2023 Kia Sorento Other Problems

While driving on the interstate at 70 mph, the front section of your panoramic sunroof suddenly shattered and exploded with no apparent cause from road debris or hazards. This is a safety concern since it happened spontaneously at highway speed. The repair will likely involve replacing the entire panoramic sunroof glass panel and frame assembly.

Your vehicle caught fire without warning while parked at a gas station in June 2025. You first noticed excessive smoke and a burning smell coming from the air vents shortly after starting the car, and flames quickly appeared in the rear AC vent area, causing the entire vehicle to become engulfed in flames within minutes. A recall notice arrived months later in November 2025 that may be related to the cause. The fire put you and your children in immediate danger, and Kia has not yet provided assistance despite multiple contact attempts.

Your rear window has spontaneously shattered twice without any warning or obvious cause — once overnight in February and again while driving in March, with the second incident producing an extremely loud noise and sending glass into the vehicle interior. There were no extreme weather changes, suspicious activity, or other identifiable triggers for either failure. This appears to be a recurring defect rather than an isolated incident. The repair will likely involve replacing the rear window glass and investigating the window regulator and frame for manufacturing defects.

Your front end shakes noticeably when you brake, especially on the highway. The dealership claimed to fix it once, but the problem returned shortly after; when you brought it back, they refused to repair it again without charging you. Additionally, your check engine light came on while driving on the highway, and the dealership cleared it but couldn't explain why it appeared—they incorrectly suggested your gas cap was loose. Resolving these issues will likely involve inspecting your brake system components and diagnosing the engine fault code that triggered the warning light.

Your radiator developed damage that your dealer attributed to a rock chip while driving on the highway. You're concerned that the radiator lacks adequate protection and that this represents a design defect rather than normal wear, especially given the risk of fire or engine damage. The manufacturer should consider adding a protective plate to prevent this type of damage from occurring during regular driving.

Your sunroof suddenly shattered and broke apart while you were driving. This happened without any warning or obvious cause. The repair will likely involve replacing the entire sunroof panel and checking the sunroof frame and tracks for damage.

Automatic lift gate closed and injured child. Was placing groceries in vehicle. Closed lift gate with button on lift gate, child was next to me, but hand was behind him. Liftgate closed and would not reopen. Child was injured.

Moonroof unexpectedly shattered, like a bomb had gone off, sending thousands of pieces of glass into the interior and on the vehicle occupants (including 3 children [XXX] ) INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While I was driving on an interstate road(with no vehicles around) the sun roof of my 2023 Kia Sorento exploded and the glass completely shattered and caused pieces of the broken glass to fly off. Thankfully I had the visor up so none of the glass fell onto me, otherwise myself and my two kids (3 year old and 6 month old) could have gotten seriously injured. With nearly 80% of the glass sunroof panel above the driver area popping off, that much glass falling onto me could have caused a serious distraction and caused me to run into another vehicle or lose control of the vehicle. At the time the sunroof shattered, there was nobody on the road or any external debris that could have caused the sunroof to shatter like that. I suddenly head a loud explosion that sounded almost like a shotgun being shot and was instantly startled, and when I realized we were all okay in the vehicle I heard the sound of glass sliding off the roof of my Sorento. I then began to see chunks of glass falling on the road behind me which posed as a risk to other vehicles that were behind me and caused other drivers to swerve to avoid being hit by the glass. Since this has happened, I have contacted Kia and taken it in to my local service department. The service manager (when he inspected the sunroof) stated the glass is tempered glass and should not explode when cracked or shattered. Other reports of this exact issue is prevalent online and poses a great risk to consumers, families, and other drivers on the road.

I was driving down the highway when the sunroof randomly exploded, there was no debris that hit the roof or damages to the roof prior.

Safety concern. Vehicle suddenly could not maintain highway speed; vehicle unexpectedly decelerated. We were forced to pull over on the shoulder of the freeway. We called 911 and officers came. Officer confirmed being stopped on the shoulder of a major freeway was a very dangerous situation. We had 3 adults and two sleeping children in the car. No warning signals in the vehicle prior to the incident.

The car overheated while driving and my wife and daughter had to pull over to side of road. Engine Coolant was spilling everywhere. Car was towed to Raceway Kia in Freehold NJ. The dealer advised my wife that the radiator needs to be replaced and it was NOT covered under warranty. They claim that debris from the road must have damaged the radiator and therefore it was "third party damage". I searched the web for incidents and found that this ios a design problem in the Kia Sorrento. Their design causes the vulnerability to get damage to readaitor due to leaks. This should be recalled and redesigned before someone gets seriously injured as a result.

Vehicle gear slipping acceleration loss with difficulty in proper control of the vehicle. Vehicle has a consistent noise that comes from the accelerator as if something was loose and vibrating. The wheels don’t seem to be moving at the same time and feels like the cars slightly moves side to side as if something in the structure of the vehicle has como off loose with sounds/ rattle coming from the passenger side and back. The vehicle has have wheels aligned and checked more than 6 times with continuous problems and no real solution from the dealers. The dealer has stated everything is fine and to go back if a light sensor turns on. They have said every excuse possible, from telling me that I don’t know to drive the vehicle to having the cops called on me to be removed from the premises . To the dealership telling me they will not check the vehicle. I have gone to 5 different dealership and they refuse to acknowledge my concern with the vehicle. I went ahead and place the vehicle on a lemon law and settled with Kia stating they would validate the warranty. The problem is the dealership have told me that they have to do lots of paperwork and they have to replicate the problem, but have me drive the vehicle instead of them . They stated they only drive the vehicle for about five minutes. The service advisor at time have requested authorization from me inorder for them to drive the car. When asked for a mechanic to do the testing, Ive been told they are may no be available and are working on other vehicles.I have stated the vehicle starts presenting the problem after it has been driven for a while. Again the dealership dismisses all of my claims. The vehicle doesn’t feel safe to drive and I fear a collision may happen putting my life and others at risk.

Mounting bracket for the backup camera failed and caused the camera to dangle from the car. This caused me to not be able to use the camera to view objects and surroundings directly behind the vehicle. A dealer said they fixed the part back when it was originally recalled, but the new bracket broke and the dealer is refusing to fix the issue. They said the initial recall was completed and the part is now out of warranty and therefore they will not fix it, even though the exact part that was recalled originally has now failed again.

Purchased brand new 2023 Sorento on 12/30/23. On Jan 14th, with less than 300 miles on it, had 1st incident. All lights on dash came on said Engine control system, lost all ability to accelerate. Had to get out of traffic, as safely as I could. Turned car off and waited 5 min. Turn car back on, check engine light stayed on but could give gas. Took to dealership and a code was stored in history, engine control module. 3 days later took it back to get fixed and they could reproduce problem or get any code. Put flight recorder on, drove it for 11 miles, nothing. Said they can't fix without a code. On Feb 17th, with 1500 miles, same situation. All lights on dash, cannot give any gas. Extremely dangerous in traffic. Got off road and on display it said it performed 7 checks. All showing good except Engine Management System. Shows condition with engine control system and take to dealership immediately. It was a Saturday, service was closed. Check engine light stayed on Saturday and all day Sunday. Monday, check engine off. Took to dealership, no code found. This is a brand new car and has has same problem twice now. They are saying they need a code to fix. So now I'm driving a ticking time bomb, a death trap. Scared to drive on interstate or anywhere with heavy traffic. When you loose ability to control cars speed, that's EXTREMELY dangerous. I dropped car off at KIA and will NOT pickup until they can tell me what's going on with my brand new car. Why KIA put a safety feature that "limp mode" stops the car from accelerating is beyond me. This is so scary and disappointing.

I was cleaning my Kia and I was wiping the back-up camera, the camera housing clip broke and I didnt even put any pressure.

Driving my vehicle my sunroof glass shatter, now it has a big hole in the middle. The car is at kia in laurel Maryland.

Sunroof on the vehicle blew out out of nowhere. No prior cracks or damage.

On 6/6/2023, the sunroof shattered while driving. No rock/debris collided at this time with the sunroof and I believe this is a security malfunction due to the glass overheating. This incident isn't the result of mishandling on our (the consumer's) behalf. The car dealership (VANGUARD KIA of Arlington) has denied responsibility in the defect of this car part. As such, I'm filing on for our situation and warning of others who are at risk. Additionally, no warning lamps, messages, or other symptoms of the problem were present prior to the failure.