2005 Hyundai Sonata Brakes Problems

TL* THE CONTACT OWNS A 2005 HYUNDAI SONATA. WHILE DEPRESSING THE BRAKE PEDAL, THE VEHICLE STALLED WITHOUT WARNING. IN ADDITION, WHILE TURNING THE VEHICLE LEFT OR RIGHT, THE VEHICLE STALLED. THE CONTACT HAD TO RESTART THE VEHICLE TO GET IT TO OPERATE NORMALLY. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000.

WITH FAMILY IN CAR A TRAFFIC SITUATION OCCURRED THAT REQUIRED AGGRESSIVE BRAKING. WITHOUT WARNING THE CAR NOSE-DIVED, & SWUNG STRONGLY TO THE LEFT. THE SITUATION WAS VERY SCARY & I REGAINED CONTROL. FORTUNATELY NO CAR WAS IN THE NEARBY LANE. TOOK THE CAR INTO FIRESTONE WHERE AMONG OTHER THINGS THEIR CERTIFIED MASTER MECHANIC DID A FULL BRAKE INSPECTION, CHECKED THE TIRES FOR SIZE AND PRESSURE & DID A BRAKE FLUID FLUSH. THEY ADVISED THAT THERE WAS AN ABS PROBLEM & I SHOULD IMMEDIATELY TAKE THE CAR INTO THE DEALER AS THIS IS A MAJOR SAFETY PROBLEM! I TOOK THE CAR TO THE HYUNDAI DEALER IN DENTON, TX WHO RAN EXTENSIVE DIAGNOSTIC'S AND SAID THE ABS CONTROL MODULE (589203C500) SYSTEM HAD MALFUNCTIONED, WAS DEFECTIVE FINDING ONLY FLUID FLOW TO THE LEFT FRONT BRAKE CA. THE DEALER QUOTED APPROX. $2500 FOR MATERIALS, TAX AND LABOR SAYING THERE WAS NO WARRANT COVERAGE. WE WERE SHOCKED BY BOTH THE COST TO FIX AND THAT AN APPARENT MANUFACTURING DEFECT WOULD NOT BE COVERED BY THE MANUFACTURER. AT THE DEALER 10/01/2012, I CALLED HYUNDAI MOTORS USA & FILED CASE #5034644. AFTER QUITE SOME TIME ON THE PHONE THE CASE MANAGER SAID THERE WAS NO WARRANTY COVERAGE, THEY FELT NO RESPONSIBILITY FOR THE DEFECT AND ESSENTIALLY THAT IT WAS ALL ON ME TO FIX IT. EVEN AFTER ADDITIONALLY SHARING MY LACK OF EMPLOYMENT & TOUGH FAMILY FINANCIAL SITUATION IT WAS, "SORRY WE CAN DO NOTHING AS YOUR VEHICLE IS OUT OF WARRANTY. WE NOW HAVE NO CHOICE BUT TO FIGURE OUT HOW TO PAY FOR THE REPAIR OUT OF POCKET AS THE CAR IS CRUCIAL TO OUR NEEDS. *TR

TL* THE CONTACT OWNS A 2005 HYUNDAI SONATA. THE CONTACT STARTED THE IGNITION AND THE REAR BRAKE LIGHTS BEGAN TO ILLUMINATE CONTINUOUSLY WITHOUT APPYING THE BRAKE PEDAL. THERE WAS A RECALL RELATED TO THE DEFECT ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 09V122000 (SERVICE BRAKES, HYDRAULIC: SWITCHES: BRAKE LIGHT). THE VIN WAS INELIGIBLE UNDER THE RECALL. THE VEHICLE HAD NOT BEEN REPAIRED AND THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 108,000.

I OWN A 2005 HYUNDAI SONATA. IT SEEMS THAT THE BRAKES ACT FUNNY (DON'T WORK RIGHT/LONGER STOP TIME) WHENEVER IT IS WET OR COLD OUT. I HAVE HAD WORK DONE ON IT BY THE DEALER AND WAS INFORMED THAT THE FRONT BRAKES WERE FROZE UP AND ONLY HALF WORKING. THEY WANTED $45 TO CLEAN THEM FOR ME. INSTEAD I HAD MY NORMAL MECHANIC DO THE CLEANING WHEN HE REPLACED MY REAR BRAKE PADS AND ROTORS. HE DID THE CLEANING FOR FREE. ABOUT A MONTH LATER ON MY WAY HOME, DRIVING THROUGH THE RAIN I CAME UP TO A STOP LIGHT WITH 3 OR 4 VEHICLES STOPPED AT IT, I PRESSED THE BRAKE WITH ABOUT FIFTY FEET BETWEEN MY VEHICLE AND THEIRS TRAVELING AT 45 MPH AND THE CAR DIDN'T SLOW DOWN AT ALL. I USED MY EMERGENCY BRAKE TO SLOW DOWN BUT STILL HIT A VEHICLE IN FRONT OF ME. NO ONE WAS HURT. I CAN'T SAY THE SAME FOR MY CAR... IT HIT AN SUV. THE SUV HAD MINOR DAMAGE BUT MY CAR'S FRONT END WAS DESTROYED, AND THE AIRBAGS DIDN'T DEPLOY. THE CAR WAS TAKEN BACK TO MY MECHANIC FOR REPAIRS AND TO HAVE THE BRAKES CHECKED AND THE BRAKES WERE STICKING A LITTLE BUT ALL HE COULD FIGURE OUT IS THAT THE CALIPERS NEED MORE CLEARANCE. THE BRAKES WORKED FOR HIM WITH NO FIXING BUT HE ALSO DROVE IT IN FAIR/SUNNY WEATHER. TO SUM UP THE INFORMATION I DO REGULAR MAINTENANCE ON MY VEHICLE. THE BRAKES HARDLY, IF AT ALL WORK IN COLD AND WET WEATHER. AND NOTHING IS REALLY BEING DONE EVEN AFTER I CALLED THE DEALERSHIP ABOUT THE ISSUE. WHEN I SPOKE TO THE MECHANIC AT THE DEALERSHIP HE SAID IT WAS COMMON FOR THIS CAR TO HAVE BRAKES FREEZE UP DUE TO RUST BUILDUP AND OFFERED TO MAKE AN APPOINTMENT TO HAVE THEM CLEANED (ONCE AGAIN FOR $45) THERE IS ALSO A PART AVAILABLE FOR EXTRA MONEY OF COARSE THAT IS A NEW CALIPER SLIDE ASSEMBLY WITH ADDITIONAL CLEARANCE. THIS TELLS ME THAT HYUNDAI KNOWS ABOUT THE ISSUE BUT IS UNWILLING TO DO ANYTHING ABOUT IT. *TR

2005 HYUNDAI SONATA - 20,700 MILES FAILED SAFETY INSPECTION DUE TO SEVERE BRAKE RUST. *TR

AT APPROXIMATELY 40,000 MILES, THE REAR BRAKE DISINTEGRATED DUE TO DRAGGING AND I WAS INFORMED IT WAS MY DRIVING. ONLY ONE REAR BRAKE MALFUNCTIONED IN THIS WAY, HOWEVER ALL ROTORS HAD TO BE "TURNED DOWN" AND NEW BRAKES WERE INSTALLED ALL AROUND EVEN THOUGH ALL OTHER 3 PADS WERE LIKE NEW. AT 72,000 THE FRONT BRAKE DID THE EXACT SAME THING AND THE REAR BRAKE WAS CLOSE TO BEING DETRIMENTAL TO THE ROTOR. THE FRONT ROTORS COULD NOT BE "TURNED-DOWN" AGAIN, SO NEW ROTORS WERE APPLIED. THIS PARTICULAR MECHANIC, AT A WELL KNOW FACILITY INFORMED ME THAT HYUNDAI'S ARE NOTORIOUS FOR WEARING OUT BRAKES AND THEY SEE THIS CONTINUED PROBLEM. THEY ALSO INFORMED ME THAT THE HYUNDAI DEALER IS QUITE AWARE OF THIS ISSUE. I AM NOW ON A "WATCH" AT THIS MECHANIC'S SHOP TO KEEP FROM HAVING YET ANOTHER BRAKE ISSUE. SOMETHING CAUSES THE BRAKES TO DRAG AND WEAR QUICKLY AND NOT ALWAYS THE SAME BRAKE. THE BRAKE PEDDLE, AFTER THE FIRST HYUNDAI SERVICE, WENT TO FLOOR AND I WAS INFORMED THAT THE SONATA IS DESIGNED FOR THE "OLDER" CUSTOMER WHOSE REACTION TIME IS SLOWER AND MORE UNSTEADY, THEREFORE THE BRAKING IS LONGER AND SOFTER. AFTER THE NEW MECHANIC ADJUSTED EVERYTHING, MY BRAKES ARE NORMAL. *TR

HUSBAND DRIVING AT LOW SPEED, CAR IN FRONT OF HIM STOPPED; BRAKES ON SONATA FAILED-HIT BRAKE PEDAL TO THE FLOOR, BUT SONATA STILL DID NOT STOP; CAR WAS AT THE DEALER (SAVAGE HYUNDAI) THE WEEK BEFORE FOR INSPECTION AND ALL WAS FINE; HUSBAND HIT CAR IN FRONT OF HIM AND THAT PERSON HIT ANOTHER CAR. IN ADDITION, AIR BAGS DID NOT DEPLOY EVEN THOUGH THERE WAS $6700 WORTH OF FRONT END DAMAGE; TOLD DEALER-SAID HIGH HIT; CALLED HYUNDAI-IMPLIED DAMAGE WAS HIGH AND PERHAPS AIR BAGS SHOULD HAVE DEPLOYED, BUT MAKE IT VERY DIFFICULT TO FILE A FORMAL COMPLAINT; SAID WE NEEDED PICTURES, ETC.; CAR WAS AT THE HYUNDAI DEALER BEING FIXED; BOTH HYUNDAI DEALER AND HYUNDAI CORPORATE NOT MAKING THINGS EASY. *NM

DT*: THE CONTACT STATED WHILE TRAVELING AT LOW SPEEDS THE BRAKES FAILED CAUSING TWO ACCIDENTS. THE PEDAL WAS DEPRESSED TO THE FLOOR. THE VEHICLE HAS BEEN IN FOR BODY REPAIRS HOWEVER, THE DEALER HAS NOT BEEN CONTACTED ABOUT THE BRAKES. NO INJURIES WERE REPORTED AND POLICE REPORTS WERE FILED. UPDATED 03/22/06*JB