN DECEMBER 2015. IT TOOK TWO TRIPS TO TOYOTA DEALER (AND $3700) TO HAVE THIS FIXED.

WHILE DRIVING APPROXIMATELY 25 MPH ON A CITY STREET, THE BRAKE SYSTEM FAILED ENTIRELY WHEN ATTEMPTING TO STOP AT A RED LIGHT. THERE WAS NO PREVIOUS WARNING THAT THE BRAKES WERE NOT FUNCTIONING. IN THE MOMENT OF FAILURE, THE ABS WARNING SYSTEM ALERT SHOWED ON THE DASHBOARD DISPLAY. EVENTUALLY, THE BRAKES BEGAN TO WORK AGAIN, AND I PULLED TO THE SIDE OF THE STREET AND TURNED OFF THE VEHICLE. NO WARNING LIGHTS OR INDICATORS SHOWED AFTER RESTARTING THE VEHICLE, AND THE BRAKING SYSTEM APPEARED TO BE SOMEWHAT FUNCTIONAL AGAIN. THE MECHANIC WE BROUGHT IT TO WAS ABLE TO REPLICATE THE PROBLEM IN THE SAME CONDITIONS, BUT IS AS YET UNCLEAR ON WHAT IS CAUSING THE FAILURE.

ABS AND VSC SYSTEM WARNING LIGHTS CAME ON SUDDENLY FOR THE FIRST TIME WHILE I WAS DRIVING. I PARKED THE CAR AND IT WOULD NOT START. I WAS STRANDED AND SUDDENLY HAD A CRITICAL BRAKE FAILURE WITH NO PRIOR WARNING. MY VEHICLE HAS LOW MILEAGE AT APPROX. 70,000. THIS IS A DANGEROUS FAILURE WHICH HAS BEEN COVERED BY WARRANTY IN PREVIOUS MODELS AND IS STILL A PROBLEM.

WHEN APPLYING PRESSURE TO THE BREAKS THERE IS A CHIRPING SOUND. TOYOTA HAS DEEMED THIS AN ABS ACTUATOR FAILING ISSUE; WHICH IS AN ISSUE I HAVE SEEN REPEATEDLY ONLINE POSTED BY OTHER HY HI DRIVERS. I AM ALSO SEEING 2 YEARS PREVIOUS HAVE BEEN RECALLED FOR THIS VERY ISSUE. WHY IS THE RECALL NOT EXTENDED AND IS THERE ANY WAY FOR IT TO BE? THE COST OF THE VEHICLE TO THE COST OF REPAIR IS SO GREAT AND UNFORTUNATELY, THIS IS NOT A NORMAL FAILURE THAT IS TO BE EXPECTED. ITS TO MY UNDERSTANDING THAT A COMPLETE FAILURE CAN CAUSE A VERY UNAVOIDABLE FATAL CRASH AS THE BREAKING SYSTEM FAILURE WOULD LOCK UP ALL BREAK FUNCTION. THIS HAS OCCURRED IN THE PAST TOO WITH VEHICLES UNDER FURTHER DETERIORATION OF THE ABS ACTUATOR. WOULD YOU PLEASE GIVE HEAVY THOUGHT TO AN EXTENSION OF THE WARRANTY TO COVER THIS ISSUE FOR THE 2008 MODELS? ITS A GREAT RISK TO HIGHLANDER DRIVERS AND THOSE AROUND US.

ABS SYSTEM HAS FAILED JUST LIKE EVERYONE ELSE. PUMP KEEPS COMING ON EVERY 5 SECONDS OR SO. SCREEN TELLS YOU TO STOP THE CAR AND CONTACT THE DEALER. TOYOTA NEEDS TO COVER THIS EXPENSIVE REPAIR OR AT LEAST SOME PORTION OF IT.

AFTER RESEARCHING ONLINE, I HAVE NOTICED THIS IS A VERY COMMON ISSUE AND TOYOTA ISSUED RECALLS OUT FOR 2006 & 2007 BUT HAS NOT ACKNOWLEDGED 2008 AS HAVING THE SAME ISSUE. I WAS ALMOST IN AN ACCIDENT AND NOTICED THERE ARE OTHERS OUT THERE THAT HAVE BEEN IN ACCIDENTS. WHY IS IT THAT NOTHING HAS BEEN DONE TO CORRECT THIS? FIRST, I HEARD AN AIRY SOUND WHEN BRAKING THEN A SOFT BRAKE PEDAL BEFORE ALMOST COMPLETE BRAKE FAILURE. THE HIGHLANDER TRULY FELT LIKE IT WAS NOT STOPPING. I LITERALLY HAD TO PUT MY COMPLETE BODY WEIGHT ON THE BRAKE PEDAL TO FINALLY GET IT TO STOP AS IT KEEPS SURGING FORWARD. IT WAS SCARY, TO SAY THE LEAST. I WAS IN A HEAVY POPULATED PARKING LOT. I COULD'VE HIT A PEDESTRIAN OR HIT ANOTHER CAR BECAUSE I COULDN'T GET THE CAR TO STOP FROM SURGING FORWARD. AFTER ALL THIS, FINALLY, LIGHTS APPEARED. (ENGINE LIGHT, BRAKE LIGHT, VSC LIGHT & SKID LIGHTS CAME ON). WOULDN'T YOU THINK AFTER JUST BEING FULLY SERVICED AT A TOYOTA DEALERSHIP, SOMETHING WOULD'VE BEEN NOTICEABLE? I REACHED OUT TO TOYOTA CORP. AND AGAIN I WAS TOLD THIS IS NOT COMMON AND NO RECALLS HAVE BEEN ISSUED. I SAW A VERY COMMON DENOMINATOR THAT ONCE THE HIGHLANDER HITS A CERTAIN MILEAGE THIS HAPPENS AND A VERY COSTLY MASTER CYLINDER AND BRAKE BOOSTER NEEDS TO BE REPLACED. A PARKING LOT AND IN MOTION.

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE DRIVING 45 MPH, THE BRAKES COMPLETELY MALFUNCTIONED. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKES TO STOP THE VEHICLE AND AVOID A CRASH. THE CONTACT ALSO STATED THAT THE ABS WARNING INDICATOR ILLUMINATED AT THE TIME OF THE FAILURE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE DEALER (TOYOTA OF STAMFORD, 909 E MAIN ST, STAMFORD, CT 06902, (203) 348-3751) STATED THAT THE BRAKES WERE NOT COVERED BY A RECALL AND THE CONTACT WOULD HAVE TO PAY FOR THE REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND CONFIRMED THAT THERE WERE NO RECALLS ASSOCIATED WITH THE VIN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 265,000.

I WAS DRIVING ON THE STREET AND AN ERROR MESSAGE DISPLAYED ALONG WITH A LOUD RINGING SOUND. THE MESSAGE ON THE SCREEN SAID TO PULL OVER IMMEDIATELY AND CALL A DEALER BECAUSE THERE IS A BRAKE MALFUNCTION. IT ALSO SAID TO CHECK THE ABS AND THE VSC. I COULD FEEL THE MY BRAKE PEDAL WASN'T REACTING WHEN I PRESSED ON IT. I HAD TO PRESS THE PEDAL ALL THE WAY DOWN REALLY HARD TO GET THE CAR TO SLOW DOWN.

ABS ACTUATOR NOT WORKING. BRAKE MALFUNCTION WARNING ON DISPLAY SCREEN.

WHEN DRIVING IN ROUTINE CITY DRIVING AT LOW SPEED, BRAKE WARNING LIGHTS LIT UP DASH. "CHECK BRAKE SYSTEM, CHECK VSC SYSTEM, CHECK ABS SYSTEM, PULL TO SIDE AND GO TO DEALER" DEALER DIAGNOSED PROBLEM AS BRAKE ACCUMULATOR PUMP ASSEMBLY. PART ALONE COST ABOUT 2,000.00 PLUS LABOR. PART IS NOT COVERED UNDER ANY WARRANTY AND UNLESS YOU FIX IT, IT IS UNSAFE TO DRIVE. THIS PART HAS FAILED IN OTHER TOYOTA MODELS THAT HAS RESULTED IN A RECALL. ,

UNDETECTED BRAKE FLUID LEAK WHILE IN USE. VEHICLE UNDERCARRIAGE WAS CHECKED FOR LEAKS BUT NOT VISIBLE.

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT THE BRAKE WARNING INDICATOR ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ACCUMULATOR AND ACTIVATOR FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER STATED THAT THE REPAIR WAS NOT COVERED BY WARRANTY OR RECALL. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 10/06/16*LJ *TR

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE DRIVING AT 5 MPH, THE BRAKE PEDAL WAS DEPRESSED AND BECAME STUCK. THE CONTACT HAD TO DEPRESS THE BRAKE PEDAL MULTIPLE TIMES TO RELEASE THE PEDAL. THE CHECK ENGINE AND BRAKE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE BRAKE BOOSTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THE BRAKE SENSOR, VSC SENSOR AND THE TRAC OFF SENSOR LIGHTS ILLUMINATED. THE CONTACT THEN NOTICED THAT THE BRAKING SYSTEM MALFUNCTIONED, MAKING THE VEHICLE DIFFICULT TO STOP. THE CONTACT INDICATED THAT ADDITIONAL PRESSURE WAS APPLIED TO THE BRAKE PEDAL IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS DIAGNOSED BY THE DEALER WHERE THE CONTACT WAS INFORMED THAT THE HUB OF THE WHEEL BEARING WAS CORRODED. THE CONTACT STATED THAT BOTH REAR WHEEL HARNESSES WERE REPLACED TO REPAIR THE DEFECT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 94,154.

WHILE DRIVING AT 35 MILES PER HOUR, THE BRAKE LIGHT ON THE DASHBOARD CAME ON, BRAKE PEDAL BEGAN GOING ALL THE WAY DOWN WHILE BRAKING, AND THE BRAKE PEDAL BEGAN MAKING NOISE. I STOPPED THE CAR, OPEN THE HOOD AND FOUND THAT ALL MY BRAKE FLUID WAS GONE. THE TOYOTA DEALERSHIP WAS NEARBY I DROVE THE CAR SLOWLY TO THE DEALERSHIP. THEY CHECKED THE BRAKE SYSTEM ONLY TO FIND OUT THAT ALL THE BRAKE FLUID WAS IN THE BRAKE BOOSTER. MY SERVICE ADVISER TOLD ME THE BRAKE SYSTEM FAILED DUE TO BAD SEALS BETWEEN THE MASTER CYLINDER AND THE BRAKE BOOSTER. NOW THE MASTER CYLINDER AND BRAKE BOOSTER NEED TO BE REPLACED. I PURCHASED THE HIGHLANDER BRAND NEW IN 2008. THE VEHICLE IS ONLY 5 YEARS OLD WITH APPROXIMATELY 78,420 MILES ON IT AND HAS BEEN SERVICED EVERY 5,000 MILES EVER SINCE I PURCHASED IT. THIS SHOULD NEVER HAPPEN TO A VEHICLE THAT HAS BEEN WELL MAINTAINED. IT'S A SERIOUS SAFETY MATTER, AND MY BRAKES HAD JUST BEEN REPLACED ALONG WITH THE BRAKE FLUID AT THE SAME DEALERSHIP ON OCTOBER 02, 2013. *TR

THE RIGHT FRONT BRAKE OF MY 2008 TOYOTA HIGHLANDER POPPED LOUDLY WHEN I BACKED UP. IT SOUNDED AND FELT LIKE THE BRAKE LOCKED UP. THIS PROBLEM SEEMED TO HAVE ALREADY EXISTED SINCE THE DAY I PURCHASED THE BRAND-NEW VEHICLE IN DECEMBER 2008, AND IT GOT WORSE AND WORSE. THEREFORE, I TOOK THE VEHICLE TO A TOYOTA DEALER FOR INSPECTION AND THE THEY SAID, "THERE IS NOTHING WRONG WITH THE BRAKE. IT IS NORMAL AND IS JUST THAT THE BREAK IS SHIFTING." HOWEVER, I ASKED THEM WHY THE POPPING SOUND "ONLY" CAME FROM THE RIGHT FRONT BRAKE. THEY AVOIDED MY QUESTION AND DID NOT ANSWER. AS MY CONCERNS OVER THE BRAKE GREW MORE AND MORE, I TOOK MY VEHICLE TO THE SAME DEALER AGAIN, BUT THEY SAID, "MY VEHICLE IS OUT OF WARRANTY AND I HAVE TO PAY $45 TO HAVE IT RE-CHECKED." I TOLD THEM THAT WHEN MY VEHICLE WAS INSPECTED FOR THE PROBLEM THE FIRST TIME, IT WAS STILL UNDER WARRANTY, AND THE PROBLEM NEVER WENT AWAY; INSTEAD, IT BECAME EVEN WORSE. HOWEVER, THEY STILL INSISTED THAT I HAD TO PAY IN ORDER TO HAVE IT INSPECTED AGAIN. I WAS SO DISAPPOINTED I LEFT THE DEALERSHIP. AT THE TIME OF THIS WRITING, THE RIGHT FRONT BRAKE STILL MAKES A LOUD, ANNOYING POPPING SOUND WHEN I BACK UP MY VEHICLE, WHICH MAKES ME WORRY THAT THE BRAKE COULD MALFUNCTION ANYTIME WHEN I AM ON THE ROAD. *TR

BRAKE MALFUNCTION SPEED SENSOR. *TR

TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 25 MPH AND APPLYING PRESSURE TO THE BRAKES, THE CONTACT NOTICED THAT THE VEHICLE CONTINUED TO ACCELERATE. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY PERFORMED A DIAGNOSTIC TEST WHICH CONCLUDED THAT THE BRAKE BOOSTER HAD BURST AND WOULD NEED REPLACING. THE DEALER PERFORMED THE REPAIRS AND THE MANUFACTURER PAID FIFTY PERCENT OF THE REPAIR COSTS. THE APPROXIMATE FAILURE MILEAGE WAS 53,000. UPDATED 05/03/11*LJ UPDATED 05/11/11

I WAS INVOLVED IN A CAR ACCIDENT ON 08/17/2010 WHILE DRIVING MY 2008 TOYOTA HIGHLANDER THAT HAS 23000 MILES ON IT. THE ACCIDENT CAUSED ME TOTAL DAMAGE TO MY CAR AND PUT MY LIFE IN DANGER DUE TO FAILURE IN THE BREAK/ACCELERATION SYSTEM ON THE CAR. THE CAR DID NOT STOP BUT ACCELERATED EVEN THOUGH WHEN I WAS PRESSING THE BREAK WHICH CAUSED ME TO HIT A TRUCK THAT WAS PASSING IN FRONT OF ME. I EXPLAINED TO THE EMERGENCY CREW THAT THE ACCIDENT WAS BECAUSE OF FAILURE OF THE BREAK/AND ACCELERATION SYSTEM ON THE TOYOTA CAR AND I EXPLAINED THE SAME THING TO THE POLICE OFFICER WHO WAS PRESENTED ON THE SCENE. I LIKE TO MENTION HERE THAT THE TOYOTA DEALER SENT ME A NOTE OF DEFECTION ABOUT MY CAR PRIOR TO THE ACCIDENT AND I TOOK THE CAR TO THE DEALER SHOP AND SPENT 2 HOURS THERE TO HAVE IT FIXED. THE CAR NOW IS AT THE STATE FARM INSURANCE AND I CAN EMAIL/SEND YOU THE CAR PICTURES AFTER THE ACCIDENT.

I RECEIVED A VSC ERROR CODE, ON A 2008 TOYOTA HIGHLANDER, NOT THE HYBRID MODEL, BUT A LIMITED TOP OF THE LINE MODEL. THE VEHICLE STARTS TO ACCELERATE BY ITSELF & THEN WHEN YOU SLAM ON THE BRAKES TO TRY TO STOP IT, IT FAILS TO STOP. IN ORDER TO AVOID SLAMMING INTO THE VEHICLE IN FRONT OF ME & TO THE RIGHT OF ME, I CHOSE TO TURN LEFT HARD & RUN INTO THE CONCRETE DIVIDER. THIS WAS THE 2ND OCCASION THAT THIS TYPE OF FAILURE HAS HAPPENED TO ME. THE 1ST TIME WAS ON DECEMBER 15, 2010 & I ALSO CHOSE TO TURN LEFT HARD & STRIKE THE DIVIDER INSTEAD OF REAR ENDING THE VEHICLE IN FRONT OF OR SIDE SWIPING THE VEHICLE TO THE RIGHT OF ME. ON THE 1ST OCCASION, NONE OF THE AIRBAGS DEPLOYED & BECAUSE OF THAT I ENDED UP STRIKING MY HEAD ON THE EITHER THE DRIVERS SIDE GLASS OR SOME HARD OBJECT AND LOSING MY SHORT TERM MEMORY. THE VEHICLE & THEN CROSSED 3 LANES OF TRAFFIC, FINALLY OFF OF AN EXIT RAMP & CAME TO REST AFTER STRIKING A FENCE POLE. THE 2ND TIME IT HAPPENED WAS ON AUGUST 16, 2010. I ALSO CHOSE TO STRIKE THE CONCRETE DIVIDER AS OPPOSED TO STRIKING THE VEHICLE IN FRONT OF ME OR TO THE RIGHT OF ME. THEN SOMEHOW I ALSO CROSSED 3 LANES OF HIGHWAY & FINALLY COMING TO REST AFTER STRIKING A LIGHT POLE. THE DRIVER SIDE CURTAIN AIRBAG DID DEPLOY THIS TIME SO I DID NOT LOSE CONSCIOUSNESS NOR DID I LOSE MY SHORT TERM MEMORY. IT WAS AT THAT POINT THAT I NOTICED THAT A 2ND ERROR CODE ALSO CAME UP STATING BRAKE FAILURE. *TR

NOTED RECENTLY ON MYCARSTATS.COM SIX COMPLAINTS REGISTERED WITH NHTSA REGARDING 2008 HIGHLANDER BRAKE PROBLEMS AND FIVE COMPLAINTS REGISTERED WITH NHTSA REGARDING 2008 HIGHLAND ELECTRIC PROBLEMS THAT INVOLVE BRAKES AND ELECTRONIC CONTROLS. I AM SUBMITTING THE FOLLOWING EXPERIENCES WITH MY 2008 HIGHLANDER BECAUSE THEY MIRROR MANY OF THE COMPLAINTS. THE BRAKES ON MY HIGHLANDER HAVE BEEN AN ISSUE FROM THE FIRST WEEKS OF OWNERSHIP. I HAVE TAKEN THE CAR TO A LOCAL TOYOTA DEALERSHIP AND COMPLAINED ABOUT THE BRAKES. THE DEALERSHIP DID ADJUST THE EMERGENCY BRAKE WHICH THEY INDICATED WAS OUT OF ADJUSTMENT BUT HAVE STATED THAT THE BRAKES ARE WORKING NORMALLY. MY SPECIFIC COMPLAINT IS BRAKE RESPONSE. THERE IS ROUGHLY AN INCH OF PEDAL TRAVEL BEFORE THE BRAKES BEGIN TO RESPOND. IF ONE MUST MAKE A HARD EMERGENCY STOP THE VSC CONTROL WILL ENGAGE. ON ONE OCCASION, WHILE DRIVING IN TOWN A CAR RAN THROUGH A TRAFFIC LIGHT IN FRONT OF ME. I HIT THE BRAKES HARD - THE VSC LIGHT CAME ON - AND THE CAR SLOWLY STOPPED. THERE WAS NO ACCIDENT BUT IT WAS EXTREMELY CLOSE. I HAVE FOUND THAT IF I ROUTINELY PRESS ON THE BRAKE PEDAL UNTIL THE VSC LIGHT COMES ON THAT THE PEDAL TRAVEL IS REDUCED. I TOOK THE HIGHLANDER TO AAA AUTO DIAGNOSTICS AND THEY CONFIRMED THE PEDAL/VSC. AAA WAS UNABLE TO READ THE HIGHLANDER COMPUTER BECAUSE THEY DID NOT HAVE THE PROPRIETARY TOYOTA COMPUTER INTERFACE. THE LOCAL TOYOTA DEALER HAS STATED THAT THE DEPRESSED PEDAL AND VSC LIGHT RESPONSE IS NORMAL. I ALSO NOTED COMPLAINTS OF SUDDEN ACCELERATION WHEN PUTTING THE CAR INTO GEAR. I HAVE NEVER EXPERIENCED A SURGE TO THE DEGREE MENTIONED IN THE COMPLAINTS REFERENCED ABOVE, HOWEVER, WHILE PUTTING THE CAR INTO DRIVE WITH MY FOOT ON THE BRAKE I HAVE HAD THE CAR SURGE FORWARD. I NOW ALWAYS HAVE THE EMERGENCY BRAKE ON WHILE PUTTING THE VEHICLE INTO DRIVE. THE DATE LISTED BELOW IS THAT OF MY FIRST COMPLAINT TO THE LOCAL TOYOTA DEALER. *TR

RECENTLY I WAS INVOLVED IN A MINOR REAR-END ACCIDENT. THE IMPACT SPEED WAS APPROX 10-15 MPH AND LIGHT TO MODERATE DAMAGE WAS DONE TO MY VEHICLE, WHICH IS A 2008 HIGHLANDER. PRIOR TO THIS ACCIDENT I NOTICED MY ANTI-SKID BRAKING SYSTEM ACTIVATED AT A POINT I WOULD CONSIDER TO BE PREMATURE. THIS PREMATURE ACTIVATION LIMITS THE BRAKING POWER OF THE VEHICLE WHEN IT IS NEEDED. THIS PROBLEM WAS BROUGHT TO THE ATTENTION OF SOUTH COUNTY TOYOTA IN COSTA MESA, CA AND THEY STATED THE VEHICLE WAS OPERATING TO SPECIFICATION. I AM STILL CONCERNED ABOUT THE ISSUE AND WOULD LIKE TO HAVE IT EVALUATED BY A TOYOTA MOTORS REP WHILE I AM PRESENT. I DO BELIEVE THIS PREMATURE ACTIVATION OF THE ANTI-SKID SYSTEM WAS A CONTRIBUTING FACTOR IN MY RECENT ACCIDENT AND IT MAY HAVE BEEN PREVENTED IF THE FULL BRAKING POWER WAS AVAILABLE. AT THE TIME OF THE ACCIDENT THE STREETS WERE DRY AND IT HAD NOT RAINED IN SEVERAL WEEKS. THE VEHICLE SUFFERED MODERATE FRONT END DAMAGE WHICH HAS SINCE BEEN REPAIRED. TOYOTA WAS NOTIFIED OF THE ACCIDENT AND THEY HAVE FAILED TO CORRECT THE ISSUE OR ADMIT THERE IS ANYTHING WRONG WITH THE VEHICLE. AS OF RIGHT NOW I CAN DUPLICATE THE BRAKE FADE/ ISSUE 100% OF THE TIME. *TR

WE HAVE A 2008 TOYOTA HIGHLANDER WITH INTERMITTENT FAILURE OF THE ANTI-LOCK BRAKES AND VEHICLE STABILITY CONTROL SYSTEM (ABS/VSC). FOR NO APPARENT REASON, THE ABS/VSC WILL MALFUNCTION AND BRAKES OPERATE INCORRECTLY. IT IS AN INTERMITTENT PROBLEM THAT COMES AN GOES. WE HAVE ALMOST HAD AN ACCIDENT IN THE SNOW IN OHIO. WE HAVE HAD THE CAR INTO THE DEALER 4X WITHOUT RESOLUTION SINCE NOBODY KNOWS WHAT IS WRONG. IT HAS BEEN AN ONGOING ISSUE SINCE IT STARTED JAN 2010. *TR

I HAVE TOYOTA HIGHLANDER 2008 FROM AUG 2008. THIS CAR HAS A PROBLEM WITH BRAKING. FIRST WINTER IT WAS UNSAFE TO PARK CAR ON SHOPPING PARKING, BECAUSE OF CLOSE PROXIMITY TO OTHER CARS. HIGHLANDER WAS NOT STOPPING, IT CONTINUED MOVING WITH MY LEG ON THE BRAKE PEDAL. THIS CAR WAS NOT SLOWING DOWN. I DROVE MANY DIFFERENT SUVS FROM RENTAL COMPANIES, LIKE CHEVY TRAIL BLAZER, GMC ACADIA, JEEP TWO DIFFERENT MODELS, BUT NEVER HAD ANY PROBLEMS WITH BRAKES. I WENT TO THE DEALERSHIP THREE TIMES AND EACH TIME THEY TOLD ME THEY CANNOT DO ANYTHING. I'M USED TO THIS CAR NOW, BUT BRAKING STILL NOT GOOD. IT REQUIRES DEEP PRESSURE ON THE PEDAL AND CAR IS STOPPING LONGER. *TR

OUR 2008 TOYOTA HIGHLANDER HAS HAD THE SAME INTERMITTENT BRAKING PROBLEM SINCE WE PURCHASED IT IN 2008. WHEN WE BRAKE FOR THE FIRST SECOND OR SO OF DEPRESSING THE BRAKE PEDAL THE BRAKES WILL EITHER NOT RESPOND OR THERE WILL BE A SLIGHT SURGE IN ACCELERATION. AFTER FURTHER DEPRESSION OF THE BRAKE PEDAL, THE BRAKES WILL ENGAGE, BUT THE INITIAL ENGAGEMENT IS NOT SMOOTH. IT FEELS LIKE SOMEONE THAT HAS BRAKED THEIR VEHICLE TOO RAPIDLY. THIS ISSUE COMES AND GOES. WHEN WE TAKE IT TO THE DEALER, THEY SAY THEY CANNOT RECREATE THE ISSUE AND SAY THERE IS NOTHING WRONG WITH THE VEHICLE. *TR

LEFT AND RIGHT REAR BRAKES STAY ENGAGED WHEN APPLIED AND WILL NOT DISENGAGE FOR UP TO 2 MINUTES AFTER RELEASED. I WAS TOLD THAT THE MECHANISM (APPARENTLY THE CALIPERS) WAS CORRODED. *TR

BRAKE FAILURE ON 2008 TOYOTA HIGHLANDER: I TURNED CAR ON & SHIFTED INTO REVERSE TO BACK OUT OF PARKING SPACE. THERE WAS NO RESISTANCE ON THE BRAKE PEDAL. CAR ROLLED BACKWARD & WOULD NOT STOP. I APPLIED EMERGENCY BRAKE AND CAR STOPPED. WHEN E-BRAKE WAS ON I TESTED TO SEE IF THERE WAS PRESSURE ON THE BRAKE PEDAL - THERE WAS NONE. AT THIS POINT I PUT CAR INTO PARK AND TURNED OFF ENGINE, WAITED A FEW MINUTES AND RESTARTED ENGINE. STILL NO BRAKE PRESSURE AND SHIFTER WOULD NOT COME OUT OF PARK POSITION. I TURNED THE ENGINE OFF AND THEN ON AGAIN AND RELEASED EMERGENCY BRAKE. AT THIS POINT THE CAR SHIFTED OUT OF PARK AND THERE WAS PRESSURE IN THE BRAKE PEDAL. I DROVE VEHICLE SAFELY TO NEAREST TOYOTA DEALERSHIP (WHERE VEHICLE WAS PURCHASED). COMPUTER CHECK INDICATED NO PROBLEM WITH BRAKES. MANUAL/VISUAL CHECK REVEALED A GAP LEAKING BRAKE FLUID BETWEEN THE MASTER CYLINDER AND THE BRAKE BOOSTER , BOTH OF WHICH WERE SUBSEQUENTLY REPLACED BY THE DEALERSHIP. *TW

TOYOTA 2008 HIGHLANDER-BRAKING SYSTEM HESITATES LIKE THE PRIUS IS DESCRIBED. IT FREEZES UP AND DOESN'T REACT AS QUICKLY AS IT IS PUSHED. THIS IS ONGOING. *TR

NO PREVIOUS BRAKING PROBLEMS EXPERIENCED. FIRST HEARD AN AIRY SOUND WHEN BRAKING THEN SOFT BRAKE PEDAL AND THEN ALMOST COMPLETE BRAKE FAILURE. DEALER FOUND A VACUUM LEAK IN BRAKE BOOSTER. REPAIR WAS REPLACEMENT OF THE BRAKE BOOSTER. *TR

BRAKE PEDAL SPONGY AT LOW ENGINE OPERATING SPEEDS. *TR