2003 Ford Explorer Wipers & Visibility Problems

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHEN ATTEMPTING TO CLOSE THE REAR WINDOW, THE CONTACT NOTICED THAT THE REAR LIFTGATE WINDOW HINGES WERE CRACKING AND WERE TILTED ON ONE SIDE. THE CONTACT, A CERTIFIED MASTER TECHNICIAN, STATED THAT THE WINDOW NEEDED TO BE REPLACED. THE CONTACT CALLED FORT MILL FORD AT (866) 680-5276 (LOCATED AT 801 GOLD HILL RD, FORT MILL, SC 29708) AND WAS INFORMED THAT THE VIN WAS NOT INCLUDED IN ANY RECALLS. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. WHILE DRIVING 50 MPH, A LOUD NOISE WAS HEARD WHEN THE SUN ROOF EXPLODED WITHOUT WARNING. THERE WERE NO INJURIES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHEN OPERATING THE VEHICLE, THE REAR HATCH DOOR AND THE REAR HATCH WINDOW BECAME UNSECURED AND OPENED DUE TO A CRACK NEAR THE REAR WINDOW WIPER. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 40,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. WHILE DRIVING APPROXIMATELY 25 MPH, A NOISE EMERGED FROM THE REAR HATCH WINDOW. THE CONTACT PULLED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND NOTICED THAT THE PIECE THAT HELD THE WINDOW IN PLACE WAS FRACTURED. THE VEHICLE WAS REPAIRED FOR THE SAME FAILURE IN MARCH OF 2015. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 159,149.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE HINGES ON THE REAR WINDSHIELD WERE LOOSE AND THE REAR WINDOW WAS NOT PROPERLY SECURED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

I HAD JUST PUT A BAG OF GROCERIES IN THE BACK, WAS CLOSING THE REAR GLASS HATCH WHEN IT EXPLODED ABOUT 1/3 OF THE WAY DOWN. VERY LOUD NOISE, AND TINY GLASS PIECES SHATTERED ACROSS 3 PARKING SPOTS, INTO AND ALL AROUND OUR VEHICLE, INCLUDING THE GROCERIES WHICH I DISCARDED. THIS CAR IS NOT INCLUDED IN THE RECALL.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE GLASS AND THE WINDOW ON THE REAR LIFTGATE PANEL CRACKED. THE CONTACT STATED THAT THE DEALER REPLACED IT THREE TIMES, BUT THE FAILURE OCCURRED BECAUSE THE MATERIAL WAS NOT MADE TO EXPAND OR CONTRACT BASED ON THE WEATHER. THE FAILURE MILEAGE WAS UNAVAILABLE.

WHILE THE VEHICLE WAS PARKED IN FRONT OF MY HOUSE, THE REAR WINDOW EXPLODED AND I HAVE A CCTV VIDEO SHOWING IT WAS NOT SMASHED OUT. AFTER READING THAT THERE HAD BEEN A PREVIOUS RECALL ISSUED IN 2004, I CONTACTED FORD TO INQUIRE ABOUT THE RECALL STATUS. THEY INFORMED ME THAT THE PREVIOUS OWNER OF THE VEHICLE HAD ALREADY BROUGHT IT IN FOR THIS RECALL. AFTER THE RECALL REPAIRS TO PREVENT THE REAR WINDOW EXPLOSION, IT STILL EXPLODED LATER ON. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. THE CONTACT STATED THAT THE LIFT GATE GLASS DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 04V442000 (STRUCTURE) DUE TO THE VEHICLE BEING A TWO DOOR AND NOT A FOUR DOOR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 100,000.

WHEN CLOSING THE GLASS TAILGATE THE RIGHT HINGE THAT ATTACHES THE GLASS TO THE TAILGATE BROKE CAUSING THE GLASS TO DETACH FROM THE CAR AND FALL HITTING ME IN THE LEFT ARM UPDATED 09/16/14*LJ UPDATED 3/18/2015 *JS

2 COMPLAINTS - BACK REAR HATCH PANEL UNDER REAR WINDOW HAS MULTIPLE CRACKS LIVE IN AUGUSTA GA AND VISIT FLORIDA AND THIS SEEMS TO BE A COMMON PROBLEM EVERY MAKE BODY LIKE MINE HAVE THIS CRACK AND SOME PANEL HAS EVEN FALLEN OFF. THIS HAS TO BE A MANUFACTURING PROBLEM FOR THIS LARGE AMOUNT OF SUV'S TO HAVE THE SAME PROBLEM SEE MORE WITH PROBLEMS THAN WITHOUT. ALSO RECENTLY HAD PROBLEMS WITH WINDOW INTERMITTENTLY NOT GOING DOWN AND BACK UP AFTER ICE STORM IN AUGUSTA THIS YEAR ALL FOUR WINDOWS STOPPED GOING UP AND DOWN. THIS ALSO SEEMS TO BE A COMMON PROBLEM WITH THIS MODEL AND BODY STYLE OF FORD EXPLORERS. OWNED A 1993 FORD EXPLORER EDDIE BAUER HAD APPROX. 300,000 MILES ON IT BEFORE I GOT RID OF IT AND THE MOST HAPPENED TO THIS CAR WAS THE TRANSMISSION AND REAR BRAKE LEAK WHICH WAS THE MOST EXPENSIVE PROBLEM I HAD. WISH I STILL HAD THE 1993 EXPLORER BECAUSE MY 2003 MAKES ME HESITANT ABOUT PURCHASING ANOTHER FORD EXPLORER NO MATTER HOW MUCH I LIKE THEM THIS ONE WILL MAKE TURN TO ANOTHER MAKE OF CAR. ONCE A LOYAL FORD OWNER NOT SO SURE NOW. YOU WOULD THINK THAT FORD WILL BE AS LOYAL TO US AS WE ARE OF THEM, IT IS THE LITTLE THINGS THAT MAKE YOU FRUSTRATED AND NOT WANTING TO PURCHASE ANOTHER. IF YOU CAN'T DEPEND ON THE SMALLER THINGS HOW CAN WE DEPEND ON THEM WITH THE LARGER THINGS. ONCE A LOYAL FORD OWNER. *JS

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK, THE REAR LIFT GATE SPONTANEOUSLY EXPLODED, LEAVING GLASS INSIDE AND OUTSIDE OF THE VEHICLE. THE CONTACT WAS NOT INJURED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS SCHEDULED TO BE REPAIRED. THE FAILURE MILEAGE WAS 185,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. THE CONTACT STATED THAT THE REAR HATCH BACK WINDOW PIN BECAME FRACTURED AND CAUSED THE SPRING AND THE WINDOW TO SEPARATE FROM THE FRAME. THE DEALER PREVIOUSLY REPLACED THE HATCH BACK PIN HOWEVER THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 110,000 AND THE CURRENT MILEAGE WAS 145,000.

BACK GLASS ON LIFT GATE EXPLODED. GLASS WENT EVERY WHERE. NO ONE WAS IN THE THANK GOODNESS.VEHICLE WAS JUST SITTING IN DRIVEWAY. IT JUST EXPLODED AND SHATTERED. THERE WAS NOTHING WRONG WITH THE GLASS. THE ONLY THING THERE WAS A CRACK ON LOWER PANEL THAT HAD BEEN THERE FOR ABOUT 3 YEARS. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE AIR CONDITIONER AND DEFROSTER WOULD NOT OPERATE WHEN ACTIVATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO ADVISED THAT BOTH THE AIR CONDITIONING/HEATER SWITCH AND THE BLOWER MOTOR WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE 130,000.

AS I WAS DRIVING THE SUN VISOR DROPPED, AND STARTED TO DANGLE AND SWING TOWARDS MY FACE. IT STARTLED ME AND I SWERVED THE CAR A LITTLE, TRIED TO DODGE THE VISOR FROM HITTING ME IN THE FACE/HEAD, AND THEN PULLED INTO A PARKING AREA. I NOTICED THE SUN VISOR HINGE HAD CRACKED AND THE WIRING CAME LOOSE. I TOOK IT TO THE FORD DEALER QUICK LANE AND THEY STATED IT WOULD COST ME BETWEEN $120-$250 DEPENDING ON THE COLOR AND IT WOULD NEED TO BE REWIRED DURING INSTALLATION. THIS COULD CAUSE SOMEONE TO HAVE AN ACCIDENT OR INJURY, AND THERE IS NO REASON THIS PART SHOULD OF BROKEN LIKE THIS. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 -10 MPH OVER A ROAD BUMP, THE HATCH BACK WINDOW DETACHED AND FELL FROM THE VEHICLE WITHOUT WARNING. THE CONTACT PULLED OVER AND SAW THAT THE HINGES TO THE REAR WINDOW WERE SEVERELY RUSTED, CAUSING THE WINDOW TO DETACH. THE VEHICLE WAS NOT INSPECTED BY A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS LATER CONTACTED AND ADVISED HIM THAT THE VEHICLE WAS TOO DANGEROUS TO DRIVE AND SHOULD NOT HAVE PASSED STATE INSPECTION. THE FAILURE MILEAGE WAS APPROXIMATELY 147,000. THE CURRENT MILEAGE WAS APPROXIMATELY 148,000.

ALL 4 OF THE WHEEL BEARINGS HAD TO BE REPLACES IN A MATTER OF 5 MONTHS THE REAR WINDOW HAS A CRACK IN THE FIBERGLASS COVERING RIGHT DOWN THE MIDDLE SAID NOT COVERED NOT A HEALTH RISK BUT THE MOLDING IS STILL CRACKED FROM THE BOTTOM OF WINDOW TO THE BOTTOM OF THE MOLDING PIECE BRAKE LIGHTS STAY ON UNTIL U GET BACK IN AND TAP THE BRAKES THEN THE LIGHT SHUTS OFF. *TR

REAR WINDOW HINGES BROKE FOR THE SECOND TIME. THEY WERE FIXED ONCE WITH RECALL AND ARE NOW BROKE AGAIN. ALSO THE BACK LIFT GATE PANEL HAS CRACKED. *TR

MY SON WENT TO LEAVE IN EXPLORER. NOTICED HATCH HAD POPPED OPEN (HAS BEEN DOING THIS) AND WHEN HE CLOSED THE TWO INCH OPENING THE GLASS EXPLODED ON HIM AND ALL OVER DRIVEWAY. GLASS PIECE IN EYE WHICH IS OK AND SCRAPES ON ARMS AND FOOT. THIS COULD HAVE BEEN SO MUCH WORSE AND WANT ANSWERS TO WHY THIS HAPPENED. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT CONFIRMED THERE WAS A CRACK LOCATED ON THE PANEL OF THE REAR WINDOW. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO BE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 125,000 AND THE CURRENT MILEAGE WAS 177,000.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER A RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 07E104000 (VISIBILITY: GLASS, SIDE/REAR). THE REPAIR WAS PERFORMED PRIOR TO THE PURCHASE OF THE VEHICLE. THE REMEDY WAS INSUFFICIENT, AS A RESULT TO THE REAR LIFTGATE HINGE FAILING TO SECURE THE WINDOW GLASS PROPERLY. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE MALFUNCTION. THE APPROXIMATE FAILURE MILEAGE WAS 109,000.

BLEND DOOR ACTUATOR NOT WORKING. NOT ABLE TO DEFROST WINDOWS EASILY.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACTED STATED THAT THE REAR WINDOW PANEL WAS FRACTURED NEAR THE BOTTOM. THE CONTACT WAS CONCERNED THAT THE WINDOW WOULD FRACTURE FROM THE VEHICLE AND BREAK. THE MANUFACTURER WAS CONTACTED AND ADVISED THAT THERE WERE NO A RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000.

THE FRONT WINDSHIELD ON MY 2003 FORD EXPLORER REACHES EXCESSIVE TEMPERATURES. IN MILD WEATHER ON A SUNNY DAY THE INTERIOR OF THE WINDSHIELD CAN BECOME SO HOT IT CAN EASILY MELT ITEMS PLACED AGAINST IT. ADDITIONALLY, IT APPEARS THIS IS THE ORIGINAL WINDSHIELD FROM THE MANUFACTURER. *TR

WHILE PULLING OUT OF A PARKING LOT AT A SLOW SPEED THE BACK WINDOW ON MY FORD EXPLORER SPORT SHATTERED. THE GLASS WAS COMPLETELY GONE AND NUMEROUS PIECES ENDED UP INSIDE AND OUTSIDE OF THE VEHICLE. THERE WAS ABSOLUTELY NO OBJECT FROM THE OUTSIDE THAT WOULD HAVE CAUSED THIS INCIDENT. THE LIFT GATE HAD NOT BEEN OPENED PRIOR TO THIS EVENT. I BELIEVE IT WAS CAUSED BY THE HINGES AND THE MANNER IN WHICH THEY WERE DESIGNED TO ATTACH TO THE GLASS THAT TRIGGERED THIS EXPLOSION OF THE REAR WINDOW.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING APPROXIMATELY 40 MPH THE HEATER STOPPED WORKING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHO STATED THAT THE TEMPERATURE BLEND DOOR NEEDED REPLACING. THE VEHICLE HAD NOT BEEN REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 130,000 AND THE CURRENT MILEAGE WAS 150,000.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE AIR CONDITIONER FUNCTIONED BUT THE HEAT DID NOT. THE CONTACT REPLACED THE THERMOSTAT AND STATED THAT THERE WERE NO LEAKS IN THE HEATING COIL. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THE REACTOR COULD HAVE BEEN THE CAUSE OF FAILURE. THE CURRENT AND FAILURE MILEAGES WERE 133,700.

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED A CRACK IN THE PANEL ATTACHED TO THE GLASS OF THE REAR LIFTGAGE. THE CRACK WAS SMALL AT FIRST BUT BECAME LARGER OVER TIME. THE VEHICLE HAD NOT BEEN TAKEN TO BE INSPECTED FOR THE PROBLEM. ALSO, THE HEATED STOPPED BLOWING HEAT AND WAS TAKEN TO AN AUTHORIZED DEALER WHERE THE CONTACT WAS INFORMED THAT THE BLEND DOOR ACTUATOR NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 46,000.

TL*THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. WHILE THE VEHICLE WAS PARKED AND UNOCCUPIED THE REAR WINDOW WINDSHIELD SHATTERED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT IT DOES NOT SHATTER ON ITS OWN. THE MANUFACTURE ADVISED THE CONTACT TO FILE A COMPLAINT WITH NHTSA. THE VEHICLE WILL BE REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGES WERE 50,000.

TEMPERATURE BLEND DOOR STARTS MAKING A CLICKING NOISE AND THEN THE HEATER STARTS PUTTING OUT COLD AIR. THE FRONT WINDOW DOESN'T DEFROST. NO HEAT IN THE FRONT OF THE VEHICLE WHEN TEMPERATURES OUTSIDE CAN REACH 0 DEGREES. THE AVERAGE COST TO REPAIR THE PART IS $734. *TR

TL* THE CONTACT OWNS A 2003 FORD EXPLORER. THE REAR WINDSHIELD HAS DEVELOPED CRACKS, WHICH SUBSEQUENTLY CAUSED THE WINDSHIELD WIPERS TO FAIL. SHE TOOK THE VEHICLE TO THE DEALER FOR INSPECTION, BUT THEY DID NOT PERFORM AN INSPECTION. THE MANUFACTURER ADVISED HER TO REPAIR THE VEHICLE, AND IF HER MODEL TYPE WAS RECALLED, SHE COULD INQUIRE ABOUT REIMBURSEMENT. THE VEHICLE WAS IN THE PROCESS OF BEING REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 64,000.

I WAS DRIVING MY 2003 FORD EXPLORER AT 70 MPH IN THE FAST LANE OF THE FREEWAY AND DECIDED TO PULL THE DRIVER'S SIDE VISOR DOWN TO CUT DOWN ON THE SUN'S GLARE. ALL OF A SUDDEN, THE PLASTIC MOUNT THAT HOLDS THE VISOR METAL STEM IN PLACE SHATTERED AND THE VISOR CAME LOOSE DANGLING IN FRONT OF MY FACE BY AN ELECTRICAL CABLE. THE VISOR WAS SEVERELY OBSTRUCTING MY VISION SO I HAD TO QUICKLY GRAB THE IT AND HOLD IT OUT OF THE WAY WITH MY LEFT HAND WHILE STEERING WITH MY RIGHT TO NEGOTIATE ACROSS 4 LANES OF FREEWAY TRAFFIC UNTIL I COULD STOP THE VEHICLE ON THE FREEWAY SHOULDER. THE ELECTRICAL CABLE DOES NOT HAVE A CONNECTOR SO IT IS NOT POSSIBLE TO DISCONNECT IT FROM THE VEHICLE. AS A RESULT, I HAD TO DRIVE THE NEXT 20 MILES USING MY LEFT HAD TO HOLD THE VISOR UP WITH MY LEFT HAND WHILE DRIVING WITH MY RIGHT UNTIL I COULD REACH HOME. *TR

TL*THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. WHILE DRIVING APPROXIMATELY 45 MPH ON NORMAL ROAD CONDITIONS, AN EXCESSIVELY LOUD RATTLE AND WIND NOISE WAS COMING FROM THE INTERIOR REAR OF THE VEHICLE. THE DRIVER INSPECTED THE VEHICLE AND OBSERVED THAT THE LIFTGATE HINGE FAILED AND THE BOLTS LOOSENED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR INSPECTION. THE TECHNICIAN STATED THE FAILURE WAS DUE TO THE LIFTGATE HINGE WHICH WAS A COMMON PROBLEM WITH THIS VEHICLE. NHTSA CAMPAIGN ID NUMBER; 04V442000 (STRUCTURE:BODYHATCHBACK/LIFTGATE;HINGE AND ATTACHMENTS) IS A IDENTICAL TO THE FAILURE; HOWEVER, THE VEHICLE WAS EXCLUDED FROM THE RECALL SINCE IT ONLY APPLIED TO FOUR DOOR VEHICLES. THE VEHICLE WAS TEMPORARILY REPAIRED AND RESUMED OPERATION WITH CAUTION. THE CONTACT IS AWARE OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 65,000. UPDATED 05/18/09. *LJ THE REAR DEFROSTER WAS INOPERATIVE. UPDATED 05/20/09.*JB

3 LARGE CRACKS IN PLASTIC TRIM BELOW GLASS ON REAR LIFT GATE "APPEARED" AFTER A COLD/ICY DAY. *TR

WHILE OUT OF TOWN, VACATIONING AND TOURING FOR FALL COLORS, I LOST ALL POWER TO THE CLIMATE CONTROL SYSTEM AFTER A SHORT COFFEE STOP. WHEN I STARTED MY EXPLORER I NOTICE I HAD NO HEAT, FANS, DEFROSTER OR POWER TO THE CLIMATE CONTROL SYSTEM. THINKING I HAD BLOWN A FUSE, I OPENED THE OWNERS MANUAL AND CHECKED THE FUSE DIAGRAM PAGES FOR THE SYSTEM THAT WAS NOT WORKING. I CHECKED ALL THE FUSES INDICATED BUT, I FOUND NONE OF THEM HAD BLOWN. AFTER DETOURING AND HEADING FOR THE LOCAL SMALL TOWN, I PURCHASED AN EMERGENCY FUSE REPLACEMENT AND TESTER KIT AS IT WAS NOW GETTING DARK, TRYING TO CONTINUE RE-CHECKING ANY FUSES (WHILE IN THE CONFINED AND MOST AWKWARD PLACE TO INSTALL A FUSE CONTROL PANEL UNDER THE DASH BOARD ON THE DRIVERS SIDE) WAS GOING TO HAVE TO WAIT TILL DAYLIGHT. ON MY RETURN TO MY CAMPSITE I CHANGE THE HEAD LIGHTING FROM AUTO TO MANUAL AND PULLED OUT ON THE KNOB TO TURN ON THE FOG LIGHT SYSTEM. AS I DID THIS ALL POWER TO MY CLIMATE CONTROL SYSTEM RETURNED AND WAS WORKING NORMAL AGAIN. THIS COULD HAVE BEEN A REAL PROBLEM AS THE NEXT MORNING I WOKE UP TO FROST AND 0` TEMPERATURE AND OVERCAST FOR THE DAY. *TR

2003 FORD EXPLORER - 65K MILES - BLEND DOOR ACTUATOR 7.6HP FAILED CAUSING A/C TO REMAIN IN ON POSITION WITH NO HEAT OR DEFROSTER. *TR

MY BACK REAR WINDOW EXPLODED WHILE I WAS AT WORK. IT HAPPEN AT 400AM SO IT WAS NOT HOT. *TR

TL*THE CONTACT OWNS A 2003 FORD EXPLORER SPORT. WHEN THE CONTACT ATTEMPTED TO OPEN THE REAR WINDOW, IT COMPLETELY SHATTERED. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE FAILURE OCCURRED WITHOUT WARNING. THE CURRENT AND FAILURE MILEAGES WERE 68,843.

I HAVE A FORD EXPLORER AND THE BACK GLASS FELL AND IT HANGING OFF. WHY BEFORE I BOUGHT THE CAR LAST YEAR THE PROBLEM WASN'T FIXED. *TR

MY BACK WINDSHIELD EXPLODED LAST THURSDAY WHILE PARKED IN MY DRIVEWAY. NOT ONLY DID THE GLASS EXPLODE, BUT THE FIBERGLASS UNDERNEATH THE GLASS WAS PULLED AWAY FROM THE BACKEND OF THE TRUCK IN A BOWING POSITION. I HAD THE BACK HINGE REPLACED AFTER THE RECALL, IT'S BEEN LESS THAN 12 MONTHS AND THE FORD DEALERSHIP IN NASHUA WILL DO NOTHING FOR ME, STATING THAT THEY HAVE NEVER SEEN ANYTHING LIKE THAT BEFORE AND THERE ARE NO OTHER COMPLAINTS. WHEN I ASKED TO SPEAK TO THE AREA FACTORY REP, THEY INFORMED ME THAT THEY DIDN'T HAVE ONE. I ASKED TO SPEAK TO THE MANAGER, WHO PRETTY MUCH SAID, HERE'S YOUR HAT, WHAT'S YOUR HURRY, OUT YOU GO...HE THEN FLAGGED ME AS BEING AN "IRATE" CUSTOMER. I AM A MOTHER OF 4 YOUNG CHILDREN, GOD FORBID THEY HAD BEEN IN THE CAR WHEN THAT HAD HAPPENED. FORD SHOULD BE ASHAMED OF THEMSELVES..FORD-BUILT STRONG MY LEG! ANYONE INTERESTED IN FILING A CLASS ACTION LAWSUIT IN THE STATE OF NH, PLEASE LET ME KNOW, I AM GOING TO CONTACT MY LAWYER TODAY. *TR

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. WHILE DRIVING 55 MPH WITH THE CRUISE CONTROL ACTIVATED, THE CRUISE CONTROL FAILED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER AND THEY STATED THAT THE CRUISE CONTROL WIRING FAILED. THERE IS A RECALL FOR THE VEHICLE SPEED CONTROL, BUT HIS VIN WAS NOT INCLUDED. THE RECALL NUMBER WAS UNKNOWN. THE CURRENT MILEAGE WAS 11,550 AND FAILURE MILEAGE WAS 11,330. UPDATED 06/25/08. *LJ THE CONSUMER STATED AFTER THE DEALER FIXED THE RECALLED REAR HATCH PROBELM, THE CARGO HATCH FLEW OPEN WHILE DRIVING DOWN THE HIGHWAY. A

I AM ATTEMPTING TO RECTIFY A WELL KNOW PROBLEM ON MY 2003 FORD EXPLORER REGARDING THE HEATER BLEND DOOR FOR THE FRONT HEATING UNIT. IN THIS PARTICULAR INSTANCE I HAVE NO HEAT HERE IN MICHIGAN OF ALL PLACES. DOES FORD HAVE A RECALL FOR THIS PROBLEM? I HAVE SPOKEN TO SEVERAL FORD PEOPLE AND THEY SAY THIS IS A VERY COMMON PROBLEM. IF THE AIR BLEND DOOR BREAKS AND THE SYSTEM IS LOCKED IN THE A/C MODE, DEFOGGING/DEFROSTING THE WINDSHIELD WILL BE A CHALLENGE. EVER TRIED TO MELT ICE WITH AN AIR CONDITIONER? WE HAVE A RESPONSIBILITY TO REPORT SAFETY ISSUES. WHEN THE DEALER CALLED BACK , THE FIRST QUESTION WAS THE VEHICLE?S MILEAGE. WHEN I REPORTED 79K MILES THEY SAID SORRY, THE CUT-OFF FOR ASSISTANCE WAS 75K MILES. I ARGUED THAT THE PROBLEM WAS LOGGED AT 40K MILES WITH NUMEROUS FOLLOW-UP CALLS. THEY REFUSED. I CALLED THE 1-800 ASSISTANCE NUMBER AGAIN AND GOT A REAL BONEHEAD. SHE CONFIRMED THAT 75K MILES WAS THE CUT-OFF. I ASKED TO SPEAK TO THE GENTLEMAN TO WHOM I HAD PREVIOUSLY REGISTERED MY COMPLAINT, GIVING HER HIS IDENTIFICATION NUMBER. SHE REFUSED. I HUNG UP AND DIALED THE 1-800 NUMBER AGAIN. THIS TIME I GOT A KIND LADY WHO TOLD ME THAT THE FIELD ENGINEER HAD THE AUTHORITY TO OFFER COMPENSATION. I CONTACTED THE DEALERSHIP TO SCHEDULE AN APPOINTMENT AND THEN LEARNED THAT THE FIELD ENGINEER HAD BACKED OUT OF THE DEAL AND I WAS ABOUT TO FORK OVER $700 FOR REPLACEMENT. HOW IN THE WORLD DOES THE CUSTOMER GET HOSED FOR THIS AMOUNT OF MONEY. I BOUGHT THE TRUCK, KEPT IT INSURED, DID MY MAINTENANCE AND DUE TO A FACTORY DEFECT, I STILL HAVE TO PAY? UNLESS THE VEHICLE IS IN A CRASH OR FIRE, AN AIR PLENUM SHOULD LAST LONGER THAN THE BODY OF THE VEHICLE. THE ON-GOING SAGA CONTINUES, AS THIS BECOMES A SAFETY ISSUE, NOW I CAN'T SEE OUT OF MY WINDOW DUE TO SNOW AND ICE. *TR

FORD TAURUS 2003, WINDSHIELD WAS HIT WITH A STONE WHILE DRIVING ON HIGHWAY ON MAY 10, 2007, A CHIP WAS VISIBLE AND WITHIN A FEW DAYS BECAME A 12 INCH CRACK. HAD REPLACED AT A COST OF $197.34. *TR

TL*THE CONTACT OWNS A 2003 FORD EXPLORER. THE CONTACT STATED THAT THE PLASTIC UNDERNEATH THE REAR LIFTGATE'S GLASS DOOR HAS BEGUN TO CRACK. THE DOOR STILL OPERATES PROPERLY. THE VIN WAS UNAVAILABLE. THE CURRENT MILEAGE IS 78,000 AND FAILURE MILEAGE WAS 74,000.

TL*-THE CONTACT OWNS A 2003 FORD EXPLORER EDDIE BAUER EDITION. THE REAR WINDOW CRACKED NEAR THE LOCATION OF THE FORD EMBLEM. THE NHTSA WEBSITE LISTED SEVERAL RELATED COMPLAINTS. THE MANUFACTURER WAS AWARE OF THE DEFECT, AND WILL NOT AUTHORIZE THE REPAIR. THE CURRENT AND FAILURE MILEAGE WERE BOTH 49,000.*AK

TL* - THE CONTACT CALLED ABOUT THE 2003 FORD EXPLORER XLT. THE CONTACT STATED THAT THE AIR BAG LIGHT STAYED ON, AND WHEN IT WAS ON, THE AIRBAG DEACTIVATED WHICH WAS A SAFETY PROBLEM. IT HAPPENED ALL THE TIME. THE FUSES HAVE BEEN CHANGED UNDER WARRANTY, AND NOW THAT IT WAS NOT UNDER WARRANTY, IT WAS NO LONGER REPAIRED FREE OF CHARGE. THE CONTACT STATED THAT SHE WAS TOLD BY ONE SERVICE STATION THAT IT WAS STANDARD FOR THE FUSES TO BLOW BECAUSE OF THE FUSE BOX LOCATION. ANOTHER SERVICE STATION TOLD THE CONTACT THAT THIS WAS NOT TRUE THAT THE FUSE BOX WAS TO HIGH IN THE CAR FOR PEBBLES TO BE ABLE TO GET INTO THE FUSE BOX. ALSO, THE WINDSHIELD WIPERS WON'T TURN OFF BY THEM SELVES, EVEN WHEN THE KEYS WERE OUT OF THE IGNITION. THE CONTACT STATED THAT THE AIRBAG LIGHT AND THE DOOR AJAR LIGHT WERE CONSISTENTLY ON. MOREOVER, THE ELECTRONIC SEAT WOULD NOT MOVE FORWARD OR BACKWARD. SHE HAD THE SEAT REPAIRED TWICE AND IT FAILED AGAIN. FINALLY, CONTACT STATED THAT THE VEHICLE WAS MAKING A KNOCKING NOISE IN THE FRONT AND REAR OF THE VEHICLE'S UNDERCARRIAGE. THE VEHICLE CLANKED STOPPING, TURNING TO GO FORWARD, OR JUST SITTING STILL. THE FIRST TIME THE CONTACT TOOK THE VEHICLE FOR REPAIR SHE WAS TOLD BY THE REPAIR SHOP THAT IT WAS THE DRIVER'S SEAT THAT WAS CAUSING THE CLANKING NOISE, AND THE SECOND TIME SHE WAS TOLD THAT THE NOISE WAS NOT SOMETHING THEY COULD IDENTIFY BECAUSE DURING DIAGNOSTIC TESTING IT DID NOT SHOW A SPECIFIC FAILURE CODE. THE CURRENT AND FAILURE MILEAGE WERE BOTH 114000.*AK

TL* - THE CONTACT OWNS A 2003 FORD EXPLORER XLS. THE CONTACT STATED THAT THERE WAS A PANEL BELOW THE REAR WINDOW THAT CRACKED IN HALF VERTICALLY. THE VEHICLE WAS PARKED IN THE DRIVEWAY ,AND WHEN HE GOT TO THE VEHICLE HE FOUND IT THAT WAY. HE HAD NOT DRIVEN THE VEHICLE THAT DAY. THE CONTACT WAS CONCERNED THAT THERE WERE MANY COMPLAINTS CONCERNING THIS PROBLEM. ALSO, THE REAR WINDOW OF EXPLODED . THE FAILURE AND CURRENT MILEAGE WERE 48000.*AK

TL* - THE CONTACT OWNS A 2003 FORD EXPLORER EDDIE BAUER EDITION. THE REAR WINDOW CRACKED NEAR THE LOCATION OF THE FORD EMBLEM. THE NHTSA WEBSITE LIST SEVERAL RELATED COMPLAINTS. THE MANUFACTURER IS AWARE OF THE DEFECT AND WILL NOT AUTHORIZE THE REPAIR. THE CURRENT MILEAGE WAS 50,000 AND THE FAILURE MILEAGE WAS 49,890. *AK

TL* -THE CONTACT OWNS A 2003 FORD EXPLORER WITH AN ODOMETER READING 58000 MILES AND THE FRONT DEFROSTER DID NOT WORK. THE CONTACT STATED THAT WHILE WAS DRIVING AT 45 MPH HE HEARD SOUND COMING FROM DASHBOARD, THEN THE DEFROSTER FAILED TO BLOW HOT AIR. PRESENTLY, ONLY COLD AIR BLEW OUT FROM THE DEFROST. THE CONTACT TOOK THE CAR TO THE DEALER, AND THEY TOLD HIM THAT THE VEHICLE WAS OUT OF WARRANTY, AND HE WOULD HAVE TO PAY FOR THE REPAIR. ALSO, HE CALLED THE MANUFACTURER, AND THEY TOLD HIM TO TAKE IT TO THE DEALER TO HAVE IT FIXED BECAUSE THERE IS NO RECALL AT THIS TIME.*AK UPDATED *JB

TEMPERATURE CONTROL DOES WORK. FAILURE OF BLEND DOOR OR EVAPORATOR ASSEMBLY HEAT DOES NOT WORK AND WINDSHIELD DEFROST DOES BLOW WARM AIR. BLEND DOOR MOTOR OR PLENUM BOX IS AT FAULT.*JB

THE CONSUMER'S 2003 FORD EXPLORER HAD A ROCK CHIP THE WINDSHIELD. A CRACK DEVELOPED FROM THE CHIP. *KB THE CRACK RAN THE ENTIRE LENGTH OF THE WINDSHIELD. THE CONSUMER BELIEVES THE WINDSHIELD ARE POORLY MANUFACTURED. *NM

OWNER WAS DRIVING ON A RESIDENTIAL STREET AT APPROXIMATELY 25 MPH WHEN WITHOUT WARNING THE REAR GLASS SHATTERED. OWNER CONTACTED THE MANUFACTURER AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *NM MANUFACTURE STATED RECALL ONLY APPLIED TO 4 DOOR MODEL, NOT 2 DOOR MODEL WHICH THE CONSUMER OWNS. *BF *NM

WHILE DRIVING 35 MPH REAR WINDOW SHATTERED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

NO PARTS WERE AVAILABLE FOR RECALL 04S20 CONCERNING REAR WINDSHIELD. STERLING FORD 703-430-7700. *AK *TC

NHTSA SAFETY RECALL 04V-442 OF 2003 FORD EXPLORER FORD IS REFUSING TO FIX MY VEHICLE. FORD IS STATING MY VEHICLE HAS NO RECALLS AND THIS RECALL DOES NOT EFFECT MY VEHICLE. I WAS DRIVING DOWN A ROAD WITH NO OTHER CARS WHEN MY REAR WINDSHIELD EXPLODED. THIS CAUSED ME TO THINK SOMEONE WAS SHOOTING OR ATTACKING WHICH ALMOST CAUSED ME TO CRASH MY VEHICLE THINKING I WAS UNDER ATTACK. THE POLICE CAME AND WROTE A REPORT, INVESTIGATED AND FOUND NO EVIDENCE OF MALICIOUS ACTS. FORD IS REFUSING TO RESOLVE THIS AND WILL NOT SAY WHY MY VEHICLE IS NOT EFFECTED. *NM

DURING COLD / SNOW WEATHER WINDSHIELD WIPERS WOULD NOT WIPE THE FRONT WINDSHIELD PROPERLY. THIS CAUSED THE WINDSHIELD WIPERS TO FREEZE AGAINST THE FRONT WINDSHIELD, RESULTING IN POOR VISIBILITY. THE DEALER WAS NOTIFIED.*AK

A CONSUMER SAFETY CAMPAIGN 04520 WAS RECEIVED FOR THE REAR GLASS FALLING OUT OR CRACKING. CONSUMER TOOK VEHICLE FOR AN OIL CHANGE AND THE DEALER DID NOT HAVE THE PART FOR THE VEHICLE. CONSUMER WAS CONCERNED THAT SOMEONE WILL BE INJURED, AND HE WILL BE LIABLE FOR THE INJURIES. MANUFACTURER STATED NO PARTS HAVE ARRIVED YET. *AK

GLASS IS LITERALLY HANGING FROM THE FRONT PASSANGER WINDOW FRAME. THIS IS RESULTING IN OBSTRUCTION OF VISION.

THE REARVIEW MIRROR IN MY VEHICLE HAS ABOUT 20% OF ITS CAPACITY BLOCKED BY THE OVERHEAD COMPARTMENT. *LA

BACK (REAR) WINDOW DOES NOT CLOSE PROPERLY. REQUIRES NUMEROUS ATTEMPTS. *LA

GLASS OF FRONT WINDSHIELD LEAKING, WE HAD IT RESEALED AND IT IS AGAIN LEAKING AND THE NEW SEAL IS LIFTING. THE REAR LIFTGATE WINDOW WAS LEAKING AND THE WATER WAS LEAKING IN BETWEEN THE INNER AND OUTER PANELS. WHEN THE LIFTGATE IS OPENED ONE GETS AN UNEXPECTED SHOWER. THIS TOO REQUIRED REPAIRING.*AK DUP

FORD EXPLORER XLS. REAR WINDOW SHATTERED FOR UNKNOWN REASON. THE WINDOW APPEARS TO BE UNDER ALOT OF TENSION.? *JB

WHILE DRIVING AT UNDER 50 MPH, THERE IS A SQUEAK THAT COMES FROM THE ENGINE COMPARTMENT. IT SOUNDS LIKE A RUSTY SUSPENSION SPRING. HOWEVER, THIS SQUEAK IS HEARD AT EXACTLY 35 SECOND INTERVALS. I FOUND THIS TO BE ASSOCIATED WITH THE AIR CONDITIONER. IF IT IS TURNED OFF, THE NOISE GOES AWAY. THE NOISE IS PRESENT ANYTIME THE VENTILATION SYSTEM IS ON. I TOOK THE AUTOMOBILE TO COURTESY FORD IN POULSBO, WASHINGTON. I WAS TOLD THAT THE NOISE WAS NORMAL. I FIND THIS HARD TO BELIEVE. I DONT THINK FORD WOULD WANT ITS AUTOMOBILES GOING DOWN THE STREET WITH AN INTENTIONAL LOUD SQUEAK. I THINK THIS IS SOMEHOW ASSOCIATED WITH WHAT EVER CONTORLS THE AIR HANDLING SYSTEM, SUCH AS THE COMPUTER. HELP ME FIND AN ANSWER. *AK

2003 FORD EXPLORER SITTING IN GARAGE. REAR HATCH GLASS EXPLODED AS HATCH WAS HALF WAY TO BEING CLOSED.*AK

WHILE DRIVING REAR WINDOW EXPLODED WITHOUT WARNING. DEALER NOTIFIED. *AK

WHILE DRIVING THE 2003 FORD EXPLORER, THE RIGHT REAR WINDOW SHATTERED UNDER NORMAL DRIVING CONDITIONS. *NLM

REAR VIEW MIRROR GIVES A FALSE IMAGE, WHEN THERE ARE NO CARS BEHIND VEHICLE DRIVER CAN OT SEE IN REARVIEW WINDOW. BUT IF CARS ARE BEHIND DRIVER CAN SEE. CONSUMER WAS INVOLVED IN AN ACCIDENT AS A RESULT, DRIVER WAS INVOLVED IN AN ACCIDENT. *AK

THE DRIVER'S POWER WINDOW BUTTON WAS VERY SENSITIVE. THE SLIGHTEST TOUCH/BUMP CAUSED THE WINDOW TO OPEN FULLY. THE CONSUMER ALMOST HAD AN ACCIDENT DUE TO THIS PROBLEM, WHILE DRIVING IN A RAIN STORM. *JB

CONSUMER STATED THAT REAR LIFT GATE GLASS SHATTERED WHILE VEHICLE WAS PARKED IN A "COOL" PARKING LOT ON A "COOL" DAY. TS