2005 Ford Explorer Steering Problems

Your steering column feels tight and stiff when you start the truck, making the ignition key hard to turn and the gear shifter difficult to move from Park to Drive—though it loosens up once the engine is running. You're concerned the steering could lock up or the column could break, potentially leaving you stranded. This issue may be caused by binding or friction in the steering column assembly and could require inspection and lubrication or replacement of internal components.

I TRIED TO PUT THE CAR IN DRIVE AND THE SHIFTER BROKE OFF/

CAR STALLED WHILE DRIVING AT HIGHWAY SPEEDS. BRAKES AND STEERING BECAME IMPAIRED. LUCKY, I WAS IN THE RIGHTMOST LANE AND WAS ABLE TO NARROWLY AVOID COLLISION. INCIDENT OCCURRED AFTER A ~3HR DRIVE AS I WAS EXITING THE HIGHWAY (I.E. SLOWING DOWN). UPON RESTART, ENGINE TURNED OVER, BUT WAS UNDRIVEABLE DUE TO ITERATIVE SURGE/STALL CYCLES.

HELLO WHILE DRIVING DOWN THE HIGHWAY, THE UPPER BALL JOINT IN THE DRIVERS SIDE FRONT BROKE AND CAUSED DAMAGE TO THE AXLE, TIRE, AND WHEEL. THIS CAUSED ISSUES WITH CONTROL OF VEHICLE AND COULD HAVE CAUSE A MUCH GREATER ACCIDENT THAN WHAT OCCURRED. I WAS ABLE TO AVOID A MAJOR ACCIDENT, PARTIALLY DUE TO THE LOW SPEED AT THE TIME, HOWEVER HAD THIS OCCURRED WHILE I WAS ON THE INTERSTATE OR ON A CROWDED HIGHWAY, THIS COULD HAVE HAD EXPONENTIALLY WORSE OUTCOMES. I HAVE BEEN TOLD BY NUMEROUS MECHANICS THAT THE BALL JOINTS ARE AN ISSUE FOR FORD EXPLORERS AND THIS ISN'T MY FIRST ISSUE WITH THEM MYSELF. I ALSO HAD ISSUES WITH MY 2004 EXPLORER. THIS WAS NOT AN ORIGINAL PART TO THE VEHICLE AND WAS CHECKED LESS THAN A WEEK BEFORE IT BROKE AND PASSED INSPECTION. PLEASE LOOK INTO BALL JOINT ISSUES FOR FORD EXPLORERS AND KEEP SOMETHING LIKE THIS FROM HAPPENING AGAIN. A PICTURE OF THE VEHICLE IS BELOW. PLEASE CONTACT ME FOR MORE INFORMATION IF NEEDED. HTTP://OI59.TINYPIC.COM/T658XD.JPG. *TR

BECAUSE OF THE RECENT GM RECALL IGNITION ISSUE, I THOUGHT I SHOULD LET SOMEONE KNOW ABOUT THE SERIOUS SIMILAR ISSUE I HAD 3 TIMES BEFORE I TRADED MY CAR IN. THE CAR WOULD JUST SHUT OFF WHILE DRIVING. AND ALL 3 TIMES, I PULLED TO THE SIDE OF THE ROAD AND RESTARTED THE CAR AND CONTINUED ON MY WAY. I WAS LUCKY TO HAVE A PLACE TO PULL OVER SAFELY. I TOOK IT TO MY MECHANIC TWICE, FOUND NOTHING WRONG. TOOK IT TO FORD AND THEY FOUND NOTHING WRONG. I TRADED THE 2005 FOR A 2011. I ALSO TOLD THE DEALER THAT I TRADED IT INTO ABOUT THE ENGINE JUST SHUTTING OFF FOR NO REASON AND TO CHECK OUT THE PROBLEM BEFORE THEY SOLD IT AGAIN. *TR

I OWN A 2005 FORD EXPLORER THAT I PURCHASED IN JUNE, 2005. ON SATURDAY, FEBRUARY 21, 2009, I ATTEMPTED TO SHIFT MY 2005 FORD EXPLORER, WHICH HAD ROUGHLY 49,000 MILES DRIVEN AT THE TIME, INTO REVERSE IN ORDER TO BACK OUT OF MY DRIVEWAY. IN DOING SO, THE GEARSHIFT ALMOST COMPLETELY BROKE AWAY FROM THE STEERING COLUMN. I WAS ABLE TO TURN THE IGNITION OFF, BUT WAS UNABLE TO REMOVE THE KEY FROM THE IGNITION. AFTER HAVING THE VEHICLE TOWED TO THE DEALER, I WAS INFORMED THAT THE GEARSHIFT IS NOT A SERVICEABLE PART AND THAT THE ENTIRE STEERING COLUMN WOULD NEED TO BE REPLACED. THE SERVICE REPRESENTATIVE STATED SHE HAD NEVER SEEN THIS ISSUE BEFORE, IT WAS NOT COVERED UNDER WARRANTY, AND THE COST FOR A NEW STEERING COLUMN AND ASSOCIATED LABOR WOULD BE MORE THAN $1,600. SHE ALSO INFORMED ME THAT A USED STEERING COLUMN FROM A JUNKYARD WOULD COST MUCH LESS, BUT THAT SHE WOULD NOT BE ABLE TO PROVIDE THE EXACT AMOUNT UNTIL EARLY MONDAY MORNING. ON MONDAY MORNING, I WAS INFORMED BY KRF SOUTH THAT THEY COULD OBTAIN A USED STEERING COLUMN AND THE TOTAL COSTS FOR PARTS AND LABOR WOULD BE $620. I CHOSE TO HAVE THE USED USED STEERING COLUMN INSTALLED DUE TO THE PRICE DIFFERENTIAL. SIMPLY PUT, A GEARSHIFT SHOULD NOT BREAK OFF FROM THE STEERING COLUMN THROUGH NORMAL VEHICLE USE. I BELIEVE THIS TO BE A SERIOUS SAFETY ISSUE THAT SHOULD BE ADDRESSED BY FORD. I WAS FORTUNATE ENOUGH TO BE ABLE TO TURN OFF THE IGNITION AFTER THE GEARSHIFT BROKE AWAY. HAD I NOT BEEN ABLE TO TURN THE VEHICLE OFF, I WOULD HAVE NEEDED TO REMAIN IN THE VEHICLE WITH MY FOOT ON THE BRAKE UNTIL I COULD GET ASSISTANCE. NOW I HAVE A REPLACED STEERING COLUMN, WITH THE EVERLASTING THOUGHT THAT THE GEARSHIFT COULD BREAK OFF AT ANY POINT IN THE FUTURE. I HAVE A WIFE AND 3 SMALL CHILDREN AND I AM HESITANT ABOUT HER USING THE VEHICLE DUE TO THE FACT THIS MAY VERY WELL HAPPEN AGAIN. *TR

STARTED EXPLORER TO BACK OUT OF DRIVEWAY AND THE GEAR SHIFTER BROKE OFF OF THE STEERING COLUMN. HAD TO REPLACE ENTIRE STEERING COLUMN FOR $1500. NO PREVIOUS PROBLEMS AT ALL. *TR

I OWN A 2005 FORD EXPLORER. THIS INCIDENT HAPPENED IN NOVEMBER OF 2009. THE FORD EXPLORER HAD APPROXIMATELY 80,000 MILES ON IT. I PULLED INTO MY SISTER'S DRIVEWAY WHICH IS A FLAT, GRAVEL DRIVEWAY. THE FORD EXPLORER IS AN AUTOMATIC TRANSMISSION. I SHIFTED THE CAR INTO PARK AND THEN EXITED THE FORD EXPLORER. AFTER EXITING THE FORD EXPLORER, IT STARTED MOVING BACKWARDS. THE OPEN DOOR KNOCKED ME DOWN AND THEN THE TIRE ON THE DRIVER'S SIDE RAN OVER MY LEG. MY SISTER RAN AND STOPPED THE CAR. THE GEAR SHIFT MOVED FROM PARK INTO REVERSE. *TR

THIS INCIDENT REFERS TO A 2005 FORD EXPLORER EDDIE BAUER VIN # [XXX]. AFTER MAKING AN INVESTMENT TO PURCHASE A VEHICLE, ONE SHOULD NOT HAVE TO WORRY ABOUT THE SAFETY OF HIMSELF OR FAMILY BECAUSE THE GEAR SHIFTER BROKE OFF OF THE STEERING COLUMN. THIS IS WHAT HAS HAPPENED TO ME, THEN GOING TO THE FORD DEALER FOR A PART AND BEING TOLD IT COST 1300.00 DOLLARS TO REPLACE THE ENTIRE STEERING COLUMN. WHEN THE CHEAP WHITE METAL THAT HELD IT TOGETHER JUST SHEARED OFF. DOES A DEATH NEED TO OCCUR TO DO SOMETHING ABOUT THIS? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

FROM THE ORIGINAL PURCHASE TO NOW 95K MILES I HAVE COMPLAINED OF A ONGOING PROBLEM WITH THE FRONT END OF OUR 2005 FORD EXPLORER SPORTS TRAC. THEY HAVE REPLACE A NUMBER OF PART AND CONTINUE TO TELL US THAT ITS A CHARACTERISTIC OF THE VEHICLE TO HAVE VIBRATION. I HAVE ASKED SEVERAL TIME FOR THEM TO TAKE THE VEHICLE BACK WITH THEM REFUSING. THEY HAVEN'T BEEN ABLE TO FIX IT. AS 100% DISABLED PTSD VETERAN I HAVE HIT MY LIMIT WITH THEM. THIS IS A PIECE OF CRAP AND I PAY ALMOST 600 A MONTH AND HAVE TO FIX IT ALL THE TIME. *TR

I WAS DRIVING ON 77 NORTH IN FANCY GAP, VA, WHEN SUDDENLY I LOST POWER STEERING AND ACCELERATION. I NOTICED SMOKE COMING FROM CAR AND IN FACT THE CAR IN FRONT OF ME SAID HE NOTICED BLACK SMOKE AND FLAMES UNDERNEATH THE CAR. I PULLED OVER TO THE SHOULDER AND THE CAR WAS IMMEDIATELY IN FLAMES. I EXITED THROUGH DRIVER SIDE DOOR. MY PASSENGER HAD TO EXIT THROUGH DRIVER DOOR AS WELL BECAUSE FLAMES WERE SPREADING ACROSS THE PASSENGER SIDE OF THE CAR. WE DISTANCED OURSELVES FROM THE VEHICLE AS THE ENTIRE THING BECAME ENGULFED IN FLAMES. CARROLL COUNTY FIRE DEPARTMENT AND VA STATE POLICE ARRIVED. IT TOOK OVER 45 MINUTES FOR THE FIRE TO BE EXTINGUISHED; THE CAR KEPT RE-IGNITING, EVEN AFTER SEVERAL APPLICATIONS OF WATER AND ANTI-FLAME CHEMICALS. THE ENTIRE VEHICLE MELTED, INCLUDING TIRES. NOTHING WAS SALVAGEABLE. THE VEHICLE WAS A 2005 FORD EXPLORER WITH ONLY 47,000 MILES. IT WAS METICULOUSLY MAINTAINED AND RECENTLY SERVICED. *TR

TL* THE CONTACT OWNS A 2005 FORD EXPLORER. WHEN ATTEMPTING TO START THE VEHICLE, THE ENGINE BEGAN TO SPUTTER. SHE RESTARTED THE VEHICLE TO RESUME NORMAL VEHICLE OPERATION. ON ANOTHER OCCASION WHILE DRIVING, THE POWER STEERING AND BRAKES FAILED WITHOUT WARNING, WHICH CAUSED HER TO CRASH INTO A FENCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR INSPECTION ON TWO SEPARATE OCCASIONS. THE FAILURE WAS CONTRIBUTED TO THE FUEL SENSOR AND THROTTLE POSITION SENSOR. THE THROTTLE POSITION SENSOR WAS REPLACED. THE REPAIR DID NOT REMEDY THE FAILURE. THE FAILURE MILEAGE WAS 45,000. THE CURRENT MILEAGE WAS 80,000. THE VEHICLE IDENTIFICATION NUMBER WAS UNAVAILABLE.

WHILE DRIVING FOR THE ORGANIZATION MEALS ON WHEELS, I PROCEEDED TO TRY AND SHIFT FROM PARK TO REVERSE AND THE STEERING OR GEAR SHIFT LEVER SNAPPED OFF. I WAS UNABLE TO PUT MY CAR INTO GEAR AND CALLED A TOW TRUCK WHICH TOWED THE CAR TO A FORD DEALERSHIP FOR REPAIRS. I AM WAITING FOR AN ESTIMATE FROM THE SERVICE CENTER. *TR

DT*: THE CONTACT STATED WHILE THE VEHICLE WAS PARKED, FLUID WAS DISCOVERED ON THE DRIVEWAY FROM AN UNKNOWN SOURCE. UPON FURTHER INSPECTION, THE STEERING GEAR BOX WAS LEAKING POWER STEERING FLUID. ALTHOUGH THE VEHICLE WAS NOT SEEN BY A DEALER, THE CONTACT CONTINUED TO MONITOR THE POWER STEERING FLUID LEVEL.

DT: THE CONTACT STATED WHILE HIS DAUGHTER WAS DRIVING A 2005 FORD EXPLORER SPORTS TRACK AT 20-25 MPH THE FRONT PASSENGER WHEEL FELL OFF. THE CONSUMER STATED THE KNUCKLE BEHIND THE WHEEL BROKE. THE ZONE MANAGER FOR THE FORD MANUFACTURER STATED THAT THE DRIVER MUST HAVE HIT SOMETHING FOR THIS TO HAPPEN. THE CONSUMER STATED THE DRIVER DID NOT NOTICE ANY INDICATION THAT THERE WAS A PROBLEM WITHIN THE VEHICLE. THE CONSUMER CONTACTED THE MANUFACTURER, AND ACCEPTED THE RECOMMENDATION OF THE ZONE MANAGER. *AK