2008 Hyundai Santa Fe Body & Structure Problems

Your car's frame has rusted through, making it unsafe to drive even though it has fewer than 100,000 miles. Severe rust on the frame compromises the structural integrity of your vehicle. A mechanic will need to inspect the extent of the rust damage and may recommend frame repair or replacement depending on severity.

You noticed heavy rust and corrosion on your vehicle's subframe (the metal frame that supports the car's suspension and body) after inspecting underneath your Santa Fe. The dealer confirmed the problem but didn't repair it, and Hyundai didn't offer assistance. This type of corrosion can potentially weaken the structural integrity of your vehicle over time.

2008 HYUNDAI SANTA FE- The car goes to the dealer every 6 months for the grease and oil and then the New York State Inspection every November. That car has been up on the lifts numerous times since 2008 and I am now just being informed the undercarriage - driver side frame was rotted. I don't think the frame could have rotted out since my last inspection in November of 2022. I found the recall was from 2017 campaign #947.I was never notified of this recall, I feel Hyundai has put me as risk to be involved in an accident if the undercarriage falls out. If it was a warranty job back in 2017 I would have been covered as I had a 10 year warranty which would have expired November 2018. Hyundai should repair the vehicle at no cost to me as I was never notified of of the recall for service campaign 947 and I would have been covered under the 1O year warranty . This was negligence on Hyundai's behalf I might not have this problem if the service campaign #947 was performed in 2017 / 2018. If they knew the campaign was out there it should have been completed with one my New York State Inspections in November of of 2017 or 2018. This question goes to Hyundai- on the invoice it states LIFETIME OIL CHANGES - why was I charged $19.98? I asked the service advisor and his was reply was we got bought out and no more free oil changes. Not a good answer - I should be grandfathered in and refunded the $21.55.

I noticed a Crack in the lower part of the windshield on the driver's side. I was told by Safelite there was rust around the windshield and they would not replace the windshield unless the rust was repaired.

FRONT SUB FRAME IS RUSTING SEVERELY. LAST INSPECTION WAS MARGINAL. INSPECTOR SAID IT PROBABLY WON'T PASS INSPECTION AT THE NEXT INTERVAL TIME. *TR

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT TOOK THE VEHICLE TO WRIGHT HYUNDAI (10677 PERRY HWY, WEXFORD, PA 15090) BECAUSE HE HEARD SQUEAKING NOISES COMING FROM THE FRONT END OF THE VEHICLE. THE CONTACT WAS INFORMED THAT THERE WAS A HOLE IN THE FRAME OF THE VEHICLE. THE CONTACT QUESTIONED THE DEALER ABOUT THE NOISES, BUT NO DIAGNOSTIC TEST WAS RENDERED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND PROVIDED CASE NUMBER: 326790. THE MANUFACTURER OFFERED A BUYBACK ABOVE THE KBB VEHICLE VALUE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 135,000.

THE INTERIOR DRIVER'S SIDE INTERIOR DOOR HANDLE BROKE WHEN I TRIED TO OPEN IT.

DRIVING DOWN A ROAD AT NIGHT AND THE SUNROOF SUDDENLY FLEW OFF THE TOP OF CAR. I HAVE BEEN DRIVING A RENTAL SINCE IT HAPPENS AND HAVE CONTACTED HYUNDAI CORP AND FINALLY RECEIVED A CALL FROM THEM ON FEB TUES 27TH BUT HAVE NOT RESOLVED WHAT THEY ARE GOING TO DO ABOUT THIS WITH ME OR CARSTAR COLLISION CENTER WHERE MY CAR IS SITTING NOW. THE CONSUMER STATED THE SUNROOF WAS REPAIRED UNDER THE RECALL, THE UNDER CARRIAGE HAD NOT. THE CONSUMER REQUESTED TO BE REIMBURSED FOR THE RENTAL CAR. *JS

TAKATA RECALL MY 2008 HYUNDAI SANTA FE HAS PAINT THAT CHIPPED AWAY ABOVE THE DRIVER SIDE, RIGHT ABOVE THE WINDSHIELD. THE PAINT STILL CONTINUES TO REMOVE ITSELF FROM THE BODY IN CHUNKS. THE ISSUE BEGAN ABOUT A YEAR AGO. AND I DO NOT EXPECT PAINT TO REMOVE ITSELF WITH ANY RUST/ ROCK CHIPS IN THE AREA OF PAINT MISSING. THE SUV HAS 136,800 MILES ON IT, BUT PAINT SHOULD NOT BE COMING OFF IN CHUNKS. I LOOKED ONLINE AND OTHER INDIVIDUALS HAD A SIMILAR ISSUE WITH THEIR HYUNDAI. IT'S NOT JUST A PROBLEM WITH THE SANTA FE. IT'S ALSO SONATA'S, ELANTRA'S AND OTHER HYUNDAI MODELS. THE MISSING PEARL WHITE PAINT NOW SHOWS BARE METAL AND IS NOW SHOWING SIGNS OF SURFACE RUST.

PEELING PAINT ON ROOF GAS TANK DOESN'T REGISTER IF TANK IS EMPTY OR FULL.

2008 HYUNDAI SANTA FE. CONSUMER WRITES IN REGARDS TO BROKEN DRIVER INSIDE DOOR HANDLE THAT SPLIT IN HALF. ALSO, WATER SOLVENT CONTAINER SPLIT DUE TO COLD WEATHER TEMPERATURES. CONSUMER UNABLE TO ADD WASHER FLUID. *SMD

2008 HYUNDAI SANTA FE OFF CENTER HEAD ON COLLISION RESULTING IN SEVERE LEG TRAUMA. INTEGRITY OF THE FIRE WALL FAILED RESULTING IN METAL PUSHING PAST THE FIREWALL IN TO THE DRIVERS SIDE AREA ENTRAPPING THE LEG ON THE FEMUR. THIS INJURY RESULTED IN A DANGEROUS AMOUNT OF BLOOD LOSS IN TO THE CAVITY OF THE THIGH. *TR

ON FEBRUARY 14, 2009 I INCURRED A SCALP LACERATION THAT REQUIRED 6 STAPLE SUTURES WHEN I HIT MY HEAD WITH THE REAR HATCHBACK DOOR OF MY 2008 HYUNDAI SANTA FE SUV. I LATER LEARNED FROM OTHER MOTORISTS THAT THIS HAS HAPPENED TO THEM IN THEIR SUV'S. I WOULD SUGGEST A VISIBLE WARNING STICKER BE PLACED SOMEWHERE NEAR THE PULL STRAP WARNING MOTORISTS WHEN THEY LOWER THEIR HATCHBACK DOORS. *TR

TL*THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT PURCHASED THE VEHICLE FOR ITS FUEL ECONOMY AND WEIGHT CAPACITY TO TOW A TRAILER. AT THE DEALER, THE WEIGHT CAPACITY WAS LISTED AS 3,197 IN THE REAR AND 2,976 IN THE FRONT. THE CONTACT RECEIVED A RECALL LETTER, WHICH DECREASED THE WEIGHT CAPACITY OF THE VEHICLE. THE CONTACT FEELS THAT THE MANUFACTURER WAS MISLEADING SINCE HE BELIEVED THAT THE VEHICLE COULD TOW A CERTAIN AMOUNT OF WEIGHT AS DISCUSSED AT THE DEALER. THE CONTACT DOES NOT WANT TO DRIVE THE VEHICLE AND FEELS THAT HIS FAMILY'S LIVES COULD BE IN DANGER. THE FAILURE MILEAGE WAS 4,000. UPDATED 09/10/08 *BF UPDATED 09/17/08. *JB