2004 Toyota Tacoma Tires Problems
7 owner-reported tires complaints from NHTSA data
Data sourced from NHTSA public database. For informational purposes only. Always consult a qualified mechanic.
Tires Recalls (1)
TIRES:TEMPORARY/EMERGENCY SPARE TIRE
Toyota is recalling certain model year 2001 through 2004 Tacoma light trucks manufactured from August 28, 2000, through August 27, 2004, and originally sold, or currently registered, in the following cold climate states with high road salt usage: Connecticut, Delaware, Illinois, Indiana, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. The spare tire in the subject vehicles is located underneath the rear of the vehicle and held by a spare tire carrier. A lift plate on the carrier is used to help raise, lower and retain the tire. During its manufacture, the lift plate may not have been sufficiently coated with anti-corrosion materials. If the plate is insufficiently coated and the vehicle is operated in cold climate regions where road salts are frequently used, road spray can reach the carrier assembly and corrode the lift plate.
Fix: Toyota will notify owners, dealers will inspect the vehicle and replace the spare tire carrier lift plate as necessary, free of charge. The recall began in February 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Owner Complaints (7)
Your steering wheel shudders significantly while driving at various speeds. When you took your truck to have the tires balanced and rotated, the mechanic found that the front tires were out of round, had separated belts, and fractured beads—meaning they couldn't be serviced. The tires failed at around 20,000 miles of use. Replacing the damaged tires with a new set should resolve the shuddering issue.
Parts you may need:
As an Amazon Associate, MyCarTSB earns from qualifying purchases.
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA EQUIPPED WITH BLACKLION TIRES, TIRE LINE: CILERRO, TIRE SIZE: 205/70/R15, DOT NUMBER: 5417. THE CONTACT STATED THAT THE TIRES WERE DRY ROTTED AND CRACKING ON THE TREAD AND SIDEWALLS CAUSING AIR TO LEAK FROM THE TIRES. THE FAILURE HAD OCCURRED ON THE FRONT DRIVER'S SIDE TIRE AND THE REAR PASSENGER'S SIDE TIRE. THE LOCAL MR. TIRE WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 75. THE VIN WAS NOT AVAILABLE.
TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 12V542000 (TIRES).THE VEHICLE WAS TAKEN TO NOURSE TOYOTA LOCATED AT 423 N BRIDGE ST, CHILLICOTHE, OH 45601 WHERE DIAGNOSED THAT THE FRAME WAS CORRODED AND WOULD CRUMBLE IF THE RECALL WAS COMPLETED. THE DEALER INFORMED THE CONTACT THAT THEY DID NOT WANT TO BE RESPONSIBLE FOR ANY DAMAGES TO VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND OPENED CASE 1803261619 BUT NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 133,000.
TL* THE CONTACT WAS A FRIEND TO THE DRIVER OF A 2004 TOYOTA TACOMA EQUIPPED WITH TOYO OPEN COUNTRY TIRES H/T/ TUFF DUTY TIRES, SIZE: 265/70/R16 (NA). THE CONTACT STATED THAT THE REAR DRIVER'S SIDE TIRE WAS FLAT. THE CONTACT ATTEMPTED TO ADD MORE AIR TO THE TIRE, BUT THE TIRE WOULD NOT REMAIN INFLATED. THE CONTACT STATED THAT THE DRIVER HAD TO CONSTANTLY REFILL THE AIR IN THE TIRE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE TREAD WAS SEPARATED. THE VEHICLE WAS ALSO TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THERE WAS A PIN HOLE IN THE TIRE THAT NEEDED TO BE REPLACED. THE TIRE FAILURE MILEAGE WAS APPROXIMATELY 20,000. THE VIN AND VEHICLE FAILURE MILEAGE WERE NOT PROVIDED.
I WAS INFORMED IN DECEMBER OF 2012 OF A RECALL ON MY 2004 TACOMA WHERE THE SPARE TIRE HOLDER COULD RUST AND FALL OFF. AS OF 4/24/2013 I STILL HAVEN'T BEEN NOTIFIED OF WHAT TOYOTA,S PLAN TO FIX THIS PROBLEM IS. WHAT CAN I DO? *TR
A WEEK AFTER BUYING MY TACOMA (04) WE WERE DRIVING ON THE FREEWAY AND W/ONLY 496.4 MILES ON IT, THE TRUCK STARTED TO SHAKE CONTINUOSLY, IT STARTED SMOKING AND THE STEERING WHEEL SEIZED UP ON ME. I MANAGED TO AVOID A HUGE CAR ACCIDENT, AND PULLED TO THE SIDE OF THE ROAD. WHEN WE GOT OUT WE SAW THAT MY BACK DRIVERS SIDE TIRE WAS COMPLETELY GONE AND HAD A SIDEWALL BLOWOUT W/NOTHING LEFT ON THE TIRE. I CALLED TOYOTA AND THEY WOULD DO NOTHING FOR ME SINCE IT WAS THE TIRE, I HAD TO TAKE IT TO A TIRE COMPANY. I DID GET THE ONE TIRE REPLACED BUT IT WAS A TIRE THAT DIDN'T MATCH MY OTHER 3. I HAD REQUESTED ALL OF MY TIRES TO BE INSPECTED AS WELL AS MY TRUCK BUT NO ONE WOULD COOPERATE.
VEHICLE WAS EQUIPPED WITH 4 GOODYEAR WRANGLER TIRES, SIZE P205/75R15, DOT # M6ULF00R1203. THE OUTER SIDEWALL ON THE RIGHT REAR TIRE COMPLETELY EXPLODED. THERE WAS NO PUNCTURE. CONSUMER WAS ABLE TO PULL OVER TO THE RIGHT. *AK