2016 Ford Escape Fuel System Problems

Your car may randomly produce struggling sounds from the fuel pump and generate an error code (P1450), which can cause the engine to stall unexpectedly at any time—including while driving through intersections or turns. This issue has been recalled on the Ford Fusion, which shares identical engines and fuel systems with your Escape, but no recall has been issued for your model yet. The underlying problem is with the fuel canister purge valve, and the dealership has charged you for diagnostic fees despite this being a known issue. Fixing this will likely involve replacing the fuel canister purge valve.

While driving my vehicle my vehicle would suddenly stall while in motion. This stalling happens while driving and has stalled in the middle of intersections causing passing vehicles to slam there breaks to avoid hitting me. In addition my vehicle has stalled and almost causing rear end collisions. There would be no warning signs or no lamps that turn on when it first stalls. After the initial stalling of the vehicle it would rough idle, tug and continue to stall. Until I get to a destination. A check engine lamp may turn on once in awhile but not always. If the mechanic shop is closed and I try to take my car the next day the lamp would be off and it would not stall anymore until I use it further. I have taken my car to a Napa when the engine lamp turned on and pulled a code for fuel pump. Although when I get it to my mechanic the light has turned off and they cant get a code from it. This has been happening for approximately a year now. It also seems to happen when fuel gets to quarter tank or less. This happens multiple times approximately 1-2 times everyb2 weeks.

The contact owns a 2016 Ford Escape. The contact stated while the vehicle was stationary, the vehicle became hard to shift into gear. The check engine warning light was illuminated. The contact's daughter took the vehicle to a dealer to be diagnosed. The contact was informed that the canister purge valve, valve cover, oil pan gasket, engine, and turbo needed to be replaced. The contact had received an unknown recall notification for the transmission. The contact authorized the canister purge valve to be replaced. The manufacturer was made aware of the failure and referred to the NHTSA Hotline. The failure mileage was approximately 119,500.

The contact owns a 2016 Ford Escape. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, who determine that the canister purge valve was stuck in the open position. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 80,000.

The contact owns a 2016 Ford Escape. The contact stated that after parking in the vehicle, the odor of fuel was present inside the garage. Upon inspection, the contact discovered fuel leaking from under the vehicle. The vehicle was taken to the local mechanic who diagnosed that the fuel lines had rusted and failed causing a fuel leak. The vehicle was not yet repaired. The manufacturer and local dealer were notified of the failure. The failure mileage was 23,000.

Car suddenly stalled out and stopped. Restarted and stalled again, and several more times. Diagnosed with fuel pump failure.

The contact owns a 2016 Ford Escape. The contact stated that while his wife was driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who retrieved a code indicating a failure of the fuel separator sensor. Further investigation determined that the sensor was stuck in the open position, potentially exposing the vehicle occupants to toxic fumes. The contact stated that the diagnosis was confirmed by a second independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline. The failure mileage was 32,825.

The contact owns a 2016 Ford Escape. The contact stated while driving at various speeds, she smelled an abnormally strong gasoline odor inside the cabin of the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer where it was diagnosed but no failures were found. The contact's son used the OBD reader and Ford computer system to diagnose that the fuel line originating from the engine to the fuel tank appeared to be clogged. The contact's son diagnosed that the purge valve Evap System had failed and needed to be replaced. The manufacturer was notified of the failure and opened a case. The manufacturer informed the contact that the vehicle needed to be diagnosed by the dealer, and it would then be determined whether they could assist with the repair. The vehicle was not repaired. The failure mileage was approximately 14,000.

The contact owns a 2016 Ford Escape. The contact stated that the transmission was previously replaced. The contact stated that after refueling, the vehicle was unable to restart immediately. The contact depressed the accelerator pedal while turning on the vehicle to correct the failure. Additionally, the vehicle made abnormal sounds and would shake and then stall while driving. The vehicle was taken to an independent mechanic, who diagnosed that the canister purge valve needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that there was no recall associated with the VIN. The failure mileage was approximately 150,000.

The contact owns a 2016 Ford Escape. The contact stated that immediately after refueling the vehicle, the vehicle failed to start as needed. The vehicle was towed to an independent mechanic to be diagnosed. The mechanic was unable to determine the cause of the failure. The mechanic was able to start the vehicle. The contact stated that on another occasion while driving at an undisclosed speed, the engine started to rev causing the vehicle to lunge forward. The contact stated that the vehicle was difficult to control. The vehicle was stopped and then towed back to the independent mechanic. The cause of the failure was not determined. The local dealer was notified of the failure. The manufacturer was not yet contacted. The failure mileage was 140,002.

2016 Ford Focus SE check engine light code P1450 Malfunctioning Canister Purge Valve / Fuel Tank Vacuum. This error is common and known. This causes the engine to not start after fueling. And engine to buck / stall while in Motion / driving. Yet no recall notice on file for vin.

My car has 25000.00 miles on it. This started last year. It is a 2016 escape. Runs fine until I put gas in it. The car will not start after I fill up. I thought I was crazy, as that is the only time it does this. Once I get it started it is fine until I fill up again. I look online to see if anyone else had this problem and found out it is common with this car. I spent 257.00 for new purge valve and it fixed the problem. The car never showed a check engine or code. This is a comon problem and should be recalled!

VEHICLE AT VARIOUS TIMES ACTS AS IF IT IS NOT GETTING FUEL, TENDS TO ALMOST STALL, SEEMS TO BE WHEN MAKING START FROM BEING STOPPED THEN MOVING FORWARD AND SOMETIMES WHEN MAKING LEFT TURN AT LIGHT, OCCASIONALLY ON RIGHT .

TL* THE CONTACT OWNS A 2016 FORD ESCAPE. THE CONTACT STATED THAT AFTER REFUELING, THE VEHICLE WOULD NOT IMMEDIATELY RESTART. AFTER RESTARTING THE VEHICLE, WHILE DRIVING AT UNDISCLOSED SPEEDS, THE VEHICLE HESITATED AND STALLED WITHOUT WARNING. THE CAUSE OF THE FAILURES WERE NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 107,000. THE CONSUMER STATED SNOW WAS ENTERING THE VEHICLE AT THE HATCH AND THE DRIVER SIDE BACK DOOR.

2016 FORD ESCAPE WHILE DRIVING THE CAR GOES INTO LIMP MODE ESPECIALLY ON HOT DAYS. WHILE DRIVING ON THE EXPRESSWAY WITH MY FAMILY IN THE CAR, THE VEHICLE JUST SHUTS DOWN AND I PRAY THAT I CAN GET OVER TO THE SHOULDER TO TURN IT OFF AND LET IT REST. IS NOT PULLING ANY CODES SO THEY CAN'T FIGURE OUT WHAT NEEDS TO BE FIXED. I BOUGHT THIS VEHICLE BRAND NEW. IT IS SCARY KNOWING IT COULD SHUT DOWN AT ANY TIME WHILE I AM DRIVING WITH MY FAMILY IN IT. FORD NEEDS TO FIX THIS PROBELM ASAP!

EMISSIONS PURGE VALVE IS BAD/STUCK. TRUCK STALLS WHILE DRIVING AT TIMES. WHEN SHUT OFF TO GET GAS, MUST WAIT 20 MINUTES BEFORE TRUCK WILL START.

DRIVING DOWN VERY BUSY STREET AND VEHICLE STALLED AS I PULLED UP TO TRAFFIC LIGHT AND CAME TO A STOP. AS MANY AS 3-4 TIMES I WAS ALMOST REAR ENDED WHILE TRYING TO GET VEHICLE STARTED. PROBLEM SEEMED TO ONLY OCCUR WHEN FUEL TANK IS BELOW 1/2 TANK AND I WOULD NOTICE FUEL FILL PORT FLAPPER VIBRATING AND SUCKING AIR INTO FUEL TANK. THE FORD FOCUS HAS THIS RECALL ON THE CANISTER PURGE VALVE, WHY NOT ON A FORD ESCAPE. SAME PART USED ON BOTH. THIS PROBLEM WENT ON FOR TWO WEEKS BEFORE I COULD GET VEHICLE INTO DEALERSHIP.

THE VEHICLE WAS TRAVELLING DOWN RURAL HIGHWAY ON A HOT DAY. IT SHUT DOWN ALMOST IN THE MIDDLE OF NOWHERE. THE TEMPERATURE OUTSIDE WAS 99 DEGREES. THE FUEL LEVEL WAS AT A QUARTER TANK. THE DRIVER THEN LEFT THE VEHICLE OFF ON THE SIDE OFF THE ROAD FOR 10 MINUTES AND WAS ABLE TO TRAVEL ANOTHER 20 MILES BEFORE BREAKING DOWN AGAIN.

DRIVER WAS DRIVING ON DIRT ROAD ON A HOT DAY. THE TEMPERATURE WAS 102 DEGREES OUTSIDE. THE VEHICLE BEGIN TO LOSE POWER AND SUDDENLY IT JUST STALLED. THE DRIVER THEN WAITED A FEW MINUTES AND TURNED THE VEHICLE BACK ON AND IT HAPPENED AGAIN UNTIL IT FINALLY WOULDN'T TURN BACK ON. THIS TIME THE DRIVER WAITED AN ADDITIONAL 20 MINUTES AND FINALLY IT WORKED AGAIN UNTIL THEY MADE IT BACK TO A GAS STATION. THE FUEL LEVEL WAS BARELY UNDER A HALF A TANK. THE VEHICLE TENDS TO SHUT DOWN ON A HOT DAY WHEN FUEL GOES BELOW A HALF A TANK. IT IS CONSISTENT WITH OTHER 2016 FORD ESCAPES.

TL* THE CONTACT OWNS A 2016 FORD ESCAPE. AFTER REFUELING THE VEHICLE, THE ENGINE WOULD NOT IMMEDIATELY RESTART. ONCE THE ENGINE WAS RESTARTED, THE VEHICLE WOULD HESITATE AND SPUTTER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 56,000. *BF *JB

ENGINE LIGHT HAS BEEN GOING ON AND OFF FOR A FEW MONTHS NOW. FIRST GARAGE TOLD ME THAT IT WAS THE O2 SENSORS, SO I REPLACED THEM. THAT NIGHT THE CHECK ENGINE LIGHT CAME BACK ON AGAIN SO I BRING OUT BACK IN, THIS TIME IT'S THE CATALYTIC CONVERTER. I HOLD OFF AND GET A DIAGNOSIS FROM ANOTHER SHOP, 3 HITS WITH THE 2.0 TURBO. I BRING IT INTO FORD TODAY AND THEY'RE SAYING IT'S BOTH.

2016 ESCAPE WITH NO HISTORY OR PROBLEMS PRIOR TO EVENTS HERE. DURING A TRIP FROM HOME APPROXIMATELY 50 MILES AWAY VEHICLE OPERATED JUST FINE. AFTER A 5 MIN STOP, I RE-ENTERED AND STARTED THE VEHICLE. AFTER ABOUT 2 MILES AND WHILE ON THE HIGHWAY TRAVELING 70 MPH VEHICLE SUDDENLY SHUTTERED AND ACCELERATION AGGRAVATED THIS SITUATION. POWER LOSS WAS PRESENT, AND VEHICLE STALLED OUT. I COASTED TO SHOULDER. ATTEMPTED NUMEROUS RESTARTS THAT WOULD SEEM TO CATCH BUT SOON STALL OUT. EVENTUALLY GOT THE VEHICLE TO RUN ENOUGH TO LIMP OFF THE HIGHWAY. VERY LOW POWER. PARKED FOR 20 MIN AND RESTARTED WITH NO APPARENT ISSUE. ENGINE LIGHT WAS PRESENT SINCE FIRST STALL. DROVE ABOUT 1 MILE AND SYMPTOMS RETURNED. LOW POWER AND STALLED OUT. VEHICLE RESTARTED AND I AGAIN LIMPED OFF HIGHWAY. EVENTUALLY GOT TO EXIT AND OFF INTO A PARKING LOT. NUMEROUS STALLS AND NEVER ANY REAL POWER. WAITED FOR A TOW FROM THERE AND VEHICLE RESTARTED WITH NO ISSUES WHEN DRIVING IT ONTO THE TOW TRAILER. FUEL PRESSURES WERE NORMAL, AND CODES WERE P06A7, P0106 AND P0236 WERE PRESENT AND PERMANENT WHICH WAS ALSO A NEW DEVELOPMENT. PERMANENT CODES HAVE BEEN ELUSIVE. A PREVIOUS RECALL ON 2013-2014 ESCAPES FITS THIS ISSUE EXACTLY. AFTER NUMEROUS HOURS OF RESEARCH, I AM CONVINCED THIS IS THE SAME ISSUE INVOLVED IN THE PREVIOUS FORD TSB 13-12-12 AND THE PREVIOUS TSB 13-7-5. I WAS IN GREAT DANGER WHEN THIS VEHICLE STALLED ON THE HIGHWAY WITHOUT WARNING. RUSH HOUR TRAFFIC ON 70 PLUS MPH ROAD WITH ALMOST NO SHOULDER. BECAUSE OF THIS AND THE DISABLING OF THE AIRBAGS WHEN THIS FAILURE OCCURS ALONG WITH THE SEAT BELT ACTUATORS, I THINK IT'S REASONABLE TO ASSUME THIS IS A SAFETY ISSUE. I'M CONFIDENT THIS ISSUE CAN BE REPLICATED.

CODE P1450 WHICH IS EMISSION PROBLEMS. REGULATES THE FLOW OF STORED FUEL VAPORS FROM ESCAPING INTO THE ATMOSPHERE. FORD SHOULD HAVE A RECALL.

AS I WAS DRIVING ON THE FWY MI CAR STOPPED ACCELERATING I PULLED OVER AND MY CAR TURNED OFF. I HAD A QUARTER TANK OF GAS LEFT ONCE I TRIED TO TURN IT ON IT WOULD NOT LET ME. I HAD TO CALL A TOW. I NOW HAD A CHECK ENGINE SIGN ON. I TOOK IT TO AUTOZONE AND THEY SAID I NEEDED A NEW PURGE CANISTER VALVE. BUT THAT DOESNT EXPLAIN WHY IT DID NOT WARN ME ON THE FWY THAT I NEEDED GAS .

CAR LOSES THROTTLE RESPONSE RANDOMLY. LUCKILY I'VE HAD SOMEWHERE TO GET OFF ROAD EVERYTIME ON HIGHWAY. WHEN SEARCHING CODE FOUND OUT THERE WAS A FIELD SERVICE ACTION TO REPLACE THROTTLE BODY. WE WERE NEVER NOTIFIED. THEY REFUSE TO REPLACE NOW.

CAR STARTED VIBRATING WITH REDUCED POWER. THE ERROR CODE WAS P2111: THROTTLE ACTUATOR CONTROL SYSTEM - STUCK OPEN

VEHICLE WAS IN MOTION AND IT STARTING SHUTTING OFF. CAME TO A POINT WHERE IT HAD TO BE SHUT OFF FOR 10 MINUTES TO TRAVEL ANOTHER 20 MILES BEFORE REOCCURRING.

WHILE TRAVELING VEHICLE BEGAN TO LOSE POWER AND BEGIN TO SHUT OFF. IT BECAME MORE FREQUENT WHERE IT WOULD NOT START. WE HAD TO LET IT SIT FOR 10 MINUTES TO RESTART BACK UP FOR ANOTHER 20 MILES OF TRAVEL.

VEHICLE WAS IN MOTION GOING SPEED LIMIT WHEN IT STARTED TO SHUT DOWN. IT BECAME MORE FREQUENT AND LASTED LONGER TO START AND TO STAY RUNNING. WHEN SHUT DOWN FOR 10 MINUTES IT WOULD TRAVEL ABOUT 20 MILES BEFORE HAVING ISSUES ONCE AGAIN. FOUND OUT WHEN THE FUEL HAS UNDER A HALF A TANK THE PROBLEM BECOMES MORE FREQUENT.

VEHICLE WAS IN MOTION GOING SPEED LIMIT WHEN IT STARTED TO SHUT DOWN. IT BECAME MORE FREQUENT AND LASTED LONGER TO START AND TO STAY RUNNING. WHEN SHUT DOWN FOR 10 MINUTES IT WOULD TRAVEL ABOUT 20 MILES BEFORE HAVING ISSUES ONCE AGAIN. FOUND OUT WHEN THE FUEL HAS UNDER A HALF A TANK THE PROBLEM BECOMES MORE FREQUENT.

VEHICLE WAS IN MOTION GOING SPEED LIMIT WHEN IT STARTED TO SHUT DOWN. IT BECAME MORE FREQUENT AND LASTED LONGER TO START AND TO STAY RUNNING. WHEN SHUT DOWN FOR 10 MINUTES IT WOULD TRAVEL ABOUT 20 MILES BEFORE HAVING ISSUES ONCE AGAIN. FOUND OUT WHEN THE FUEL HAS UNDER A HALF A TANK THE PROBLEM BECOMES MORE FREQUENT.

VEHICLE WAS IN MOTION GOING SPEED LIMIT WHEN IT STARTED TO SHUT DOWN. IT BECAME MORE FREQUENT AND LASTED LONGER TO START AND TO STAY RUNNING. WHEN SHUT DOWN FOR 10 MINUTES IT WOULD TRAVEL ABOUT 20 MILES BEFORE HAVING ISSUES ONCE AGAIN. FOUND OUT WHEN THE FUEL HAS UNDER A HALF A TANK THE PROBLEM BECOMES MORE FREQUENT.

VEHICLE WAS IN MOTION GOING SPEED LIMIT WHEN IT STARTED TO SHUT DOWN. IT BECAME MORE FREQUENT AND LASTED LONGER TO START AND TO STAY RUNNING. WHEN SHUT DOWN FOR 10 MINUTES IT WOULD TRAVEL ABOUT 20 MILES BEFORE HAVING ISSUES ONCE AGAIN. FOUND OUT WHEN THE FUEL HAS UNDER A HALF A TANK THE PROBLEM BECOMES MORE FREQUENT.

VEHICLE WAS IN MOTION GOING SPEED LIMIT WHEN IT STARTED TO SHUT DOWN. IT BECAME MORE FREQUENT AND LASTED LONGER TO START AND TO STAY RUNNING. WHEN SHUT DOWN FOR 10 MINUTES IT WOULD TRAVEL ABOUT 20 MILES BEFORE HAVING ISSUES ONCE AGAIN. FOUND OUT WHEN THE FUEL HAS UNDER A HALF A TANK THE PROBLEM BECOMES MORE FREQUENT.

VEHICLE WAS IN MOTION GOING SPEED LIMIT WHEN IT STARTED TO SHUT DOWN. IT BECAME MORE FREQUENT AND LASTED LONGER TO START AND TO STAY RUNNING. WHEN SHUT DOWN FOR 10 MINUTES IT WOULD TRAVEL ABOUT 20 MILES BEFORE HAVING ISSUES ONCE AGAIN. FOUND OUT WHEN THE FUEL HAS UNDER A HALF A TANK THE PROBLEM BECOMES MORE FREQUENT.

VEHICLE WAS IN MOTION GOING SPEED LIMIT WHEN IT STARTED TO SHUT DOWN. IT BECAME MORE FREQUENT AND LASTED LONGER TO START AND TO STAY RUNNING. WHEN SHUT DOWN FOR 10 MINUTES IT WOULD TRAVEL ABOUT 20 MILES BEFORE HAVING ISSUES ONCE AGAIN. FOUND OUT WHEN THE FUEL HAS UNDER A HALF A TANK THE PROBLEM BECOMES MORE FREQUENT.

VEHICLE WAS IN MOTION GOING SPEED LIMIT WHEN IT STARTED TO SHUT DOWN. IT BECAME MORE FREQUENT AND LASTED LONGER TO START AND TO STAY RUNNING. WHEN SHUT DOWN FOR 10 MINUTES IT WOULD TRAVEL ABOUT 20 MILES BEFORE HAVING ISSUES ONCE AGAIN. FOUND OUT WHEN THE FUEL HAS UNDER A HALF A TANK THE PROBLEM BECOMES MORE FREQUENT. THIS TIME THE FUEL TANK WAS FULL BUT IT STARTED ACTING UP.

VEHICLE WAS IN MOTION GOING SPEED LIMIT WHEN IT STARTED TO SHUT DOWN. IT BECAME MORE FREQUENT AND LASTED LONGER TO START AND TO STAY RUNNING. WHEN SHUT DOWN FOR 10 MINUTES IT WOULD TRAVEL ABOUT 20 MILES BEFORE HAVING ISSUES ONCE AGAIN. FOUND OUT WHEN THE FUEL HAS UNDER A HALF A TANK THE PROBLEM BECOMES MORE FREQUENT.

WHILE TAKING OFF FROM 0 - 20 MPH VEHICLES HESITATES WHILE ACCELERATING CAUSING VEHICLE TO ALMOST STALL IN TRAFFIC. HAVE TO PUMP GAS PEDAL REPEATEDLY TO TRY TO GET CAR MOVING. REPORTED TO DEALERSHIP FOUR TIMES WITH NO REPAIR GIVEN FOR THE PROBLEM OF CAR STALLING WHILE TAKING OFF. HAS DONE THIS SINCE PURCHASED IN 2016 AND CONTINUES UNTIL TODAY. BROUGHT IN FOUR TIMES TO DEALERSHIP CAZENAVE'S MOTOR CO.BUT VEHICLE CONTINUES TO STALL. CONCERNED OF BEING HIT WHILE STALLED IN FAST MOVING TRAFFIC OR WHILE APPROACHING ENTRANCES AND EXITS OR WHILE MAKING TURNS. CONCERNED OF BAD ACCIDENT DUE TO VEHICLE STALLING IN TRAFFIC.

CAR STALLS WHILE DRIVING. IS VERY DIFFICULT TO START BACK UP.

AFTER FUELING CAR STALLS AND DIES.

HESITATES ON QUICK EXECRATION. MOVING AT ANY SPEED AS FAR AS I CAN TELL. HAPPENS WERE EVER I "HIT THE GAS". BAD WHEN I NEED TO GET OUT OF THE WAY!

ON THURSDAY, MAY 19, 2016 MY WIFE WAS RETURNING HOME WITH A CARLOAD OF KIDS. THEY WERE ON THE HIGHWAY AND THE CRUISE CONTROL WAS SET WHEN THE CAR SLOWWED RAPIDLY AND THE ENGINE DIED. SHE WAS ABLE TO RESTART THE CAR AND GET TO THE CURB AFTER TRAFFIC PASSED. SEVERAL MINUTES LATER THE CASE WAS RESTARTED AND WAS DRIVEN TO THE DEALER A MILE AWAY BY MISSED BADLY ASK THE WAY THERE. THE DEALER MECHANIC WAS ALSO STRANDED IN THE VEHICLE THE NEXT DAY AND IT WAS DECIDED THAT THE THROTTLE BODY HAD GONE BAD. FORTUNATELY IT WAS LATE WHEN OUR INCIDENT OCCURRED; DURING RUSH HOUR THIS COULD HAVE CAUSED A SERIOUS ACCIDENT.

TRANSMISSION SLIPS WHEN BACKING UP. PROBLEM IS PERIODIC BUT IS BAD ENOUGH THAT THE CAR WOULD BE SLOW TO REACT TO EMERGENCIES SUCH AS BACKING FROM INTERSECTION WHEN IT OCCURS. PROBLEM OCCURS WHEN CAR IS WARMED UP AND MOST OFTEN WHEN GOING FROM FORWARD TO STOP TO BACKING. WHILE PARKING THIS PROBLEM CAUSES THE CAR TO STALL AND THEN LURCH BACKWARDS.