2000 Volkswagen Passat Suspension Problems

ENGINE MOUNTS BROKE AND I REPLACED THEM ON MAY 10, 2014, THEN THEY BROKE AGAIN ON JULY 6, AND I AGAIN REPLACED THEM NOW THEY BROKE AGAIN TODAY AS I WAS PULLING OUT OF THE GAS STATION. WAS THERE ANY TYPE OF RECALL RELATIVE TO THE MOUNTS OF THE ENGINE IN THIS MODEL WHICH IS THE 200 PASSAT WAGON WITH MANUAL TRANSMISSION. THE WINDOWS ALSO KEEP STEAMING UP AND STRONG SMELL OF ANTI FREEZE. *TR

CREAKING, GROANING, CLUNKING, SQUEAKING OUT OF THE FRONT END, MOST NOTABLY AT LOW SPEEDS OVER BROKEN PAVEMENT, SPEEDBUMPS, COMING TO A SLOW STOP AND PULLING AWAY SLOWLY FROM A STOP. CONTROL ARMS ISSUE. *TR

THE CONTROL ARMS IN MY 2000 VW PASSAT NEED TO BE REPLACED. I BELIEVE THAT THIS IS A DESIGN DEFECT. CONTROL ARMS SHOULD NOT FAIL AFTER ONLY 116,000 MILES. *TR

I HAVE HAD MY 2000 VW PASSAT FOR A LITTLE OVER TWO YEARS AND IT HAS BEEN A MONEY PIT! I HAVE HAD SO MANY PROBLEMS SINCE A MONTH OR SO AFTER I BOUGHT MY CAR. I BOUGHT THE CAR FROM A PRIVATE PARTY, TEST DROVE THE CAR, HAD IT CHECKED OUT BY A MECHANIC, AND I HAVE PUT THOUSANDS OF DOLLARS INTO THE CAR. I BOUGHT THE CAR JUST BEFORE MY SENIOR YEAR IN HIGH SCHOOL THINKING I MADE A WONDERFUL CHOICE, AND I HAD TO REPLACE A NEW RIGHT SIDE BOOT JUST AFTER A MONTH OF OWNING THE CAR. THE CHECK ENGINE LIGHT/ABS/AIRBAG KEPT COMING ON AND BEEPING AT ME, AND I HAD TO BUY A WHOLE NEW BRAIN TO THE CAR OVER $1500. I HAD TO REPLACE THE TIMING BELT WAY BEFORE THE MILE WARRANTY, OIL LEAKS WHICH RUINED SOME WIRES, NEW SHOCKS/SHOCK ABSORBERS, NOW THE WINDOW WILL GO PART WAY DOWN, BUT WILL NO LONGER GO UP... AND MY HEADLIGHTS ARE FOGGED UP WHICH I HAVE NOTICED ON ALL OTHER 2000 PASSATS...! MANY THINGS HAVE GONE WRONG WITH THIS CAR. I AM SO FRUSTRATED WITH THE CAR. I DO NOT RECOMMEND A VW TO ANYONE! I AM GOING INTO THE SECOND YEAR OF COLLEGE AND HAVE SPENT MOST OF MY SAVINGS ON THIS PIECE OF JUNK. I THINK AFTER FIXING A PART OF THE CAR THAT IT SHOULD RUN WITHOUT ANY PROBLEMS. SINCE I HAVE PUT SO MUCH MONEY INTO THIS CAR I CANNOT AFFORD TO GET A RELIABLE CAR. THERE IS SOMETHING SERIOUSLY WRONG WITH VW AND THE RECALLS! AS FAR AS I AM CONCERNED THE WHOLE CAR SHOULD BE RECALLED!!!! *TR

PURCHASED MY 2000 PASSAT IN 2003, HAD NUMEROUS PROBLEMS SINCE. IT SEEMED LIKE EVERYTHING ON THE CAR HAD TO BE REPLACED. THE CONTROL ARMS, O2 SENSORS, TWICE, BELTS, STEREO DIDN'T TURN ON, ALL NEW HOSES RIGHT AWAY, ALL 4 WINDOW REGULATORS, AND NOW TO TOP IT ALL OFF, THE ABS LIGHTS KEPT COMING ON. MY HUSBAND HAS A 2000 AUDI A4, VIRTUALLY THE SAME CAR, AND HAD TO REPLACE ALL OF THE SAME THINGS. THE ABS SEEMED TO WORK FINE, BUT THE DEALER SAID IT WOULD BE $1800 TO FIX IT. I LOOKED AT SOME ONLINE FORUMS AND FOUND THOUSANDS OF PEOPLE WITH SIMILAR PROBLEMS. THE MANUFACTURER, (BOSCH OR VOLKSWAGEN, SHOULD DO SOMETHING ABOUT THIS. MY CAR HAS BEEN PARKED SINCE AUGUST 2006 BECAUSE I DON'T HAVE MONEY TO FIX IT! I AM COLLEGE STUDENT. HELP!

9/2003: HEADLIGHTS AIMED INCORRECTLY; ROAD WASN'T ILLUMINATED. WITHIN 2 WKS, 1 OF THE BULBS BURNED OUT. WITHIN A WEEK OF THE 1ST, THE 2ND BULB BURNED OUT. COST TO HAVE HEADLIGHTS REPOSITIONED & BULBS REPLACED: $267. 9/2003: REAR TAIL LIGHT OUT. COST TO HAVE BULB REPLACED BY MECHANIC: $32.50. 11/2003: BOTH REAR WINDOWS OFF TRACK. COST TO TEAR DOORS APART & FIX: $159.75. 12/2003: ELECTRICAL PROBLEMS WITH FRONT POWER WINDOWS. NEVER KNOW IF WINDOW WILL GO UP OR DOWN. 2004: HAD CAR IN FOR (AT LEAST) 3 DIFFERENT DASHBOARD WARNING CODES. ONE HAD SOMETHING TO DO WITH FUEL, OR THE FUEL TANK OR SOMETHING. AFTER SOME TRIAL AND ERROR ON MY MECHANIC'S PART, DISCOVERED THAT UNSCREWING AND TIGHTLY RESCREWING GAS CAP FIXED THE PROBLEM. COST TO DIAGNOSE AND "FIX": $165. HAD (AT LEAST) TWO OTHER WARNING CODES IN 2004 THAT REQUIRED ME TO TAKE THE CAR IN. 6/24/2005: HAD BEEN HEARING CRUNCHING SOUND FROM FRONT RIGHT PORTION OF CAR THAT WAS PARTICULARLY APPARENT WHEN HITTING A POTHOLE, A DIP IN THE ROAD OR ATTEMPTING A TIGHT 360 TURN. MECHANIC (SPECIALIZING IN EUROPEAN CARS) IDENTIFIED A BAD CONTROL ARM. COST OF REPAIR & ALIGNMENT: $713.70. COST OF RENTAL CAR: $100.88. TOTAL: $814.58. NOTE: THE LEFT SIDE HAS BEEN MAKING THE SAME SOUND SINCE 12/2005. HAVE NOT YET REPAIRED IT. 10/24/05: CAR STARTED GOING DEAD INTERMITTENTLY. THE CAR HAD LESS THAN 60000 MILES ON IT. REPLACED BATTERY FOR $106.50. 1/2006: TEMP GAUGE MAXED OUT, COOLANT BOILED OVER, SMOKE & STEAM ISSUED FROM HOOD IN LESS THAN 8 MINUTES AT IDLE. COOLED CAR FOR 2L HOURS, REPLACED COOLANT AND DROVE TO MECHANIC, WHO REPLACED THERMOSTAT, WATER PUMP & TIMING BELT. COST: $725. 2/2006: BRAKES ARE SPONGY AND PROVIDE NO RESISTANCE UNTIL NEARING THE FLOOR. MECHANIC SAYS ROTORS AND BRAKE PADS ARE FINE. 6/2006: TRANSMISSION GETS STUCK IN 1ST GEAR. MUST STOP THE CAR, TURN IT OFF AND THEN RESTART. THIS IS AN ELECTRICAL PROBLEM AND IS GOVERNED BY THE COMPUTER. COST TO FIX: UNKNOWN. 6/2006: FRONT WINDOW NOW OFF TRACK. HAVE NOT YET FIXED IT. *NM

DT: THE CONTACT WAS COMPLAINING ABOUT A FRONT SUSPENSION CONTROL ARM:LOWER ARM PROBLEM. THE RUBBER BOOT PREMATURELY WORE OUT. HE RECEIVED A SPECIAL SERVICE ACTION FOR THIS PROBLEM IN NOVEMBER 2004 FROM THE MANUFACTURER. HE TOOK THE VEHICLE TO LOCAL DEALER FOR REPAIRS. LATER, WHILE HE WAS INSPECTING THE VEHICLE, HE DISCOVERED THE DEFECTIVE PART HAD NOT BEEN REPLACED. WHEN HE CONTACTED THE DEALER, THEY WERE NO LONGER WILLING TO OFFER A FREE REMEDY UNDER THIS SPECIAL SERVICE CAMPAIGN. THE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. *AK

I HAVE OWNED THIS VEHICLE FOR A LITTLE OVER A YEAR. DURING THIS TIME THIS PASSAT HAS HAD SEVERAL SUSPENSION PROBLEMS. THE UPPER CONTROL ARMS HAVE BEEN POINTED OUT AS A PROBLEM BY VARIOUS SERVICE CENTERS AND VW. THE CONTROL ARMS HAVE BEEN REPLACED TWICE AND THE PASSAT HAS AGAIN DEVELOPED A LOUD SQUEAKING NOISE FROM THE FRONT END OF THE VEHICLE. *NM

NOTICE CLUNKING AND SCHREECHING SOUND WHEN TURNING THE STEERING WHEEL. INDEPENDENT MECHANIC INFORMED OF LOWERCONTROL ARM DEFECTIVE. CAR CONTINUED TO MAKE CLUNKING SOUND WHEN TURNING, MECHANIC DIAGNOSED UPPER CONTROL (BALL JOINT) FAILURE.

I OWN A 2000 VOLKSWAGEN PASSAT. I WAS DRIVING ON A CITY STREET UNDER NORMAL CONDITIONS AND THE CONTROL ARM ON THE FRONT PASSENGER SIDE CRACKED CAUSING ME TO LOOSE CONTROL OF THE CAR. FORTUNATELY I WAS ABLE TO STOP WITHOUT FURTHER INCIDENT. THE CONTROL ARM IS BEING REPLACED. HOWEVER, THE INCIDENT COULD HAVE BEEN MUCH WORSE UNDER DIFFERENT DRIVING CIRCUMSTANCES.

CATASTROPHIC FAILURE OF FRONT END PARTS (TIE-RODS, UPPER LINKS) WHEN CAR HAD 59,000 MILES ON IT. *AK

(1) DRIVING ON EXPRESSWAY AT NORMAL HIGHWAY SPEED WHILE ROUNDING CURVE CAR MADE A LOUD SNAPPING NOISE AND BEGAN SWERVINGUNCONTROLABLY TO THE RIGHT. (2) CAR CAME TO REST HALF ON AND HALF OFF OF THE HIGHWAY, LANE HAD TO BE CLOSED AND TRAFFIC JAM RESULTED. (3) DEALER SAID RIGHT FRONT AND REAR UPPER CONTROL ARMS FAILED. PARTS MUST BE REPLACED.*AK

OVER THE PAST COUPLE OF YEARS I HAVE NOTICED VARIOUS NOISES COMING FROM THE FRONT END OF MY VEHICLE. UPON INSPECTION, NO PROBLEMS WERE NOTED BY THE SERVICE CENTERS I TOOK THE VEHCILE TO.*AK HOWEVER, THE STEERING CONTROL ON THE VEHICLE HAS SUDDENLY GOTTEN VERY BAD. AFTER TAKING THE VEHICLE TO A SERVICE CENTER, THEY TOLD ME BOTH OF THE TIE-ROD ENDS IN MY 2000 VW PASSAT HAVE FAILED AT 100,000 MILES. BOTH OF THE FRONT WHEELS HAVE A HUGE AMOUNT OF "PLAY" IN THEM WHICH LEADS TO THE CAR BEING DIFFICULT TO CONTROL, ESPECIALLY AT HIGHWAY SPEEDS. I HAVE OWNED MANY CARS AND IT IS VERY UNUSUAL TO HAVE THESE CRITICAL PARTS GO BAD IN A VEHICLE THIS EARLY. THE ESTIMATE FOR THE REPAIR WORK WAS WELL OVER $500. I HAVE GOTTEN NUMEROUS SECOND OPINIONS, AND ALL HAVE COME TO THE SAME CONCLUSION: THE TIE-RODS ARE BAD. ALL OF THEM ALSO TELL ME THEY HAVE SEEN THIS FAILURE ON THESE VEHICLES BEFORE AND NOT ON ANY OTHER VEHICLES AND THAT IT SEEMS TO BE A DEFECT IN THE DESIGN. AS OF YET, I HAVE NOT HAD THE VEHCILE REPAIRED BUT I HOPE TO DO SO SOON.

THE UPPER AND LOWER CONTROL ARMS ON BOTH SIDES OF THE FRONT OF THE VEHICAL ARE FAILING. THE DEALER SAID THAT IT WAS VERY ODD TO SEE THESE ITEMS FALING AT ONLY 67,000 MILES. IF THEY WERE TO COMPLETELY FAIL IT WOUD CAUSE THE DRIVER TO LOSE CONTROL OF THE VEHICAL. THIS SAME FAILURE HAS OCCURED ON A NUMBER OF OTHER VEHICALS OF THE SAME MODEL.*AK

CONTROL ARMS ON 2000 VOLKSWAGEN PASSAT ARE FAILING. THE CAR HAS 55,000 MILES; ARMS ALSO FAILED AT 36,000 AND WERE REPLACED. THIS IS NOT ACCEPTABLE; I HAVE ALSO HEARD OF PEOPLE WHO HAD THE CONTROL ARMS BREAK WHILE DRIVING. THIS PROBLEM HAS HAPPENED TO MANY, MANY OWNERS.*AK

STEERING WAS MAKING A FUNNY NOISE - BROGHT CAR IN FOR SERVICE WAS TOLD IT WAS UNSAFE TO DRIVE IT HOME. HAD TO REPLACE ALL CONTROL ARMS (4) DEALER SAID THIS WAS COMMON ON THIS VEHICLE. CAR HAD 60,000 MILES ON IT. THESE ITEMS SHOULD NOT FAIL SO SOON - COST $1600 TO REPAIR. *AK

A NOISE WAS HEARD IN THE FRONT END WHEN TURNING THE STEERING WHEEL LEFT OR RIGHT. CONSUMER TOOK VEHICLE TO THE DEALER, AND DEALER DETERMINED THAT UPPER AND LOWER BALL JOINTS WERE DEFECTIVE. *AK *MR

IT WAS DETERMINED THAT BOTH UPPER AND LOWER LINKS ON MY 2000 PASSAT HAD FAILED WITH 48,000 MILES ON THE CAR. *LA

FRONT UPPER CONTROL ARM NEEDS REPLACEMENT BECAUSE BALL JOINT IS LOOSE. THIS CAUSES SEVERE RATTLING WHEN DRIVING OVER EVEN LITTLE BUMPS. *JB

ARM CONTROL BALL JOINTS AND BUSHINGS PREMATURELY FAILED ON VEHICLE. BALL JOINT FAILURE WAS SO SEVERE THAT IT COULD HAVE SEPARATED FROM THE RACK AND DISABLED STEERING OF VEHICLE.*AK

CONTROL ARMS ON THIS MODEL ARE CHRONICALLY FAILING. EVERY PASSAT OWNER I HAVE TALKED TO IS HAVING A SIMILAR PROBLEM. MY VEHICLE IS ONLY AT 40000 AND THE CONTROL ARMS ARE STARTING TO CRACK AND TEAR. PLEASE INVESTIGATE AND CONSIDER A SAFETY RECALL. A CONTROL ARM FAILURE AT HIGH SPEED COULD BE FATAL.*JB

CONTROL ARM FAILURE LEADING TO SUSPENSION BREAKDOWN. SECOND OCCURRENCE IN 60000 MILES. FIRST OWNER. NOT HAPPY ABOUT VW'S INABILITY TO CLAIM FAULT FOR PROBLEM. *NLM

SEVEN OF THE EIGHT CONTROL ARMS ON MY 2000 VW PASSAT HAVE FAILED. THERE HAS BEEN A RECALL ISSUED IN EUROPE FOR THE SAME PROBLEM. LIKEWISE, THE AUDI A4 SHARES THE SAME CHASSIS AND SAME FRONT END SUSPENSION. JUST LIKE THE VOG RECALLED THE PASSAT AOA HAS RECALLED THE A4. HOWEVER VOA HAS DECIDED TO NOT ISSUE A RECALL AND RISKING THE PASSAT CUSTOMER BASE INJURY OR EVEN DEATH. WHY IS IT THE EXACT SAME PARTS WERE RECALLED AND THE SAME CHASSIS, BUT VOA HAS NOT RECALLED THE PASSAT. THE DEALERSHIP HAS TOLD ME THAT IT WILL COST 1,400.00 DOLLARS TO REPLACE THE CONTROL ARMS. NHTSA NEEDS TO QUESTION VOA ON THIS MATTER. MY CAR HAS 40,000 MILES ON IT AND IS BEING MAINTAINED BY A VOLKSWAGEN TECHNICIAN. THERE IS JUST NO REASON WHY A PART THAT IS DESIGNED TO LAST THE LIFE OF THE CAR HAS FAILED AT 40,000 MILES. *JB

VW WILL NOT COVER THE REPAIR OF THE CONTROL ARMS AND AFTER RESEARCHING THE WEB I FOUND THAT FAILURE OF THE CONTROL ARMS ARE NORMAL FOR THIS MODEL. *PH *JB **DIMSII IVOQ ENTRY POSTED AFTER 12/12/02 CUT OVER TO ARTEMIS**770854

THE CONSUMER STATES THE PROBLEM IS THE CONTROL ARM BUSHINGS BECAUSE THE CAR CREAKS OVER BUMPS AND WHEN BEING DRIVEN AROUND CORNERS ALSO WHEN YOU SIT DOWN IN THE CAR IT CREAKS. *JG

CONTROL ARM FAILURES ARE VERY COMMON ON THIS SUSPENSION DESIGN, PLEASE INVESTIGATE FURTHER BEFORE THERE ARE FATALITIES. *AK

THERE IS A NOISE IN FRONT, UNDERNEATH VEHICLE WHILE WHEELS ARE IN MOTION. DEALERSHIP IS AWARE OF PROBLEM.*AK

SUN ROOF LEAKS - DRAINS CLEANED BY DEALER TWICE - STILL LEAKING. DRIVER'S SEAT BACK MOVES FORWARD WHEN BRAKE APPLIED. DEALER CLAIMS THIS IS NORMAL. SEAT BACK CAN BE MOVED BY HAND. CAR HAS VIBRATION AND STEERING WHEEL SHAKES AT MOST SPEEDS. DEALER CLAIMS TIRES ARE THE PROBLEM. HOWEVER, TIRES HAVE BEEN INSPECTED TWICE (AT MY EXPENSE) BY INDEPENDENT DEALERS WHO STATE TIRES ARE O.K. WHEELS REBALANCED, FRONT END ALIGNED, (ALL AT MY EXPENSE) AND PROPLEM PERSISTS. VW REFUSES TO HELP CLAIMING PROBLEM IS RELATED TO TIRES.*AK

DEALER HAS FAILED SEVERAL TIMES TO CORRECT STEERING PROBLEM. CAR HAS CONSTANT VIBRATION AND STEERING WHEEL SHAKE ON TURNS. FRONT END ALIGNED (NOT NEEDED) WHEELS BALANCED AND ROTATED (AT MY EXPENSE) WITHOUT PROBLEM CORRECTION. SUNROOF LEAKS. DRIVER'S POWER SEAT MOVES WHEN COMING TO A FULL STOP. DEALER STATES THIS IS OK

CONTROL ARM FAILURE IS COMMON AMONG VW PASSATS. PLEASE DO SOMETHING ABOUT THIS POTENTIALLY LIFE THREATENING PROBLEM.*AK