2020 Chevrolet Silverado 1500 Engine Problems

Your engine suddenly shut off while driving at highway speeds with no warning, forcing you to coast across two lanes of traffic to reach the shoulder. The dealership diagnosed this as engine seizure caused by bearing failure due to oil starvation — a documented issue with the 6.2L V8 engine in your model year, though GM has only issued recalls for 2021-2024 models. Repair will likely require a complete engine replacement covered under warranty or GM's goodwill program.

Your engine suddenly seized and completely stopped working without any warning lights or gauge alerts appearing beforehand. The dealership confirmed that the engine has seized up and will need significant repair or replacement.

Your engine is making loud knocking sounds and has lost all oil pressure, which indicates severe internal engine damage. A mechanic has determined that the engine will need to be replaced rather than repaired. This typically involves removing the damaged engine and installing a new or rebuilt engine block with all associated components.

Your engine's lifter failed while driving on the highway, causing a sudden loss of power during rush hour traffic on a multi-lane interstate. This near-miss with other vehicles could have resulted in a serious accident. The repair will likely involve replacing the failed lifter and inspecting the engine for any related damage.

Your engine experienced a major failure when a lifter failed, which caused metal debris to spread throughout the engine. This damage was severe enough to require a complete engine replacement.

Your 2020 Silverado 1500 lost engine power while driving at about 25 mph, and your check engine light came on. The dealer diagnosed a complete engine failure at approximately 89,000 miles. The repair was not completed due to cost, but the manufacturer has been notified and a case was filed.

Your engine shut down while driving at 40 mph, but restarted after you turned the truck off and back on. A few days later at 75 mph on the highway, your truck shook violently, the check engine light flashed, and the engine made ticking and groaning sounds. When inspected, cylinder 5 wasn't firing properly and had severely damaged itself internally. Your truck needs a complete engine replacement.

Your engine failed while you were driving on the interstate towing an RV, which created a dangerous situation. This appears to be related to known issues with the 6.2L engine. Chevrolet replaced the engine, but you had to pay for it yourself rather than having it covered under warranty.

While driving on the interstate in the early morning, your engine suddenly made a loud noise and lost power, preventing you from accelerating normally—creating a dangerous situation with traffic behind you. Your Chevrolet dealer found that an engine lifter had broken and damaged the camshaft, with no warning lights appearing beforehand. The repair will likely involve replacing the broken lifter and inspecting or replacing the damaged camshaft.

Your 2020 Silverado 1500 with an L87 engine is experiencing power loss and noisy engine sounds at startup, similar to issues covered under recall for 2021 models. The dealer determined the engine needs significant internal repairs including pistons, rings, bearings, gaskets, and seals, but GM has only authorized repair parts rather than full engine replacement because your model year isn't part of the recall. Your truck became unable to start at 68,833 miles and required towing to the dealer. The repair will likely involve disassembling the engine and replacing the internal components identified by the dealer.

While driving at 40 mph, you heard a loud banging noise from your engine. A dealer diagnosed the problem as worn lifters and camshaft that need replacement. This issue occurred at 120,000 miles. Fixing this will require the dealer to remove and replace both the lifters and camshaft.

Your engine and right side valve lifters completely failed while your truck was parked, with no warning lights to alert you beforehand. You've experienced ongoing engine problems since 2022, and the dealer confirmed this is a known issue with your truck's year and model that GM hasn't recalled yet. The fix will likely require engine repair or replacement and lifter inspection/replacement by a certified technician.

Your engine's lifters have failed, causing a noticeable loss of power while you're driving. This is a serious engine problem that requires professional repair to prevent further damage. The repair will likely involve removing the valve cover and replacing the failed lifter components.

We own a 2020 Silverado with a 6.2L L87 engine… I am aware of open investigation # EA25007… Our vehicle had sudden engine failure.. no prior warning lamps before failure. (Our vehicle had no open recalls) Once vehicle engine failed left us with no power… had to coast vehicle to a stop. Will not restart. Verified proper oil level on dipstick so vehicle was not low on oil. Had to tow vehicle to shop .. retrieved code P0016 - crankshaft position Oil pan was removed and found bearing material as mentioned by GM issued recall 25V-274. Verified oil pickup tube was not clogged. All symptoms explained by 25V-274, we’ve experienced.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that immediately after leaving the dealer after the vehicle was purchased, the check engine warning light illuminated. Several days later, there was a loud knocking sound coming from the engine before the engine failed. The contact referenced NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); however, the VIN was not included in the recall. The vehicle was taken to a dealer and an independent mechanic, but was not repaired. The vehicle had experienced catastrophic engine failure. The check engine warning light was displayed, and audible knocking was coming from the engine. The manufacturer was notified of the failure. The failure mileage was 153,000.

At highway interstate travel speeds, vehicle was losing intermittent power. Exhaust at stopped, idle during trip smelled heavily of gasoline. White smoke blowing from exhaust with only 38k miles on the truck. Dealership is replacing the entire engine now and sounds like GM doesn’t want them to fully explore the cause of failure.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving 75 MPH, the vehicle lost motive power with a tapping sound coming from the front passenger’s side of the vehicle. The message "Monitor Brake Service System" was displayed. The vehicle was pulled over to the side of the road and inspected, but no failure was found. The vehicle was taken to an independent mechanic, where it was diagnosed and determined that the lifters and camshaft needed to be replaced. The vehicle was not repaired. The vehicle was taken to a different independent mechanic, where it was diagnosed and determined that the lifters and camshaft needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 160,000.

I pulled up to a traffic light at a busy intersection in Lubbock, TX, and the engine just shut down on approach to a red light. The vehicle still had power (radio, headlights, AC/heater, etc.) but the engine would not start or even turn over and try to start. The vehicle was towed to a Chevy dealership in Lubbock, TX, and they said they believed it was an internal engine failure but wouldn’t be able to look at it for several weeks. I had it transported to my hometown in Taylor, TX, and my certified mechanic replaced the starter and battery solenoid but the engine still wouldn’t start. They drained the oil and found metal shavings in the oil. They too believe that the engine suffered a catastrophic failure and needs to be replaced.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, the vehicle unexpectedly sputtered. There were no warning lights illuminated. The dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The approximate failure mileage was 73,000.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while his son was driving 75 MPH, there was a knocking sound coming from the vehicle. The driver pulled over and turned the vehicle off, but the vehicle failed to restart. The check engine warning light was illuminated. Upon researching the failure, the contact associated the failure with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The vehicle was towed to the local dealer, where it was diagnosed and determined that the engine had seized. The vehicle was not repaired. The manufacturer was contacted and confirmed that there was no recall coverage on the VIN for the failure. The failure mileage was approximately 165,000.

The 6.2L engine failed. The same as the 2021-2024 recalls.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving approximately 65 MPH, the vehicle started to hesitate with several unknown warning lights illuminated. The contact stated that there was a misfire in the engine, and her husband pulled off the roadway and turned off the vehicle. The vehicle was restarted and driven back to the residence at speeds no greater than 50 MPH. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the left engine lifters had collapsed and needed to be replaced. The contact was advised by the dealer that the right-side engine lifters should be replaced while the engine was disassembled. The vehicle was not yet repaired. The manufacturer was informed of the failure. The failure mileage was approximately 96,000.

The truck had a lifter failure which caused the pushrod to bend damaging the camshaft as well. I spent $5000 dollars just for the problem to happen again. I’ve have spent nearly $10000 on this issue. This not something you expect from a truck that you pay nearly $60000 for.

Driving on highway truck lose power, engine lights start to flash and cracking noises start to come from engine. The lose of speed almos cause another vehicle to rear end me, Truck gave no signs or warnings before. Truck was delivered to a local shop and due abundant amount of metal flakes in oil engine need to be replaced

GM declared my original engine as unfixable and decided to replace my engine luckily with 2 weeks remaining in warranty. It had similar clicking noise to everything else I've seen related to this 6.2L having issues. It currently has a new engine that can be inspected if need be. As well as receipt given to me from Klein Chevy from engine replacement. My engine could've failed while driving if I didnt notice the clicking noise prior to getting it looked at. Putting other in danger if driving on a public roadway. Yes the noise/defect was reproducible upon dealer looking at it. Unsure if the vehicle was inspected by the actual manufacturer but they removed my motor and sent it back to the factory. Was never inspected by police or insurance that im aware of There was no check engine light or warning lamps, only thing I noticed was a clicking noise that the common layman would have probably missed, they appeared roughly around 46,000 miles.

Engine Failure 6 Nov 2025 Yes, engine is available for inspection. Possible loss power, unable to control the vehicle. Vehicle engine failure has been confirmed by dealership, Ruben Milton Chevrolet and Jim Hudson Cadillac in Augusta Georgia. Vehicle has not been inspection by manufacturer, police, insurance representatives. No warning light, no knocking noise, no messages on dashboard.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while starting the vehicle, there was an abnormal odor coming from the vehicle. Upon inspecting the vehicle, the contact became aware of coolant leaking from the front of the vehicle near the transmission, with the check engine warning light illuminated. The contact retrieved DTC: P0016. The vehicle was taken to the dealer, where it was diagnosed, and determined that the coolant control valve, motor mount, and camshaft timing had failed. The dealer informed the contact that the coolant control valve, motor mount, and wiring harness needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The approximate failure mileage was 88,000.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that upon starting the vehicle, there was an abnormally loud engine camshaft bearing sound coming from the engine. The engine warning light was illuminated. The vehicle was taken to the local dealer, and after three days, it was determined that the camshaft bearing had failed, and the engine needed to be replaced. The vehicle was not repaired. The contact linked the failure with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling) and NHTSA Action Number: EA25007 (Engine and Engine and Engine Cooling). The manufacturer was contacted and opened a case. The failure mileage was approximately 45,000.

What component or system failed or malfunctioned, and is it available for inspection upon request? Based on information from ODI Resume EA25007 & Safety Recall N252494002, it is more than likely engine connecting rod bearing failure. How was your safety or the safety of others put at risk? I was traveling at freeway speed, 70mph when it occurred. Has the problem been reproduced or confirmed by a dealer or independent service center? 11/25/25 at 12:33 (pacific), I am currently stranded 190 miles from home and waiting for the truck to be towed to the dealer. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? It has not. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? Prior to Failure: Since I’ve owned the vehicle, I’ve notice slight ticking and slight knocking during cold start within the engine bay. At the time the noises seemed normal and not cause-for-concern. At Time of Failure: I was traveling on level grade on the highway when I heard a deep knock from the front, bottom left side of the engine bay. Within about a minute from the initial noise, I received a “check engine” warning light and a message of “ESC Warning” displayed on my instrument cluster. At that moment, I noticed the engine noise become more prevalent and constant. I immediately slowed and coasted to my next exit off the freeway.

The Engine began to make a knocking noise at ~62000 miles on the odometer. I assume it was bearing failure. MURREY CHEVROLET GMC diagnosed the problem as catastrophic engine failure with the repair being a replacement of the engine. There were no warning lamps. This is a 2020 Chevrolet Silverado High Country with the 6.2L engine.

Fan started running non stop, we overheated, engine cut out and says reduced power. This diesel engine has 80k miles which is nothing for a diesel.

Loss of power when driving and a shutter feeling when accelerating. I took the vehicle to the dealership for repairs and was told the torque converter was replaced due to it being faulty but problem still persists.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while his son-in-law was driving 61 MPH, the vehicle made an abnormal clanking sound and stalled. The driver pulled over safely. The OnStar Mobile App alerted the driver of an issue with the vehicle. The contact stated that the vehicle was making an abnormal ticking sound prior to the failure. Upon arriving to the location of the vehicle, the contact noticed an oil leak underneath the vehicle. The contact stated that he was a certified mechanic, and the vehicle was towed to the contact's Auto Repair Shop, where the contact determined that the rod had gone through the engine block. The contact called an unknown local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 80,000.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving approximately 40 MPH, there was an abnormal pop and ticking sound coming from under the hood. The check engine and several other unknown warning lights were illuminated. The vehicle was taken to a local independent dealer, where it was diagnosed with a failure in cylinder #7 and piston failure. The vehicle was not repaired. The local dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 99,600.

Driving at normal highway speeds, "service parking brake", "service engine", and "electronic stability control" lights illuminated on the dash with no prior warning. When attempting to accelerate, to maintain highway speed there was noticeable roughness to the engine along with a tapping sound. I slowed and made the trip back to my home under reduced power. The vehicle was towed to the dealer the following day per the dealer's service advisor instructions. Issue was diagnosed as a collapsed lifter, bent lifter rod and damaged cam lobe. Total repair cost exceeded $10,000. Internet search of this issue reports a number of drivers reporting similar issues with the Chevrolet 5.3 liter engine. If this issue had occurred in a more congested traffic area it could have caused an accident when my engine power was suddenly reduced without warning.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated while driving at various speeds, the vehicle was shaking and vibrating abnormally. There was no warning light illuminated. The contact stated the failure was a recurring failure. The vehicle was taken to a local dealer and the contact was informed that the oil level was low, and oil was added. The dealer had not diagnosed the vehicle. The contact stated that the failure reoccurred. The contact had been checking the oil level and was constantly adding oil. The contact stated that the same dealer had changed the spark plugs and fuel injectors in January 2025. Recently the contact was unable to start the vehicle, and the vehicle was towed to the same dealer. The vehicle was not diagnosed; however, the dealer advised that the failure might have occurred due to a failure with the transmission. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 136,888.

Lifter failure

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving 70 MPH and depressing the accelerator pedal, the engine failed and shut off independently. An independent mechanic and dealer were contacted. The vehicle was towed to an independent mechanic, and the contact was informed that the crankshaft had melted. The vehicle was then towed to dealer, where it was diagnosed and determined that the crankshaft had melted and there was a rod bearing failure. The engine was replaced, and the vehicle was repaired. The contact related the failure to NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING); however, the VIN was not included in the recall. The manufacturer was notified of the failure but offered no assistance. The contact was referred to the NHTSA Hotline to report the failure. The failure mileage was 76,000.

Coolant control valve failure. Dealer inspected vehicle and it was confirmed that it needed to be replaced. Check engine light came on fan started spinning at a high speed and the vehicle went into low power mode. When I spoke with the dealer, this is a known issue so much to the point where the cooler control valve is on backorder and I’ve had to wait for over a month now. Projected cost to replace with labor is over $3000.

While driving the active fuel management changed my truck from 4 cylinders to 8 cylinders. This is when I heard a loud bang and a bunch of lights came on the dash and my truck started shaking and shuttering. I was able to regain control of it, but I came close to crashing. I now require a whole new engine at 100000 miles. After talking to multiple shops this ks a known issue. While they dont always catastrophic fail, mine did and almost cost me to crash. This is a serious safety concern.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving 55 MPH, several unknown warning lights illuminated. The vehicle was towed to the dealer where it was diagnosed. The dealer became aware of an abnormal sound coming from the lifters and camshaft, which failed to create a misfire. The contact was informed that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was not notified of the failure. The failure mileage was approximately 68,000.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while operating the vehicle, there was an abnormal rattling sound coming from the engine compartment. The vehicle was driven to the local dealer, who diagnosed the vehicle and determined that the engine was faulty and needed to be replaced. No further information was available. The vehicle was not yet repaired. The manufacturer was notified of the failure. The contact was informed of NHTSA Action Number: PE25001 (ENGINE, ENGINE AND ENGINE COOLING). The contact indicated that the vehicle had experienced the failure listed in the recall. The failure mileage was 60,000.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, there was a loud knocking sound coming from the engine compartment, and the vehicle shook violently, with several unknown warning lights illuminated. The vehicle was taken to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and referred the contact to the NHTSA Hotline for further assistance. The failure mileage was approximately 84,000.

My problem is the same as many others with the 3.0 Duramax engine. I h e the P0016 code indicating the the timing chain that can cost up to $10k and sudden engine failure if not repaired. My vehicle is only 5 years old and has 98K miles at the moment.

I was on a trip to Iowa and noticed a loud ticking noise starting in my engine. There was no warning lights on the dash to indicate any problems. I checked the oil and notice it was not registering on the dip stick. I added over a quart of oil and the noise continued. My truck was just at a dealer 2 weeks prior for an oil change and they noted that everything was good and in proper working order. No leaks or no other issues. I set up an appointment at a chevy dealer at the destination which I was traveling to for a check up. About 60 miles from the dealership, my check engine light went on. I immediately stopped and checked all my fluids which were showing normal ranges. I dropped my truck off for inspection and they advised me that my lifters need to be replaced. I authorized the repair and after the new ones where installed, they tested my truck and noticed that there was still a ticking noise coming from the engine and was not holding any oil pressure. They advised me that the motor needed to be replaced at a cost of almost $15,000. I will request all pictures and videos taken by the dealership for further inspection if needed.

Had sudden engine failure at 82k and have been told I need a new engine. Can't afford it, GM says there's nothing they can do to help cover the repairs. I have a new engine on backorder, nobody knows when it will be in, they told me they have other customers who have been waiting for new engines for months.

While driving in Southern Utah my truck gave me a Service ESC (Electronic Stability Control) Warning, Service Parking Brake Warning, and check engine light that was for code P0303. I had the vehicle towed to the local Chevrolet dealership and it was diagnosed with lifter failure and camshaft damage because of the lifter failure. Safety was compromised because of the failure of the ESC and the loss of power and stability of the engine. I didn't receive warnings prior to the failure. This appears to be a well-known issue with several service bulletins issued for the vehicle.

There was a significant oil leak that was diagnosed during a routine oil change in March of 2025. The dealership that identified the leak attempted to pass it off as something that was out of warranty even though the vehicle had an additional six months and 45,000 miles of warranty (3.0 diesel). The leak was significant enough that loss of oil could cause the engine to fail and result in a crash. Subsequently, another dealership identified the leak and repaired the seal around the lower crankcase. It did not repair the oil leak- there are three additional reports/complaints to file.

This is for the second oil leak that occurred in the 2020 Chevrolet Silverado with the 3.0 diesel engine. It was identified as a leak in the oil pan. The previous repair was for the lower crankcase seal. The service advisor at the dealership stated this is another problem area with the Chevrolet 3.0 diesel engine, and a defect from the manufacturer. He also mentioned it is a common repair they complete on these LM2 engine. It is worth noting, the initial repair didn't last 60 days before another oil leak presented itself. This is the second of four repairs that were done on this vehicle. **No loaner vehicle was given during the repair.**

The second oil leak repair and the first repair for the oil pan failed within one week of the previous repair. This is the third oil leak that occurred in the LM2 engine in the 2020 Silverado. It was identified as an additional leak in the oil pan which had already been repaired the week prior. This is a failure within seven days from the previous repair. I lost 1/2 quart of oil during a 650-mile drive back from vacation. I took pictures of the oil level before leaving and driving home. During our drive, we passed through an area called Yermo where it was 107 degrees at 11am. The two closest Chevrolet dealerships are either 45 minutes or 1.5 hours one-way. I was incredibly frustrated since imagine being stranded in 107-degree weather with your family on the side of the road unable to run AC. It is a serious life, health, and safety issue at this point. I called GM and opened a case expecting them to assist me with the issues with the truck. Fast forward to today, I spoke with Jill at GM, they closed the case without even reaching out to me. This was the third of four oil repairs that have been conducted on my vehicle and the LM2 engine. It isn't a safe engine to have. **No loaner vehicle was given during the repair.**

After three oil leak repairs in my LM2 3.0 diesel engine in my 2020 Chevrolet Silverado RST, you would think that would be enough to repair the manufacturer's defects, but it wasn't. I think the saying is fourth time is the charm? The third repair which was a second oil pan lasted a whopping 48 hours before leaking. This time it ended up being the timing chain cover that was leaking. Again, the service advisor mentioned that these are known to leak too due to a defect from the manufacturer. I even got a call from the service manager, and he said that anything area that could and does leak oil on these LM2 engines has been replaced and/or repaired, so I should be good for the future. I called into GM as per their instructions to update them on the fourth oil leak, and where the repairs were taking place. Fast forward to nearly two months later, and no one from GM attempted to contact me, and Jill stated that the case was closed and wouldn't disclose why. The only thing she could do was open another case. I declined since GM couldn't be bothered to address the issues they know they have in the LM2. The dealership the work was done in, the service advisors, the service techs, and the service manager all discussed in great detail the issues Chevrolet is having with the 3.0 diesel engine. GM knows this and refuses to address this. At this point, my vehicle spent 37 days in 2.5 months at the dealership fixing oil leaks that at any time could have caused engine failure and resulted in a crash. This truck is our dedicated family vehicle as my wife and I each daily Subaru WRX's. GM has done nothing and will do nothing. Someone needs to issue recalls to address the oil leak issues with the LM2 before it results in someone's death. I wish I wouldn't have wasted time contacting GM. I should have filed these complaints and got legal representation for the Magnuson-Moss Warranty Act. **NO loaner vehicle was given during the entire 37-day repair duration.**

Motor suddenly loss power and load knocking noise. After taking it to the dealer they said that number 3 cyl.connecting rod had an issue . This sounds like the same recall for the 2021 to 2024 6.2 engines. They gave me a quote for a new engine ( 20000) that was not available for 4 to 5 weeks if not more. I was on vacation at the time and ended up buying a new truck from them. I was not happy.

Lifter failure on the 5.3L L84 engine. Due to Dynamic fuel management that come with the trucks.

Having failure with the engine coolant control valve. Have taken my truck to the dealership for overheating and they always come and say that they can’t find an issue. They also informed me that I need to bring it back when my motor blows a head gasket which is complete bull.

About 3 months after the 5 year 100000 mi warranty with only 70000 miles on the duramax diesel engine the exhaust brake part of the engine emissions/exhaust split along the weld. Have seen a number of these reported on the internet as well. Sounds like a manufacturing problem. The vehicle's check engine light came on and it's now at the dealership getting a new exhaust brake housing and bracket replaced. If this was in California or the 12 states listed would be covered for 8yrs/100000 miles.

Engine seized my truck has been at the Chevorlet Tempe dealership I filed a claim with GM still no response.

My 2020 Chevrolet Silverado 1500 LT with the 3.0L Duramax diesel engine has experienced three separate failures of the coolant control valve over a span of less than two years. Each failure resulted in the vehicle entering reduced engine power mode, which drastically limits acceleration and the ability to maintain safe driving speeds — particularly dangerous on highways or in heavy traffic. Chronology of Failures: October 2023: First coolant control valve failure. Part was backordered. Repair took ~6 weeks. June 2024: Second failure of the same part. Another 6-week delay in repair due to part availability. June 2025: Third failure of the same part. Vehicle is currently inoperable and unsafe to drive. Each time, the failure triggered a check engine light and immediately placed the truck into reduced power mode. This issue significantly compromises driver safety, especially in high-speed or congested environments, where limited acceleration can increase the risk of collisions. Safety Concerns: Loss of acceleration power at critical times (merging, overtaking, etc.) Unpredictable vehicle behavior Extended unavailability of parts leads to prolonged periods without a functional vehicle Possible underlying design flaw or recurring part defect Given the recurrence, safety risks, and the number of similar complaints I have seen from other owners, I believe this is a widespread and systemic defect that deserves NHTSA investigation. Requested Action: I urge the NHTSA to investigate the frequency and root cause of coolant control valve failures on the 3.0L Duramax engine in the 2020–2022 Silverado models. This is not an isolated incident, and repeated failures of a critical engine cooling component warrant a safety recall or technical service bulletin (TSB) requiring redesign or replacement with a permanent fix.

Lifter failure and miss fire

Was driving on the interstate on [XXX]. While driving, the truck suddenly slowed down and lost power. The check engine light came on and then after about a minute a message popped up on the dash saying that the truck was in reduced-power mode to prevent engine damage, or something like that. It slowed to roughly 50mph and I had to drive for maybe 5 miles to reach the next exit, narrowly avoiding collision from behind with cars driving upwards of 75. Pulled off the road to the first parking lot, then got towed to the nearest Chevy dealership in Shawnee, Oklahoma. The diagnosis was a blown connecting rod that had occurred while driving on the interstate, resulting in a necessary total engine replacement. The truck was repaired in Shawnee, Oklahoma at the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving my truck the engine completely shut down. All the dash lights came on initially but then only the check engine light stayed on. My truck never would start back up after that. It was towed to GM dealership who diagnosed catastrophic engine failure.

2020 Chevy Silverado LTZ 6.2 V8 10 Speed. Started having issues with hesitation/shudder. Dropped off at a Chevrolet dealership for a diagnostic. The dealership pointed to a potential transmission issue. After having the truck for several days, they reported nothing wrong. Said they drove the truck, checked the transmission fluid, and couldn't find any issues. Picked up the truck and took it to a local repair shop. That shop drove it, but could not re-create the issue I was describing. I opted to have the transmission fluid flushed in hopes of fixing the shudder/hesitation I was feeling. After picking up the truck and driving it a couple hundred miles, the issue was still present. I made another appointment at the same local shop. This time, they called me saying the issue I'm feeling is the same problem that's been happening to these engines, the dreaded AFM (Active Fuel Management) system is starting to fail. I was told by the shop it's only a matter of time before the entire engine fails. The only way to fix the issue is to delete the AFM system by removing the old parts within the engine and replacing with new parts that do not use the AFM system. This would cost approximately $6,000 to complete.

Was driving on highway and vehicle went into "engine power reduced" and dropped from 60mph down to 35mph and then steadily decelerated down and wouldn't go over 18mph. Per mechanic it is the engine coolant control valve and the part is not available and could be months to a year before the part is available. Online shows this is a widespread issue with GM / Chev vehicles but no recall has been ordered and parts not available anywhere. Completely unacceptable to pay $65000 for a vehicle that is just barely 5 years old and have this kind of issue and manufacturer doing nothing about it.

Oil pump went out. Got it repaired. Then, a few days later, while driving on the freeway at 70MPH the engine made a lot of noise then quit in middle of the freeway leaving me vulnerable to being hit. Was able to coast in neutral to the edge of the road. Has 73000 miles on it. Dealer says I need an engine replacement after just spending $5,500 for oil pump replacement. Has been at the dealer over a month and no replacement engine is available.

The engine seized up. Yeah, the truck is at a trusted mechanic and he told me that the engine seized. No warning signs. The truck wouldn't start and the engine light was on.

The lifters failed which caused the camshaft to destroy itself. I am now looking at having to replace my entire motor because of this. This is a similar problem to the current recall going on with the 2021 through 2024 trucks with the same motor. I have 146,000 mi on my truck

Cylinder Four misfire code. PO304 Dealer has discovered lifter failure. Total to replace all lifters on effected side $4300.00 Vehicle is garage kept and serviced per required dealership. All service records have been kept. No other issues with Truck 83K miles.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, there was a ticking sound coming from underneath the hood of the vehicle. The contact stated that the sound was evident when the vehicle was started, and while the vehicle was idling. The check engine warning light was flashing, and the vehicle was shaking while idling and while driving at various speeds. The vehicle was taken to the dealer, who diagnosed that the engine had failed due to a failure with the lifters. Additionally, there was coolant leaking into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was 79,400.

Lifter issues, loss of power, flashing check engine light

On [XXX] I pulled off from a Red Light and vehicle started flashing codes. I slowed down and engine was missing. I had vehicle towed to Gilmore's Auto Center in Culpeper Virginia. The truck was diagnosed later that day as a Rod Bearing failure. The engine gave no warnings prior to that day. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated after an independent mechanic had performed an oil change on the vehicle, the vehicle was moved and parked. The contact stated that upon attempting to start the vehicle, the vehicle failed to start. The mechanic diagnosed that the engine had seized and there were metal shavings in the oil. The vehicle was towed to the dealer, where it was diagnosed that the engine needed to be replaced. The dealer informed the contact that the manufacturer had denied coverage because the vehicle was previously serviced by an independent mechanic. The vehicle was repaired at the contact's expense. The contact related the failure to NHTSA Action Number: PE25001 (Engine, Engine and Engine Cooling). Additionally, the contact stated while idling and while driving at various speeds, the vehicle made an abnormal whining sound. The vehicle was taken to Bomnin Chevrolet Dadeland (8455 S Dixie Hwy, Miami, FL 33143), where it was diagnosed that the transmission was failing and there were metal shavings found in the transmission. The dealer replaced the transmission. The vehicle was repaired. The manufacturer was not contacted. The failure mileage was approximately 25,000.

chevy has a well known issue with lifters failing in the 5.3 motor because of the afm. it has failed on me twice and had to pay twice to get this fixed and i’m concern one day the engine will just blow like other people have complained about. i even went to the dealership and even spoke to the part department and they have admitted this but no fix for it has been put in place. we need a recall on this motor that’s effecting thousands of people.

While highway driving on 4/8/2025, for the 3rd time in 3 months, engine light came on and I lost all control of my cruise control, parking brake disabled and loss of engine power immediately reducing my highway speed to approximately 50 mph which was very dangerous. I had to cautiously return home & called the Chevy dealer immediately. They had repaired the lifters twice before, with the most recent repair on the lifters and push rod just one month earlier. This second repair was covered under their repair warranty. Currently, it took about 10 days before a loaner car was available (after a poor google review). To date (4/30/2025) I have not received ANY feedback from the dealer (Starling Chevrolet in Mt. Pleasant, SC) regarding any repair or engine diagnosis. The symptoms of this third failure was just like the previous two failures (3 failures in 3 months!). I feel like this vehicle has Major issues as I have also had to have the radio/infotainment system replaced twice since the original purchase. PLEASE have Chevrolet do an engine recall on their 5.7 liter engine!!

While traveling on a rural state highway, the #8 lifter bearing failed, causing the engine to lose considerable power and the dash light to come on. No advanced warning of engine problems was noticed prior. The transmission also went into limp mode not allowing the vehicle to shift gears. At the same time the ABS and ESC systems also went into a safety mode diminishing the stopping power of the vehicle. Upon inspection by a licensed mechanic it was discovered that the #8 lifter bearing and the camshaft were both damaged at that time. Total replacement cost was over 10k and it took almost 6 months to find a rebuilt L87 engine at that time because there was almost no supply available as a result of these engines having multiple failures nationwide

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that after starting the vehicle, the engine made ticking and knocking sounds while idling. No warning light was illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the year and VIN were not included in the recall. The manufacturer was made aware of the failure. The failure mileage was approximately 59,000.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that when the vehicle was started, there was an abnormal rattling sound coming from the engine compartment. The contact stated there was no warning light illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the cam shaft, rod bearings, and lifters had failed, and the engine needed to be replaced. The vehicle was repaired. The manufacturer was informed of the failure and referred the contact to the NHTSA Safety Hotline to report the failure. The failure mileage was 71,773.

The engine failed while I was driving. It started to run very rough and then the check engine light came on as well as multiple other lights. I limped it to my mechanic who found that cylinder #4 had failed and rotated which tore up the cam shaft. Total damages came to 10,404.28. I have all receipts. Safety for myself and others were impacted because it lost power immediately and could have put me or other motorists in a position to react quickly not to crash.

Engine (v8) lost power and made terrible noise at 72,000 miles. Dealer installed a remanufactured engine and charged me $5109 and took 12 weeks to complete the work. GM claimed there were “unaware” of any issues with these engines even though an internet search showed tons and f people with the same problem.

The 2.7L turbo engine failed. The truck is available for inspection. All maintenance has been up to date. It was recently serviced for a seperate recall. The truck gave a reduced engine power message and within minutes lost power. A truck of this age, with maintenance done regularly should not experience engine failure.

The engine seized unexpectedly and without warning during driving. Being sudden and without warning it risked the occupants of the vehicle being injured as they struggled to get off the road and out of harms way on the road. The vehicle was taken to the nearest Chevrolet dealer to be inspected where we were told that the engine had suffered a total engine failure and would need to be replaced entirely. The vehicle WAS inspected and damage confirmed by the dealer at that time. Prior to the failure there were no warnings of any kind.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving 50 MPH and making a turn in the opposite direction, the vehicle lost motive power and there was an abnormal knocking sound coming from the engine. There was no warning light illuminated. The contact was able to pull over to the side of the road. The vehicle failed to restart and was towed to the dealer, where it was diagnosed and determined that the rod and the lifters had failed, causing damages to the upper half of the engine. The dealer replaced the gaskets, the rods, the guides, the lifters, the camshaft, and the transition kit. Additionally, and oil change was performed. The vehicle was not covered under warranty and was repaired at the customer's expense due to the mileage. The contact stated that while driving approximately 65 MPH on another occasion, the vehicle made an abnormally loud clunking sound and lost motive power intermittently. There was no warning light illuminated. The contact pulled over to the side of the road. The contact drove back to the residence. The vehicle was taken back to the dealer, where it was diagnosed with cylinder #8 intake valve failure. The vehicle was repaired at the contact's expense. The manufacturer was notified of the failure and a case was filed for the cylinder #8 intake valve spring replacement. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 86,000.

6.2 L Engine Failed and is at the Dealership. Technician said a lifter had dropped damaging the intake and the cylinder wall. The problem has been identified by a Dealership Service Center. Only inspection has been by the Dealership. No warning messages pryor to failure. Engine light and some messages came up right when it happened.

-Cylinder number 5 piston failure -Cylinder number 5 cylinder failure -Cylinder number 5 injector failure Vehicle was traveling at roughly 70 mph, everything operating normally. Suddenly check engine light came on, multiple traction control lights, cruise control disabled. Vehicle started to sputter and grey smoke showed out of the exhaust. Pulled over and shut vehicle off, checked oil and coolant level both were normal. Motor temp was slightly above normal. Restarted vehicle and it continued to sputter and smoke. Local shop ran codes that showed injector number 5 loss of signal. Upon further inspection a camera was sent down the number 5 cylinder, cylinder had excessive damage and metal fragments. Large amount of oil seen both on top of piston and on spark plug. It was determined that motor will need to be replaced.

Front main bearing failure. I have 97,000 miles on my truck. I have the 6.2 engine in it. I see online that GM is having a lot of issues with this engine. My dealer is trying to help me deal with GM, but GM does not want to replace my engine. They want me to pay for it. This issue could have been bad if I was driving at highway speeds with my 2 young daughters in my vehicle with me. Definitely a safety issue.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving at various speeds, there was a ticking sound coming from the engine compartment. The contact stated that the sound later became an engine knock, and the vehicle stalled. The vehicle was towed to the local dealer, who diagnosed the vehicle and determined that the engine had failed and needed to be replaced. The vehicle was not repaired and was later towed back to the residence. The manufacturer was not yet contacted. The failure mileage was 75,718.

Engine shut off while driving home from work on15 October 2024. Driving home while raining. Engine just stop and wouldn't start again.

From the time my vehicle had 30,000 miles on the engine, the engine light would come on and stay on with no apparent reason. I would take my car to my local Chevrolet dealer each time (by this time the light had gone out) and they could not find a problem. One technician told me that it sounded like a lifter problem that they were experiencing with these model vehicles. This happened approximately 8 to 10 times before the lifter failed. In January 2025, while driving on the Interstate Highway I experienced a sudden engine vibration and immediate 50% loss of power. Upon returning home, I took my truck to my local Chevrolet dealer where I purchased my vehicle. Upon inspection, I was told that it was apparent that a hydraulic lifter had failed. I left my vehicle at the dealership for the repair of the failed lifter which cost me $4,800. Two months later, I experienced the same problem with the engine, more violently vibrating. I again took my vehicle to the dealership and they confirmed another lifter had failed and took it in for repair under warranty from the prior lifter repair. I had again experienced more than 50% engine loss and had to get off of the interstate and travel on a side road because I could not maintain a speed over 45 to 50 mph. They repaired the same failed lifter bank that they had repaired the first time. Now, I am holding my breath, just waiting for the lifters on the other bank to fail for me to have to put in another $4,800-$5,000. I believe that this is an engine flaw that Chevrolet knows about. They have done nothing to fix this issue and have left it on the backs of the customer. Chevrolet needs to be accountable for these types of problems!

The engine started making a strange sound while driving. Was taken to dealership were it was found that the engine was going bad due to a lifter failure. The engine only has 64,000. miles on it and was maintained by dealerships for routine service.

6.2L V8 had catastrophic failure due to lifters failing while driving at highway speeds.

The engine is blown. Our GM Dealership where we purchased it, inspected it and says the engine cannot be repaired and must be replaced. And independent garage gave the same diagnosis. Went from running fine one day , to bucking and stalling in traffic causing a hazard to everyone on the road. Check engine light, check brakes, stabilitrak, ALL the lights on the dash were on like a Christmas tree. It doesn't run now. Currently sitting in our driveway now unable to be driven for three months as we don't have $10,000.00 for a new engine, and the extended warranty we purchased through the dealership expired 4 months before it blew up. We are now making loan payments on a GM vehicle that did not even last the length of the loan. Seeing a report on this exact issue, we did not even know until today that there was a place we could send in a complaint to. You are welcome to inspect the truck, but you would need to come to us, as it cannot be driven. Where can we get any help with this? Please help.

Vehicle started miss firing along the highway without any previous signs of problems. The vehicle was driven straight to our home and then to the dealership a few days later. We were told there, the lifters have failed. Once they started the repairs we were also adviced the cam have suffered significant damaged and needed replacement as well. The vehicle was only inspected at the dealership once it was dropped off. The first and only sympton of the insurance was the day it failed.

At roughly 146,590~ miles the truck began making a knocking noise while driving at any speed, complainant had the truck towed to independent shop and was evaluated. Was told by shop that the engine can shaft pitted and engine metal shards had exploded and shattered throughout the engine. Making the opportunity for engine stalling or risk of fire/ smoking while operating the vehicle extremely likely. Complainant was told there was no access to engine replacements or parts at this time and the wait time to receive one was 4-6 months. No warning lights ever went off. Engine was eventually replaced entirely when the part became available by an independent service dealer.

In November 2023 my check engine light suddenly started flashing, my service parking brake light came on, traction control light came on and service ESC message was on the DIC. Then my truck started running really rough. At the time I was going roughly 10 mph. I took it to the dealership and they found a lifter had failed. My truck was at the dealership for a month. Fast forward to now, February 2025 and today I got the exact same lights appear on my cluster and same message. I was driving approximately 50 mph and my truck felt like there was a lack of power and there was hesitation in the engine.

In November 2023 my check engine light suddenly started flashing, my service parking brake light came on, traction control light came on and service ESC message was on the DIC. Then my truck started running really rough. At the time I was going roughly 10 mph. I took it to the dealership and they found a lifter had failed. My truck was at the dealership for a month. Fast forward to now, February 2025 and today I got the exact same lights appear on my cluster and same message. I was driving approximately 50 mph and my truck felt like there was a lack of power and there was hesitation in the engine.

Check engine light came on at 100,000 and was told I need new engine from John Miles Chevrolet

significant loss of power due to engine failure related to DDI while driving.

I bought this truck with 72,000 miles on it I put about 3,000 miles on it and the engine seized. I had my mechanic inspect it and he confirmed the motor is seized. There was absolutely no warning is just stopped running and left me on the side of the road

Vehicle would not start, had it towed to a shop and they said the engine locked up. After tearing motor down the main bearing was scored and there were metal scratches.

I was driving on a wet Road with more than an inch of water on the road and all of a sudden my engine blew up I took it to the Chevrolet dealer and they told me that water got in the engine and it was my fault I feel that the engine failed and should not have

Excessive Oil consumption from new and lifter failure at 116,000 miles

Had the top of the motor rebuilt twice, first the left side, then the right side. Then GM replaced the motor out of warranty. A year and a half later the rear main seal blew and the seal was all mushroomed and out of shape.

While driving down road at around 60mph 6.2L engine started to make loud knocking noise and shaking violently while loosing all power. Truck had 79,797 miles on it at the time with all oil changes and service done at GM dealership. After having GM dealership diagnose truck, it was determined to have a spun rod bearing, causing multiple other engine components to fail. Truck was not under factory warranty and was quoted $12,200 to replace. There were no warning lights or any known issues until this incident.

Main bearing on crankshaft when out

My vehicle only has 20k miles on it and I’m already replacing a lifter and camshaft due to the active fuel management system. At the time of taking my truck in there are three other trucks for the same issue. This is known issue at my dealership and this time I’m covered under warranty, but they told me to be prepared to repair this again and next time will be out of warranty and around 5k to repair.

Engine light came on, service park brake light came on, truck started jumping and misfiring, code says cylinder 5 misfire.

Shifting problems. Transmission feels like it is going to fall out. I have taken it in several times to be fixed and my Chevy dealer can not figure it out. Problem never fixed.

I'm beginning to have similar problems with the 6.2 ecotec3 engine that gm has known problems and hasn't recalled them. Dealer indicates metal shavings from the main motor bearings. Just like others I will experience a total motor failure at anytime. This will be catastrophic if motor fails and shuts down. I fear I will be rear-ended or not be able to get out of harms way. This has happened to many with the same motor. Why would there not be a safety recall on a known safety issue. Others affected have been injured even killed because there vehicle just stopped in the middle of a roadway. I currently fear for my families safety and cannot simply opt out of a vehicle with only 18,000 and thousands invested. Instead it sits waiting for the right thing to be done. To be repaired to safely use. Thank you kindly.

Total engine replacement at 62k. The junk lifter system government regulation has compromised our Vehicles. Active fuel management systems are used expensive trash changes to our American motors that generate extreme hardship for single vehicle owners.

Vehicle is burning oil. I drove 300 miles and had a low oil message pop up. Vehicle still had 50% oil life left.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated while driving approximately 35 MPH, there was an abnormal sound from the engine compartment. The contact stated that the check engine warning light was illuminated. The contact had taken the vehicle to a local dealer, where it was diagnosed and determined that the serpentine belt needed to be replaced. The vehicle was repaired. The contact stated that the failure recurred, and the vehicle was taken back to the same dealer and was repaired. The contact was concerned that the serpentine belt had failed twice. The manufacturer was informed of the failure. The failure mileage was approximately 3,500.

Problem started while driving on the highway, I was speeding up from the ramp to merge into the highway. As I got to 62 mph the dashboard started blinking that i could only go up to 62 mph max. Cruise control was not on. I drove to my destination at that speed with the message on the dashboard. I arrived at my destination, parked, turned it off, a couple of hours later turned it on to drive again. At this point, the dashboard message was that I could only drive it max speed 42 mph and "service tire monitor system" I towed to my mechanic given i could not drive at that speed on the highway back home. The mechanic said it was time for a brake change and that might be the issue. He changed all the brake pads and rotors and the truck drove fine again for less than a week. As i was getting on the highway, the truck started to jerk like it wanted to stop as i was speeding up, i was going 45 mph. There was a clanking sound coming from the engine. Then multiple things started flashing on the dashboard; check engine, traction control, messages reading "service parking brake" and "service ESC" I turned the truck off for a couple of minutes on the highway shoulder. Turned it back on, the same messages were still on the dash. I again could only drive it max in the 40's mph. The faster I tried to go, the more heavy and forced the truck felt. I had to park it over night in a parking lot. The next day i scheduled an appointment with a mechanic in town who checked it and said i would be needing a new engine, that he had seen this same problem a couple of weeks ago on a same truck. He quoted me $9K.I towed the truck back home and had another mechanic come take a look at it, he was getting the codes 0P50D and P0304.He exchanged the 4 cylinder for the good 1 cylinder to see if the codes would change from #4 to #1 and it did not. He said the issue was internal at that point and suggested I go take it to the dealership under the warranty. Its not under warranty, it ended at 60K miles and I have 80K now.

I have a 3.0 LTRe Dura Max issue is if the (Timing Belt ) or actually the oil pump drive belt breaks the engine will lose power if this happens in the middle of an intersection or major highway you will loose total power

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated while driving 50 MPH, the vehicle started shuddering, made an abnormal clunking sound, and lost motive power. The check engine warning light was illuminated. The contact was able to pull to the side of the road. The contact was able to restart the vehicle and drove to the nearest independent mechanic, where it was diagnosed that the engine had experienced an internal failure. The mechanic determined that the crankshaft, the lifters, an unknown valve, and other unknown parts needed to be replaced. The vehicle was repaired. The dealer was not notified of the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 79,000.

PIP5921 Bulletin.

Check engine light came on, I plugged my code reader in and was given P0498 ERROR CODE. Upon doing research and calling around to 3 different Chevrolet service centers I was told that it is a know issue with the fuel pump control module on all gm trucks. I am part of a truck group of over 150 and 85 of us has had this issue and all are currently waiting for the part to come in which is back ordered over months. Why has there been no recall and service bulletins yet if all 3 of the service managers agreed of the known issue.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that the vehicle was parked; however, while attempting to restart the vehicle, the vehicle failed to restart. The vehicle was towed to the dealer where it was diagnosed with a failed fuel modular control regulator and the fuel modular control regulator needed to be replaced. The vehicle was repaired. The manufacturer was made aware of the failure but did not assist. The failure mileage was approximately 30,878.

Notice the engine temp was rising, had notice I was slowly losing coolant in my overflow tank. Then while driving it started making noise that the engine overheated need to idle vehicle then as I pulled to a stop light the rims bogged down the whole vehicle shut down The radiator has a small leak in the plastic reservoir on the driver's side of radiator. Could have cause a big problem if I was in traffic when it shut down cause I had no control to turn the wheel or anything else once that happened.The vehicle got extremely hot very fast.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that the engine misfired and the vehicle stalled while driving at various speeds. Upon inspection, the contact discovered that the engine springs and rocker arms were bent. The contact replaced the lifters due to the failure. The manufacturer and the dealer were notified of the failure but offered no assistance. The vehicle was repaired. The failure mileage was approximately 65,000.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated while driving at various speeds, the check engine warning light and brake warning light had illuminated, and the message “Engine Powering down Mode” was activated causing the vehicle to shut off. The vehicle was towed to the local dealer who was unable to determine the cause of the failure. The contact stated that the failure had occurred on several occasions and the throttle body, Oxygen sensors were replaced along with an engine programming update was performed but the failure continued to occur. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 77,154.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the emission system warning light and the throttle control warning light were illuminated. Additionally, the contact stated that the vehicle shuddered while being started. The vehicle was taken to the dealer, who replaced the spark plugs and made several other unknown repairs. The dealer also informed the contact that the engine needed to be replaced. The manufacturer was not made aware of the failure. The failure mileage was approximately 70,000.

Lifters are failing. This is an ongoing problem with GM engines. They used faulty parts and engines are failing and nothing is being done about it.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated while driving 65-70 MPH, the engine started shuddering. The message "Reduced Power" was displayed, and the check engine warning light was illuminated. The contact stated that the vehicle lost motive power and failed to restart. The contact pushed the vehicle to the side of the road with assistance. The contact was able to restart the vehicle after a while. The vehicle was taken to the dealer, where it was diagnosed that the camshaft intake actuator screws had detached, and the engine and turbocharger needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was filed. The failure mileage was approximately 77,200.

On a 3 year old vehicle, I had a dash full of warning lights come on along with the engine light. Upon checking the code for the engine, it shows a misfire on cylinder 5. Looking online, chevy has a tsb # pip5776c regarding lifter failure. It appears this is an ongoing issue with many of the vehicles as verified by an engine repair shop. They stated then engine may need replacement as they have found in the past. For a 3 year old vehicle with more year of payments this is not right. They know of an issue and after speaking with a dealer, they said its on me because I am over the mileage warranty. I do not have the repair done yet--it is not cheap

I have 75,000 miles on my vehicle and in the last 15,000 miles my check engine oil keeps going off. I change my oil every 5000 miles, I am having to add 1 quart of oil about every 1000 miles. I do not see any leaks or old oil on or around engine.

Lifter failure caused several different warning lights and misfiring and chugging. Vehicle never died, but might have if it had continued to be driven.

While driving, the service emission system light activated indicating the truck would be reduced to 65mph. This was due to a faulty EGR wiring harness that controlled the EGR sensor.

I am a volunteer firefighter. On Friday, June 24th 2022, I was responding to an emergency call around 1am. There was an active rainstorm and standing water on parts of the street. While driving through roughly 5-6" of water on the way to the fire station, my truck's engine suddenly shut off and I came to a stop. While stalled, I watched multiple cars travel through the same intersection with no issues. My fellow firefighters helped me get my truck to a nearby parking lot to sit and dry out. The following day my truck still would not start so I had it towed to the dealership where I leased the truck which was still under a full bumper-to-bumper warranty. After initial diagnostics, I was told there was water in my intake and I had to get my insurance company involved for the dealership to continue with the repairs. With no other choice, I opened up a claim and was given an estimate of over $9,500 for the repairs due to the engine being "Hydro-locked". I called GM and filed a complaint. They called the dealership and called me back stating the dealership told them I drove through a flooded road and damaged my engine. I did some brief research online and found several examples from multiple sources with the exact same issue. I feel that this is a design flaw and that this needs to be investigated further as I was stranded by myself, in a heavy rainstorm, in the middle of a roadway at 1am. There is no reason that a 2020 Chevy Trail Boss should not be able to travel through the amount of water that stalled my engine. There was nothing negligent about my actions and at no point was I worried about traveling through the water that I drove through. I feel like I am being treated unfairly in this situation and I would like someone to look through the databases to see how many similar consumer reports there have been regarding this design flaw. This is a major safety issue!

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated that while driving at an undisclosed speed, the vehicle experienced reduced engine power. The reduced engine power warning message was displayed. The vehicle was towed to the dealer where it was diagnosed that the rear main seal needed to be replaced. The dealer replaced the rear main seal; however, the failure recurred. The vehicle was taken back to the dealer, and the dealer replaced the rear main seal a second time; however, the failure recurred with engine oil leaking onto the ground. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 11,340.

Vehicle has approximately 15789 miles. Loud taking sound coming from engine began November 2, 2021 as I was on Highway. Dealer advises all 8 lifters and cam need replacement. My investigation reveals that this is a persistent problem with this type of vehicle and many reports have been made about this same issue throughout the USA. My service advisor advised me that they have already repaired several of the same vehicles for the same problem. Engine is defective and requesting a recall to release entire engine now that this engine will need major overhaul.

Service ESC and Parking Brake error. Drove to work with no issues. Started up to drive home and I kept hearing a "Ping" noise like hail hitting my roof. Then I thought my transmission was going out while driving. It is almost like it is firing out of order. Dealership ordered multiple parts: Misfire in cylinder 4 plus issue with the heads and push rod. GM decided that the issue it to be repaired rather than a new engine be put in.

The contact owns a 2020 Chevrolet Silverado 1500. The contact stated while driving 10 mph, the vehicle drove through a puddle of water, shuddered and jerked then loss motive power. The contact was not able to restart the vehicle. The contact had the vehicle towed to a local dealer who inspected the vehicle and diagnosed the failure as water entering the engine, and that the engine needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure. The failure mileage was 21,400.

Service ESC and Service Parking Brake error. This was followed by loud pinging noises from the engine. Sounds like a misfire and knocking heads or valves.

ONE OF THE COOLANT HOSES RUBS UP AGAINST THE CRANKSHAFT CAUSING HOSE TO BUST AND LEAK REDUCED ENGINE POWER LIGHT COMES ON AND CHECK ENGINE LIGHT CHEVY HAD TO USE A DIFFERENT HOES TO NOT RUB AGAINST THE CRANKSHAFT

WHILLE SITTING AT A RED LIGHT, THE AUTOMATIC ENGINE STOP FEATURE ACTIVATED AND STOPPED THE ENGINE. WHEN I RELEASED THE BRAKE AND STEPPED ON THE GAS PEDDLE THE ENGINE DID NOT RESTART. THE VEHICLE HAD TO BE TOWED IN FOR REPAIR. THE DEALER MADE REPAIRS IN A SOMEWHAT TIMELY FASHION EXCEPT THAT THE PART HAD TO BE ORDERED FROM THE FACTORY AS NONE WERE AVAILABLE. WOULD HAVE THOUGHT A STARTER DESIGNED TO START AND STOP NUMEROUS TIMES A DAY WOULD HAVE LASTED JUST A WHILE LONGER?

HOLLOW VALVE STEM FAILURE. METAL SHARDS GOT INTO THE OIL & SEIZED UP THE MOTOR. WAS DRIVING 35MPH AT NIGHT ON A BUSY 2 LANE CITY STREET, NO SHOULDER. LESS THAN 1,200 MILES ON THE ENGINE

THE TRUCK IS NEW WITH 700 MILES. SEPTEMBER 26TH 2020 I CAME TO A STOP AT A LIGHT.AS I TOOK OFF THE TRUCK STARTED TO JERK AND THE CHECK ENGINE LIGHT CAME ON. I IMMEDIATELY DROVE IT HOME. AS I WAS DRIVING HOME WHILE IN MOTION THE TRUCK WOULD JERK WHEN IT WAS CHANGING GEARS. I RECEIVED A TEXT FROM GM THAT SAID TO HAVE THE ENGINE OR TRANSMISSION SERVICED WITHIN 7 DAYS. I DID NOT DRIVE IT UNTIL I WAS ABLE TO TAKE IT TO CHEVY. SEPTEMBER 28TH 2020 ON THE WAY THERE THE VEHICLE DID THE SAME THING. ON SEPTEMBER 30TH 2020 THE CHEVY TECHNICIAN SAID THE TRUCK WAS READY HE SAID THE PROBLEM WAS A TRANSMISSION CONTROL MODULE THAT WAS NOT PLACED CORRECTLY. I PICKED THE TRUCK UP OCTOBER 1ST 2020 AND DROVE IT STRAIGHT HOME JUST FINE. OCTOBER 2ND IN THE MORNING DRIVING TO WORK THE TRUCK STARTED TO JERK AGAIN AND THE CHECK ENGINE LIGHT CAME ON AND I RECEIVED ANOTHER TEXT FROM GM SAYING TO HAVE THE ENGINE OR TRANSMISSION SERVICED WITHIN 7 DAYS. ON THE WAY TO CHEVY I HAD TO STOP AT A LIGHT WHEN THE LIGHT CHANGED GREEN THE TRUCK DID NOT WANT TO TAKE OFF AND STARTED TO ROLL BACK AND I ALMOST HIT A VEHICLE. I PUT THE TRUCK IN PARK TURNED IT OFF RESTARTED IT THEN SAFELY DROVE IT TO CHEVY. TODAY IS OCTOBER 4TH AND I HAVEN'T HEARD ANYTHING FROM CHEVY I DID NOT BELIEVE THAT A TRANSMISSION CONTROL MODULE WOULD BE PLACED INCORRECTLY FROM THE FACTORY I BELIEVE THIS TRUCK HAS SOME KIND OF DEFECT AND IS UNSAFE TO DRIVE UNTIL CHEVY FIGURES OUT THE PROBLEM.

TL* THE CONTACT OWNS A 2020 CHEVROLET SILVERADO 1500. THE CONTACT STATED THAT THE KEY CEASED IN THE IGNITION AND THE VEHICLE WOULD NOT START. SEVERAL UNKNOWN WARNING LIGHTS ILLUMINATED INCLUDING THE CHECK ENGINE WARNING LIGHT. THE CONTACT STATED THAT SEVERAL UNKNOWN DEALERS WERE CONTACTED BY PHONE. THE CONTACT STATED THAT AN INDEPENDENT MECHANIC WAS ABLE TO GET THE VEHICLE STARTED HOWEVER, THE CHECK ENGINE WARNING LIGHT WAS AGAIN ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE HAD BEEN TAKEN FIVE TIMES TO SEVERAL UNKNOWN DEALERS WITH THE PURGE VALVE BEING REPLACED THREE TIMES. THE VEHICLE WAS TAKEN TO JIM BROWNE CHEVROLET BUICK GMC OF DADE CITY (10741 U S 301, DADE CITY, FL 33525, (352) 567-1222) AND REMAINED AT THE DEALER WHILE THE MECHANICS ATTEMPTED TO DUPLICATE THE FAILURE BY DRIVING THE VEHICLE OVER SEVERAL DAYS AND SEVERAL MILES. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS REFERRED TO THE DEALER AND PROVIDED A CASE NUMBER. THE CONTACT WAS ALSO PROVIDED A CASE NUMBER. THE FAILURE MILEAGE WAS 13,900.

AT COLD START UP, THE TRUCK IMMEDIATELY ILLUMINATED THE CHECK ENGINE LIGHT WITH A MESSAGE OF REDUCED ENGINE POWER. A SHUT DOWN AND RESTART PRODUCED THE SAME RESULTS. SHUT THE TRUCK OFF AND PULLED THE TROUBLE CODE P26BB. NEXT START UP, CHECK ENGINE LIGHT WAS STILL ON, BUT THE REDUCED ENGINE POWER MESSAGE WAS GONE. DROVE IT TO THE DEALER WITH NO PROBLEMS, WHERE THEY DIAGNOSED A FAULTY COOLANT FLOW VALVE. 38 DAYS LATER IT STILL SITS AT THE DEALER STILL NOT REPAIRED. IF THIS PROBLEM WAS TO HAPPEN UNEXPECTEDLY WHILE DRIVING, REDUCED ENGINE POWER COULD PRODUCE DANGEROUS CONDITIONS IN CERTAIN SITUATIONS ( IE PULLING INTO TRAFFIC, MERGING). *TR

ON A VERY RAINY DAY I WAS DRIVING AROUND THE BLOCK I WENT THROUGH SEVERAL SMALL PUDDLES FROM RUN OFF SO NO MORE THAN TWO-THREE INCHES OF WATER. WITH A LOT OF RAIN AND SPLASHING FROM OTHER VEHICLES. MY TRUCK SPUTTERS AND DIES, NO DEEP WATER, NO OFF-ROADING. I WAS TOLD TODAY THAT THE TRUCK IS WATERLOCKED AND IT ISNT COVERED UNDER WARRANTY. I AM ASTOUNDED AS THIS WAS REGULAR DRIVING, HERE IS MY FACTORY LIFTED UP TRUCK WITH TONS OF CLEARANCE BROKE DOWN IN THE MIDDLE OF THE STREET AND LITTLE CARS PASSING ME BY DRIVING THE SAME ROAD I DID. THIS IS OBVIOUSLY A DESIGN FLAW OR SOMETHING AS I DON'T UNDERSTAND IF THIS TRUCK IS SO FRAGILE HOW COULD I EVER TAKE IT TO A BOAT RAMP. I BOUGHT A TRUCK TO USE AS A TRUCK.