2011 Honda Odyssey Brakes Problems

BRAKE PEDAL IS SOFT AND GOES ALMOST TO THE FLOOR. HAVE HAD THE MASTER CYLINDER, BRAKE PADS, AND CALIPERS REPLACED AT DAVID MCDAVID IN 2018. BRAKE PEDAL REMAINED SOFT AND GOES ALMOST TO THE FLOOR. HAD MASTER CYLINDER REPLACED AGAIN IN 2021 AT A PRIVATE FACILITY AND BRAKE PEDAL IS STILL NOT FIRM AS IT SHOULD BE.

EITHER THE BRAKE ROTORS WARP OR THE PADS DEPOSIT SOMETHING ONTO THE ROTORS. THE CAR HABITUALLY GOES THROUGH BRAKES, A SINGLE LONG DESCENT WILL CAUSE BRAND NEW BRAKES TO JUTTER BACK AND FORTH VIOLENTLY, WHICH IS UNNERVING FEELS LIKE IT DECREASES BRAKE EFFECTIVENESS. EVEN IN LIGHT USE THE ROTORS HAVE TO BE SURFACED AND PADS ARE REPLACE TWICE A YEAR. THIS IS MENTIONED VERY FREQUENTLY ONLINE IN FORUMS, AND WHEN BROUGHT UP TO A DEALERSHIP THEY DENY ANY CHRONIC BRAKE PROBLEMS. THEY INSIST DRIVERS MUST BE "RIDING THE BRAKES".

WHEN BRAKING THE VEHICLE SHAKES AND THE BRAKES VIBRATE TO THE POINT THAT THE VEHICLE FEELS UNSAFE. THIS HAS BEEN A CONTINUAL PROBLEM. BRAKES HAVE BEEN INSPECTED AND WE ARE TOLD THAT THE ROTORS ARE WARPED AND NEED TO BE REPLACED. THIS HAS BEEN DONE THREE TIMES AND NOW, AT 96,000 MILES WE ARE BEING TOLD THAT THE BRAKES/ROTORS NEED TO BE REDONE AGAIN. I WROTE TO HONDA IN 2017 AND NEVER RECEIVED A REPLY. THE HONDA DEALER SAYS IT IS NOT A SAFETY ISSUE. SUPPOSEDLY A NEWER VERSION OF ROTOR WAS ISSUED AND INSTALLED THE LAST TIME, BUT THE PROBLEM IS BACK. FROM A DRIVER'S PERSPECTIVE THIS IS A SAFETY ISSUE AND HONDA SHOULD MAKE IT RIGHT. THEIR BRAKE COMPONENTS ARE UNDERSIZED OR NOT ENGINEERED PROPERLY FOR THE SIZE OF THE VEHICLE. THE VIBRATION IS NOT FELT ANYTIME THAT THE BRAKES ARE APPLIED, BUT MORE SIGNIFICANTLY WITH HIGHER SPEEDS AND QUICKER STOPS.

TL* THE CONTACT OWNS A 2011 HONDA ODYSSEY. WHILE DRIVING AT AN UNKNOWN SPEED, THE ABS INDICATOR ILLUMINATED AND THE VEHICLE ABRUPTLY BRAKED. THE CONTACT ALSO STATED THAT THE VEHICLE ACCELERATED WITHOUT THE ACCELERATOR PEDAL BEING DEPRESSED. THE VEHICLE WAS TOWED TO AUTOFAIR HONDA (200 KELLER ST, MANCHESTER, NH 03103) WHERE IT WAS DIAGNOSED THAT THE ALTERNATOR NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED THE FOLLOWING DAY. THE VEHICLE WAS TOWED BACK TO THE DEALER FOR FURTHER DIAGNOSTIC TESTING AND REPAIRS. THE MANUFACTURER WAS CONTACTED. THE FAILURE MILEAGE WAS 105,000. THE VIN WAS NOT AVAILABLE.

TODAY, AT HONDA DEALERSHIP, WAS INFORMED THAT THE REASON OUR VEHICLE SHAKES AND VIBRATES ROUGHLY AT HIGH SPEEDS (WHEN BRAKING) IS DUE TO WARPED ROTORS. WAS TOLD HONDA HAS DISCONTINUED MAKING THOSE ROTORS AND WOULD NEED THEM REPLACED WITH NEW ROTORS THAT HAVE BEEN MADE LARGER. KNOWN ISSUE, BUT NOT COVERED, COST APPROX $800 TOTAL WITH NEW PADS, ETC. VERY FRUSTRATED THAT A PART HAS BEEN DISCONTINUED AND DEEMED UNSAFE T BE USED AGAIN, BUT NO RECALL OR REIMBURSEMENT FOR THIS.

SOFT BRAKE PEDAL GOES TO THE FLOOR. TOOK TO SHOP BRAKE SYSTEM HAD TO BE REVELED. AFTER 2 WEEKS DOING SAME PROBLEM. MASTER CYLINDER BEEN CHECKED WITH NO ISSUES

I OFFICIALLY PURCHASED A USED 2011 HONDA ODYSSEY FROM A LOCAL HONDA DEALERSHIP ON OCTOBER 5, 2016. BEFORE I LEFT WITH THE NEW VEHICLE, THE DEALERSHIP SERVICE DIVISION REPLACED BOTH THE FRONT AND REAR BRAKE PADS ON THE VEHICLE (SEE ATTACHED PHOTOS FOR SERVICE/REPAIR INVOICE DATED 10/4/2016). ON OCTOBER 7-8, 2016, I DROVE THE CAR ON A STATE HIGHWAY IN SOME MOUNTAINOUS AREAS BOTH ON A UPHILL AND DOWNHILL SLOPE AT ABOUT 30-50 MPH. I NOTICED THAT ESPECIALLY WHEN DRIVING ON A DOWNWARD SLOPE, WHEN I APPLIED THE BRAKES EVEN SLIGHTLY, THE CAR BEGAN TO PERCEPTIBLY SHUDDER. THE GREATER THE SLOPE OF THE ROAD, THE GREATER THE SHUDDERING EFFECT. I RETURNED WITH THE VEHICLE TO THE HONDA DEALERSHIP FOR ANOTHER UNRELATED REASON, BUT INQUIRED ABOUT THE SHUDDERING AND ASKED IF DURING THE DEALERSHIP'S SAFETY INSPECTIONS IF ANY PROBLEMS RELATED TO THE BRAKES HAD BEEN DISCOVERED, SINCE THE PADS WERE BRAND NEW. THE TECHNICIAN AT THE DEALERSHIP INFORMED ME THAT THE ROTORS HAD BEEN WARPED DUE TO EXCESSIVE HEAT FROM BRAKING. AFTER I PRESSED HIM FOR MORE INFORMATION, HE TOLD ME THAT VIRTUALLY EVERY RECENTLY-PRODUCED HONDA ODYSSEY (I.E., MODELS MANUFACTURED IN THE LAST 5-10 YEARS) THAT HE HAD SEEN COME THROUGH THE SERVICE DIVISION EXPERIENCED A SIMILAR WARPING PROBLEM AFTER NEARLY EVERY 30,000-40,000 MILES DRIVEN. IN HIS OPINION, THE ROTORS INSTALLED IN HONDA ODYSSEYS WERE ACTUALLY MUCH TOO SMALL (I.E., THEY DID NOT HAVE ENOUGH SURFACE AREA) TO BE ABLE TO WITHSTAND THE HIGH AMOUNTS OF HEAT CAUSED BY THE LARGE BRAKES REQUIRED FOR THE RELATIVELY LARGER MODEL OF VEHICLE (THE VAN). HE WENT AS FAR AS TO TELL ME THAT HE WAS ACCUSTOMED TO INSTALLING LARGER-THAN-RECOMMENDED ROTORS IN SOME OF HIS CUSTOMERS' VANS TO TRY AND AVOID THE PROBLEM. HE SAID HE WOULDN'T BE SURPRISED IF A RECALL WOULD BE FORTHCOMING ON THE ROTORS. I WOULD LIKE TO REQUEST AN INVESTIGATION ON THESE ROTORS TO INITIATE SUCH A RECALL.

PUTTING BRAKES ON AT HIGH SPEED, LIKE AT INTERSTATE SPEED, VEHICLE AND STEERING WHEEL WILL SHAKE, AND VIBRATE EXCESSIVELY. WARP FRONT BRAKE ROTORS. VEHICLE ONLY HAS 40,000 MILES ON IT, BUT HAS BEEN DOING IT SINCE ABOUT 30,0000 MILES. USUALLY NOT A PROBLEM SINCE MOST OF MY DRIVING IS IN THE CITY, BUT WHEN USING THE INTERSTATE IT IS SCARY IF YOU HAVE TO MAKE AN EMERGENCY STOP. FEELS LIKE YOU CAN LOOSE CONTROL.

THE VEHICLE SHAKES QUITE A BIT WHEN BRAKING FROM HIGHWAY SPEEDS, SUCH AS WHEN ENTERING AN INTERSTATE HIGHWAY OFFRAMP. APPARENTLY THIS IS CAUSED BY PREMATURELY WARPING BRAKE ROTORS.

BRAKE ROTORS ARE WARPING , 2011 MODEL WITH 32000 MILES, FOUND MANY SIMILAR COMPLAINTS ON THIS WEB SITE.DRAGGING OR SKIPPING WHEN VEHICLE IN MOTION AND BRAKES APPLIED. DEALER CALLS IT NORMAL WEAR AND TEAR.

TL* THE CONTACT OWNS A 2011 HONDA ODYSSEY. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 65 MPH, THE BRAKE PEDAL WAS DEPRESSED AND THE FRONT END OF THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ROTORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 32,275. UPDATED 04/13/16*LJ UPDATED 04/26/16*LJ THE CONSUMER EXPERIENCED A WHEEL VIBRATION AND SHIMMY FROM THE FRONT OF THE VEHICLE ON FOUR SEPARATE OCCASIONS. THE BRAKES AND ROTORS WERE SERVICED EACH TIME. UPDATED 05/02/16. *JB *JS

IN 2011 AFTER WE BOUGHT THE VEHICLE WE TOOK A TRIP TO COLORADO WHERE OUR BRAKES FAILED, I WAS PUSHING THE BRAKES GENTLY DOWN A HILL AND AFTER ABOUT 1 MINUTE THE CAR STARTED TO SHAKE VIOLENTLY, I THOUGHT I HAD A FLAT SO I PULLED OVER AND CHECKED BUT THE TIRES WERE FINE, THAN I REALIZED THAT THE DISC BRAKES HAVE WARPED MAKING THE CAR DIFFICULT TO SLOW DOWN, AFTER WE MADE IT BACK HOME WE TOOK THE CAR BACK TO THE DEALER WERE THEY TURNED THE BRAKES TO SMOOTH IT OUT AND TOLD US IT WAS FINE. IT WAS FINE FOR A LITTLE WHILE 2-3 MONTHS WHEN IT STARTED DOING IT AGAIN, WE TOOK THE CAR BACK TO THE DEALER AGAIN THIS TIME THEY REPLACED THE DISCS IN THE FRONT BUT THEY DIDN'T WANT TO WE JUST HAD TO FIGHT WITH THEM TO GET IT DONE. IT DIDN'T TAKE BUT ABOUT 5000 MILE WHEN IT STARTED DOING THE SAME THING, THIS TIME I CALLED OTHER FRIENDS WHO OWNED THE SAME STYLE MINIVAN AND THEY TOLD ME THAT THEY EXPERIENCED THE SAME ISSUE WITH THE BRAKED, THIS TIME I ORDERED A SET OF HIGH PERFORMANCE DISC BRAKE SET FOR THE FRONT TO SEE IF IT MAKES A DIFFERENCE AND IT DID. I HAD THOSE DISC BRAKES ON FOR 2 YEARS AND THE CAR IS FINE, THE ISSUE IS THAT THE BRAKES ARE NOT MADE WELL ENOUGH TO HOLD UP ON THE LONG TERM, BECAUSE AFTER BRAKING DOWN HILL FOR ABOUT A MILE THE DISC BRAKES IN THE FRONT WARP AND CAUSE THE VEHICLE TO SHAKE VIOLENTLY, I TOLD MY FRIENDS WHAT I DID TO REMEDY THE PROBLEM AND THEY ALL FOLLOWED MY LEAD TO CHANGE OUT THE FACTORY FRONT DISCS WITH A BETTER QUALITY ONE, AND THAT SEEMS TO BE WORKING FOR NOW. I STRONGLY SUGGEST SOME TO LOOK INTO THIS MATTER BECAUSE HONDA SHOULD HAVE UPGRADED THE BRAKES ON THEIR OWN WHY SHOULD I HAVE TO PAY OUT OF POCKET WHILE THE VEHICLE IS STILL UNDER WARRANTY TO HAVE A SAFETY ISSUE LIKE THIS FIXED. I CAN TELL YOU THIS THAT I WILL NOT BE OWNING ANY HONDA PRODUCT IN THE FUTURE, I HAD TOO MANY ISSUES WITH THIS ONE.

VIBRATION IN BRAKE PEDAL AND STEERING WHEEL WHEN BRAKING, EXTREMELY NOTICED AT SPEEDS ABOVE 45 MILES PER HOUR. DEALER DID NOT ACKNOWLEDGE PROBLEM AT 09/12/2012, BUT FOUND AND 'FIXED' WARPED BREAK ROTOR AT ABOUT 45000 MILES ON 7/9/2013. PROBLEM (VIBRATION AND PULSING OF STEERING WHEEL AND BRAKE PEDAL) SOON REAPPEARED AND ON 7/27/2015 RETURNED TO DEALER AND WAS TOLD THAT WARPING HAD AGAIN OCCURRED. CALLED HONDA, WHO SAID THAT THE THEY WERE NOT RECALLING THE ORIGINAL BRAKE ROTOR (PART NUMBER 45251-TK8-A01 EVEN THOUGH IT IS NO LONGER AVAILABLE AND HAS BEEN REPLACED BY 45251-TK8-A02. THE NEW BRAKE ROTOR NOW BEING PUT ON 2011 AND LATER HONDA ODYSSEY HAS INCREASED INTERNAL THICKNESS (MORE MASS AND SMALLER AIR VENTS) AND OTHER CHANGES. FOR MY CAR, THE OLDER ROTOR IS DEFECTIVE, WHY HAS IT NOT BEEN RECALLED?

WHILE BRAKING, THE STEERING BEGIN TO SHIMMY. CHECKS BY A TIRE/BRAKE SHOP VERIFIED THAT THE FRONT ROTORS WERE WARPED. ROTORS WERE REMOVED AND TURNED TO REMOVE WARPING. SATISFACTORY PERFORMANCE OF BRAKING WAS RESTORED BUT AT 60,000 MILES PROBLEM BEGAN TO REOCCUR . I INTEND TO REPLACE ROTORS AND PADS WITH QUALITY MATERIAL (NON HONDA PARTS) TO CORRECT THE PROBLEM. I'M GREATLY DISAPPOINTED WITH HONDA AND THEIR POOR MATERIAL QUALITY.

SEVERE VIBRATION WHILE BRAKING AT ANY SPEED ABOVE 45 MPH. I'M REPORING THIS PROBLEM MAY 2015, HOWEVER I HAVE NOTICED THIS GOING ON FOR ABOUT 2 YEAR AND DIDN'T KNOW WHAT IT COULD BE, THOUGHT IT WAS ROAD CONDITIONS. SINCE I DON'T DRIVE FREEWAYS VERY OFTEN (VERY LOW MILES ON MY 2011 HONDA ODYSSEY) I DIDN'T GIVE IT MUCH THOUGHT, HOWEVER NOW THAT I'M DRIVING MORE FREQUENTLY AT HIGHER SPEEDS ON VARIOUS ROADS, THERE IS DEFINETELY A VIBRATION UPON BRAKING.

TL* THE CONTACT OWNS A 2011 HONDA ODYSSEY. WHILE DRIVING APPROXIMATELY 10 MPH, THE BRAKES FAILED. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 39,000.

THE BRAKES ROTORS APPEAR TO BE WARPED AND VIBRATE VERY VIOLENTLY WHEN BRAKING MODERATELY AT HIGHER SPEEDS. THIS VIOLENT VIBRATION MAKES CONTROL OF THE VEHICLE DIFFICULT IN THOSE SITUATIONS WHEN IT OCCURS. THE DEALER HAS IDENTIFIED NOTHING WRONG. *TR

TL* THE CONTACT OWNS A 2011 HONDA ODYSSEY. THE CONTACT STATED THAT WHILE DECELERATING, THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE ROTORS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE AND VIN WERE NOT AVAILABLE. *TR

TL* THE CONTACT OWNS A 2011 HONDA ODYSSEY. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE BRAKES FAILED CAUSING AN INCREASE IN STOPPING DISTANCE AND TIME. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 11/6/13 *CN THE CONSUMER STATED DURING A RECENT DRIVE DOWN THE MOUNTAIN HILL, THE BRAKES BEGAN VIBRATING. WITH THE BRAKES VIOLENTLY PULSATING, THEY FAILED TO EFFECTIVELY SLOW THE CAR DOWN. THE FRONT BRAKE VIBRATION OCCURRED SEVERAL TIMES BEFORE ON MOUNTAIN ROADS. SEVERAL AUTO MECHANICS INCLUDING THE DEALER, GAVE A GENERAL EXPLANATION THAT HEAT BUILD-UP WARPED THE BRAKE DISCS AND CAUSED THE VIBRATION. IT WAS ALSO SUGGESTED WHEN TRAVELING DOWN STEEP MOUNTAIN ROADS, THE DRIVER SHOULD SWITCH TO 3RD GEAR AND EASE OFF THE ACCELERATOR ALLOWING THE ENGINE TO HELP REDUCE SPEED. UPDATED 11/14/13

WE BOUGHT THE VEHICLE BRAND NEW IN 2011. WE FIRST EXPERIENCED THE PROBLEM WITH THE BRAKES IN APRIL 2012 (AT 19,327 MILES) WHEN HEAVY VIBRATION WAS FELT DURING BRAKING. THE VEHICLE WAS TAKEN TO HONDA FOR INSPECTION, DETERMINED THE ROTORS WERE WARPED. NEW PADS WERE REPLACED AND ROTORS RESURFACED. EIGHT MONTHS LATER (AT 30,593 MILES), SAME ISSUE OCCURRED AGAIN. ROTORS WERE WARPED FOR UNKNOWN REASON; NECESSITATING A RESURFACING AND REPLACEMENT OF BRAKE PADS FOR THE SECOND TIME. SEVEN MONTHS AFTER SECOND VISIT (AT 38,841 MILES), THE SAME ISSUE OCCURRED FOR THE THIRD TIME - THE ROTORS WERE FOUND WARPED AGAIN. LIKE THE PREVIOUS VISITS, THE ADVISER WAS NOT ABLE TO ARTICULATE THE CAUSE OF THE ISSUE, ONLY THIS TIME BLAMED MY DRIVING BEHAVIOR. I TOLD THE ADVISER I HAVE OTHER VEHICLE WHICH IS DRIVEN AND HANDLED IN THE SAME WAY BUT DOES NOT NEED CONSTANT BRAKE SERVICES LIKE THE ODYSSEY (3 TIMES IN 16 MONTHS). HE THEN CHANGE HIS THEORY AND CONCLUDED THAT I WASN'T DRIVING ENOUGH - NOT ALLOWING THE PADS TO PROPERLY SYNC WITH THE ROTORS, AND SUGGESTED I SHOULD DRIVE THE VEHICLE MORE. TO MAKE MATTER WORSE, I WAS FORCED BY THE ADVISER TO AGREE THAT THE DEALER WILL NOT BE WARRANTING ANY MORE FRONT BRAKE JOB BECAUSE I WASN'T DRIVING ENOUGH AND THAT THE ISSUE COULD REAPPEAR AGAIN 6 MONTHS LATER. I CONTACTED AMERICA HONDA BUT THEY OFFERED NO ASSISTANCE, SINCE THEY INDICATED THERE WERE NO KNOWN ISSUE FILED. I FEEL THE VEHICLE WAS POORLY MADE OR ASSEMBLED THUS CREATING THE ABOVE ISSUE. *TR

WHEN WE PURCHASED THIS VEHICLE THE DEALER TOLD US THE ODYSSEY HAS A NEW AND IMPROVED BREAKING SYSTEM. SIX MONTHS AFTER WE PURCHASED THE VEHICLE WE HAD A WOBBLE WHEN BREAKING (8,000 MI). WE TOOK THE VEHICLE TO THE DEALER AND WERE TOLD NOTHING WAS WRONG. THE ISSUE CONTINUED TO GET WORSE AND WE RETURNED AGAIN AT 20,000 MILES. AT THAT POINT WE WERE TOLD THE ROTORS WERE WARPED BUT IT IS AN "ANNOYANCE" AND NOT A SAFETY ISSUE. NOW AT 38,000 MILES THE VEHICLE SHAKES VIOLENTLY WHEN BREAKING. I AM TOLD ITS MY DRIVING HABITS THAT CAUSED THIS. I HAVE NEVER HAD ANOTHER CAR WITH BREAK ISSUES PRIOR TOT 50,000 MILES. THE DEALER WANTS $350 TO FIX WITH NO GUARANTEE THE ISSUE WILL NOT OCCUR IN ANOTHER 8K MILES.

TL* THE CONTACT OWNS A 2011 HONDA ODYSSEY. THE CONTACT STATED THAT WHILE APPLYING THE BRAKES, THE VEHICLE AND THE BRAKE PEDAL VIBRATED, AND SHOOK ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER SEVERAL TIMES FOR THE BRAKE FAILURE. THE DEALER RESURFACED THE FRONT ROTORS TWICE; HOWEVER THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 2,000 AND THE CURRENT MILEAGE WAS 14,000. UPDATED 09-18-13 *BF THE ROTORS WERE RESURFACE TWICE.

TL* THE CONTACT OWNS A 2011 HONDA ODYSSEY. THE CONTACT STATED THAT WHILE TRAVELING 65 MPH, THE CONTACT DECELERATED AND THE VEHICLE SHOOK VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FRONT ROTORS AND BRAKES WERE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 20,000.

FRONT BRAKES PULSATING SEVERELY AND STEERING WHEEL SHAKING 2-3 INCHES BACK AND FORTH WHEN APPLYING BRAKES... NOW IT HAPPENS AT ALL SPEEDS. *TR

THE 2011 HONDA ODYSSEY BRAKES FAILED WHEN APPLIED WHEN THE VAN WAS PLACED IN REVERSE. THE BRAKE PEDAL TRAVELED ALL THE WAY TO THE FLOOR ON APPLICATION OF THE BRAKES AND DID NOT RETURN BACK. AS THE PEDAL DID NOT RETURN BACK WAS UNABLE TO PUMP THE BRAKE TO BUILD ANY HYDRAULIC PRESSURE. THE VEHICLE WAS BROUGHT TO A HALT USING THE PARKING BRAKE. SUBSEQUENTLY THE BRAKES STARTED WORKING AGAIN. THE DEALERSHIP ON INSPECTION REPORTS A BRAKE MASTER CYLINDER FAILURE. HONDA WHEN CONTACTED DIRECTLY DOES NOT ACKNOWLEDGE ANY SUCH PRIOR INCIDENT REPORTS. HOWEVER AT LEAST TWO SUCH FAILURES HAVE BEEN REPORTED ON THE SAME MAKE, MODEL YEAR BY OTHER OWNERS ON HONDA OWNER FORUMS. I HUMBLY REQUEST THAT YOU INVESTIGATE THIS ISSUE BEFORE ANY FATALITIES OCCUR. HONDA IS UNWILLING TO ACKNOWLEDGE A SYSTEMIC FAILURE. *TR

TL* THE CONTACT OWNS A 2011 HONDA ODYSSEY. THE CONTACT STATED THAT WHILE DEPRESSING THE BRAKE PEDAL AT APPROXIMATELY 40 MPH, HE NOTICED A VIBRATION IN THE PEDAL. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE TECHNICIAN STATED THE ROTORS WOULD HAVE TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 16,000. *TR

SIR / MADAM: I BOUGHT A 2011 HONDA ODYSSEY TOURING ELITE, IN DECEMBER, 2010. IT HAS A DEFECTIVE FRONT BRAKE SYSTEM WHICH CAUSES THE FRONT ROTORS TO WARP AND THE BRAKE PADS TO GLAZE OVER FROM OVERHEATING; CAUSING ALL THESE COMPONENTS TO PREMATURELY WARE OUT. I BELIEVE ALL HONDA ODYSSEY'S HAVE THIS SAME PROBLEM. HONDA SAYS THE FRONT ROTORS ONLY HAVE A 12,000 MILE WARRANTY, SINCE IT IS A WEAR ITEM, I AM RESPONSIBLE FOR THE COST OF ALL REPAIRS. ON TWO (2) OCCASIONS, WHILE TRAVELING ON THE US INTERSTATE HIGHWAYS, DOWN STEEP MOUNTAINS IN COLORADO AND NORTH CAROLINA, THE STEERING WHEEL STARTED SHAKING 3 INCHES ' WHICH IS VERY FRIGHTENING ' SO MUCH SO, I STARTED LOOKING FOR THE 'RUNAWAY TRUCK RAMP'! THE VEHICLE CURRENTLY HAS APPROXIMATELY 46,000 MILES AND HAS HAD TWO (2) SETS OF FRONT ROTORS INSTALLED, THE CURRENT ROTORS HAVE BEEN TURNED AT LEAST THREE (3) TIMES, AND THREE (3) SETS OF FRONT BRAKE PADS. THE FRONT END CURRENTLY SHAKES WHEN THE BRAKES ARE APPLIED BECAUSE THE ROTORS ARE WARPED AGAIN BUT THE DEALER WANTS TO WAIT LONGER BEFORE TURNING THEM (THEY ARE ALMOST TO THE MINIMUM ROTOR THICKNESS). I HAVE DOCUMENTED THESE PROBLEMS BY EMAIL AND IN PERSON WITH THE LOCAL HONDA DEALER, HONDA MANUFACTURING AND HONDA USA. HONDA'S DISTRICT CUSTOMER SERVICE MANAGER DROVE THE VEHICLE AT 46,073 MILES AND ACKNOWLEDGED THE FRONT ROTORS WERE WARPED. HOWEVER, HONDA DENIES THERE IS A FRONT BRAKE PROBLEM. EVERY OTHER AUTOMOBILE I HAVE EVER OWNED HAS NOT REQUIRED BRAKE PADS BEFORE 50,000 PLUS MILES, NOR NEW ROTORS BEFORE 100,000 PLUS MILES. THERE ARE SEVERAL OTHER NON-SAFETY RELATED ISSUES WITH THIS VEHICLE. ANY AND ALL EMAILS AND SERVICE RECORDS ARE AVAILABLE FOR REVIEW. IF YOU WOULD LIKE TO DISCUSS THIS MATTER PLEASE DO NOT HESITATE TO CALL. *TR

WHEN USING BRAKES TO DECELERATE FROM SPEEDS OVER 45 MPH, THE STEERING WHEEL BEGINS TO VIBRATE AND SHAKE. AN INITIAL CALL TO THE DEALER SAID THAT DUE TO EXCESSIVE HEAT AND WEAR, THE ROTORS MAY BE WARPED AND WAS TOLD TO BRING IT IN TO GET ROTORS RESURFACED. I ASKED WHETHER THIS WAS COMMON AT ABOUT 16000 MILES. DEALER TOLD ME THAT SHOULDN'T BE THE CASE UNTIL AROUND 45,000-75,000 MILES. MY WIFE DRIVES THE VEHICLE UNDER "NORMAL" CONDITIONS (DRIVING KIDS TO SCHOOL, ETC.) AND DOES NOT BREAK EXCESSIVELY OR SUDDENLY. *TR

SHAKES WHEN BRAKING AT SPEEDS OVER 45 MPH, DRASTICALLY INCREASING 45-0 MPH STOPPING DISTANCE, ROTORS HAVE BEEN RESURFACED ONCE AND PADS REPLACED ALREADY AT APPROXIMATELY 13000 MILES. AT 25968 ROTORS NEED TO BE RESURFACED AGAIN, PADS ABOUT 50%, HONDA ADVISES THAT ROTORS WILL NEED TO BE RESURFACED ABOUT EVERY 12000-13000 MILES TO MAINTAIN SAFE DRIVING CONDITIONS. NO MOUNTAINOUS DRIVING, OR HARD BREAKING, NEVER HAD TO RESURFACE OR REPLACE ROTORS ON ANY OF MY EIGHT PREVIOUS VEHICLES, INCLUDING A MINI VAN. *TR

TL* THE CONTACT OWNS A 2011 HONDA ODYSSEY. THE CONTACT STATED THAT WHILE DRIVING 65 MPH THE STEERING BEGAN TO SHAKE VIOLENTLY. AFTER STOPPING FOR GAS AND LETTING THE BRAKES COOL OFF THE SHAKING CEASED. THE VEHICLE WAS TAKEN TO A DEALER WHO DECIDED TO REPLACED THE ROTORS AFTER HAVING THEM ROTATED THREE PREVIOUS VISITS. THEY CONTINUE TO WARP AND CAUSE THE SHAKING IN THE STEERING. THE FRONT BRAKES HAD BEEN REPLACED THREE TIMES. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 12,000 AND THE CURRENT MILEAGE WAS 36,000.

TL* THE CONTACT OWNS A 2011 HONDA ODYSSEY. THE CONTACT STATED THAT THE BRAKES AND ROTORS WOULD CONTINUOUSLY WEAR PREMATURELY. THE CONTACT DID NOT STATE WHAT CAUSED THE BRAKES AND ROTORS TO WEAR AT LOW MILEAGE. AS A RESULT OF THE WORN ROTORS, THE STEERING WHEEL BEGAN TO SHAKE WHEN DRIVING AT LEAST 50 MPH. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 17,000.

NOTICED WHEN DRIVING AT HIGHWAY SPEED AND THEN HAVING TO BRAKE ABRUPTLY THERE WOULD A PULSATION AND THE STEERING WOULD START SHUTTERING. DEALER DIAGNOSED IT AS UNEVEN BRAKE PAD WEAR DUE WARPED ROTORS. *TR

BRAKE COMPONENTS DEFECT.

MY 2009 HONDA ODYSSEY EX HAS 30,000 MILES AND HAS ONGOING BRAKE ISSUES. THE BRAKES ARE SOFT AND GOES TO THE FLOOR AND THE VAN DOES NOT STOP UNLESS I PUMP THE BRAKES. THE BRAKES ALSO MAKE A LOUD GRINDING SOUND WHEN TRYING TO STOP QUICKLY AND WHEN GOING DOWNHILL:(FREEWAY OFF RAMPS). IT IS NOT THE ABS BRAKING SYSTEM. THERE IS NO PULSATING FEELING ON THE BRAKE PEDAL. THE VAN DOES NOT STOP WHEN THE BRAKES HAVE THIS GRINDING SOUND. MY HONDA DEALER HAS LOOKED AT THE BRAKES AND THEY SAY "NO ISSUES". THEY SAY BRAKE PADS AND ROTORS ARE FINE. THEY WERE CHECK AT EVERY OIL CHANGE AT THE DEALERSHIP. I HAD THE SAME SOFT BRAKES ISSUES WITH MY 2007 HONDA ODYSSEY. THE DEALER ALSO SAID NO PROBLEMS BUT THERE WAS A RECALL WITH SOFT BRAKES PROBLEMS. I'M WORRIED WHEN I HAVE TO GO UP TO THE MOUNTAIN AND COME BACK DOWN THE HILL. THERE HAS TO BE A DESIGN FLAW TO HAVE OTHER HONDA ODYSSEY OWNERS COMPLAIN ABOUT THEIR BRAKES. *TR