1999 Volkswagen Passat Fuel System Other Problems

ON 6/10/2004, I HAD MY VW PASSAT REPAIRED AT MITCHELL VOLKSWAGEN, CANTON, CT, FOR ROUGH IDLE AND CHECK ENGINE LIGHT. DEALER FOUND SCAN CODES FOR CYLINDER #2 MISFIRES AND RANDOM/MULTIPLE MISFIRES. DEALER REPLACED ICM IGNITION CONTROL MODULE AND CLEARED FAULT. THEN DEALER ATTEMPTED TO SET BASIC SETTINGS AND A NEW PROBLEM WAS GENERATED, THROTTLE BODY WOULD NOT ADAPT. I NOW HAVE A CONTINUOUS CHECK ENGINE LIGHT. DEALER DID NOT EXPLAIN WHY THEY TRIED TO SET THE BASIC SETTINGS FOR THE REPLACEMENT OF THE ICM. IT IS MY UNDERSTANDING THAT IF THE BASIC SETTINGS ARE NOT PERFORMED CORRECTLY A MALFUNCTION TO THE THROTTLE VALVE CONTROL CAN OCCUR. THE DEALER TOLD ME THE THIS PROBLEM MAY BE SELF CORRECTING. IF IT DOES CORRECT ITSELF, I NEED TO REPLACE THE THROTTLE BODY FOR APPROX. $500.00. I HAVE SPENT MORE THAN $539.00 TO HAVE MY ICM REPLACED AND NOW HAVE A NEW PROBLEM. NOW I AM TOLD "MAY REQUIRE REPLACEMENT OF THE THROTTLE BODY TO CORRECT, WILL NOT CAUSE VEHICLE TO RUN ROUGH, MAY CAUSE SURGING AT IDLE OR SLIGHT HESTITATION ON ACCELERATION, PART NEEDS TO BE ORDERED. IT MAY CORRECT ITSELF IN 200 MILES. THE DEALER SAID IT'S OK TO DRIVE THE VEHICLE UNDER THESE CONDITIONS (CHECK ENGINE LIGHT AND HESTITATION AND SURGING). I CONTACTED VW CUSTOMER SERVICE AND THEY AGREE WITH THE DEALER. I THINK THIS IS A MANUFUCTURE'S DEFECT IN DESIGN AND YOU SHOULD NOT HAVE TO DRIVE A VEHICLE WITH A CHECK ENGINE LIGHT WITH HESTITATION AND POSSIBLE SURGING, THESE ARE SAFETY ISSUES. THE VW CUSTOMER SERVICE WOULD NOT GIVE ME SOMEONE ELSE AT VW TO EXPRESS MY SAFETY CONCERNS.*AK

GAS GUAGE INDICATE THERE IS GAS IN VEHICLE. BUT, VEHICLE WOULD STOP RUNNING DUE TO AN EMPTY GAS TANK. DEALER HAS SEEN VEHICLE SEVERAL TIMES, AND CANNOT FIND SOLUTION. *AK