2002 Toyota Rav4 Electrical Problems

Your car is lagging and jerking when you accelerate from a complete stop, as if it's struggling to shift into gear. In one incident, your engine stalled while climbing a mountain, and you lost power steering, forcing you to use the emergency brake to regain control. A transmission specialist identified the issue as a faulty engine control module (ECM), which has been reported as a known problem in your model year.

FEDERAL EMISSIONS WARRANTY FOR THE ECM ON 2001-2003 TOYOTA RAV4'S PALM SPRINGS TOYOTA FAILED TO NOTIFY OR ADVISE THAT THIS MUCH NEEDED REPAIR NEEDED TO BE DONE, HOWEVER DID NOTIFY AND REPAIR THOUSANDS OF DOLLARS OF OTHER REPAIRS IN THE OPEN AVAILABLE AND ALLOTTED TIME FRAME THAT THIS ECM SHOULD HAVE BEEN REPLACED.

THE ECM WHICH CONTROLS THE TRANSMISSION FAILED.

ECM MALFUNCTION. *TR

MY MOTHER HAD THE ENGINE CONTROL MODULE FIXED JUNE OF 2013. SHE HAD TO PAY FOR THIS REPAIR HERSELF BECAUSE TOYOTA REFUSED TO FIX IT, EVEN THOUGH THEY SENT LETTERS OUT TO PEOPLE SAYING THAT THEY WOULD COVER THE COST TO REPAIR THIS KNOWN ISSUE. AFTER 1900.00 LATER, SHE PAID FOR IT. A YEAR LATER I OWN THIS SAME VEHICLE AND THE SAME THING HAS GONE BAD. ITS JUST OUT OF THE WARRANTY. I ALMOST GOT HIT DUE TO THE CAR STALLING WHEN I PULLED OUT AT AN INTERSECTION. THIS IS A KNOWN PROBLEM, AND IT WAS PAID FOR BY ANOTHER FAMILY MEMBER. YET IT HAS THE SAME ISSUE. TOYOTA NEEDS TO FIX THIS PROBLEM. HORRIBLE COSTUMER SERVICE. *TR

THE ECM MALFUNCTION. *TR

ON STARTING, THE CAR THE BATTERY LIGHT CAME ON AND STAYED ON. A MONTH OR SO LATER I NOTICED A CLUNKING IN THE TRANSMISSION AS THE AUTOMATIC WENT TO A HIGHER GEAR. THIS PROBLEM STILL REMAINS. *TR

TOYOTA 2002 RAV4, AUTOMATIC TRANSMISSION PROBLEM WHEN SWITCHING INTO FIRST / SECOND GEAR, CAR WILL HICCUP, AND OR NOT ACCELERATE AS EXPECTED. AAMCO TRANSMISSION SPECIALISTS CONFIRMED DEFECTIVE ECM MODULE FAILURE, AND REQUIRE A FULL TRANSMISSION REBUILT. TOYOTA APPARANTY KNOWS ABOUT THIS PROBLEM, AND HAS ISSUED SERVICE ADVISORY, BUT NO RECALL. PROBLEM CAN RESURFACE ANY ANYTIME, VERY HIGH POTENTIAL FOR ACCIDENTS AS CAR WILL FAIL TO ACCELERATE OR JUST STALL WHEN ENTERING INTERSECTIONS AND OR FREEWAYS.

AUTO: 2002 TOYOTA RAV4 ISSUE: ECU OR ECM COMPLAINT: TOYOTA REFUSES TO REPAIR ANY TRANSMISSION DAMAGES ASSOCIATED WITH THE FAULTY COMPUTER PART. DESCRIPTION: WHEN PRESSING THE GAS WHILE ACCELERATING FROM A COMPLETE STOP, THE TRANSMISSION WILL NOT SHIFT PROPERLY. JERKY MOVEMENTS IN THE LOWEST GEARS AND REVERSE; SLUGGISH WHEN PEDAL FULLY PRESSED. CURRENT RESOLVE: TOYOTA WILL REPLACE THE ECM, THOUGH THE PART WILL TAKE 2-3 WEEKS DUE TO HIGH DEMANDS. TOYOTA WILL NOT REPAIR ANY OTHER TRANSMISSION DAMAGES ASSOCIATED WITH THE FAULTY PART. *TR

I HAVE A TOYOTA RAV4 AND ITS COMPUTER BROKE. WE TOOK IT TO MANUFACTURE AND THEY SAID THE COMPUTER IS FREE TO REPLACE UNDER WARRANTY, HOWEVER, THEY CHARGE US REPAIR COST AROUND $700. IS IT LEGAL TO CHARGE FOR THE REPAIR FOR ANYTHING UNDER WARRANTY? *TR

MY WIFE WAS DRIVING OUR RAV 4 WITH MY SON ABOARD. THE CAR BEGAN EXPERIENCING TROUBLE ACCELERATING, CAR WOULD HESITATE, THEN ALL OF A SUDDEN IT WOULD LURCH FORWARD. IT WAS TOTALLY UNSAFE TO DRIVE AT THAT POINT. I HAVE LEARNED THAT THIS IS DUE TO A FAULTY ECM WHICH HAS CAUSED THIS VEHICLE TO BE EXTREMELY UNSAFE. II TOOK THE CAR TO MY MECHANIC AND SURE ENOUGH THE CAR SHOWED THE P0755 OBD II CODE WHICH INDICATES THAT THE ISSUE IS WITH THE ECM. F LEFT UNATTENDED, THE TRANSMISSION WILL REQUIRE REPLACEMENT AT A COST OF $4000 - $5000. I TALKED TO TOYOTA ABOUT IT AND THEY SAID A REPAIR WAS COVERED UNDER A CUSTOMER SUPPORT WARRANTY EXTENSION PROGRAM (*CASE # 1010011845). HOWEVER, NOW I TALK TO FITZGERALD TOYOTA IN GAITHERSBURG (JUDITH) AND THEY INDICATE THAT THEY HAVEN'T EVEN HEARD OF THIS PROGRAM. *TR

MY 2002 TOYOTA RAV4 BEGAN HAVING PROBLEMS SHIFTING IN APRIL 2010. IT WAS INTERMITTENT, AND WASN'T CAUSE FOR CONCERN UNTIL MY CHECK ENGINE LIGHT CAME ON IN MAY 2010. THE SYMPTOMS OF THE PROBLEM WITH MY VEHICLE ARE THAT IT STALLS, HESITATES, AND HAS A STOP / GO (JERKING) TYPE OF ACTION WHILE DRIVING IT. AT THAT TIME, I TOOK IT TO A SERVICE TECHNICIAN AT MY LOCAL TOYOTA DEALER WHERE I PURCHASED BOTH OF MY TOYOTAS. THEY TOLD ME THAT THE ECM HAD TO BE REPLACED AND WOULD COST AROUND 1,300 DOLLARS. MIND YOU, I HAD TO PAY 75 DOLLARS FOR THE DIAGNOSTIC CHECK. THE FOLLOWING WEEK, I TOOK MY RAV4 TO A LOCAL TRANSMISSION SHOP, HAD IT DIAGNOSED FOR A SECOND OPINION AND HE CONFIRMED THAT THE ECM UNIT WAS BAD AND NEEDED TO BE REPLACED, WHICH COST ME YET, ANOTHER 75 DOLLARS FOR THE DIAGNOSIS. HE ALSO INSTRUCTED ME NOT TO CONTINUE TO DRIVE THE CAR BECAUSE IT COULD POSSIBLY HARM THE TRANSMISSION. SINCE DOING SO, I HAVE BEEN DOWN TO ONE CAR FOR TWO AND A HALF MONTHS BECAUSE I SIMPLY DON'T HAVE THE MONEY TO HAVE IT REPAIRED. AFTER DOING SOME RESEARCH ONLINE, I FOUND OUT THAT TOYOTA HAS KNOWN ABOUT THIS PROBLEM SINCE 2006. IT IS A SERIOUS SAFETY ISSUE WHEN ENTERING TRAFFIC, OR TRYING TO MOVE FROM A STOP LIGHT OR STOP SIGN, AS YOU DON'T KNOW WHEN THE CAR IS GOING TO SHIFT INTO GEAR OR NOT. TOYOTA HAS NOT ISSUED A RECALL, NOR HAS NOT DONE ANYTHING TO RESOLVE THE ISSUE. I AM DISGUSTED THAT IN 2006 TOYOTA REALIZED THERE WAS AN ISSUE WITH THE ECM, WHICH COULD RUIN THE TRANSMISSION. INSTEAD OF LETTING CONSUMERS KNOW ABOUT THIS ISSUE AS SOON AS THEY REALIZED, THEY SENT A TECHNICAL SERVICE BULLETIN TO DEALERSHIPS AND SERVICE AREAS, BUT FAILED TO LET THEIR OWN CUSTOMERS KNOW. ACCORDING TO INTERNET RESEARCH, THIS PROBLEM GENERALLY STARTS AROUND 90,000 MILES AND CAUSES CONSIDERABLE DANGER WITH JERKING AND SHIFTING PROBLEMS. ACCORDING TO INTERNET RESEARCH, THIS PROBLEM GENERALLY STARTS AROUND 90,000 MILES AND CAUSES CONSIDERABLE DANGER WITH JERKING AND SHIFTING PROBLEMS. *TR

I RECENTLY HAD A FAILURE OF THE CONTROL MODULE (ECU), I WAS TOLD BY MY MECHANIC THAT THIS PROBLEM CAME UP FREQUENTLY FOR RAV 4S OF YEARS 2002 AND 2003 AND THAT TOYOTA WAS AWARE OF THIS ISSUE SINCE 2006 ' BUT NEVER RECALLED THE CARS! AFTER SEARCHING ON THE INTERNET I NOTICED THAT THERE WERE HUNDREDS OF COMPLAINTS REGARDING EXACTLY THE SAME ISSUE AND EVEN A CLASS ACTION LAWSUIT FOR THE SAME MATTER FILED IN 2009. THE REPLACEMENT COST ME $758.50 TO REPLACE (WITH A REFURBISHED ONE) AND I HAD TO RENT A CAR DURING THE REPLACEMENT PROCESS ' WHICH COST ME $131.32 ' THEREFORE A TOTAL OF $889.82. *TR

2002 TOYOTA RAV4 ALL OF A SUDDEN WOULDN'T SHIFT BETWEEN 3RD AND 4TH GEAR. TO OK IN IMMEDIATELY INTO DEALERSHIP TO BE CHECKED. SAID IT WAS THE ECM. IT WAS ALREADY TAKEN IN FOR RECALL AND IS ANOTHER MALFUNCTION OF SAME PROBLEM. IF YOU DRIVE IT WILL RUIN YOUR TRANSMISSION. I AM VERY DISAPPOINTED IN THE DEALERSHIP AS THEY ONLY SAID TO CALL TOYOTA. I HAVE DONE THAT AND AM WAITING A RESPONSE. THERE ARE MANY COMPLAINTS ON THIS AND 220,000 TOYOTA VEHICLE HAVE ISSUES. MY CAR ONLY HAS 56000 MILES ON IT AND SHOULD STILL BE COVERED BUT THEY STOP AT 8 YEARS. I AM 25 DAYS PAST WARRANTY. DUE TO THEM KNOWING AND ALREADY RECALLING THEM THEY SHOULD BE LIABLE. *TR

MY 2002 TOYOTA RAV4 CHECK ENGINE LIGHT CAME ON. THE LIGHT WENT OFF A FEW DAYS LATER, BUT MY HUSBAND TOOK IT TO A MECHANIC TO HAVE IT LOOKED AT. THE MECHANIC SAID THE ECU (COMPUTER) FAILED. A FEW DAYS LATER THE CAR HAD PROBLEMS SHIFTING, AND IT STARTED BUCKING ON THE HIGHWAY. I DID SOME RESEARCH ON THE INTERNET, AND CAME TO FIND OUT THAT THIS IS A KNOWN DEFECT WITH THE 2002 TOYOTA RAV4. THERE WAS A TOYOTA INTERNAL MEMO WRITTEN IN 2006 ADMITTING THE DEFECT. MY HUSBAND AND I BOUGHT THIS CAR BRAND NEW. THE CAR HAS ONLY 60,000. MILES ON IT. WE CALLED TOYOTA TO SEE IF THEY WOULD HONOR THE WARRANTY (WE ARE THREE MONTHS OVER THE WARRANTY) AND THE DEALERSHIP SAID NO, AND TOYOTA HEADQUARTERS GAVE US A CASE NUMBER, AND REFERRED US BACK TO THE DEALERSHIP. WE HAVE BEEN LOYAL TOYOTA CUSTOMERS. WE ALSO BOUGHT A 2007 TOYOTA SIENNA. IT IS UNCONSCIONABLE THAT A COMPANY IS PUTTING ITS CUSTOMERS AT RISK WITH A DEFECTIVE PART, AND THEN HIDING IT FROM THE VEHICLE OWNER. WE NEVER RECEIVED A MEMO ABOUT THE DANGER OF THIS VEHICLE. DOES SOMEONE HAVE TO BE KILLED IN ORDER FOR OUR GOVERNMENT TO GET INVOLVED? TOYOTA SHOULD BE ORDERED TO REPLACE THE DEFECTIVE PARTS THAT IT WILLFULLY SOLD TO ITS CUSTOMERS AND THEN TRIED TO COVER IT UP! *TR

I HAVE A 2002 TOYOTA RAVE 4, I HAVE EVEN COMPLAINED TO THE DEALERSHIP WHERE I BOUGHT THE VEHICLE. I COMPLAINED ABOUT IT SPEEDING OUT OF CONTROL WHEN I USED THE CRUISE CONTROL AND IT STILL DOES AND I CAN REPRODUCE IT EVERY TIME ON THE SAME ROAD. I ALSO HAD COMPLAINED ABOUT STEPING ON THE BREAKES AND THE CAR NOT WANTING TO STOP. DEALERSHIP TOLD ME "IT WAS IN MY HEAD, AND THAT THEY COULDN'T FIND ANYTHING WRONG WITH IT." I WAS ACTUALLY IN A CAR ACCIDENT ON MY WAY INTO THE DEALERSHIP TO HAVE THEM CHECK THE SAME PROBLEM AGAIN. I REPORTED IT SEVERAL TIMES TO THEM AN I HAVE HAD THE CAR SINCE 2005.

IN THE FALL OF 2008, THE FACTORY INSTALLED CRUISE CONTROL ON MY 2002 TOYOTA RAV 4 FUNCTIONS INTERMITTENTLY. IT WILL WORK FOR A SHORT PERIOD ON ANY LONG TRIP THEN WILL CAUSE VEHICLE TO DECELERATE. SOMETIMES CANNOT GET IT TO WORK AGAIN. LIGHT WILL FLASH ON AND OFF ON THE DASHBOARD. HAVE TAKEN IT IN TO LOCAL TOYOTA DEALERSHIP WHO CANNOT GET IT TO DUPLICATE. THE MECHANIC STATES EVERYTHING IS FINE. DUE TO SEMI-FUNCTIONAL CRUISE, THE MILEAGE ON A LONG DISTANCE TRIP HAS DECREASED FROM 30-32 MPG TO 24-26MPG.REPORTED THIS TO TOYOTA IN 2009 AND GIVEN A CASE # WHICH I HAVE MISPLACED. THEY DID NOT APPEAR TO BE CONCERNED OR ADMIT THEY HAD A PROBLEM. EXTENDED WARRANTY (TO 100,000 MILES) WILL NOT COVER THE REPAIR. THERE IS INDEED AN ELECTRICAL ISSUE GOING ON, BUT NO ONE SEEMS TO SOLVE THE PROBLEM OR CARE. IN SEARCHING I HAVE FOUND OTHER PEOPLE WHO HAVE POSTED COMMENTS REGARDING THE SAME ISSUE WITHOUT RESOLUTION. *TR

TL*THE CONTACT OWNS A 2002 TOYOTA RAV4. THE CONTACT STATED THAT THE ECU BOARD FAILED ON THE VEHICLE AND THAT THE DEALER SAID THAT THEY WERE AWARE OF THE FAILURE. THE DEALER STATED THAT THE ECU BOARD NORMALLY FAILED AT 75 MILES ON HIS YEAR, MAKE AND MODEL VEHICLE. AFTER THE ECU FAILED THE VEHICLE BEGAN TO LUNGE FORWARD WHEN IT SHIFTED. THE FAILURE MILEAGE WAS 82,000 AND THE CURRENT MILEAGE WAS 105,000. UPDATED 05/10/10 *BF UPDATED 05/11/10. *JB

AFTER HAVING AN OXYGEN SENSOR REPLACED IN THE EXHAUST SYSTEM OF MY 2002 TOYOTA RAV4 ON 02/02/10, I NOTICED THAT MY CAR BEGAN ACCELERATING SLUGGISHLY. APPROXIMATELY 50 MILES AFTER THE SERVICE WAS PERFORMED, I NOTICED MY CAR JERKED WHEN SHIFTING THROUGH GEARS 1-3 AND THE TACHOMETER WOULD REV TO 3000 RPMS. THE CAR THEN RAN FINE FOR APP. 4 DAYS WITH NO GEAR SLIPPAGE. A WEEK LATER THE GEARS STARTED SLIPPING AGAIN WITHOUT WARNING AND THE CAR SEEMED TO HAVE NO POWER WHEN THE GAS PEDAL WAS FULLY ENGAGED DURING A RIGHT HAND TURN TO MERGE WITH ONCOMING TRAFFIC. THE CAR THEN BUCKED VIOLENTLY. THIS RESULTED WITH MY PASSENGER AND I BECOMING ANXIOUS/SCARED BECAUSE WE DIDN'T KNOW IF THE TRAFFIC COMING TOWARD US WOULD HAVE HIT US IF WE SUDDENLY LOST POWER. I IMMEDIATELY DROVE MY CAR HOME WHERE IT HAS REMAINED PARKED AND SET AN APPOINTMENT WITH A TOYOTA DEALER EXPLAINING THE PROBLEMS. ACCORDING TO SIMILAR STORIES FROM FELLOW RAV4 OWNERS, THERE IS A PROBLEM WITH THE ELECTRONIC CONTROL MODULE CAUSING IRREVERSIBLE DAMAGE TO THE TRANSMISSION. I AM TAKING THE CAR TO THE DEALER TO HAVE IT 'OFFICIALLY' DIAGNOSED ALTHOUGH IT ONLY CODES TO HAVE THE O2 SENSOR REPLACED, WHICH I DID. *TR

WAS DRIVING IN A 55 MILE HIGHWAY CAR FELT LIKE WAS DRIVING THROUGH SLUDGE. ENGINE LIGHT CAME ON. THEN CAR STARED JERKING GOT TO SIDE OF ROAD AND HAD TOWED TO TOYOTA DEALER SHIP SAID THE TRANSMISSION CHIP WAS BAD COST AROUND $1300.. AND NEW TRANSMISSION ALTOGETHER WOULD COST ME $6000.*TR

2002 TOYOTA, RAV4, MY CHECK ENGINE LIGHT CAME ON, THE CAR ONLY HAS 50,000MILES ON IT, I HAVE JUST RECENTLY HEARING ABOUT THIS SAME PROBLEM WITH MANY OTHER TOYOTA RAV 4 OWNERS. *TR

MY 2002 TOYOTA RAV4 HAD ISSUES WITH THE ECU (COMPUTER) WHICH CONTROLS THE GEAR SHIFTING. THE SYMPTOMS ARE STALLING/PAUSING BETWEEN 1ST AND 2ND AND/OR 2ND AND 3RD GEAR. WHEN IT HAPPENS, PRESSING ON THE GAS HAS NO EFFECT - CAR DOES NOT ACCELERATE. OCCURS QUITE FREQUENTLY AFTER THE PROBLEM SURFACES. ON 10/8, AS I WAS TAKING A LEFT TURN ONTO A MAIN ROAD, I HAD A STALL AND COULD NOT ACCELERATE. THERE WAS AN ONCOMING CAR THAT HAD ENOUGH TIME TO STOP AND DID NOT HIT ME. I HAD MY MOTHER AND 14 MONTH OLD DAUGHTER IN THE BACK. I RESEARCHED THE ISSUE ONLINE AND FOUND THIS SAME COMPLAINT FOR HUNDREDS OF RAV4 OWNERS. THE ECU (COMPUTER) FAILS AFTER SIGNIFICANT MILEAGE (I'M AT 135K), CAUSING THE TRANSMISSION TO BE AFFECTED. IF THE ECU REPAIR DOES NOT SOLVE THE PROBLEM, THE TRANSMISSION NEEDS TO BE REBUILT. I HAD THE ECU RE-BUILT FOR $1,413 ($1200 FOR THE PART ALONE) AND IT SEEMS TO HAVE FIXED MY ISSUE. *TR

I HAVE A 2002 RAV 4 WITH 60K MILES AND THE ECM IS FAULTY AND IS CAUSING MY TRANSMISSION TO SLIP, FLARE UP, AND ALMOST GOT ME KILLED IN CAR ACCIDENT AD MY VEHICLE WOULD NOT MOVE IN TRAFFIC UNTIL IT FINALLY GRABBED AND WENT FORWARD. NOW, I HAVE TO SPEND $4000 TO HAVE MY TRANSMISSION FIXED AT 60K MILES. I AM OUTRAGED THAT TOYOTA HAS NOT RECALLED THIS FAULTY COMPUTER ECM. IT'S DANGEROUS AND DEFECTIVE AND NEEDS TO BE RECALLED. I WILL BE CONTACTING AN ATTORNEY AS 1000'S OF OTHERS ARE HAVING THE SAME PROBLEM AND DISCUSS A CLASS ACTION LAWSUIT. *TR

MY 2002 TOYOTA RAV4 HAS A KNOWN DEFECT WITH THE ELECTRONIC CONTROL MODULE WHICH CAUSES THE TRANSMISSION TO GO BAD WHICH RESULTS IN THE CAR HESITATING AND JERKING WHICH ALMOST CAUSED AN ACCIDENT. I HAD THE CAR TOWED TO TOYOTA DEALERSHIP AND THEY REFUSED TO FIX ANYTHING BECAUSE THEY WILL ONLY FIX THIS FAULTY ECM IF THE CAR IN UNDER 80,000 MILES, MINE HAD 80,800. *TR

I HAVE A 2002 TOYOTA RAV4L. MY PROBLEMS STARTED YESTERDAY. THE CAR IS NOT SHIFTING PROPERLY. IT STALLS AS IF THE CAR WERE PUT INTO NEUTRAL AT 20MPH AND AGAIN AT ABOUT 40MPH. I WAS ALMOST HIT BY ANOTHER CAR BECAUSE MY CAR WOULD NOT MOVE WHEN THE GAS WAS PUSHED IT JUST REVVED THE ENGINE. I AM AFRAID TO DRIVE THIS CAR. I PURCHASED IT IN DEC OF 2006 AND AM STILL PAYING FOR THIS CAR. FROM WHAT I HAVE READ I HAVE THE SAME TYPE ISSUE AS MOST OTHERS- THE ECM. THIS IS UNSAFE AND TOYOTA NEEDS TO FESS UP. THEY KNEW ABOUT THIS PROBLEM IN EARLY 2006 BECAUSE A TSB WAS SENT OUT TO ALL TOYOTA DEALERS. IF WE HAD BEEN NOTIFIED OF THIS AT THE TIME OF PURCHASE OR IN 2006 THE 2002 WOULD HAVE MOST LIKELY STILL BEEN UNDER WARRANTY. THEY KEPT IT QUIET UNTIL NOW AND PEOPLE ARE CATCHING ON. I HAVE SENT A COMPLAINT TO THE DEALERSHIP WHERE MY CAR WAS PURCHASED AND AM WAITING TO HEAR BACK WHAT THEY INTEND TO DO IN THIS CASE. I AM WILLING TO TAKE IT AS FAR AS I NEED TO GO TO MAKE THEM REPAIR THE CAR AT NO COSTS TO ME. FROM WHAT I HAVE READ IT WOULD COST MORE TO REPAIR THE CAR THAT WHAT THE VALUE OF THE CAR ACTUALLY IS AT THIS POINT. I AM VERY DISAPPOINTED AND WILL NEVER BUY ANOTHER TOYOTA AGAIN BECAUSE OF THE DECEPTION AND THE INCONVENIENCE AND LACK OF CONCERN OF THE SAFETY OF THE CONSUMER FROM TOYOTA. *TR

ECM FAILED ON 2002 TOYOTA RAV4 CAUSING ERRATIC AUTO TRANSMISSION SHIFTING AND CAR SPEED TO VARY WIDELY WHILE IN TRAFFIC. NO 'CHECK ENGINE' LIGHT WARNING. TOYOTA KNOWS OF THE PROBLEM AND DID NOT PROVIDE ANY WARNING. I HAD TO PAY A REPAIR BILL OF $5358.00 TO REPLACE THE ECM AND TRANSMISSION. *TR

CHECK ENGINE LIGHT CAME ON. TOOK TO TOYOTA. THEY TOLD ME I NEEDED A NEW ECM THAT THERE WAS A TSB ON THE MAKE MODEL AND YR OF MY VEHICLE RAV4 2002/I DROVE HOME AND TOLD MY BOYFRIEND THAT THE ECM REPLACEMENT IS 1600 DOLLARS. ONE WEEK LATER I WAS DRIVING TO TOYOTA TO HAVE FIXED AND MY CAR WOULD NPT ACCELERATE. IT WOULD STOP AND GO AND I BARELY MADE IT THROUGH A VERY BUSY INTERSECTION.. I WAS AT 83,000 MILES AND OUT OF WARRANTY WHEN THIS HAPPENED. OF COURSE I HAD TO ABSORB THE COST.. *TR

THE CAR DOES NOT RESPOND PROPERLY WHEN ATTEMPTING TO ACCELERATE. THE CAR JERKS/TRANSMISSION JERKS AND REMAINS AT A SLOW SPEED, RESPONDING MUCH LATER. THIS IS DANGEROUS WHEN MERGING OR SIMPLY DRIVING ON A HIGHWAY. I BOUGHT THIS CAR FOR MY TEENAGE DAUGHTER FROM A MAJOR TOYOTA DEALER. WHEN I TEST DROVE IT, IT SEEMED FINE. THE DEALER APPARENTLY, DID NOT KNOW WHAT WAS WRONG. I TOOK IT TO ANOTHER TOYOTA DEALER WHO IDENTIFIED THE PROBLEM. THIS CAR WAS APPARENTLY IN EXCELLENT CONDITION, OBVIOUSLY A FALSEHOOD. I HAVE HAD THE CAR CHECKED OVER - THIS IS THE ONLY PROBLEM - A DEADLY ONE. *TR

ECM IS FAULTY. CAUSING VEHICLE TO "MISSHIFT" FROM 1ST TO 2ND GEAR. THE MISSHIFTING CAUSES CAR TO STALL FOR A FEW SECONDS TILL SHIFTING IS COMPLETED, CAUSING POTENTIAL REAR-END OR SIDE-HIT(AT INTERSECTIONS) ACCIDENTS. HAVE ALMOST BEEN HIT TWICE. SUGGESTED BY DEALERSHIP TO "REFLASH" ECMA; COMPLETED; NO CHANGE. NOW SUGGESTED TO REPLACE PART (ESTIMATED COST OF + LABOR) RESEARCHED ON INTERNET, THERE ARE SEVERAL WEB SITES THAT HAVE CUSTOMERS COMPLAINING TO TOYOTA WITH NO SOLUTION (SUCH AS HTTP://WWW.CARCOMPLAINTS.COM/TOYOTA/RAV4/2002/TRANSMISSION/PROBLEMS_SHIFTING.SHTML AND HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.F0C40D0/573) CONTACTED TOYOTA AND THEY OFFERED NO SOLUTION BECAUSE A THERE WASN'T A "SPECIAL SERVICE CAMPAIGN" AKA RECALL. ADVISED ME TO SEEK OUTSIDE HELP. *TR

AFTER 30 MINS OF HWY/PKWY DRIVING, THE CAR SHUT OFF WITHOUT WARNING WHILE TRAVELING APPROX 45 MPH. NO WARNING LIGHTS BEFORE INCIDENT AND NO PREVIOUS ISSUE AT ALL. STEERING AND BRAKES BECAME SLUGGISH, AND WE LACKED BASIC ACCIDENT AVOIDANCE MEASURES. HAD WE BEEN TRAVELING FASTER AND/OR IN DENSER TRAFFIC THE CAR WOULD HAVE PRESENTED A MAJOR OBSTACLE TO ONCOMING VEHICLES, PLACING BOTH US AND OTHER DRIVERS ETC. IN DANGER. THE DEALER COULD NOT DUPLICATE THE PROBLEM AND SO MADE NO REPAIR. THE CAR SHUT OFF AGAIN IN STOP-AND-GO TRAFFIC 2 WEEKS LATER. THE DEALER EVENTUALLY REPLACED A TRANSMISSION CHIP. THE CAR THEN RAN WITH HESITATIONS AND SOME DELAY IN SHIFTING FOR SOME WEEKS. FINALLY, AT 60 MPH IN HIGHWAY TRAFFIC THE CAR STARTED TO JERK, FAIL, AND BUCK. AGAIN THE DEALER COULD NOT DUPLICATE THE PROBLEM AND REFUSED TO ADDRESS IT. WE DISCOVERED THROUGH RESEARCH ON LINE THAT THIS MODEL TOYOTA RAV4 2002 HAS A PROBLEM WITH ITS ONBOARD COMPUTER OR ECM, FOR WHICH TOYOTA EXTENDED ITS WARRANTY. OUR CAR IS WITHIN THE WARRANTY LIMITS BOTH AS TO YEARS AND MILEAGE. TOYOTA IS SUPPOSED TO REPLACE THE ECM IN THIS MODEL UNDER THIS WARRANTY. OUR DEALER HAS REFUSED TO DO SO AND HAS SENT US BACK OUT ON THE ROAD WITHOUT ANY SECURITY AGAINST ANOTHER FULL ENGINE STOP IN HIGHWAY TRAFFIC. *TR

I BEGAN NOTICING THAT MY AUTOMATIC 2002 RAV 4 WAS JERKING WHEN SHIFTING, WOULD REV AT HIGH RPMS BEFORE SHIFTING AND AT TIMES FELT LIKE IT WOULD NOT SHIFT AT ALL. LIKE OTHERS, I DID AN INTERNET SEARCH AND FOUND THAT IT IS A PROBLEM WITH THE ECM THAT MANY OTHERS HAVE EXPERIENCED. MY CAR HAS 119K MILES ON IT AND IS OUT OF WARRANTY SO I AM EVALUATING MY OPTIONS ON HOW TO DEAL WITH THIS PROBLEM. THE CAR IS UNDRIVABLE, AS IT IS A SAFETY RISK WHEN THE CAR IS UNABLE TO ACCELERATE NORMALLY IN STOP AND GO TRAFFIC. IT LOOKS LIKE THIS PROBLEM WILL COST ABOUT A THOUSAND TO GET A NEW ECM, AND MUCH MORE IF THE DAMAGE IT HAS DONE TO THE TRANSMISSION NOW REQUIRES A TRANSMISSION REBUILD. *TR

AT 84,000 MILES THE CAR STARTED SURGING FOR NO REASON, STALLING WHILE MOVING ON THE HIGHWAY, AND STALLING WHILE APPROACHING INTERSECTIONS. HAPPENED TWO TO THREE TIMES DAILY, CAUSING A NUMBER NEAR MISS ACCIDENTS, REAR ENDS. TOOK IT TO THE DEALER WHO REPLACED THE COMPUTER. THIS WAS VERY DANGEROUS AND EASILY COULD HAVE CAUSED AN ACCIDENT. *TR THE CONSUMER STATED HE EXPERIENCED SUDDEN ACCELERATION. UPDATED 07/26/10.*JB

CAR BEGAN HAVING SHIFTING PROBLEMS. I WAS TOLD BY A SHOP THAT THE ECM IS A KNOWN PROBLEM. IT IS A SAFETY HAZARD SINCE IT OFTEN FAILS IN INTERSECTIONS. *TR

TL*THE CONTACT OWNS A 2002 TOYOTA RAV4. WHILE IDLING OR DRIVING AT VERY LOW SPEEDS, THE VEHICLE WOULD CONSISTENTLY FAIL. THE DEALER STATED THAT THE ELECTRONIC CONTROL MODULE NEEDED TO BE REPROGRAMMED. IMMEDIATELY AFTER THE REPAIR, THE FAILURE RECURRED. THE DEALER REPLACED THE ECM AT THE COST OF $1,225.69, WITHOUT THE CONTACT'S APPROVAL. THE REPAIR WAS NOT INCLUDED IN HER EXTENDED WARRANTY. SHE CALLED THE MANUFACTURER, BUT THEY REFERRED HER BACK TO THE DEALER. THE FAILURE AND CURRENT MILEAGES WERE 89,000.

ECU OR ENGINE COMPUTER UNIT. THIS COMPUTER IS BAD. WHEN SHIFTING .THE AUTOMATIC TRANSMISSION IN THE COMPUTER DOES NOT KNOW WHAT GEAR TO SHIFT IN. THIS IS SCARY WHEN IN TRAFFIC. IT WOULD START IN LETS SAY 2ND GEAR THEN BANG BACK TO 1ST GEAR. WHAT A JOLT FOR YOU AND THE DRIVER BEHIND YOU. *JB

THE CAR SUFFERED MECHANICAL DEFECT AND THE FRONT END BAR WAS BROKEN, WHEN FRONT END BAR BROKE IT LOST DIRECTION AND HIT ANOTHER CAR IN FRONT. THE HIGHWAY PATROL CAME TO TAKE THE ACCIDENT REPORT. WE WERE DRIVING AT 25MPH ON FREEWAY NUMBER 405. I HAVE CALLED MY AUTO INSURANCE AND I WAS GIVEN A CASE NUMBER. I HAVE FULL COVER. I AM WAITING FOR A RESPONSE FROM MY AUTO INSURANCE TO FIX THE CAR. I HAVE CONTATED TOYOTA AND I ALSO HAVE A CASE WITH THEM. THE CASE NUMBER IS 200603011457. I HAVE TOYOTA AND THE CLAIMS REPRESENTATIVE IS CHRISTY. CHRISTY HAVE SAID TO WAIT AT LEAST 60 DAYS. I CAN'T WAIT 60 DAYS. I NEED MY CAR. THE AUTO INSURANCE HAS NOT GIVEN ME A RENTAL. I HAVE COMPLAINT TO THE COMMISSIONER OF AUTO INSURANCE IN CALIFORNIA. THEY WILL CONDUCT AND INVESTIGATION. THE CASE NUMBER WITH MY AUTO INSURANCE IS 10000148757. MY AUTO INSURANCE CARRIER IS INFINITY. WHAT I WANT IS TOYOTA TO REPLACE MY CAR. THE CAR IS A TOTAL LOSS. I FEEL THIS BROKEN BAR SHOULD BE RECALL.*AK

I HAD DRIVEN ABOUT 3 MILES THEN GOT STUCK IN A TRAFFIC JAM. AT THAT TIME, I COULD SMELL SOMETHING BURNING BUT I THOUGHT IT WAS THE CAR IN FRONT OF ME. FINALLY, I GOT OFF THAT ROAD AND DROVE ANOTHER 10 MILES BUT I AGAIN NOTICED THE BURNING SMELL. I CHECKED THE PANEL AND THE CAR WAS NOT RUNNING HOT. NEXT, A SMALL CURL OF SMOKE CAME FROM UNDER HOOD ON PASSENGER SIDE. THEN SUDDENLY SMOKE BEGAN BILLOWING FROM UNDER THE HOOD AND INTO THE CAR THROUGH THE VENT. I LOST STEERING AND BRAKING. I REMOVED THE KEY FROM THE IGNITION, BUT THE CAR CONTINUED MOVING FORWARD. THEN THE CAR ABRUPTLY STOPPED. FLAMES ENGULFED THE ENGINE. THE FIRE DEPARTMENT CAME OUT AND EXTINGUISHED THE FIRE BUT THE CAR WAS TOTALED. *AK

ENGINE COMPARTMENT CAUGHT ON FIRE RIGHT AFTER CONSUMER PARKED VEHICLE. CONTACTED DEALER, AND THE DEALER WAS NOT WILLING TO DO ANYTHING.*AK