2008 Bmw X5 Fuel System Problems

The contact owns a 2008 BMW X5. The contact stated that the vehicle was taken to the dealer for the driver’s air bag replacement and the fuel pump replacement recall; however, after the recall repairs, the vehicle stalled inadvertently while driving. The vehicle was taken to the dealer who replaced the fuel pump twice. The contact stated that the failure recurred while at the stop light in the middle lane of a road. The contact was able to move the vehicle to the side of the road with the assistance of the police patrol. The vehicle was towed to the contact's residence. The contact stated that he was able to restart the vehicle the next day; however, the failure recurred while driving. The vehicle was towed to the dealer who installed a fuel pump relay switch; however, the failure persisted. The vehicle was towed to an independent mechanic who took the vehicle apart and diagnosed that the fuel pump needed to be replaced. The contact advised the dealer to forward the fuel pump for replacement; however, the dealer denied and advised the contact that he had to pay for the part if the repair was not completed at the dealer. The manufacturer was notified of the failure. The vehicle was repaired. The failure mileage was approximately 85,000.

MY CAR STARTED LEAKING GASOLINE FROM BACK UNDER REAR PASSENGER TIRE, AFTER I WAS RUNNING FOR MORE THAN ONE HOUR, I EXPERIENCED GASOLINE SMELL AND I CHECKED IT OUT AND I SAW A GASOLINE DRIPPING FROM THE AREA, THE CAR WAS ON AND RUNNING BUT WHEN I STOPPED THE CAR I SMELLED GASOLINE SO I FALLOWED THE SMELL AND I SAW THE DRIPPING, I TURNED OFF AND WAITED FOR THE CAR TO COOL DOWN, AND I STARTED AFTER AND THE LEAK STOPPED, NOW I'M WORRIED ABOUT IT, BECAUSE I CAN'T DRIVE THE CAR TO FAR OR FOR TO LONG BECAUSE I MIGHT GET BIGGER ISSUES, BECAUSE THE LEAK IS RIGHT BEFORE THE MUFFLER AND THE MUFFLER GETS HOT , AND MAYBE IF A DRIP GETS TO THE MUFFLER SOMETHING BAD CAN HAPPEN, I JUST NEED SOME HELP WITH THIS ISSUE, THANK YOU

I WAS DRIVING IN INTERSTATE 4 HWY. GOING ABOUT 50 MPH TRYING TO SPEED BUT NO CONTROL OF THE ACCELERATOR. THANKFULLY I MANAGED TO MERGE RIGHTS IN THE CAR SWITCH FROM DRIVING PARK. I CALLED BMW HEADQUARTER AND THEY SAID DAYS NO RECALL FOR THIS VEHICLE. ALSO I CONTACTED MAY WARRANTY COMPANY "CONCORD AUTO PROTECT" THEY SAID IT'S NOT COVERED BECAUSE IT'S UNDER RECALL. SO I HAVE NO IDEA HOW'S RIGHT?! PLEASE HELP ME. THANKS

TL* THE CONTACT OWNS A 2008 BMW X5. WHILE DRIVING 50-70 MPH, THE ACCELERATOR PEDAL WAS APPLIED, BUT THE BRAKES FAILED TO RESPOND AND THE VEHICLE STALLED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE LOCAL DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 122,000.

2008 BMW X5. CONSUMER WRITES IN REGARDS TO IN-TANK FUEL PUMP REMEDY UNAVAILABLE RECALL ISSUES. *LD *JS

WE HAD A DEFECTIVE IN-TANK FUEL PUMP REPLACE IN SEPTEMBER 2016 BY AN INDEPENDENT MECHANIC. WE THEN RECEIVED A RECALL FROM BMW USA IN DECEMBER 2016. WE'VE SINCE HAD BMW SAN DIEGO REVIEW THE INSTALLATION AND THEY DETERMINED THAT THE PART INSTALLED WAS NOT A BMW PART SO BMW USA DENIED REIMBURSEMENT UNDER THE TREAD ACT. WE THEN CONFIRMED WITH OUR MECHANIC THAT BMW PARTS WERE USED AND FORWARDED THIS INFO TO BMW BUT THEY STILL REFUSE TO REIMBURSE. WE REPLACE A DEFECTIVE PART AND SHOULD BE COMPENSATED . REFERENCE; BMW CORRESPONDENCE [1-8113168403] . I ASKED FOR PHOTOS AND THEIR DENIAL IN WRITING AND THEY REFUSED TO PROVIDE EITHER. I SAW THE PART INITIALLY REMOVED AND IT WAS BURNED UP INSIDE THE GAS TANK!!!

WE ARE SMELL GASOLINE INSIDE THE CABIN WHILE WE WERE DRIVING AND ALSO WHEN WE STOP WE COULD STILL SMELL GASOLINE. WE TOOK IN TO THE BMW SHOP ON JULY 5, 2017, BUT THEY SAID THEY DIDN'T THE RECALL IN-TANK FUEL PUMP PART YET

MY 2008 X5 SPORT 4.8I WITH 76,000 MILES IN NOR CA HAS HAD 3 PETRIFYING EPISODES OF ENGINE STALLING IN THE MIDDLE OF THE STREET WHILE DRIVING MY KIDS TO SCHOOL AND MYSELF TO WORK AT LOW SPEED -SUB 40MPH IN MIDDLE OF 2016 AND EARLY 2017! THANKS GOD WE WERE SAVED AND DID NOT GET REAR ENDED FROM ONCOMING TRAFFICS BECAUSE I WAS ABLE TO QUICKLY PULL THE VEHICLE OVER INTO A SIDE STREET AND STORE PLAZA, BUT THE INCIDENTS WERE FRIGHTFUL AND TRAUMATIZED OUR WELL-BEING! 2 OUT OF 3 INCIDENTS, THE VEHICLE COULD NOT BE DRIVEN (MADE LOUD ENGINE NOISE AND COULD NOT START WITH ENGINE LIGHT LID UP) AND IT WAS TOWED TO A BMW CERTIFIED SHOP FOR REPAIR. FIRST AND SECOND INCIDENTS WERE THE FAULTY FUEL PUMP AND THE FAULTY OXYGEN SENSOR WAS FOR THE THIRD INCIDENT AND BOTH PARTS WERE REPLACED WITH THE REPAIR COST WAS MORE THAN $2000. I HAVE HAD THE FAULTY FUEL PUMP ISSUES REPAIRED BECAUSE SAFETY OF OUR FAMILY AND SAFETY OF OTHER DRIVERS ON THE ROAD COMES FIRST. BMW HAS RECENTLY ISSUE THE RECALL ON FAULTY FUEL PUMP LATE 2016 AND THE PART WILL NOT BE AVAILABLE UNTIL LATE SPRING 2017. BMW SHOULD VOLUNTARILY ISSUE REIMBURSEMENT NOTICE FOR ALL OF THE REPAIR COSTS ON ANY RECALLED ISSUES THAT WERE TAKEN PRIOR TO THE RECALLS POSTED TO ILLUSTRATE GOOD FAITH TO ITS CUSTOMERS. IN EARLY MARCH 2017 WE HAVE DECIDED TO BUY A RELIABLE AND SAFER VEHICLE (NOT A BMW) BECAUSE OUR 2008 X5 4.8I IS NOT SAFE AND TOO DISTRESSFUL FOR US TO DRIVE AND ALSO FOR THE SAFETY OF OTHER DRIVERS ON THE ROAD. FOR THE AMOUNT OF MONEY WE HAVE PAID FOR THIS SPORT 4.8I X5 BRAND NEW IN 2008, WE NOR ANYONE ELSE WOULD NOT EXPECT THAT IT HAS HAD MANY FAULTY AND MALFUNCTION ON ITS BASIC SAFETY PARTS AND ALSO ON OTHER PARTS. BMW SHOULD GET ITS ACT TOGETHER AND BE ACCOUNTABLE FOR ALL OF THESE BASIC SAFETY AND RELIABLE PARTS TO LIVE UP TO ITS NAME AND THEME AS THE ULTIMATE DRIVING MACHINE AND NOT AS A POTENTIAL ULTIMATE KILLING MACHINE!

TL* TAKATA RECALL. THE CONTACT OWNS A 2008 BMW X5. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V364000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. UPDATED 02/21/17*LJ THE CONSUMER ALSO REFERENCED A FUEL TANK RECALL.

ON SEPTEMBER 2, AROUND MIDNIGHT, AFTER ABOUT 30 MINUTES OF STOP AND GO TRAFFIC AT THE BORDER, MY 2008 BMW SAV X5 AWD 4DR 3.0I COUGHED, CHOKED, STOPPED AND REFUSED TO BE REVIVED. WE WERE AT THE FRONT OF A LONG LINE OF FOLKS HEADING THROUGH CUSTOMS INTO CANADA. YES, AT THE HEAD OF THE LINE. IT WAS SO EMBARRASSING! AFTER FUSSING FOR ANOTHER 30 MINUTES TRYING TO GET IT INTO NEUTRAL, SEVERAL ABLE BODIED CANADIAN CUSTOMS OFFICERS PUSHED IT INTO THEIR COUNTRY. THE TOW TRUCK DRIVER CAME ANOTHER 40 MINUTES LATER AND TOOK US TO A BMW SERVICE SHOP IN MONTREAL. SIRS, WHAT'S SO HARD TO SWALLOW ABOUT THIS BREAKDOWN IS THAT WE COMPLETED THE ROUTINE MAINTENANCE SERVICE ON THE CAR JUST 7 DAYS BEFORE AT NEW COUNTRY BMW IN HARTFORD, CT. WITH THE EXCEPTION OF A NEGLIGIBLE OIL LEAK THAT THEY SAID WAS NO PROBLEM, I WAS ASSURED THAT MY CAR WAS FINE. BUT, IT TURNS OUT THAT IT WAS NOT; AND LIKE AN INCREASINGLY LARGE NUMBER OF BMWS, THE FUEL PUMP FAILED. WHAT'S MORE, IT IS CLEAR TO ME NOW THAT, BACK IN 2014, THE CAR WAS FAILING TO START AND WOULD CUT OFF WHILE DRIVING AROUND MY TOWN (I WAS TOO AFRAID TO TAKE IT ON THE HIGHWAY AT THAT TIME). ON MORE THAN ONE OCCASION, I TOOK IT IN FOR SERVICING AND EVENTUALLY IT WAS 'FIXED (THOUGH THE FUEL PUMP WAS NEVER REPLACED UNTIL THIS LAST FAILURE). AND SO, I SUSPECT THAT I HAVE PAID FOR A MANUFACTURING DEFECT AT LEAST THREE TIMES AND I'M SICK OF IT. I THINK THAT BMW SHOULD REIMBURSE ME FOR THE REPAIR AND THE COST OF TOWING AND THE RENTAL TO LEAVE CA AND RETURN TO PICK UP THE CAR.

THE CAR WOULD NOT STARTOR STALL AT THE TRAFFIC LIGHT

WHEN I WAS DRIVING AROUND 30 MPH AND ABOUT TO MERGE ONTO THE HIGHWAY, AN ORANGE WARNING SIGN CAME UP THAT THE ENGINE WAS OVERHEATING AND THEN IMMEDIATELY AFTERWARD A RED SIGN CAME UP STATING THAT THE ENGINE WAS OVERHEATED AND I COULD HEAR THE LOUD NOISE FROM THE FAN. IMMEDIATELY AFTER THAT THE VEHICLE STALLED AND I HAD TO PULL OVER TO THE SHOULDER. I WAITED FOR ABOUT 15 MIN. AND WHEN I RESTARTED THE VEHICLE, THE FAN WAS STILL LOUD AND THE RED ENGINE OVERHEATED SIGN CAME UP AGAIN. I THEN HAD THE VEHICLE TOWED TO A REPAIR FACILITY. THEY DIAGNOSED THE ISSUE AS A DEFECTIVE ELECTRIC WATER PUMP AND SAID THAT THE WATER PUMP AND THERMOSTAT NEED TO BE REPLACED. THE ESTIMATE FOR REPAIR INCLUDING PARTS AND LABOR IS AROUND $1700.00. THE VEHICLE IS BEYOND THE 4 YEAR, 50000 MILES WARRANTY AND APPARENTLY THERE ARE NO RECALLS FOR THIS ISSUE. SEARCHING THE INTERNET, I AM SEEING NUMEROUS COMPLAINTS FROM 2008 BMW X5 OWNERS WHO EXPERIENCED THIS EXACT SAME ISSUE AND HAD THE SAME DIAGNOSIS. THIS IS A VERY SERIOUS SAFETY ISSUE - WHEN DRIVING ON A BUSY HIGHWAY AND SUDDENLY LOSING ALL POWER IN THE VEHICLE, VERY FEW DRIVERS WOULD BE LUCKY ENOUGH TO PULL OVER SAFELY AND AVOID A SERIOUS ACCIDENT. I REQUEST THAT THE NHTSA CONSIDER THIS SERIOUS SAFETY ISSUE FROM A RECALL PERSPECTIVE DUE TO THE POTENTIAL HARM IT CAN DO TO THE LIVES OF MOTORISTS WHO MAY NOT BE LUCKY ENOUGH TO AVOID A SERIOUS CRASH. I BELIEVE THE MANUFACTURER SHOULD BE HELD ACCOUNTABLE FOR THE BASIC SAFETY OF THE VEHICLE. THEY SHOULD THE NEEDFUL TO HELP OWNERS FIX THE ISSUE PROACTIVELY, BEFORE IT CAUSES HARM TO MORE MOTORISTS. *TR

2008 BMW X5. CONSUMER STATES ENGINE LOST ALL POWER WHILE DRIVING *TGW THE CONSUMER STATED HER DAUGHTER WHO WAS DRIVING, ATTEMPTED TO ACCELERATE, BUT TO NO AVAIL. AS SHE STEERED THE VEHICLE TO THE EMERGENCY LANE, THE ENGINE WAS NON-RESPONSIVE. THE GEAR SHIFTED AUTOMATICALLY INTO NEUTRAL AND THEN INTO PARK FROM WHICH IT WOULD NOT MOVE. THE VEHICLE WAS TOWED TO THE DEALER. AN INSPECTION REVEALED FAILURE OF THE FUEL DELIVERY SYSTEM THAT WAS THE SUBJECT OF A NATIONWIDE RECALL. *JB

2008 BMW X5 3.0SI. ATTORNEY WRITES ON BEHALF OF CLIENT IN REGARDS TO INCOMPETENT REPAIRS *TGW THE CONSUMER TOOK THE VEHICLE TO THE DEALER, BECAUSE THE CHECK ENGINE LIGHT ILLUMINATED. PURSUANT TO A VOLUNTARY NATIONAL BMW RECALL, THE DEALER REPLACED THE FUEL DELIVERY UNIT ON THE VEHICLE. EIGHT DAYS LATER, THE VEHICLE STALLED IN THE MIDDLE OF THE ROAD. THE ENTIRE ELECTRICAL SYSTEM SHUT DOWN. THE CONSUMER WAS UNSUCCESSFUL AT TRYING TO RESTART THE VEHICLE AS IT WOULD NOT COME OUT OF PARK. A BMW TECHNICIAN CAME TO THE CONSUMERS LOCATION AND HIS INSPECTION REVEALED AN ISSUE WITH THE FUEL DELIVERY SYSTEM. THE EXACT ISSUE THAT THE DEALER HAD SUPPOSEDLY ADDRESSED A WEEK PRIOR. THE GAS GAUGE SHOWED THE GAS LEVEL AT A LITTLE UNDER HALF A TANK, WHEN IN FACT THE VEHICLE HAD RAN OUT OF GAS. APPARENTLY, THE LEVEL FLOAT WAS STUCK ON THE TANK SIPHON WHICH OBSTRUCTED A PROPER READING OF HOW MUCH GAS WAS IN THE TANK. *JB

ENGINE MALFUNCTION! REDUCED POWER WAS THE MESSAGE I RECEIVED ON MY DASH DISPLAY. I TOOK PHOTOS OF THE DISPLAYED MESSAGE. CAR WENT FROM 65 MPH DOWN TO 18 MPH IN A MATTER OF SECONDS IN THE FAR LEFT LANE OF THE INTERSTATE HIGHWAY. COULD HAVE BEEN KILLED. HAD TO CHUG AND LURCH OVER THREE LANES OF SPEEDING TRAFFIC TO GET TO THE RIGHT SHOULDER OF THE ROAD. I'VE ALREADY HAD THE FUEL PUMP REPLACED BY BMW RECALL (A RECALL THAT I WAS NEVER NOTIFIED BY BMW THAT THE RECALL EXISTED). APPARENTLY THE FUEL PUMP RECALL WAS NOT ALL OF THE PROBLEM AS THIS SAME ENGINE MALFUNCTION STILL OCCURS AND THE CAR STILL BEHAVES THE SAME AS BEFORE THE FUEL PUMP RECALL. TOOK THE CAR TO THE DEALER THE VERY NEXT DAY. HE CLEARED A CODE IN MY ONBOARD COMPUTER AND DID NOTHING TO FIX THIS PROBLEM. THIS PROBLEM WITH MY BMW 535XI WAGON IS GOING TO GET SOMEONE IN MY FAMILY KILLED OR SERIOUSLY INJURED. I'VE READ MULTIPLE COMPLAINTS ONLINE FROM BLOGGERS REGARDING THIS SAME PROBLEM. WHY IS BMW NOT FIXING THE PROBLEM. AT THE TIME THE FUEL PUMP WAS REPLACED THE DEALER ALSO REPROGRAMMED MY CAR'S ONBOARD COMPUTER AND CHECKED THE FUEL IN THE TANK WHICH, ACCORDING TO THE DEALER APPEARED TO BE FINE. *TR

TL*THE CONTACT OWNS A 2008 BMW X5. WHILE DRIVING APPROXIMATELY 30 MPH MAKING A LEFT TURN THE VEHICLE STALLED. SHE STATED THAT THE FUEL GAUGE DISPLAYED THE INCORRECT AMOUNT OF FUEL WITHOUT WARNING. THE FUEL GAUGE DISPLAYED MORE FUEL THAN WHAT WAS IN THE FUEL TANK. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO REPLACED THE FUEL SENSOR. THE FAILURE AND CURRENT MILEAGES WERE 39,400.

TL*THE CONTACT OWNS A 2008 BMW 535XI (NA). WHILE DRIVING APPROXIMATELY 35 MPH, THE ENGINE BEGAN SMOKING. THE DEALER MADE THREE ATTEMPTS TO DIAGNOSE THE FAILURE. THE HIGH PRESSURE FUEL PUMP WAS REPLACED BUT IT CRACKED AGAIN. THE VEHICLE WAS BEING REPAIRED BY THE DEALER. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE CURRENT MILEAGE WAS 30,100. THE FAILURE MILEAGE WAS APPROXIMATELY 22,000.

PURCHASED A 2008 BMW 535I IN JUNE 2008. VEHICLE HAS 30,000 MILES ON IT. ABOUT SIX MONTHS AFTER PURCHASING THE VEHICLE, STARTED TO HAVE THE "ENGINE MALFUNCTION/REDUCED POWER" LIGHT COME ON ABOUT EVERY THREE MONTHS. TWO MONTHS AGO, THE SAME THING HAPPENED BUT THE VEHICLE SHUT OFF AT A STOP LIGHT. HAD THE VEHICLE TOWED AND THE FUEL PUMP WAS REPLACED. HAD THE VEHICLE BACK FOR APPROX TWO WEEKS AND SAME THING HAPPENED AGAIN. HAD THE VEHICLE TOWED. THEY REPLACE SOME FUEL INJECTORS AND SPARK PLUGS. HAD THE VEHICLE BACK APPROX 3 WEEKS. HAPPENED AGAIN. LUCKILY STILL NOT ON THE FREEWAY. DROVE THE VEHICLE IN TO THE DEALER. THEY REPLACED MORE FUEL INJECTORS. HAD THE VEHICLE BACK A WEEK AND THE VEHICLE SHUT OFF ON THE FREEWAY IN TRAFFIC IN LOS ANGELES GOING 65 MPH AND ALMOST WAS IN A MAJOR TRAFFICE ACCIDENT. CALLED THE DEALER TODAY (SATURDAY) AND THE SERVICE DEPT IS NOT IN ON WEEKENDS. SALES MANAGER SAID "TAKE THE VEHICLE SOMEWHERE ELSE" AND "IT WON'T AFFECT US IF SOMEONE IS KILLED OR INJURED AND A LAWSUIT IS FILED". AFRAID TO DRIVE THE VEHICLE AT THIS POINT.

WHILE ACCELERATING, THE ENGINE LOST POWER AND WENT INTO NEUTRAL. I WAS ABLE TO PUT IT BACK INTO DRIVE AND THE CAR VERY SLOWLY REGAINED MOMENTUM. A FEW MINUTES LATER, AFTER THE CAR HAD BEEN TURNED OFF, I RESTARTED IT, PUT IT INTO REVERSE TO BACK OUT OF A PARKING PLACE, PUT IT INTO DRIVE TO MOVE FORWARD, TRIED TO ACCELERATE, THE CAR WENT INTO NEUTRAL AGAIN AND WOULD NOT MOVE FORWARD. I TRIED TO PUT IT INTO DRIVE AGAIN BUT WITH NO SUCCESS. THE CAR WAS DEAD AND MESSAGE FLASHED ON "REDUCED ENGINE POWER." FORTUNATELY I WAS IN A PARKING LOT AND NOT ON A HIGHWAY. THE CAR HAD TO BE TOWED TO THE DEALER. THE RMFD HIGH-PRESSURE PUMP HAD TO BE REPLACED. BMW TOLD ME THAT THIS WAS A COMMON PROBLEM AND THAT THE WARRANTY ON THIS PART HAD BEEN EXTENDED TO 10 YEARS, 120,000 MILES. THE OLD PART IS NOT AVAILABLE. *TR

I HAD MY CAR IN FOR ROUTINE SERVICE TWO WEEKS AGO, AND I MENTIONED THAT THE CAR HAD BEEN SLOW TO START IN THE MORNING, AND IDLED ROUGHLY. I WAS TOLD THAT THE CAR WAS 'REPROGRAMMED" AND THAT SHOULD TAKE CARE OF THE ISSUE. YESTERDAY, WHILE I WAS DRIVING ON THE HIGHWAY, THE ENGINE MALFUNCTION LIGHT CAME ON, AND THE CAR LOST ACCELERATION, AND I HAD TO PULL OVER ON THE RIGHT, THROUGH 3 LANES OF RUSH HOUR TRAFFIC WITH A CAR THAT BARELY ACCELERATED. I TOOK THE CAR TO THE DEALER WHO SAID IT WAS A BAD SENSOR. THIS MORNING, MY WIFE WAS DRIVING THE CAR WITH MY 3 MONTH OLD DAUGHTER AND THE ENGINE MALFUNCTION LIGHT CAME ON AGAIN. MY WIFE TRIED TO FIND A SAFE PLACE TO PULL OVER, BUT THE ENGINE DIED AT THE LIGHT. SHE STARTED THE CAR AGAIN, AND MADE IT HALFWAY INTO THE INTERSECTION, AND THE CAR DIED AGAIN. SHE WAS VERY WORRIED THAT SHE WAS GOING TO GET HIT WHILE STUCK IN THE INTERSECTION. FINALLY, AFTER A FEW MORE CYCLES OF STARTING THE CAR, GOING A FEW FEET, AND THE CAR DYING, SHE WAS ABLE TO GET THE CAR INTO A PARKING LOT. THE CAR WAS TAKEN TO THE DEALER AGAIN, AND NOW THEY ARE CHANGING THE HIGH PRESSURE FUEL PUMP. *TR

HAVE HAD 3 SEPARATE INSTANCES IN THE PAST 9 MONTHS WHERE MY CAR STALLED OR SPUTTERED WITH LOSS OF POWER , AND ONCE I HAD NO STEERING OR BRAKING ABILITY. DANGEROUS SITUATION IN FREEWAY TRAFFIC. *TR

I HAVE A 2008 BMW 535 XI THAT HAS SHOWN THE REDUCED ENGINE POWER/ENGINE MALFUNCTION WHILE ON THE HIGHWAY TWICE. THE CAR REFUSED TO ACCELERATE AND BECAME VERY HARD TO MANEUVER. THANKFULLY, BOTH TIMES I WAS WITHIN A MILE OF THE HIGHWAY EXIT. I AM HESITANT TO DRIVE THIS CAR ON LONG TRAVELS BECAUSE A REDUCED ENGINE POWER MALFUNCTION COULD ENDANGER ME AND MY FAMILY. BMW ATTEMPTED TO FIX THESE PROBLEMS FIRST BY REPLACING THE HIGH PRESSURE FUEL PUMP AND THEN BY REPLACING ALL OF THE FUEL INJECTORS. THUS FAR THE PROBLEM HAS BEEN BETTER BUT I AM STILL LEERY OF THE CAR. *TR

ON 5/20/10, MY 2008 BMW 535XI SUDDENLY LOST POWER WHILE DRIVING ON A SINGLE LANE, RESULTING IN A NEAR REAR-END COLLISION. THIS HAPPENED ONCE PREVIOUSLY. BOTH TIMES THE CAR WAS TOWED AND THE DEALER SAID THEY REPLACED THE HIGH PRESSURE FUEL PUMP. I COMPLAINED ABOUT THE LATEST INCIDENCE TO BMW CUSTOMER RELATIONS AND SERVICES DEPARTMENT, CASE # [XXX] ???. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

WE WERE DRIVING ON A 55 MPH SPEED LIMIT ROAD. WE WERE GOING UP A SLOPE, OUR CAR ( BMW 5 SERIES) SUDDENLY LOST POWER AND WE WERE UNABLE TO DRIVE THE CAR BEYOND 30 MPH. WE HAD TO PULL TO THE SIDE OF THE ROAD. AFTER CONTACTING BMW, THEY INFORMED US THAT THEY CAN NOT TAKE IT TO THE DEALER AS ALL THE DEALERS ARE CLOSED ON SUNDAYS. SO WE DROVE THE CAR SLOWLY TO THE HOUSE ( 3 MILES AWAY). THE CAR WAS TOWED TO THE DEALER NEXT DAY, WERE TOLD THAT IT IS A HIGH PRESSURE FUEL PUMP FAILURE. THE PUMP WAS REPLACED. NOW WE HAVE THE CAR BACK. BMW DEALER MENTIONED THAT THERE IS NOTHING WE CAN DO TO PREVENT THIS FROM HAPPENING AGAIN, BMW IS AWARE OF THE PROBLEM. ALSO MENTIONED THAT SUCH A FAILURE IS AN ACCEPTABLE PRICE FOR THE CAR'S GREAT ENGINE. MY WIFE STOPPED DRIVING THE CAR BECAUSE THE ENGINE MAY FAIL WITH THE CHILDREN WITH HER IN THE CAR, IT WILL BE DANGEROUS. EVERY TIME I TAKE THE CAR TO AND FROM WORK I AM WORRIED THAT THE ENGINE MAY FAIL AND TRULY CAN NOT TRUST THE "GREAT ENGINE" THAT THE DEALER IS SO PROUD OF. *TR

DRIVING ON HIGHWAY 60MPH AND SUDDENLY LOST ENGINE POWER. MY SUV STARTED SLOWING AND FELT LIKE CAR WAS LOCKING UP IE. STEERING WHEEL WAS HARDER TO MOVE. PUSHING ACCELERATOR PEDAL DID NOT BRING ANY SPEED BACK TO SLOWING SUV. I WAS ABLE TO GET TO RIGHT SIDE SHOULDER FROM MIDDLE LANE AND CALLED BMW ASSIST FOR HELP. THEY WERE NOT ABLE TO HELP AT MY LOCATION IN WISCONSIN AT 8PM BUT DID CALL POLICE TO KEEP TRAFFIC AWAY FROM US (MYSELF AND 5 YOUNG CHILDREN) UNTIL A FRIEND CAME TO PICK US UP. THE CAR HAD TO REMAIN OVERNIGHT ON THE HIGHWAY UNTIL A FLATBED TRUCK WAS AVAILABLE TO TAKE IT AWAY THE FOLLOWING MORNING. ONCE THE ENGINE WAS TURNED OFF IT WOULD NOT RESTART AND NEEDED 2 MEN TO MOVE IT WHICH IS WHY IT COULDN'T BE TAKEN AWAY THAT EVENING. ONCE TAKEN TO THE BMW DEALER, INTERNATIONAL AUTOS IN MILWAUKEE, WI, THEY TOLD ME THE FUEL PUMP HAD FAILED AND THEY REPLACED IT. THE 2008 BMW X5 3.0SI HAD A LITTLE OVER 33,000 MILES ON IT AT THE TIME. THIS HAS NOT HAPPENED AGAIN AFTER REPLACEMENT OF FUEL PUMP. *TR

JUNE, 2010 - I WAS DRIVING MY 2008 BMW 535 STATION WAGON ON THE HIGHWAY (LONG ISLAND EXPRESSWAY I-495, NEW YORK) AT 65 MILES PER HOUR WHEN THE CAR LURCHED, MADE A LOUD NOISE AND LOST POWER. BMW REPLACED THE HIGH PRESSURE FUEL PUMP. AUGUST 2009 - THE CAR STARTED BUT LIGHTS ON DASH BOARD WENT ON SAYING "VEHICLE HAD REDUCED POWER". IT WAS TOWED TO BMW DEALERSHIP, WHERE THEY REPLACED THE HIGH PRESSURE FUEL PUMP. AUGUST 2008 - THE BMW LOST POWER ON THE HIGHWAY AND WAS TOWED TO DEALER. THEY MADE A REPAIR TO THE FUEL INJECTION SYSTEM. *TR

TL*THE CONTACT OWNS A 2008 BMW 535I. THE CONTACT STATED THAT THE PREOWNED VEHICLE WAS PURCHASED IN APRIL 2010. THE FUEL PUMP FAILED. THE OWNER WAS DRIVING APPROXIMATELY 65 MPH, THE VEHICLE CUT OFF . THE VEHICLE WAS RESTARTED AND TAKEN TO THE DEALER AND THE FUEL PUMP WAS REPLACED. ON JUNE 2, 2010 THE FUEL PUMP FAILED AGAIN. THE DEALER REPLACED THAT FUEL PUMP WITH A "NEW" PUMP. THE DEALER WAS DELIVERING THE VEHICLE BACK TO THE OWNER AND THE MECHANIC EXPERIENCE THE SAME FAILURE AND RETURNED THE VEHICLE TO THE DEALERSHIP. BMW DECIDED TO TAKE A FUEL SAMPLE FROM THE TANK TO DETERMINE IF THE FUEL WAS THE CORRECT. THEY ALSO ADVISED THEY HAD FOUND DEBRIS IN THE FUEL SYSTEM. BMW STATED THAT THAT THEY WOULD HAVE TO TAKE THE FUEL TANK OFF AND CLEAN IT AT THE OWNERS EXPENSE OF ABOUT $3,000.00 AS THIS WAS NOT COVERED UNDER WARRANTY. THE VEHICLE IS AT THE DEALERSHIP AT THE TIME OF THE COMPLAINT WAITING FOR REPAIRS. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 44,000.

I HAVE A 2008 BMW 535I AND RECEIVED THE DREADED "ENGINE MALFUNCTION - REDUCED POWER" READOUT. THE CAR WOULD NOT DEVELOP MORE THAN 1,500 RPMS. I TOOK IT TO THE LOCAL DEALER AND THE SERVICE ADVISOR STATED IMMEDIATELY THAT IT WAS A FAILED HIGH PRESSURE FUEL PUMP, A RATHER COMMON OCCURRENCE ON THIS PARTICULAR ENGINE. THE HPFP WAS REPLACED AND THE CAR HAS PERFORMED FINE NOW FOR ABOUT SIX MONTHS, ALTHOUGH THE AFOREMENTIONED READOUT DID APPEAR ONE MORE TIME, BUT I TURNED OFF THE ENGINE AND RESTARTED IT IMMEDIATELY AND EVERYTHING WAS FINE. *TR

THE N54 ENGINE IN THE BMW IS A HAZARD-I ALMOST GOT KILLED WHEN MY CAR STALLED ON THE ROAD-BMW REPLACED THE HP FUEL PUMP 3X ALREADY AND THE CAR IS LESS THAN 3 YEARS OLD. THESE ENGINES NEED TO BE REPLACED AS THERE IS A DESIGN FLAW. DO PEOPLE HAVE TO DIE TO FIX THE PROBLEM? *TR

2008 BMW 535I TOOK MY CAR INTO DEALERSHIP DUE TO CAR RUNNING ROUGH. THEY COULDN'T FIND ANYTHING AND SENT ME ON MY MERRY WAY. TOOK MY CAR IN ON MONDAY, MAY 4 DUE TO CAR RUNNING ROUGH AND TICKING NOISE IN ENGINE...TOLD THEM WE WERE GOING ON A 1,000 MILE ROAD TRIP THE END OF THE WEEK. THEY COULDN'T FIND ANYTHING BUT DID REPLACE SOME BRAKE ITEMS. DRIVING HOME AT THE END OF OUR TRIP, ON ACCELERATION MY CAR 'SKIPPED' THREE TIMES....A COUPLE OF MINUTES LATER I TESTED IT AND ACCELERATED AGAIN (ON FL TURNPIKE) IT 'SKIPPED' HARD AGAIN THREE TIMES. GOT OFF AT THE NEXT EXIT...AT THE LIGHT I GOT A 'ENGINE MALFUNCTION' LIGHT AND LIMPED INTO THE 7-11. PUT GAS IN CAR, CALLED BMW CONCIERGE. WE WERE CLOSE ENOUGH TO HOME TO HAVE IT TOWED TO THE DEALERSHIP, GET A DRIVER TO HELP US TRANSFER ALL OUR LUGGAGE ETC, AND TAKE US HOME. NEXT DAY CALLED DEALERSHIP...THEY HAD CAR DAY AND A HALF AND SAID IT WAS THE FUEL INJECTOR PUMP. I UNDERSTAND FROM TONS OF BMW OWNER BLOGS THAT THIS IS VERY COMMON OCCURRENCE...WE WERE FORTUNATE ENOUGH NOT TO BE GOING 65 MILES AN HOUR IN FRONT OF A SEMI LIKE MANY OTHER FAMILY'S HAVE THE MISFORTUNE OF. I ALSO UNDERSTAND THAT PEOPLE HAVE HAD TO HAVE THIS REPLACE NOT ONE, TWO, OR THREE TIMES BUT CONTINUOUS...FOUR! THIS IS ABSURD. WHERE'S BMW'S INTEGRITY TO DO THE RIGHT THING, ADDRESS THE SITUATION, AND NOT PUT THEIR CONSUMERS IN HARMS WAY. DO WE NEAR A NEAR DEATH EXPERIENCE OR OUR FAMILY'S FILING LAWSUITS ONCE WE'RE SIX FEET IN THE GRAVE FOR THEM TO STAND UP AND TAKE CARE OF THESE PROBLEMS ONCE AND FOR ALL???? *TR

WHILE DRIVING AT HIGHWAY SPEED, THE CAR BEGAN TO RUN VERY ROUGHLY. A WARNING LIGHT AND WARNING MESSAGE APPEARED, INDICATING THAT THERE WAS AN ENGINE PROBLEM. WE PULLED OFF THE HIGHWAY AND INTO A PARKING LOT. WE STOPPED THE ENGINE, WAITED A FEW MINUTES AND RESTARTED THE CAR. THE CAR CONTINUED TO RUN ROUGHLY BUT THERE WAS NO WARNING LIGHT OR MESSAGE. WE CONTINUED ON TO OUR DESTINATION (SHOPPING). WHEN WE FINISHED OUR SHOPPING, I STARTED THE CAR AND IT CONTINUED TO RUN ROUGHLY AND THE SAME WARNING LIGHT AND MESSAGE APPEARED. I WANTED TO DRIVE THE CAR TO THE DEALER FOR SERVICE BUT WHEN I PULLED OUT OF THE PARKING SPACE THE CAR STALLED. I RESTARTED THE CAR, DROVE IT ABOUT 100 FEET INTO ANOTHER PARKING LOT AND HAD THE CAR TOWED TO THE DEALER. WHEN I DESCRIBED THE PROBLEM AT THE DEALERSHIP, A SERVICE REP INDICATED THAT THEY THOUGHT IT WAS THE FUEL PUMP. I HEARD THAT THIS HAS BEEN A RECURRING PROBLEM. THE DEALER WAS NOT ABLE TO REPLACE THE PUMP WITHOUT GETTING AUTHORIZATION FROM BMW BECAUSE BMW HAD HAS SO MANY FUEL PUMP PROBLEMS. A FAILURE AT HIGHWAY SPEED THAT WOULD CAUSE THE CAR TO STALL IS A DANGEROUS CONDITION. *TR

I AM REPORTING KNOWN FAILURES AND AN "UNOFFICIAL RECALL" (SEE WEB LINK TO BMS SERVICE REPORT) OF HIGH PRESSURE FUEL PUMPS FOR 2008/2009 BMW CARS WITH THE 3 LITER TWIN TURBO ENGINES. WHEN THESE FUEL PUMPS FAIL THERE IS AN IMMEDIATE REDUCTION OF POWER AND THE CAR GOES INTO "LIMP MODE". BMW HAS RECENTLY EXTENDED THE WARRANTY ON THE FUEL PUMPS TO OVER 100K MILES AND 10 YEARS, BUT I AM CONCERNED THAT THERE HAS NOT BEEN A FORMAL SAFETY INVESTIGATION BY THE US GOVERNMENT (THAT I KNOW OF) OR A FORMAL RECALL BY BMW SINCE THIS IS A POTENTIALLY DANGEROUS SITUATION IF CARS SUDDENLY SLOW AT HIGHWAY SPEEDS. I AM THE OWNER OF A 2008 BMW 535, IT IS NOW HAVING PROBLEMS STARTING IN THE MORNING AND I AM NOW CONCERNED ABOUT WHEN/IF MY FUEL PUMP WILL FAIL - TO THE POINT I WILL NO LONGER LET MY WIFE DRIVE THE CAR. WWW.BMWBLOG.COM/2009/03/.../MORE-BMW-FUEL-PUMP-NEWS/ HTTP://WWW.E90POST.COM/FORUMS/SHOWTHREAD.PHP?T=181600. *TR

TL*THE CONTACT OWNS A 2008 BMW 535XI. THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH. THERE WAS A SUDDEN REDUCTION IN THE ENGINE POWER FOR 30 SECONDS. THE ENGINE SHUTTERED AND STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER AND THE FUEL PUMP WAS REPLACED. THE FAILURE OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO THE DEALER ON A SEPARATE OCCASION AND THE COMPUTERIZED SYSTEM SOFTWARE WAS UPDATED. THE VEHICLE WAS BEING DIAGNOSED BY THE DEALER WHEN THE COMPLAINT WAS FILED. THE MANUFACTURER HAS NOT ADDRESSED THE FUEL PUMP FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 37,500.

HIGH PRESSURE FUEL PUMP WENT OUT ON ME ON THE HIGHWAY. THE CAR STOPPED REAL FAST (NOT TO A COMPLETION), COULD HAVE CAUSED A MAJOR ACCIDENT. THANKFULLY NOBODY WAS BEHIND ME. *TR

I AM REPORTING TWO FAILURES OF THE HIGH-PRESSURE FUEL PUMP ON A 2008 BMW 535I. THE FIRST OCCURRED ABOUT ONE YR AFTER DELIVERY RESULTING IN THE CAR HAVING TO BE RETURNED TO THE DEALER IN LIMP MODE. A YEAR AFTER THE HPFP WAS REPLACED, THE EXACT SAME FAILURE OCCURRED, AND THE PUMP WAS REPLACED FOR A SECOND TIME. IMO, THIS REPRESENTS A SERIOUS SAFETY DEFECT THAT BMW SEEMS INCAPABLE OF CORRECTING. *TR

FAILURE OF THE HIGH PRESSURE FUEL PUMP (HPFP) IN MY 2008 BMW 535I. CAR LOST POWER ON THE HIGHWAY AND CAUSED A UNSAFE REDUCTION OF SPEED BEING THE CAR BY DESIGN WILL REDUCE POWER DURING THE FAILURE TO SAVE THE ENGINE. *TR

LOSS OF POWER TO CAR: 1 TURBOCHARGER REPLACED LOSS OF POWER TO CAR: FUEL PUMP REPLACED LOSS OF POWER TO CAR: 3 FUEL INJECTORS AND 3 SPARK PLUGS REPLACED. *TR

CAR ENGINE DIED WHILE DRIVING AT 50 MILES/HR. *TR

2008 BMW 535I, WITH SPORT PACKAGE WITH 3.0 LTR TWIN TURBO ENGINE. TWICE SINCE PURCHASING NEW ON 1 AUGUST 2008 THE "ENGINE MALFUNCTION-REDUCED POWER" WARNING APPEARED. IN BOTH CASES WARNING LIGHT DISAPPEARED AFTER DRIVING BETWEEN 25 AND 40 MILES AS DID THE LACK OF POWER. CAR ALSO OCCASIONALLY STARTS WITH ROUGH IDLE THAT DISAPPEARS WITHIN LESS THAN A MINUTE. CAR IS IN THE SHOP NOW FOR THE FIRST TIME AND INITIAL REPORTS SHOW RECORD OF "MISFIRE" EVENT. ISSUE COULD BE VERY DANGEROUS IF IT HAPPENS AT A VERY INOPPORTUNE TIME SUCH AS WHEN ACCELERATION IS REQUIRED TO SAFELY BLEND INTO TRAFFIC. NEEDS DEFINITIVE FIX IMMEDIATELY! MULTIPLE COMPLAINTS ON LINE IN MANY FORUMS SUGGEST THAT FIX IS NOT YET AVAILABLE FROM BMW. PERHAPS A REDESIGNED HIGH PRESSURE FUEL PUMP IS REQUIRED VICE A REPLACEMENT WITH ONE OF THE CURRENT DESIGN. *TR

2008 BMW X5 HAS A FAULTY FUEL INJECTOR PUMP AND BATTERY. *NJ THE CONSUMER STATED THE VEHICLE SUDDENLY STOPPED IN THE MIDDLE OF THE HIGHWAY. THE CONSUMER STATED THE VEHICLE STOPPED AGAIN IN THE MIDDLE OF THE HIGHWAY AFTER THE FUEL PUMP WAS SUPPOSEDLY REPLACED. THE CONSUMER WAS TOLD AGAIN THE FUEL PUMP WAS FAULTY. THE SUNROOF WAS INOPERATIVE AND THE CAMERA USED THAT GIVES GUIDANCE WHEN BACKING OUT OF SPACES WAS INOPERATIVE AS WELL. *JB

THIS CAR WAS PURCHASE BRAND NEW ON 12/12/2008. SO FAR THE FUEL SYSTEM HAS FAILED FOUR TIME. FUEL PUMP TWICE AND INJECTORS TWICE. THE CAR SUDDENLY LOOSES POWER DUE TO THIS ISSUES. MY CAR HAS 36K MILES. HAVING LOOKED AT NEWS GROUPS, A LOT OF PEOPLE ARE HAVING SIMILAR PROBLEMS WITH THIS MODEL. *TR

I WANT TO VOICE MY UTMOST DISSATISFACTION WITH MY 535I(CUSTOMER #113894) THUS FAR BASED ON FOLLOWING DETAILS. SERVICE DATE: 5/22/08, MILEAGE: 7592, VEHICLE EXPERIENCED DIFFICULTY STARTING IGNITION. YOUR SERVICE DEPARTMENT REPLACED "HIGH PRESSURE FUEL PUMP." SERVICE DATE: 1/17/09, MILEAGE: 16495, VEHICLE DISPLAYED MESSAGE, "ENGINE MALFUNCTION, REDUCED SPEED" THEN ENGINE STALLED DURING DRIVING IN 5 FREEWAY. YOUR SERVICE DEPARTMENT REPLACED "HIGH PRESSURE FUEL PUMP." LATEST EPISODE HAPPENED DRIVING IN 5 FREEWAY WITH MY TWO KIDS IN BACK SEAT. CAR STALLED IN THE MIDDLE OF FREEWAY AND I'VE HAD CLOSE CALL WITH SEMI TRUCK COMING RIGHT BEHIND ME. I THOUGHT HE WAS GOING TO SLAM RIGHT INTO ME! NEEDLESS TO THIS EXPERIENCE HAVE GIVEN ME A SCARE AND FEAR FOR MY KIDS' SAFETY, WHICH PROMPTED ME TO FILE A COMPLAIN WITH NHTSA. THIS 535I IS MY FIRST BMW AND IT WILL PROBABLY BE MY LAST ONE. I'VE HAD ACURAS BEFORE THIS VEHICLE AND HAD NOT HAD THIS TYPE OF LIFE THREATENING VEHICLE MALFUNCTION. *TR

SECOND HIGH PRESSURE FUEL PUMP FAILURE IN LESS THAN 2 MONTHS ( FIRST ONE REPLACED THE 2ND WEEK OF DECEMBER 2008 HAD ANOTHER FAIL TODAY ON THE WAY TO WORK 1/14/2009). THE HIGH PRESSURE FUEL PUMP (HPFP FROM NOW ON ) ON THE N54 MOTORS FROM BMW HAS BECOME A MAJOR ISSUE SPREADING ACROSS 3 DIFFERENT LINES ( 1,3,5 SERIES) , SOME THING NEED TO BE DONE QUICKLY, SINCE BUYING LOW CONTENT ETHANOL FUEL IS NEARLY IMPOSSIBLE. THIS WAS THE EXCUSE I WAS GIVEN, FAILURES DUE TO "HIGH" ETHANOL CONTENT ( ABOVE 10%), DRIVERS HAVE NO WAY OF TESTING AT THE PUMP HOW HIGH THE CONTENT IS EXCEPT FOR THE LABELS ON THE PUMP. *TR

HIGH PRESSURE FUEL PUMP KEEPS FAILING. LOSS OF POWER. *TR

2008 BMW 535XI WAGON. ENGINE MISFIRING/LOSING POWER AT HIGHWAY SPEEDS. DEALER FIRST RESET COMPUTER..HAPPENED AGAIN. DEALER REPLACED FUEL PUMP..HAPPENED AGAIN. DEALER REPLACED A CYLINDER INJECTOR....GOOD SO FAR. *TR

I BOUGHT A BRAND NEW BMW 525I M SPORT WHICH HAS DONE 1000 MILES. IT IS JUST 6 WEEKS OLD AND THE HIGH PRESSURE PUMP (HPP) WENT BUST. I JUST CAN'T BELIEVE IT. I BUY A CAR WITH MY HARD EARNED MONEY AND THIS HAPPENS. BMW SHOULD REALIZE THE IMPACT IT HAS ON SOMEONE WHO EXPECTS A LOT FROM HIS CAR SINCE HE IS PAYING OUT OF HIS NOSE. *TR

ADDED EXXONMOBIL GAS 9/2/2008. CAR DEAD BY 9/7/2008, AFTER DRIVING APPROX. 50 MILES. THE FUEL PUMP ON THIS VERY NEW CAR HAS FAILED. THE DEALER CLAIMS THE GAS WAS BAD (SAYS ALCOHOL LEVEL TESTED TO 15%), WHILE EXXONMOBIL INSISTS THE FUEL WAS FINE AT 10% ALCOHOL, FROM THE ETHANOL. I BELIEVE THE REAL PROBLEM IS THAT THE 2008 BMW 535XI'S CAN'T HANDLE EVEN 10% ETHANOL, SO THE FUEL PUMPS ARE FAILING. *TR