2023 Subaru Ascent Brakes Problems

Your 2023 Subaru Ascent has experienced recurring brake problems even after recall repairs in September 2024. You've noticed violent steering wheel vibration, loud grinding noises, and unsafe braking—particularly when braking downhill—and these issues returned in March 2025, worse than before. Instead of replacing the faulty components again, the dealer resurfaced the rotors, which only temporarily masked the problem rather than fixing the underlying defect. The repair process should involve diagnosing and replacing the brake rotors, pads, and related components with new parts using proper installation procedures.

Your front brakes are vibrating and causing your steering wheel to shake, even after Subaru replaced the brake rotors and pads under recall in September 2024. The problem came back after less than 9,000 miles, and when you brought it back, the dealership resurfaced the old rotors instead of replacing them as their service bulletin requires. An independent inspection found the rotors are worn beyond acceptable limits with excessive runout, but Subaru says the vehicle is operating normally. Fixing this issue will likely require replacing the front brake rotors and pads with properly measured components that meet specification.

Your brakes have needed service three times in a short period, even after one replacement and one service visit. You're concerned about safety and feel the brakes aren't holding up as they should. The dealership will need to inspect and service the brake system again to determine if there's an underlying issue causing premature wear.

Right around the 10,000 mile mark I started noticing a shake when braking. I was pretty concerned about this as the car only has the mentioned 10,000 miles. I took it to the dealership where I bought the car. They were able to fix the problem by replacing the rotors and break pads. I was informed that the rotors were warped and had hot spots. The vehicle no longer shakes when braking, but I’m worried that it will happen again in another 10k miles. It may be an issue with the size of the brakes compared to the weight of the vehicle. This causes the rotors to heat up more than intended which leads to warping and hot spots.

The brake pedal is too high for people of average height, especially women, to use properly. Our feet slip underneath the brake when using it. When our heels are on the floor, our toes barely touch the brake pedal, and going from the gas to brake pedals smoothly is impossible with our heels on the car floor. Holding our right legs up above the floor causes extreme hip pain, as well as inaccuracy when transferring between the gas and brake pedals. The fact that the brake pedal is so far forward of the gas pedal also causes inaccuracy when switching from gas to brake. My shoes have gotten caught on the brake pedal many times in the transition, costing me valuable time in depressing the brake. I contacted the Subaru dealership and they said the entire brake pedal and arm would have to be replaced and they didn’t know how to do that. I would have paid for it. I contact Subaru Corporate and they left me a voicemail but then didn’t answer any of the times I called back. I am having to get hand controls installed in order to drive safely. It’s costing thousands. Subaru needs to acknowledge this is a huge problem and change the design of its brake pedal going forward, as well as offer replacement brake pedals for those of us who already own Ascents. Please see the Subaru Ascent Forum for others’ complaints. Thank you.

I own a Subaru 2023 Ascent ([XXX]) that I purchased in December 2022. Since I got the car, the car has been nothing but a headache and has been full of issues. The car was making a squeaking noise from the break from the day we got it. I took it to the dealer (within a month, 600 miles), and after a few times going to them, they suggested it had poor brake pads. As per their recommendation, the dealer changed the brake pads. After driving another 1000 miles, the bolt of calipers came off in the middle of the road, and the car started making stuttering noise. Luckily the breaks were still functioning, so I could drive back to the dealer. I took it back to the dealer, and they told me they could fix the car once and for all. After another 2000 miles today, the car brakes failed again when I dropped the kids. I almost hit the tree in front of me, but luckily no one got hurt. I called the roadside assistance as the car was undrivable. The dealer told us that a bolt of brakes came off on the driver's side. They are currently working on fixing the breaks. This incident has made us scared and questions the car's unreliability. This car is supposed to be the safest, and that was the reason we bought this in the first place. This incident has shocked us so much that we are scared of driving it, and it's prudent for us to return the car. We are looking for an immediate solution related to returning the car and giving us our full money back. Appreciate you looking into our issue. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).