2016 Toyota Prius Other Problems

Your car has a coolant leak coming from the heat exchanger that's dripping into the exhaust pipe. This can cause coolant to be burned off and potentially damage the exhaust system over time. The repair will likely involve replacing the heat exchanger or sealing the leak.

Your car is leaking coolant, but the low coolant warning didn't alert you. While driving, you noticed the engine wouldn't accelerate normally and the engine temperature warning light flashed twice. A mechanic confirmed coolant is leaking, though the leak location wasn't immediately obvious. You may need to have the coolant system inspected for leaks and potentially have seals or hoses replaced.

Our car has approximately 65K miles on it. THREE of the door lock actuators have failed already. This is terrifying that we might not be able to lock or unlock doors in an emergency particularly with our kids in the back seat. We have had our Prius serviced regularly by an independent well regarded local hybrid car mechanic and they think it is very odd that these have all failed so quickly.

The active grille shutter system failed due to debris. There is a bulletin already that references error code P05A072 - active grille shutter stuck open. The code I got was P059F73 - active shutter grille stuck closed. Not sure why it wasn’t included in the original bulletin when the cause and part are the same. This seems to be a known problem with this vehicle that can lead to engine overheating. Bulletin referenced was T-SB-0319-17.

OUR VEHICLE IS COMPLETELY INOPERABLE. THE BATTERY WORKS BUT THE VEHICLE FLASHES ALL KINDS OF WARNING LIGHTS AND WILL NOT START UP. WE BELIEVE THAT IT MAY BE DUE TO RODENTS AS TOYOTA DEALERSHIP POINTED OUT RODENT ISSUE IN CABIN AIR FILTER LAST TIME WE WENT THERE FOR SOME SAFETY RECALL. IT SEEMS TO BE A HUGE ISSUE WITH PRIUS AND WE WOULD HAVE NEVER BOUGHT ONE HAD TOYOTA BEEN UPFRONT WITH THE RODENT ISSUES THAT THEY HAVE WITH THEIR VEHICLES. ARE THERE ANY RECALLS OR CLASS ACTION SUIT RELATED TO THIS RODENT ISSUE AND THEIR USING SOY BASED WIRING AND FAILING TO CLOSE UP RODENT ACCESS TO CABIN AIR FILTER ETC.? THANK YOU FOR YOUR TIME!

I WAS DRIVING UPHILL THEN I HAD TO MADE MAKE A STOP SIGN, CAR WOULDN'T MOVE WHEN ACCELERATING, KEPT PRESSING GAS AND STILL NOT MOVING (IT WAS ON DRIVE MODE) DECIDED TO GET OUT AND LOOK AROUND THE CAR. I HEARD UP NORMAL NOISE COMING OUT OF THE EXHAUST. I TURNED ENGINE OFF FOR SOME MINUTES AND IT MOVED. AFTER FEW MINUTES THERE WAS ANOTHER STOP SIGN. SAME THING HAPPENED BUT CAR WOULDN'T MOVE EVEN AFTER TURNING ENGINE IF FOR MORE THAN 15 MINUTES. I HAD TO LEAVE THE CAR SOMEWHERE IN THAT AREA UNTIL I GET IT TOWED. FOLLOWING DAY I TOOK IT TO TOYOTA SERVICE CENTER, THE GUY TOLD ME I WAS THE SECOND PERSON WHO HAD THIS ISSUE THAT DAY. I THINK TOYOTA SERVICE TECH DIDN'T DO GOOD DIAGNOSES AS THE REPORT SAYS I WAS PRESSING THE GAS PEDAL WHEN THE CAR WAS IN NATURAL MODE NOT DRIVE AND THE NOISE I HEARD FROM EXHAUST WAS A RESULT FROM PRESSING THE GAS WHILE CAR IN NATURAL! THAT DOESN'T MAKE ANY SENSE AND I FEEL THAT WAS AN INSULT TO ME. FIRST I LOOKED AT THE CAR MODE TO MAKE SURE IT'S ON DRIVE MODE, I EVEN CHANGED THE DRIVE MODE TO POWER MODE IN CASE IT NEEDED MORE POWER TO MOVE. SECOND. I WAS OUT OF THE CAR, BEHIND THE CAR , LISTENING TO THE NOISE FROM THE EXHAUST SO I DON'T KNOW WHO WAS PRESSING THE GAS PEDAL IN THE CAR, MAYBE THERE WAS A GHOST PUSHING THE GAS PEDAL.

ON 1/23/2020 WHILE DRIVING ON HIGHWAY I60 IN AZ AROUND 9 AM THE SUNROOF OF THE CAR EXPLOITED. NO OBJECT WAS NOTICED TO HIT THE CAR OR SUNROOF. IT'S UNKNOWN THE REASON LEADING TO THE EXPLOSION.

PAINT PEELING FROM TRIM.

THE CAR'S AIR CONDITIONING SYSTEM CONTINUALLY SETS ITSELF TO THE AUTO POSITION AND DISABLES ITSELF WHERE NOTHING YOU DO CAN ACTIVATE THE FAN THE AIR CONDITIONING THE HEAT ANYTING, GOING THROUGH ALL THE MENUS RESETTING EVERYTHING TURNING THE CAR OFF AND ON 50 TIMES DOES NO GOOD. THIS BEGAN HAPPENING WHEN THE CAR HAD ABOUT TEN THOUSAND MILES ON IT AND HAS BEEN MORE AND MORE COMMON SINCE.

ON MANY OCCASIONS WHEN I WOULD STEP ON MY BRAKE, MY CAR WOULD JERK AND THRUST FORWARD AGGRESSIVELY. I'D HAVE TO STEP HARD ON MY BRAKE SO THE CAR WOULD NOT CATAPULT PAST A STOP SIGN OR LIGHT. IT FEELS LIKE THE CAR IS STRONGER THAN THE BRAKE AND OUT OF CONTROL. WHICH IS ALARMING BECAUSE I PICK UP MY 2 YEAR OLD GRANDDAUGHTER FROM DAYCARE AND BRING HER HOME. IT'S HAPPENED WHEN I TURN CORNERS OR COME TO A STOP SIGN OR LIGHT AND I NEVER KNOW WHEN IT WILL HAPPEN.

I HAVE OWNED 3 TOYOTA PRIUS AND SINCE I PURCHASED THIS 2016 PRIUS IN 09/2016. I HAVE HAD TO REPLACE THE WINDSHIELD TWICE SO FAR, 1 IN 09/2016 AND 06/2017. AND NOW HAVE CRACKED WINDSHIELD ALL CAUSE BY SMALL ROCK CHIP STARTING IN THE CORNERS OF THE WINDSHIELD. THIS IS GETTING RIDICULOUS, I HAVE NEVER HAD THIS ISSUE WITH OTHER 2 MODELS OR OTHER VEHICLE I HAVE OWNED.

SINCE PURCHASE OF THE CAR, THE VEHICLE HAS SHIFTED FROM DRIVE TO NEUTRAL UPON BRAKING HARD. THIS HAS OCCURRED WHILE DRIVING ON THE FREEWAY. THE CAR WILL NOT RETURN TO DRIVE WITHOUT TURNING OFF THE ENGINE AND RESTARTING. IT IS NOT SAFE TO DRIVE. TOYOTA OF CARLSBAD COULDN'T REPRODUCE THE EVENT AFTER A FEW TRIES ON A TEST DRIVE, SO THEY WILL NOT DO ANYTHING ABOUT IT. I AM CONCERNED ABOUT HAVING A FATAL ACCIDENT WHILE DRIVING ON THE FREEWAY. THE EVENTS HAPPEN RANDOMLY.

UPON START UP THIS TOYOTA PRIUS VEHICLE EMITS FOUL SMELLING CHEMICAL AIR INTO THE CABIN OF THE VEHICLE. IT IS UNKNOWN HOW TOXIC THESE SMELLS ARE BUT AGGRAVATE RESPIRATORY CONDITIONS AND ASTHMATIC CONDITIONS. TOYOTA ACKNOWLEDGES THAT THEY HAVE A SERVICE BULLETIN WITH "THOUSANDS" OF COMPLAINTS FROM CONSUMERS REPORTING NOXIOUS AIR BEING EMITTED INTO THE CABIN OF THE VEHICLE. HOWEVER THEY ARE REQUIRING CONSUMERS TO PAY FOR FIXES, EVEN IF THE CONSUMER HAS A FULL WARRANTY FOR MANUFACTURER DEFECTS. THIS VEHICLE ONLY HAS ABOUT 9.2K MILES ON IT (2016) AND IS GETTING WORSE. THE PROBLEM ALWAYS HAPPENS ON VEHICLE START UP WHEN AT REST, ESPECIALLY IN WARM AMBIENT CONDITIONS. THE AC WILL BE FOUL AND NOXIOUS. IN COLD TEMPERATURES THE FIRST FEW MINUTES OF HEATING WILL ALSO EMIT FOUL AND NOXIOUS ODORS. SERVICE LINE AT DEALERSHIP ACKNOWLEDGE THESE COMPLAINTS ARE HERE BUT WILL NOT EFFECT REPAIRS UNDER DIRECTION OF TOYOTA CORPORATE. ALL REPAIRS FOR MANUFACTURING DEFECT FOR TOXIC AIR HAVE TO BE PAID FOR BY THE CUSTOMER. S

WITH THE AUXILIARY BATTERY WELL CHARGED THE GAS ENGINE WILL TURN OFF WHEN VEHICLE COMES TO A STOP. IN ORDER TO TURN THE IGNITION KEY TO THE OFF POSITION AND REMOVE THE KEY IT IS NECESSARY TO MOVE THE SHIFT LEVER TO THE PARK POSITION. AT THE SAME TIME IT IS ADVISABLE TO SET THE PARKING BRAKE. IF DISTRACTED IT IS POSSIBLE TO OPEN THE DOOR AND LEAVE THE VEHICLE WITH THE ELECTRIC ENGINE STILL RUNNING. THERE IS NO ENGINE NOISE AT ALL. THERE IS NO SIGNAL, AUDIO OR LIGHT, TO INDICATE THE ENGINE IS STILL RUNNING. I HAVE HAD THIS OCCUR ON TWO OCCASIONS, ONCE DURING DAYTIME, WITH MY SON ACCOMPANYING ME, 09/07/2017, THE SECOND TIMEL ALONE, WHEN PARKING THE CAR IN MY GARAGE AT NIGHT, 09/13/2017. ON RETURN TO THE CAR, WITH MY SON, I SEARCH FOR MY KEYS AND FOUND THE CAR'S GAS ENGINE RUNNING, EMITTING THE NORMAL ENGINE NOISE, THE KEY NOT HAVING BEEN REMOVED AFTER PARKING. WHEN TURNING OFF AND REMOVING THE KEY FROM THE IGNITION, INSIDE LIGHTS AND DRIVE LIGHTS CONTINUE TO BE ON UNTIL THE DOOR IS CLOSED, AT WHICH TIME THE LIGHTS, INSIDE AND OUT, GO OFF AFTER A BRIEF PERIOD OF TIME. THE THREE ACTIONS, MOVING THE SHIFT LEVER, SETTING THE PARKING BRAKE AND TURNING OFF THE IGNITION ALL REQUIRE USE OF THE RIGHT HAND, WITH THE MOVING OF THE SHIFT LEVER BEING MANDETORY. WITH NO AUDIBLE ENGINE NOISE IT IS EASY TO OVERLOOK THE FACT THAT THE ENGINE IS STILL RUNNING. AN AUDIBLE BEEP OR FLASHING LIGHT WOULD ALERT THE DRIVER TO THE FACT THAT SOMETHING IS AMISS. OF COURSE AN UNLOCKED PARKED CAR WITH ENGINE RUNNING IS ALSO AN INVITATION TO CAR THEFT. THE CAR'S DOORS CANNOT BE LOCKED WITH THE KEY IN THE IGNITION, BUT THERE IS NO INDICATION THAT THE DOORS HAVE NOT LOCKED WITHOUT TESTING THE DOORS FROM THE OUTSIDE. NOT HAVING SUCCESSFULLY LOCKED THE DOORS CAN ALSO BE EASILY OVERLOOKED BY A DISTRACTED DRIVER.

I HAD A VERY SMALL PEBBLE HIT MY WINDSHIELD WHILE DRIVING SLOWLY ON A RESIDENTIAL STREET. THE INITIAL IMPACT CAUSED SEVERAL SIGNIFICANT CRACKS RUNNING LENGTHWISE AND WIDTHWISE ACROSS MY WINDSHIELD INSTEAD OF JUST STARING OR PITTING AS TRADITIONALLY OCCURS. THIS IS MY THIRD PRIUS AND I HAVE NEVER EXPERIENCED A WINDSHIELD RESPONDING THIS WAY. IT APPEARS ONLINE THAT THIS HAS BECOME A VERY COMMON PROBLEM AND IT IS EXTREMELY COSTLY SINCE THEY CURRENTLY DO NOT HAVE AN AFTERMARKET AVAILABLE. AS WELL AS REQUIRING $600+ RECALIBRATION. I AM EXTREMELY DISAPPOINTED IN TOYOTA. I AM CONCERNED THAT I AM GOING TO PAY $1500 TO GET THIS FIXED (SINCE MY INSURANCE USES MY DEDUCTABLE) ONLY FOR IT TO BREAK AGAIN DUE TO A MINOR INSTANCE (AS MANY HAVE COMPLAINED ONLINE). MY UNDERSTANDING IS THAT THE NEW WINDSHIELD IS THINNER/ LIGHTER FOR MPG. IS THIS NOT COVERED ON SOME SORT OF WARRANTY OR RECALL? I'M VERY UPSET THAT THIS HAS OCCURRED AND HAVE ALWAYS BEEN EXTREMELY LOYAL TO TOYOTA, IM AT A POINT WHERE I JUST WANT TO DRIVE WITH IT CRACKED TO AVID HAVING TO FIX FUTURE CRACKED WINDSHIELDS.

THE OEM WINDSHIELDS THAT ARE INSTALLED ON NEW 2016 PRIUS 2 MODELS ARE CLEARLY NOT TO STANDARD. I HAVE A HUGE CRACK ACROSS MY WINDSHIELD FROM A VERY TINY PEBBLE WHILE TRAVELING AT 12 MPH. WHAT THE HECK TOYOTA??? I WAS TRAVELING ON THE 101 SOUTHBOUND IN LA IN A MERGING LANE MOVING AT A PACE THAT JOGGERS COULD KEEP UP WITH WHEN A STRAY PEBBLE CRACKED MY ENTIRE GLASS.

MY WINDSHIELD IS CONSTANTLY GETTING HIT WITH PEBBLES AND NOW HAVE TWO LARGE CRACKS IN MY WINDSHIELD. I AM NOT DRIVING ANY DIFFERENTLY THAN I HAVE SINCE I HAVE OWNED CARS AND I AM NOT SURE WHAT THE PROBLEM IS. IT MIGHT BE A DESIGN PROBLEM OR THE WINDSHIELD IS NOT STRONG ENOUGH TO TAKE THE FORCE OF A TINY PEBBLE.

CRACKED WINDSHIELD. NEW MODEL VEHICLE W 10000 MILES WINDSHIELD CRACKED FROM AN IMPACT OF A SMALL ROCK OR OTHER ON THE HIGHWAY. NEVER HAD THIS HAPPEN, 30+ YEARS DRIVING. VERY THIN AND FRAGILE GLASS AND COMPLICATED EXPENSIVE ELECTRONIC SENSORS WILL REQUIRE 2 REPAIR SHOPS, 7 OR MORE COMBINED HOURS, AND MANY DOLLARS FOR THE REPAIR. TOYOTA DOES NOT COVER THE REPAIR, ALTHOUGH MY CAR IS UNDER WARRANTY AND I HAVE PURCHASED A TOYOTACARE PLUS PREPAID PRENIUM MAINENTANCE PLAN. AAARGH!! FRUSTRATED CUSTOMER! IS TOYOTA GOING TO ISSUE A RECALL ON THESE LOUSY WINDSHIELDS?

I TOOK DELIVERY OF MY 2016 PRIUS IN JANUARY 2016. AT HE TIME OF DELIVERY, THE SPEEDOMETER DISPLAYED MPH, HOWEVER THE OWNER'S MANUAL INDICATED THIS COULD BE CHANGED TO KPH VIA A SIMPLE USER INTERFACE ON THE DASHBOARD. I HAVE SINCE LEARNED THAT SUCH A CHANGE IS NOT POSSIBLE FOR MY CAR, AS IT WAS MANUFACTURED EARLY IN THE 2016 MODEL YEAR PRODUCTION RUN. THE INABILITY TO ADJUST FROM MPH TO KPH MAKES IT DIFFICULT OR IMPOSSIBLE TO CORRECTLY FOLLOW THE POSTED SPEED LIMITS WHEN I VISIT CANADA. THIS REPRESENTS A SAFETY ISSUE WHICH SHOULD BE REMEDIED.

THE CAR'S WINDSHIELD SEEMS TO BE SOFTER THAN PREVIOUS MODELS. I HAD THE WINDSHIELD COMPLETELY REPLACED A FEW MONTHS AGO, AFTER A FAILED REPAIR OF A LARGE CHIP. A CHIP REPAIR WAS DONE ON THE NEW WINDSHIELD ON APRIL 7TH. IN THE CAR WASH LAST FRIDAY, I NOTICED SEVERAL SMALL CHIPS IN THE WINDSHIELD. MY HUSBAND DRIVES A 2016 TOYOTA HIGHLANDER. HIS WINDSHIELD WAS ALSO REPLACED EARLY THIS YEAR. HE NOW HAS A SIZEABLE CHIP IN THE NEW WINDSHIELD. IT SEEMS THAT THERE IS A PROBLEM WITH 2016 TOYOTA WINDSHIELDS, NOT JUST IN THE PRIUS, BUT IN OTHER MODELS AS WELL.

WHILE DRIVING CITY STREETS AT A MAXIMUM SPEED OF 55,ON SUNDAY 4/2/17, MY WINDSHIELD MUST HAVE BEEN HIT BY A SMALL STONE. I DID NOT NOTICE WHEN IT HAPPENED. ON MONDAY, 4/3/16, I NOTICED A SMALL MARK ON THE WINDSHIELD WHICH I MISTOOK FOR A BUG. I LATER NOTICED A SMALL LINE COMING FROM THE "BUG" WHICH I MISTOOK FOR FLUID. BY TUESDAY, 4/4/17, THERE WERE "LINES" IN BOTH DIRECTIONS AND I REALIZED THAT I HAD A CRACKED WINDSHIELD. BY WEDNESDAY, THE CRACK WAS 16" IN LENGTH. I TOOK MY CAR TO TOYOTA SERVICE AND WAS TOLD THAT THEY WERE NOT RESPONSIBLE UNDER WARRANTY; THIS IS SOMETHING THAT WAS CAUSED BY "IMPACT". THE CAR HAS 8400 MILES ON IT. MY CONCERN IS WITH THE QUALITY OF THAT WINDSHIELD. IF A SMALL PEBBLE CAN CAUSE THAT MUCH DAMAGE, IT SEEMS TO ME THAT THIS IS AN INFERIOR PRODUCT. I HAVE DRIVEN FOR 49 YRS IN DIFFERENT CLIMATES, THROUGH BLIZZARDS, HAILSTORMS, AND HAD FLYING DEBRIS HIT MY WINDSHIELDS. I HAVE HAD FENDER BENDERS AND BEEN REAR-ENDED. NEVER HAVE I HAD A BROKEN WINDSHIELD. A WINDSHIELD THAT IS THIS DELICATE IS A SAFETY ISSUE. IT SEEMS TO ME, THAT IN THIS WORLD OF PROFIT-DRIVEN CHOICES, THAT THE WINDSHIELDS ARE BEING MADE CHEAPER, AND THEREFORE LESS EFFECTIVE IN TERMS OF PROTECTION. I WONDER WHAT WOULD HAVE HAPPENED IF IT WERE MORE THAN A PEBBLE THAT FLEW AT MY CAR. IN CA, IT IS ILLEGAL TO DRIVE WITH A CRACKED WINDSHIELD. SO NOW I AM IN THE PREDICAMENT OF GETTING THIS FIXED IMMEDIATELY. HANDILY FOR TOYOTA, THEY WON'T REPLACE IT GRATIS, SO IT IS A NICE $1,300.00 REPAIR JOB FOR THEM. THEY PLEASANTLY ADVISED ME THAT MY INSURANCE WOULD COVER THE $800.00 OVERAGE OF MY $500 DEDUCTIBLE. WITH THE ISSUE AT HAND BEING MY SAFETY AND COMPLIANCE WITH THE LAW, I HAVE LITTLE CHOICE. CHEAP WINDSHIELDS MUST CREATE A REGULAR BASE OF REPAIR WORK FOR ALL THE AUTOMAKERS WHO USE THIS PARTICULAR AUTO GLASS. THIS SHOULD BE SERIOUSLY CONSIDERED IN TERMS OF VEHICLE SAFETY.

WHILE DRIVING THE VEHICLE STARTED TO SHAKE FROM UNDERNEATH FIERCELY, I CALLED MY MOTHER WHO CAME AND PICKED UP THE CAR SHE TURNED AROUND AND WENT BACK TO MY RESIDENCE, WHILE ATTEMPTING TO PARK IN THE GARAGE THE CAR STARTED TO ROLL DOWN THE DRIVEWAY AND THE BRAKES WOULDN'T WORK, THE CAR LANDED ON THE STREET. CITY OF LANCASTER CA

MY WINDSHIELD RANDOMLY CRACKED AND LOOKING ON-LINE THIS SEEMS TO BE A COMMON OCCURRENCE ON THE PRIUS 4TH GENERATION VEHICLES.

WE HAD AN UNEXPLAINED BLOWOUT IN A TIRE WITH LESS THAN 5000 MILES ON IT ON OUR PRIUS IV 2016 PURCHASED IN MAY. WE SAW NOTHING IN THE ROADWAY THAT WOULD HAVE CAUSED THIS. THE TIRE WAS RIPPED. THERE IS A RECALL ON THIS BRAND, BRIDGESTONE/FIRESTONE SO WAS THIS TIRE AT RISK? THE TIRE NUMBER IS P195/65R89S. THE WARRANTY IS WORTHLESS AS THEY COULD CLAIM ROAD DAMAGE AND WE CAN'T PROVE OTHERWISE. BUT WE SAW NOTHING THAT WE HIT, AND OTHER CARS PASSING US DID NOT HAVE BLOWOUTS. SO DID THE TIRE FAIL? WE THINK SO. WE WERE ON AN INTERSTATE HIGHWAY WHEN THIS HAPPENED. VERY SCARY AND NO SPARE TIRE, A SEPARATE COMPLAINT. WE COULD HAVE BEEN KILLED BY A PASSING TRUCK WHILE WAITING FOR A TOW TRUCK FOR NEARLY 2 HOURS.

WE HAD A TIRE BLOWOUT ON AN INTERSTATE HIGHWAY AND DISCOVERED THERE WAS NO SPARE TIRE IN OUR NEW CAR. THE DEVICE TO REPAIR THE TIRE DIDN'T WORK AS THE TIRE WAS RIPPED. WE HAD TO WAIT 2 HOURS FOR A TOW TRUCK, WITH HUGE TRUCKS PASSING US AT 80 MPH, VERY CLOSE. WE WERE TERRIFIED. WE STILL DON'T KNOW WHAT REALLY HAPPENED AS WE DIDN'T SEE ANYTHING THAT WOULD HAVE RIPPED THE TIRE. THE CAR IS NEW, STILL UNDER WARRANTY. EVERY CAR SHOULD HAVE A SPARE TIRE FOR EMERGENCIES LIKE THIS. WE DID NOT KNOW IT DIDN'T HAVE ONE.

THE 2016 PRIUS IV WE JUST PURCHASED 2 WEEKS AGO COMES WITH A WHITE DASH! THE WHITE DASH CREATES A HORRIBLE GLARE WHEN TRYING TO LOOK OUT EITHER DRIVER OR PASSENGER WINDOW! THE ONLY WAY TO AVOID GLARE IS DRIVE WITH WINDOWS DOWN ALL OF THE TIME. VISIBILITY IS GREATLY HAMPERED BY THE WHITE DASH REFLECTION OFF THE WINDOWS! THIS IS HUGE SAFETY ISSUE!

THE CENTER DISPLAY HAS A MIRROR HIGH GLOSS/GLARE FINISH. BECAUSE OF THIS MIRROR FINISH, WHEN THE SUN IS AT AN ANGLE COMING THROUGH EITHER THE SIDE OR BACK WINDOWS, THE SUN IS REFLECTED BACK INTO THE DRIVER'S EYES. THERE SHOULD BE A RECALL ON THE CAR TO REPLACE CENTER DISPLAY TO PREVENT ACCIDENTS.