2006 Ford Escape Brakes Problems

WHILE DRIVING AT LOWER SPEEDS AND CITY SPEEDS, ABS LIGHT COME ON WITH SERVICE BRAKE SYSTEM MESSAGE APPEARS WHILE DRIVING AND TURNING. BRAKING IS TOUGH AND BARELY STOPS EVEN WITH HARD FOOT PRESSURE ON PEDAL. THIS IS AN ONGOING PROBLEM THAT INTERMITTENTLY HAPPENS. ONCE YOU LET THE CAR SIT FOR AWHILE (SINCE YOU ARE SCARED OF DRIVING IT), THE BRAKING SYSTEM RESETS AND PROBLEM IS NOT SEEN FOR MONTHS...UNTIL IT OCCURS AGAIN. INQUIRIES TO FORD ABOUT PROBLEM ESTIMATE THE COST OF REPLACING CYLINDER, HCU, AND BLEEDING BRAKES FAR EXCEEDS THE VALUE OF VEHICLE. ANNOYING AS THIS BRAKE PROBLEM WAS IDENTIFIED AS A WEAKNESS OF THIS CAR'S BRAKING SYSTEM AS FAR BACK AS 2005! WHY DOES FORD NOT RECALL AND FIX A KNOWN PROBLEM IN A TIMELY MANNER? MAY HAVE TO SCRAP AN OTHERWISE EXCELLENT WORKING VEHICLE BECAUSE IT IS UNSAFE TO DRIVE AND UNSAFE TO FELLOW DRIVERS SINCE IT MAY NOT RELIABLY STOP.

PARKING / EMERGENCY BRAKE FAILED. CABLE ROUTED FROM HAND LEVER TO REAR BRAKES GOES THROUGH A BRACKET MOUNTED TO THE UNDERSIDE OF THE BODY. BRACKET SEPARATED FROM UNDER-BODY OF VEHICLE RENDERING HAND BRAKE INOPERABLE. VEHICLE WAS STATIONARY ON A SLOPE WITH REGULAR BRAKES APPLIED. PARKING BRAKE WAS BEING APPLIED TO KEEP THE WEIGHT OF VEHICLE ON AN INCLINE OFF OFF TRANSMISSION PARK LOCK.

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE BRAKE PEDAL WAS DEPRESSED BUT WAS FIRM. THE SERVICE BRAKE SYSTEM WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO RON DUPRATT FORD LOCATED AT 1320 NORTH FIRST ST, DIXON, CA 95620, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE BRAKE HYDRAULIC CONTROL UNIT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 95,000.

OCCASIONALLY WHEN APPLYING SMOOTH PRESSURE ON THE BRAKE PEDAL, IT BECOMES VERY FIRM AND LOOSES BRAKING POWER. IF THE PEDAL IS RELEASED AND REAPPLIED THEN THE BRAKES WORK AGAIN (FOR NOW). THIS SOMETIMES CAUSES THE "CHECK BRAKE SYSTEM" WARNING LIGHT TO APPEAR. THIS LIGHT MAY OR MAY NOT REMAIN ON AFTER TURNING THE CAR OFF FOR A WHILE. THIS ISSUE HAS BEEN REPORTED BY MANY OTHERS, AND SHOULD BE HANDLED BY FORD AS A RECALL AS A PROPERLY WORKING BRAKING SYSTEM IS VITAL TO THE SAFETY OF EVERYONE ON THE ROAD. DATE INDICATED IS OF THE MOST RECENT OCCURRENCE (ON THE WAY TO THE DEALERSHIP).

SUDDEN REDUCED BRAKING CAPACITY WHILE DRIVING. CHECK ABS LIGHT COMES ON. ONE HAS TO PUSH COMPLETELY DOWN ON BRAKES TO GET VEHICLE TO STOP. WAIT FOR 5-10 MINUTES, SYSTEM RESETS AND YOU CAN CONTINUE TO DRIVE UNTIL AT SOME DAY AND TIME THE SAME CONDITIONS REOCCUR. RESEARCH ON ISSUE INDICATES THE HCU MAYBE FAILING BUT PRICE TO REPLACE EXCEEDS THE WORTH OF THE VEHICLE. USE OF VEHICLE IS NOW LIMITED DUE TO UNPREDICTABLE ABILITY TO STOP CAR WHILE IN MOTION.

PURCHASED A 2006 FORD ESCAPE HYBRID IN OCT. OF 2018. TODAY (NOV 2019) THE BRAKE SYSTEM DECIDED TO GO OUT (A KNOWN ISSUE WITH FEH) WHILE WE WERE DRIVING ON A CURVY ROAD WHILE MY TWO KIDS WERE IN THE CAR. WE TRIED SLOWING DOWN BEFORE ENTERING THE CURVE AND THE BRAKES WOULD NOT WORK. LUCKILY WE ARE FINE BUT THE OUTCOME COULD HAVE BEEN DRASTICALLY DIFFERENT. I'VE ONLY PUT 10K MILES ON THE CAR AND NOW FORD OF OCALA IS SAYING EVEN THOUGH IT'S A KNOW ISSUE THEY WILL NOT DO ANYTHING ABOUT IT. WE SPOKE WITH DONNA WHO WAS UNDERSTANDING BUT STILL GAVE US NO SOLUTION. SHE FORWARDED THE ISSUE TO THE SALES MANAGER AND WE ARE WAITING ON HIS CALL.THEY BASICALLY STOLE 7 GRAND FROM OUR FAMILY. WE'LL BE PURSUING THIS LEGALLY UNTIL THE ISSUE GETS RESOLVED.

WAS HEADING WEST DRIVING THE VEHICLE ON ALAMEDA CROSSING WAGSWORTH BOULEVARD WHICH THE STATE OF COLORADO SAYS THAT THOSE ARE BOTH HIGHWAYS THEY'RE MORE LIKE CITY STREETS BUT HIGHWAYS WHAT IS DOING A REPAVING PROJECT I PERSONALLY DID NOT SEE ANY NOTIFICATION OF WORK GOING ON AS THEY HAD STRIP THE ASPHALT FROM WADSWORTH AND WAS REPAVING LEFT A 6IN HIGH DROP INTO THE PAVEMENT AND BACK UP TO THE OLD PAVEMENT. WHAT IS A MASSIVE JOLT THAT SURE BOTH FRONT BRAKE LINES OFF HAS NO BRAKES TO STOP HOW DO YOU USE HANDBRAKE. GOT AHOLD OF CDOT AND WAS TOLD MARTIN MARIETTA WAS THE COMPANY IN CHARGE OF THE REPAVING PROJECT WAS TOLD THEY WOULD NOT DO ANYTHING ABOUT IT AS THEY SAID THAT THERE WAS WARNING SIGNS POSTED.

I AM HAVING TROUBLE WITH MY BRAKES EVEN AFTER ALL REPAIRS AND SPENDING ABOUT $1000 DOLLARS MY CAR BRAKE DASHBOARD LIGHT IS STILL ON AND VERY LESS BRAKES ARE APPLIED .I HAVE TO PRESS BRAKES WITH LOTS OF THRUST BUT EVEN AFTER THAT VEHICLE MOVES LITTLE AHEAD

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING 45 MPH AND DEPRESSING THE BRAKE PEDAL, THE SERVICE BRAKE SYSTEM WARNING INDICATOR ILLUMINATED. THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD AND THE VEHICLE FAILED TO STOP. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE CONTACT POWERED OFF THE ENGINE. THE VEHICLE WAS RESTARTED, BUT THE FAILURE RECURRED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS LATER TAKEN TO HERTRICH FORD LINCOLN (1427 BAY RD, MILFORD, DE 19963, (302) 725-0031) WHERE IT WAS DIAGNOSED THAT THE ABS HYDRAULIC CONTROL UNIT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED DUE TO THE REPAIR FEES. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT UNDER WARRANTY. THE APPROXIMATE FAILURE MILEAGE WAS 107,405.

THIS THE SECOND FORD FOCUS HYBRID 2006 WE HAVE HAD A BRAKE PEDAL ISSUE WITH. ALREADY HAD TO REPLACE BRAKE MASTER AND HCU WITH THE 1ST ONE 2YRS AGO AND HAVE NOT HAD THE ISSUE AGAIN. HERE WE GO AGAIN WITH THE SAME MODEL DIFFERENT CAR AND WE RE VISIT THE SAME PROBLEM WITH HARD TO STOP OR WONT STOP DURING NORMAL DRIVING AND ONLY PERIODIC. WAY TOO MUCH MONEY 7000.00 WITH 83K MILES.

AS I WAS APPROACHING AN INTERSECTION AND RED LIGHT, MY BRAKES SUDDENLY STOPPED WORKING. I LITERALLY HAD TO STAND ON THE BRAKE AND IT FINALLY STOPPED MOVING. I CONTINUED TO DRIVE HOME AT LESS THAN 10 MPH AND HAD TO LET OFF THE GAS IN ORDER TO SLOW THE VEHICLE DOWN TO ATTEMPT TO USE THE BRAKES AND CAR WOULD SHAKE WHEN BRAKE WAS APPLIED. TOOK TO MECHANIC WHO CHECKED THE CODE AND IT WAS THE TRAVEL SENSOR.

ABS BREAK LIGHT CAME ON AND THE CAR FAILED TO STOP. WAS DRIVING ON THE ROAD IN A SMALL TOWN AND WAS STOPPING TO TURN ON TO A ROAD. THE PROBLEM HAD ALSO HAPPEN WHEN SOMEONE HAS STOPPED SUDDENLY IN FRONT OF ME AND I NEEDED TO BREAK SUDDENLY. HAD BREAK FLUID CHANGED AT FORD DEALERSHIP AND DID NOT FIX THE PROBLEM. WHEN YOU NEED TO STOP SUDDENLY AND HIT THE BREAKS HARD, THE PEDAL HARD IT STIFFENS UP AND WILL NOT STOP THE CAR. IF YOU TURN OFF THE CAR AND WAIT A FEW MINUTES AND TURN IT BACK ON, IT SEEMS TO RESET IT UNTIL YOU HIT THE BREAKS HARD AGAIN.

TL* THE CONTACT OWNED A 2006 FORD ESCAPE. WHILE DRIVING 62 MPH OVER A POTHOLE, THE BRAKES SEIZED AND THE VEHICLE SKIDDED SIDEWAYS. THE VEHICLE STRUCK THE BARRIERS ON THE SIDE OF THE HIGHWAY AND SPUN AROUND TWICE BEFORE STOPPING, FACING THE OPPOSITE DIRECTION. THE DRIVER'S SIDE AND WINDOW WERE SMASHED IN AND THE ALIGNMENT WAS DAMAGED. THE VEHICLE WAS TOTALED. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO A FRIEND'S BUSINESS. THE MANUFACTURER WAS CONTACTED AND PROVIDED A CASE NUMBER. THE DEALER HAD NOT BEEN CONTACTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE FAILURE MILEAGE WAS 36,000.

I WAS DRIVING AT A NORMAL SPEED, APPROXIMATELY 35 MPH, ON A CITY STREET. AS TRAFFIC SLOWED I BEGAN TO DEPRESS THE BRAKE PEDAL AND SUDDENLY I GOT SEVERAL ALERTS ON MY INSTRUMENT CLUSTER (BRAKE, ABS, AND REGEN DISCONNECT). AT THE SAME TIME I LOST ALL OR MOST OF MY BRAKING POWER. I WAS FORCED TO USE THE PARK BRAKE TO STOP THE VEHICLE, AND BARELY AVOIDED A COLLISION WITH ANOTHER VEHICLE.THIS WAS A VERY FRIGHTENING EXPERIENCE. AFTER THE VEHICLE SAT FOR A SHORT TIME, WITH THE ENGINE OFF, THE SYSTEM APPARENTLY RESET ITSELF AND WHEN I RE-STARTED THE ENGINE ALL FUNCTIONS WERE OPERATIONAL ONCE AGAIN, AND ALL THE ALERTS WERE GONE. HOWEVER, THIS PERIOD WAS BRIEF. THINKING THIS MIGHT BE A SYSTEM GLITCH, I CAUTIOUSLY DROVE THE VEHICLE HOME. THE NEXT DAY THIS FAILURE RETURNED AFTER ABOUT 20 MILES OF DRIVING. AT THIS TIME I REALIZED THAT THERE IS A SERIOUS FLAW IN THE HYBRID BRAKING SYSTEM OF THIS MODEL YEAR FORD ESCAPE, AND POSSIBLY OTHER MODEL YEARS. I CONTACTED A LOCAL FORD DEALERSHIP AND I WAS SHOCKED WHEN THEY INFORMED ME THERE ARE NO RECALLS ON THIS VEHICLE FOR THIS PARTICULAR FAILURE. AS A MECHANIC I FIND THIS RIDICULOUS. AFTER A BRIEF SEARCH ONLINE I FOUND MANY HYBRID FORD ESCAPE OWNER'S THAT HAD THE SAME PROBLEM AS I DID. AT THIS POINT I DEEMED MY VEHICLE UNSAFE TO DRIVE AND DECIDED THE BEST THING TO DO WAS TO REPORT THIS FAILURE TO THE NHTSA WITH THE HOPES THAT THE FORD MOTOR COMPANY WILL DO SOMETHING ABOUT THIS FAILURE BEFORE SOMEBODY GETS SERIOUSLY INJURED OR KILLED. MY OPINION IS THE PROBLEM IS IN THE HYDRAULIC CONTROL UNIT. (HCU). THIS IS A COMPLEX ELECTRONIC BRAKE CONTROL UNIT THAT IS SPECIFIC TO THE FORD ESCAPE HYBRID. FOR THE RECORD MY VEHICLE HAD ABOUT 146,000 MILES ON IT WHEN THIS HAPPENED.

INTERMITTENT ABS AND BRAKE WARNING LIGHT WITH ALMOST COMPLETE LOSS OF BRAKING.

VEHICLE WAS FAILING TO STOP WHEN BRAKES APPLIED. CODES CAME BACK FROM DEALER THAT HCU AND MASTER CYLINDER NEEDS TO BE REPLACED $7100 WHICH IS MORE THAN THE VEHICLE IS WORTH. OTHER YEAR MODES HAVE BEEN RECALLED AND SHOULD BE INCLUDED IN THE RECALL

WHEN APPLYING BRAKES PEDAL HAS TO BE PRESSED ALL THE WAY TO THE FLOOR AND THE CAR CONTINUES TO MOVE FORWARD ALMOST CAUSING AN ACCIDENT. AT THIS POINT THE ABS LIGHT COMES ON. *TT UPDATED 9/12/18*JB

2006 FORD ESCAPE. CONSUMER WRITES REQUESTING REIMBURSEMENT FOR DRIVER SIDE TONE RING REPAIRS. *LD THE CONSUMER STATED ON THE VEHICLE THE TONE RINGS WERE EXPOSED TO THE ELEMENTS. THIS MAKES THEM PRONE TO BREAKAGE. UPDATED 09/27/2017*JS

BRAKE PEDDLE WENT SOFT AND FAILED TO STOP VEHICLE IN REASONABLE DISTANCE FOR SPEED, LESS THAN 10 MILES/HOUR. THIS WAS ON A CITY STREET STARTING LEFT TURN AT ABOUT 10 MPH.

I WAS APPROACHING A T-INTERSECTION AND ATTEMPTED TO MAKE A STOP AT THE STOP SIGN, BUT THE BRAKE PEDAL RESISTED MY FOOT PRESSURE AND I COULD NOT GET THE VEHICLE TO SLOW DOWN. I MANAGED TO MANEUVER THROUGH THE INTERSECTION WITHOUT FURTHER INCIDENT AND SPOTTED A SAFE PLACE TO PULL OVER TO GATHER MY THOUGHTS. THE BRAKE PEDAL AGAIN FAILED TO WORK WHEN I ATTEMPTED TO PULL OVER, BUT I USED THE EMERGENCY BRAKE TO STOP THE VEHICLE.. ONLY, THIS TIME THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOOD, WITH NO BRAKING EFFECT TO THE VEHICLE. THIS TIME, UNLIKE THE FIRST, 2 BRAKE WARNING INDICATORS (ABS & BRAKES!) ILLUMINATED ON THE DRIVER'S CONSOLE. I TURNED OFF THE VEHICLE AND RESTARTED IT, AND THE INDICATORS HAD DISAPPEARED AND THE BRAKE PEDAL HAD NORMAL RESISTANCE TO MY FOOT PRESSURE AND THE BRAKES WORKED NORMALLY. I CALLED A LOCAL FORD DEALERSHIP AND THEY DESCRIBED THE PROBLEM AS A 'GLITCH', AND SAID IT WAS MOST LIKELY A SENSOR OR SOME OTHER COMPUTER MALFUNCTION, BUT THAT NO WORK DONE TO CORRECT THE PROBLEM WOULD BE COVERED SINCE THE VEHICLE IS OUT OF WARRANTY. WANTING MORE INFORMATION, I LOCATED A VIDEO ON YOUTUBE.COM THAT SHOWS ANOTHER VEHICLE WITH THE SAME PROBLEM. THE VIDEO IS SEARCHABLE AND IS FOUND UNDER THE TITLE OF 'FORD ESCAPE HYBRID BRAKE PROBLEM'. I SEARCHED FOR ANY RECALLS FOR THIS SAME VEHICLE'S VIN, BUT FOUND NONE LISTED. WHAT CAN BE DONE ON BEHALF OF THE CONSUMER, ESPECIALLY IF THOSE VIDEO COST ESTIMATIONS ARE CORRECT?

I HAVE A 2006 FORD ESCAPE WITH A DEEP CONCERN AND ISSUES WITH THE ABS (BRAKING) SYSTEM. THE ABS INSTRUMENTATION LIGHT PERIODICALLY COMES ON INDICATING AN ISSUE WITH THE BRAKING OF THE VEHICLE. THERE IS A NOTICEABLE DIFFERENCE IN THE PERFORMANCE WHILE BRAKING OF THE VEHICLE WHEN THE ABS LIGHT IS "ON". THE EXPERIENCE IS A SLIDING AND/OR JERKING WHEN THE VEHICLE IS IN MOTION. SEARCHING THE INTERNET THERE ARE MANY COMPLAINTS SURROUNDING THIS BRAKING ISSUE FOR THE FORD ESCAPE. THIS IS APPARENT IN SEVERAL MODEL YEARS FOR THIS VEHICLE. THIS IS A VERY DANGEROUS ISSUE CONCERNING BRAKE FAILURE. FORD MOTOR COMPANY AND MANY DEALERSHIPS ARE AWARE OF THIS DANGEROUS ISSUE THAT HAS NOT BEEN ADDRESSED.

REHAN BRAKE FAILURE NO WARNING WONT STOP OR GO AWAY TRUCK IS NOT ABLE TO MOVE NO BRAKES AT ALL MANY COMPLAINTS ABOUT OTHER 2006 FAILURE AND FORD SAYS THEY KNOW ABOUT IT BUT WONT DO ANYTHING FOR CONSUMERS BOUGHT A 2008 AND SAME THING IS NOW HAPPENING WITH 08 HYBRID

I BOUGHT A 10 YEAR OLD 2006 ESCAPE HYBRID WITH 73,000 MILES. AFTER 4,000 MILE THE ABS LIGHT WOULD GO ON AND THE BRAKES WOULD GO INTO MANUAL MODE AND THE WARNING LIGHTS READ CHECK BRAKE SYSTEM AND REGEN DISENAGED. AFTER RESTARTING THE CAR THE PROBLEM WOULD GO AWAY. THIS WOULD HAPPEN WHEN THE VEHICLE WAS MOVING AT VARIOUS SPEEDS. THE CAR STILL DID STOP WITH MORE BRAKE PRESSURE. WE BROUGHT IT TO THE DEALER AND THEY RESET THE ERROR CODES AND GAVE US BACK THE CAR. THEY STATED THIS WAS PER THE FORD CORPORATE STANDARDS AND THEY COULD NOT FIND ANYTHING WRONG WITH THE BRAKES DESPITE THE ERROR CODES. ABOUT 6 WEEKS LATER THE PROBLEM HAPPENED AGAIN AND KEPT HAPPENING. HOWEVER, THIS TIME THE BRAKE PEDAL IS SOFT AND WE ARE NOT CONFIDENT IT WILL STOP EVERY TIME AS IT DID BEFORE. WE BROUGHT IT BACK TO THE DEALER. NOW FORD HAS DIAGNOSED AN ISSUE WITH THE MASTER CYLINDER, HCU AND ABS COMPUTER ALL NEED TO BE REPLACED FOR $8100 (I ONLY PAID $7500 FOR THE CAR). SINCE FORD ARE THE ONLY ONES THAT CAN CALIBRATE THE ABS COMPUTER WE CANNOT GET THE REPAIR CHEAPER ELSEWHERE. FORD WILL DO NOTHING BECAUSE IT IS OUT OF THE WARRANTY PERIOD.

AFTER STARTING THE VEHICLE,(VEHICLE IS STATIONARY) THE ABS LIGHTS, AND BRAKE LIGHTS TURN ON. THE BRAKES GO INTO A SAFETY MODE, AND DON'T WORK UNLESS YOU PUSH THE PEDAL ALL THE WAY DOWN TO THE FLOOR. I CAN ALMOST ROLL DOWN MY DRIVEWAY WITH THE BRAKE PEDAL PUSHED DOWN ALL OF THE WAY. MY DRIVEWAY HAS A SLIGHT ANGLE TO IS. NOT MUCH OF AN ANGLE THOUGH. THE VEHICLE IS NOT SAFE TO DRIVE ON THE HIGHWAY IF YOU DON'T KNOW IF THE BRAKES ARE GOING TO GO OUT OR NOT.

BRAKES FAILED AT 10 MPH. ALL BRAKE LIGHTS SYSTEM ON DASH TURNED ON. BRAKE WAS HARD AND UNABLE TO STOP VEHICLE WHEN APPROACHING STOP SIGN. BRAKES THEN RELEASED AND GOT SOFT AND WOULD NOT STOP VEHICLE. HYDRAULIC CYLINDER UNIT FAILED & MASTER CYLINDER NEEDS TO BE REPLACED. WAS APPROACHING A MAJOR INTERSECTION IF BRAKES FAILED A FEW SECONDS LATER MAY HAVE BEEN A FATAL ACCIDENT.

ABS BRAKE SYSTEM

WHILE DRIVING (NOT BRAKING) THE CAR ON AN INTERSTATE HIGHWAY FOR ABOUT ONE HOUR, THE ABS AND BRAKE LIGHTS ILLUMINATED ON DASH ALONG WITH THE MESSAGE "SERVICE BRAKE SYSTEM" AND A PING SOUND. WHEN BRAKES WERE NEXT APPLIED THEY HAD BECOME VERY SOFT AND NOT AS RESPONSIVE. I PULLED INTO A SAFE AREA AND TURNED THE IGNITION OFF. AFTER WAITING A FEW MINUTES, THE CAR WAS RESTARTED AND ALL OF THE ABOVE MENTIONED LIGHTS AND MESSAGES WERE GONE AND THE BRAKES WERE WORKING CORRECTLY. CONTINUED TO DRIVE AGAIN AND THE MESSAGE DIDN'T REOCCUR FOR SEVERAL HOURS. THE PROBLEM HAS HAPPENED SEVERAL MORE TIMES ON BOTH HIGHWAYS AND RURAL ROADS AND ALWAYS FIXED BY TURNING THE CAR OFF AND LETTING IT SIT FOR A COUPLE OF MINUTES. THE PROBLEMS DON'T INITIATE WHEN WE ARE ACTUALLY BRAKING. TOOK THE CAR TO OUR FORD DEALERS SERVICE DEPARTMENT WHERE THEY RAN A DIAGNOSTICS TEST. THE REPORT THEY GAVE US SAID " VERIFIED CUSTOMERS CONCERN. RETRIEVE CODA 1524, 1526. BRAKE PEDAL TRAVEL SENSOR RELATED. ALSO RETRIEVE CODES FOR TRACTION BATTERY COOLING FANS." THE SERVICE DEPT RECOMMENDED REPLACING THE BRAKE MASTER CYLINDER (AT A COST OF $2078.95) AND THE HYBRID BATTERY COOLING FANS (AT A COST OF $716.99).

ABS LIGHT COMES ON. BRAKES ARE LOOSE. HAPPENED NOW MORE THAN 10 TIMES. WE JUST PULL OVER THE SIDE AND TURN OFF THE CAR. START AGAIN AND BRAKES WORK FINE FOR A WHILE. THIS IS AN SCARY CAR. I USE TO DRIVE MY KIDS AROUND.

BRAKES SUDDENLY FAIL. WHEN YOU ARE DRIVING DOWN THE ROAD THE POWER ASSIST TO THE BRAKE FAILS UNEXPECTANTLY AND YOU MUST USE EXTREME FORCE TO BRING THE CAR TO A STOP. THIS IS INTERMITTENT AND THEY WILL WORK AGAIN AFTER THE CAR IS SHUT OFF. I HAVE FOUND MANY COMPLAINTS OF THIS ON LINE. IT IS ONLY A MATTER OF TIME BEFORE SOMEONE IS IN A VERY SERIOUS ACCIDENT. NOT ONLY DID I FIND MANY COMPLAINTS BUT THESE WERE ACROSS SEVERAL YEARS OF PRODUCTION.

BRAKE LIGHT INTERMITTENTLY COMES ON. ABS LIGHT ALSO COMES ON - LOSS OF BRAKING ABILITY AT HIGHWAY SPEEDS WHEN ABS COMES ON.

DRIVING ON CITY STREET WHEN "SERVICE BRAKE SYSTEM" MESSAGE WAS DISPLAYED AS WELL AS ABS AND BRAKE LIGHTS ON DASH. VEHICLE HAD NO BRAKES AND EMERGENCY BRAKE HAD TO BE USED TO STOP VEHICLE.

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED AND SEVERAL WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL. ALSO, WHEN THE BRAKES WERE APPLIED, THE BRAKE PEDAL WOULD BE VERY STIFF, AND THE VEHICLE WOULD SKID. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE FAN WAS CHANGED IN THE HYBRID SYSTEM; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 75,000.

BRAKES STOPPED WORKING, DASH LIT UP LIKE A CHRISTMAS TREE.

VEHICLE DASH BRAKE LIGHT CAME ON INTERMITTENTLY. TOOK VEHICLE TO DEALER FOR DIAGNOSTIC. DEALER ADVISED MASTER CYLINDER NEEDED TO BE REPLACED FOR $2500. IN ADITION, HYDRAULIC CONTROL UNIT MIGHT ALSO NEED TO BE REPLACED, FOR AN ADDITIONAL $4000, BUT THE DEALER COULD NOT TELL UNTIL THE MASTER CYLINDER WAS REPLACED. AT THIS TIME, THERE ARE NO BRAKES AND THE VEHICLE CAN ONLY BE STOPPED USING THE HAND BRAKE AND IS NOT SAFE TO DRIVE.

I WAS DRIVING ALONG THE HIGHWAY COMING UP TO AN INTERSECTION, PREPARING TO STOP AT A RED LIGHT IN THE LEFT TURN LANE, WHEN MY BREAKS COMPLETELY FAILED. THE BREAK PEDAL WAS STIFF, AND WOULD NOT BUDGE. WE HIT TWO CARS THAT WERE SITTING AT THE INTERSECTION, TOTALING MY FORD ESCAPE AS WELL AS ONE OF THE OTHER CARS. IN THE PAST, THE "SERVICE BREAKS" LIGHT WOULD GO ON OCCASIONALLY IN THE SUMMER DURING THE HOT MONTHS, GIVING THE CAR SLIGHTLY LESS BREAK PRESSURE. THIS WAS NEVER A SERIOUS PROBLEM, AND HAS ALWAYS CORRECTED ITSELF ANYTIME I TURNED THE CAR OFF FOR A WHILE. IN ADDITION, WHENEVER HAVING THE BREAKS CHECKED, THEY COULD NEVER DETECT A PROBLEM. IN ADDITION, MY CAR HAD ROUTINE INSPECTIONS DONE DURING AN OIL CHANGE A MONTH BEFORE THE ACCIDENT, AND A FULL SERVICE INSPECTION BEFORE THIS. THIS CAR IS UNSAFE FOR THE ROAD, AND THE ACCIDENT WAS OUT OF MY CONTROL. AFTER RESEARCH, I FOUND MANY 2004-2006 HYBRID FORD ESCAPE OWNERS TO HAVE THE EXACT SAME COMPLAINTS AND EXPERIENCES.

MY ABS AND BRAKE LIGHT CAME ON AND BRAKES BECAME MANUAL. WHEN I CHECKED ON THE CODES (C1478, C1313 & C1480) I FOUND THAT THERE ARE QUITE A FEW COMPLAINTS OF THIS EXACT PROBLEM, THAT THE REPAIR COST IS RIDICULOUS AT APPROXIMATELY $5000. AND THAT THIS IS A VERY COMMON PROBLEM WITH THIS 2006 FORD ESCAPE HYBRIDS. THIS IS A SAFETY HAZARD AND SHOULD BE A RECALL BY FORD!

NEARLY IMPOSSIBLE TO BRAKE, MAJOR SAFETY ISSUE WITH THE HYDROLIC REGENERATIVE BREAKING SYSTEM AND ABS. WHILE DRIVING THE VEHICLE ON CITY STREETS, SPEEDS BETWEEN 0-40MPH THE BRAKE PEDAL WILL BECOME VERY HARD AND IMPOSSIBLE TO PRESS WITH LOSS OF BRAKING. WHEN THIS HAPPENS I AM FORCED TO RAPIDLY RELEASE THE BRAKE PEDAL AND BRAKE AGAIN (PUMPING) THE BRAKES IN ORDER TO STOP. ON SEVERAL OCCASIONS THIS PUMPING OF THE BRAKES HAS CAUSE THE BREAK PEDAL TO GO FROM HARD/IMPOSSIBLE TO PUSH TO COMPLETELY SOFT HITTING THE FLOOR WITH NO BRAKING CAPABILITIES. ON THESE OCCASIONS I AM FORCED TO PULL OF THE ROAD QUICKLY, DOWNSHIFT TO LOW GEAR AND EVEN USE THE EMERGENCY BRAKE TO AVOID CAUSING AN ACCIDENT. ONLY ABOUT 60% OF THE TIME WHEN THIS EVENT OCCURRED DOES THE ABS LIGHT, BRAKE LIGHT AND SERVICE BRAKE SYSTEM WARNING INDICATORS ILLUMINATE OR DISPLAY. WHEN THIS OCCURRES I AM USUALLY FORCED TO TURN THE ENGIN OFF, REMOVE THE KEY, LET THE SYSTEM PURGE (MAKES NOISE) AFTER THE VEHICLE SITS FOR A COUPLE MINUTES AND THEN RESTART THE VEHICLE IN ORDER TO KEEP DRIVING AND FIX THE ISSUE. SOMETIMES IT FIXES TO ISSUE FOR THE REST OF THE DRIVING TIME WHILE OTHERS ONLY WORK TEMPORARILY AND THE ISSUE RETURNS ALMOST IMMEDIATELY. I FEEL THAT THIS BRAKING ISSUE IS A HUGE SAFETY CONCERN FOR MY FAMILY AND I AND OUR PIECE OF MIND IN THE SAFETY OF THIS VEHICLE IS NOT GOOD. AS AN ADDITIONAL NOTE THIS BRAKE ISSUE ONLY BECAME EVIDENT AFTER WE HAD ANOTHER RECALL ISSUE FIXED ON THIS VEHICLE FOR STALLING. BEFORE THAT FIX WE NEVER HAD ANY BRAKING ISSUES.

THE BRAKES ON OUR 2006 FORD ESCAPE HYBRID BEGAN GRINDING AROUND FEBRUARY 2016. WE HAD THE PADS AND ROTORS REPLACED AND IT BRAKED BETTER, BUT WITHIN A MILE AFTER LEAVING THE FORD SERVICE CENTER THE BRAKE LIGHT CAME ON AND SHORTLY AFTER - WHILE MOVING - THE BRAKE PEDAL WENT TO THE FLOOR AND THERE WERE NO BRAKES. WE HAD TO COAST TO A STOP AND PULL OVER. WHEN THE CAR IS STOPPED AND TURNED ON AND OFF, YOU CAN SOMETIMES GET THE BRAKES TO WORK FOR LESS THAN A MILE. ITS SO UNSAFE, WE HAD IT TOWED TO SERVICE CENTERS FOR ESTIMATES. TWO FORD DEALERS AND ONE OTHER SERVICE PLACE INVESTIGATED THE PROBLEM THOROUGHLY AND ALL CAME BACK SAYING THE HYDRAULIC CONTROL UNIT MUST BE REPLACED AT AN AVERAGE COST OF $4,500. OTHERWISE, WE LIKE THE CAR, BUT THIS ONE REPAIR IS GREATER THAN THE BLUE BOOK VALUE AND IS VERY DANGEROUS.

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. WHILE PULLING INTO A RESIDENTIAL DRIVEWAY AT 10 MPH, THE BRAKES FAILED TO STOP THE VEHICLE AND THE PEDAL TRAVELED TO THE FLOORBOARD WHEN DEPRESSED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE MASTER CYLINDER AND HYDRAULIC SYSTEM FAILED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 114,000. UPDATED 06/08/16*LJ THE CONSUMER STATED THE BRAKE PEDAL WAS STUCK IN PLACE FOR APPROXIMATELY5-6 SECS BEFORE THE PEDAL TRAVELED TO THE FLOORBOARD. *JS

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 5 MPH, WHEN THE BRAKE PEDAL WAS DEPRESSED, THE AUTOMATIC BRAKING SYSTEM ENGAGED INDEPENDENTLY. AS A RESULT, THE VEHICLE SHOOK VIOLENTLY. THE CONTACT DISCOVERED THAT THE FRONT TONE RINGS WERE CRACKED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 70,000.

CAR HAD BEEN PARKED AT AIRPORT PARKING LOT FOR A MONTH. WHEN RETRIEVING IT UPON RETURN BRAKES FAILED, ABS AND BRAKE SERVICE WARNING LIGHT CAME ON, AND PEDDLE WENT TO THE FLOOR. WE PARKED THE CAR IN THE LOT, RENTED A CAR TO GET HOME. NEXT MORNING WE ARRANGED AAA TO TOW VEHICLE. WHEN TOW OPERATOR CAME THE VEHICLE BRAKING SYSTEMS WAS PERFECTLY FINE. WE CHOSE TO PAY HIM AND DRIVE THE CAR HOME. TOOK VEHICLE TO DEALER AND EXPLAINED THE ISSUE. THEY NEVER ACKNOWLEDGED ANY UNDERSTANDING OF THIS PROBLEM. THEY REPLACED REAR BRAKE PADS AND ROTORS BECAUSE THERE WAS ALSO LOUD BRAKE NOISE. NOW ONE YEAR LATER, JULY 27 2015, [97000+ MILES] SLOWING FOR A RIGHT TURN ON A RURAL HIGHWAY AND THE BRAKE SYSTEM FAILED AGAIN. WITH NO WARNING THE PEDDLE WENT TO THE FLOOR. WITH A CONCERTED EFFORT I WAS ABLE TO SLOW THE VEHICLE AND MAKE THE TURN WITHOUT INCIDENT. THE ABS LIGHT AND SERVICE BRAKE WARNING LIGHTS WERE LIT. CONDITION PERSISTED AS WE CONTINUED A FEW MILES TO THE SHOPPING PLAZA. AFTER SHOPPING WE DECIDED TO RETURN DIRECTLY HOME, BUT WHEN CAR WAS STARTED THE FAULT HAD CLEARED AND THE BRAKES FUNCTIONED NORMALLY. WE HAVE JUST SPENT THE MORNING SEARCHING INTERNET AND FIND THIS IS AN ISSUE FORD KNOWS ABOUT AND IS DENYING TO ACKNOWLEDGE. AND APPARENTLY IT IS VERY EXPENSIVE TO RESOLVE WITH THE NEED TO REPLACE THE HCU. WE NOW UNDERSTAND WHAT THE PROBLEM IS BUT ARE AMONG THE MANY WHO FEEL THIS IS CERTAINLY A SERIOUS ENOUGH SAFETY ISSUE FORD SHOULD PARTICIPATE IN ITS RESOLVE FOR OWNERS WITH DEFECTIVE BRAKE SYSTEMS. OUR EXPERIENCE SO FAR IS, THAT THOUGH THERE IS SOME ABILITY TO BRAKE IT IS NOT ANYWHERE EQUAL TO THE 'NORMAL' BRAKING CAPACITY AND THAT IS DANGEROUS. AND THE INTERMITTENT AND RANDOM OCCURRENCE IS TROUBLING TO SAY THE LEAST. WE WILL CONTACT THE DEALER TODAY TO GET THE REACTION TO OUR CONCERN.

DRIVING APPROXIMATELY 35 MPH, SUDDENLY RECEIVED WARNING MESSAGE ABOUT THE BRAKES AND HEARD WARNING BEEPS. IMMEDIATELY I LOST ALL BRAKING ABILITY (BRAKE PEDAL FELT SOFT AND GIVE VERY LITTLE RESISTANCE) BUT STILL HAD ACCELERATION AND STEERING CONTROL OF THE VEHICLE. I NAVIGATED THE CAR TO A SIDE STREET AND WAS ABLE TO SLOW THE CAR DOWN TO AN EVENTUAL STOP ON THE SHOULDER USING THE EMERGENCY/PARKING BRAKE. I TURNED THE CAR OFF FOR APPROXIMATELY 5 MINUTES. TESTED THE PRESSURE ON THE BRAKE PEDAL AND IT SEEMED NORMAL. I THEN STARTED THE CAR UP AND MOVED A LITTLE BIT FORWARD AND DEPRESSED THE BRAKE PEDAL AND EVERYTHING WORKED FINE. NO WARNING MESSAGES OR SOUNDS. THE CAR OPERATED NORMALLY AS I DROVE IT BACK TO A SAFE SPOT. *TR

BASICALLY, THIS IS HAPPENING AT LEAST 1 X / DAY. I AM TAKING BACK TO THE DEALERSHIP TOMORROW, BUT FORD REALLY NEEDS TO RECALL THIS VEHICLE AND GET THIS FIXED. I WAS DRIVING ON A REGULAR ROAD AND MY ABS BRAKE LIGHT AND SERVICE ENGINE LIGHT CAME ON WITH THE WARNING BELL. MY HYDRAULIC BRAKES FAILED AGAIN! I PUT MY FLASHERS ON, PULLED TO THE SIDE OF THE ROAD, I DEPRESSED THE BRAKE ALL THE WAY THE FLOOR AND ROLLED TO A STOP WITH THROBBING EMERGENCY BRAKES STILL WORKING. THEN I TURN OFF MY VEHICLE AFTER PUTTING IT INTO PARK, TAKE OUT THE KEY, WAIT A FEW SECONDS, THEN START THE CAR AGAIN. IT WORKS AGAIN TEMPORARILY. NOW, I KNOW HOW TO DEAL WITH IT AND I PLAN FOR IT SINCE IT HAPPENS ALL THE TIME, BUT IF I AM EVER IN A SITUATION WHERE I CANNOT CONTROL MY ENVIRONMENT, I CANNOT GUARANTEE SOMEONE WILL NOT BE HARMED OR KILLED AS A RESULT OF THIS FAILURE IN MY VEHICLE. PLEASE! HELP US DO SOMETHING ABOUT THIS. THIS NEEDS TO BE FIXED!!!

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE THE VEHICLE WAS PARKED, THE DRIVER SIDE BRAKE LINE FRACTURED. THE CONTACT MENTIONED THAT THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE PASSENGER SIDE BRAKE LINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURE WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 101,154.MA 08/04/15 UPDATED 9/29/2015*JS

DRIVING DOWN THE ROAD I HAD A COMPLETE LOSS OF NORMAL AND EFFECTIVE BRAKING. THE ABS AND BRAKE SERVICE LIGHTS BOTH CAME ON IN THE DASH AND IN ORDER TO BRING THE VEHICLE TO A STOP IT, IT BECAME NECESSARY TO DEPRESS THE BRAKE PEDAL AS HARD AS POSSIBLE ALL THE WAY TO THE FLOOR. WHENEVER ATTEMPTING TO BRAKE THE VEHICLE WOULD LUNGE TO THE RIGHT, CLEARLY INDICATING THAT (AT LEAST) THE FRONT BRAKE ON THE PASSENGER SIDE WAS COMPLETELY USELESS/INEFFECTIVE. NEEDLESS TO SAY, THIS WAS A VERY TRAUMATIC EXPERIENCE AS IT TOOK ALL OF MY SKILL AS A MOTORIST TO AVOID A COLLISION WITH THE VEHICLE IN FRONT OF ME AND TO PROTECT MY WIFE AND TWO CHILDREN WHO WERE ALSO WITH ME. AFTER GETTING ONLINE AND READING COUNTLESS FORUMS AND ARTICLES, I DISCOVERED THAT IT IS A DISTURBINGLY COMMON PROBLEM WITH FORD ESCAPE HYBRIDS TO LOSE EFFECTIVE BRAKING BY WAY OF A FAULTY HYDRAULIC CONTROL UNIT: A PART TO WHICH I LATER FOUND OUT COSTS AN APPROXIMATE $4,200 TO ACQUIRE. AFTER BRINGING THE VEHICLE TO A LOCAL FORD DEALER, I DISCOVERED THAT THIS WAS, IN FACT, THE EXACT PROBLEM WITH MY ESCAPE. THIS VEHICLE, APART FROM THE FAULTY HCU, IS IN INCREDIBLY GOOD SHAPE AND HAS NO OTHER MECHANICAL ISSUES. IT IS AN ABSOLUTE ATROCITY THAT FORD HAS NOT ISSUED A RECALL FOR THIS PART. IT HAS BEEN MADE VERY CLEAR THAT THEY HAVE NO INTENTION OF RECALLING THIS DANGEROUS UNIT UNTIL, INEVITABLY, FATALITIES OCCUR.

I WAS DRIVING MY DAUGHTER TO SCHOOL AND MY BRAKE LIGHT AND WARNING SOUND CAME ON WHEN I TRIED TO BRAKE FOR A RED LIGHT. I HAD TO PUSH REALLY HARD TO GET THE CAR TO STOP AND WE WERE ALMOST HIT BY ONCOMING TRAFFIC. *TR

TL*THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN ABNORMAL NOISE COMING FROM THE FRONT END OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKES AND THE BRAKE LINES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 128,000. UPDATED 5/18/15*CN

WE WERE DRIVING THE CAR ON THE FREEWAY AND SUDDENLY THE ABS LIGHT COMES ON AND THE BRAKES DID NOT WORK. THEY WERE VERY HARD TO DEPRESS AND SLOWED THE CAR VERY SLOWLY. HAD THIS HAPPENED WHEN WE NEEDED TO STOP, THERE WOULD HAVE BEEN AN ACCIDENT, WITHOUT A DOUBT. THIS HAPPENED ABOUT 3 WEEKS AGO AND MY MECHANIC RESET THE COMPUTER AND ALL WAS GOOD FOR ABOUT 2 WEEKS. THEN THE EXACT SAME THING HAPPENED AGAIN. MY MECHANIC, WHO I TRUST IMPECCABLY WAS BAFFLED BY THE WHOLE THING AND ASKED THAT WE SEND THE CAR TO A DEALERSHIP. I'VE NEVER SEEN THAT BEFORE. THE DEALER (FIRST DEALER) IS TELLING US WE NEED TO REPLACE THE MASTER CYLINDER, THEN MAYBE THE HYDRAULIC CONTROL UNIT, WHICH THANKFULLY, IS STILL UNDER WARRANTY IN CA BECAUSE IT'S A HYBRID PART. HOWEVER, IF IT IS THE HCU, WE STILL HAVE TO PAY FOR THE MASTER CYLINDER, EVEN THOUGH I SUSPECT IT'S THE HCU FROM WHAT I'VE READ ONLINE. I THEN CALLED THE DEALER WHO INSPECTED THE CAR WHEN WE INITIALLY BOUGHT IT (SECOND DEALER FROM HERE ON OUT). THE FIRST DEALER IS QUOTING US $2800 TO FIX THE MASTER, WHILE THE OTHER IS QUOTING AROUND $2000. THE SECOND ONE IS ALSO SAYING HE MIGHT BE ABLE TO DIAGNOSE THE HCU AND JUST CHANGE IT OUT WHERE DEALER 1 IS SAYING FORD SAYS IN ORDER TO CHANGE OUT THE HCU, THE MASTER HAS TO BE CHANGED FIRST. THE SECOND DEALER IS SAYING THIS SIMPLY ISN'T TRUE. WE JUST BOUGHT THE CAR FROM A PRIVATE SELLER AND FRANKLY, I'M SCARED TO DRIVE IT. I'M READING A LOT OF PROBLEMS WITH THIS PART OF THE CAR AND IT LOOKS TO ME LIKE FORD IS HAVING SOME SERIOUS, LIFE THREATENING ISSUES WITH THIS COMPONENT...AS WELL AS GIVING PEOPLE MASSIVE BILLS TO FIX THEIR CAR. THE ONLY THING THAT SHOULD COST $4000 ON A CAR SHOULD BE THE ENGINE. NOT THE BRAKE SYSTEM. THIS IS INSANITY. *TR

2006 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO BRAKE FAILURE. *SMD CONSUMER SENT ADDITIONAL CORRESPONDENCE. *SMD THE CONSUMER STATED THE SERVICE BRAKE SYSTEM WAS A SPORADIC ISSUE FOR A VERY LONG TIME. WHEN THE ERROR MESSAGE DISPLAYED, THERE WAS NO PRESSURE ON THE BRAKE PEDAL, THE POWER BRAKES FAILED, AND IN ORDER TO GET THE BRAKES TO WORK AT ALL, HE HAD TO PRESS THE PEDAL TO THE FLOOR. THE CONSUMER EXPERERIENCED A LOSS OF POWER, THE INSIDE LIGHTS DIMMED AND THE RADIO CUT OUT. IT WAS DETERMINED THE BATTERY NEEDED TO BE REPLACED. FOUR MONTHS LATER, THE SPORADIC BRAKE SYSTEM MESSAGE ILLUMINATED. THE DEALER WAS UNABLE TO FIND A PROBLEM. UPDATED 08/24/15*JB

WHILE DRIVING THE VEHICLE THE ABS LIGHT CAME ON, FOLLOWED BY THE "SERVICE BRAKE SYSTEM" REQUEST LIGHT AND THE RED BRAKES LIGHT. I HAD "SOFT BRAKES" BUT I COULD STILL USE THE BRAKES SO I DROVE THE VEHICLE TO THE LOCAL FORD FERRARIO DEALERSHIP. IT IS NOW A WEEK LATER AND I WAS TOLD THAT THE ABS NEEDED TO BE REPLACED AT A COST OF $4800.00. I THEN REPLIED TO NOT REPLACE THE ABS AS I HAVE BEEN A CAUTIOUS DRIVER FOR OVER 45 YEARS AND DRIVE DEFENSIVELY. THE SHOP TRIED UNSUCCESSFULLY TO BLEED ALL THE TIRE'S BRAKES AS I REQUESTED THAT I "AT LEAST" HAVE HYDRAULIC BRAKES AND IT BE ABLE TO MAINTAIN THE FLUID LEVEL. ALL WORKED PROPERLY EXCEPTING THE LEFT FRONT TIRE. THIS EVENING I WENT AND RETRIEVED THE VEHICLE FROM THE SHOP AFTER THEY HAD REPLACED THE LEAKING HOSE ON THE LEFT FRONT TIRE (ALSO HAD THEM REPLACE THE HOSE ON THE RIGHT FRONT TIRE). ACCORDING TO THE CONVERSATION WITH THE LEAD TECHNICIAN MY FRONT BRAKES WERE HARDLY USED (OVER 60% OF THE CARS BRAKING) AND LOOKED LIKE THEY WERE RUSTING OR CORRODED OVER WHILE THE ROTORS AND ALL THE PARTS REPLACED EXACTLY ONE YEAR PRIOR STILL LOOKED NEW. BEING CONFUSED ABOUT THIS, ASKED WHY NO ONE HAD CAUGHT THIS EARLIER. WHILE ON THE WAY HOME FROM THE SHOP (WITHOUT PROPER BRAKES AND ONLY THE EMERGENCY HAND BRAKE AND THE HYBRID LOW GEAR TO SLOW DOWN RAPIDLY WITH) I RESET ALL THE FUNCTIONS LIKE I NORMALLY DO AFTER A SERVICE SHOP VISIT. LOW AND BEHOLD THE ABS LIGHT WENT OUT, BUT THERE WERE STILL NO BRAKES WITH SMALL EXCEPTION. I AM NOW WONDERING BOTH HOW AND WHO IS GOING TO BE ABLE TO REPAIR THIS VEHICLE WITHOUT FURTHER EXCESSIVE COST (PAID OVER $480.00) THAT I'VE ALREADY INCURRED WITHOUT HAVING THE BRAKES AVAILABLE TO ME. BECAUSE I WORK CONTRACT JOBS AND TYPICALLY DRIVE TO JOBS OR JOB SITES I AM NOW WITHOUT A VEHICLE. THE LARGER CONCERN FOR ME IS THAT THIS TYPE OF FORD SUV HYBRID VEHICLE HAS A RASH OF BRAKE PROBLEMS. *TR

THE FIRST INCIDENT WAS THE ABS LIGHT ILLUMINATING AND A CHUGGING SOUND IN 2013.... TOOK IT TO THE LOCAL FORD DEALER AND THE TONE RING ON FRONT DRIVER SIDE WAS BROKEN AND REPLACED FOR $350.00. ON 12 JANUARY 2015, BOTH THE ABS LIGHT AND BRAKE FAILURE LIGHT ILLUMINATED, ALONG WITH MESSAGE TO SERVICE BRAKES. TOOK TO LOCAL FORD DEALER WHERE I WAS INFORMED THE PROBLEM WAS FAILURE OF THE ABS HYDRAULIC SYSTEM --- APPROX. $4,000.00 TO REPLACE. I DON'T HAVE $4,000.00 PLUS AVAILABLE TO INVEST IN THIS 2006 ESCAPE HYBRID.... THIS IS A KNOWN PROBLEM, HAS BEEN REPEATEDLY REPORTED, AND IS A VEHICLE SAFETY ISSUE THAT FORD APPEARS TO BE DISMISSIVE --- MUCH LIKE GM AND THE ACCELERATION ISSUE. FORTUNATELY, THERE HAVE BEEN NO REPORTED DEATHS DUE TO THIS ISSUE..... YET. WE NEED TO GET A RECALL BEFORE THAT HAPPENS. *TR

WHILE DRIVING MY 2006 FORD HYBRID ESCAPE ON THE HIGHWAY, THE ABS AND PARKING BRAKE LIGHTS CAME ON AS WELL AS A WARNING ALARM SOUNDED. THE BRAKES WENT COMPLETELY OUT, AND I HAD TO PUSH THE BRAKE PEDAL ALL THE WAY TO THE FLOOR BEFORE I COULD SLOW DOWN. THIS IS THE SECOND TIME IN ABOUT 3 MONTHS THAT THIS EVENT HAS OCCURRED. *TR

APPROXIMATELY 8-9 MONTHS AGO I FELT LIKE THE MASTER CYLINDER WAS GOING OUT IN MY 2006 ESCAPE HYBRID. I TOOK IT TO A LOCAL SHOP THAT I TRUST A FEW DAYS LATER AND THE MECHANIC DROVE IT AND THOUGHT IT WAS OK SO NO REPAIRS WERE PERFORMED. HOWEVER, AT THIS TIME HE DID NOT PERFORM ANY SORT OF A COMPUTER DIAGNOSTIC TEST BECAUSE HE FELT THE BRAKES SEEMED OK. FAST FORWARD TO APPROX. 8/17/14, I PULLED INTO MY GARAGE AND BEFORE I TURNED MY CAR OFF BOTH THE LED MESSAGE BOARD INDICATED AN ISSUE NEEDED ATTENTION (CAN'T RECALL EXACT WORDING) AND THE RED BRAKE WARNING LIGHT ON THE DASH LIT UP INDICATING THE BRAKE UNIT NEEDED SERVICE. I TOOK THE VEHICLE BACK TO THE SAME MECHANIC AND HE PERFORMED A COMPUTER DIAGNOSTIC TEST. HE GOT BACK TO FOLLOWING: "BRAKE SYSTEM DIAGNOSTICS CODE: C1471 HIGH PRESSURE ACCUMULATOR VOLUME CONSUMPTION PLAUSIBILITY FAILURE. RECOMMEND REPLACEMENT OF THE MASTER CYLINDER FIRST AND RECHECK SYSTEM. IF CODE RETURNS THE HYDRAULIC CONTROL UNIT WILL NEED TO BE REPLACED." THE COST TO PERFORM THIS WORK IS NEARLY $8,900.00 AND ALMOST ALL OF THAT CHARGE IS FOR REPLACING THESE TWO DEFECTIVE PARTS, NOT LABOR. THE COST TO REPLACE THE FAILING HYDRAULICS EXCEEDS THE BLUE BOOK VALUE OF THE VEHICLE ALSO. THIS VEHICLE HAS ONLY 91,589 MILES ON IT AND THE WHOLE HYDRAULIC SYSTEM IS FAILING. I CHECKED OUT VARIOUS INTERNET BOARDS AND IT LOOKS LIKE MY PROBLEM IS THE SAME EXACT PROBLEM SCORES OF OTHERS HAVE EXPERIENCED, AND MANY OF THEM RIGHT AT THE SAME APPROX. MILEAGE INTERVAL. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE BRAKE WARNING LIGHT ILLUMINATED. THE CONTACT ALSO STATED WHEN THE BRAKE PEDAL WAS DEPRESSED, THE VEHICLE WOULD NOT INSTANTLY STOP AND TRAVELED ABNORMALLY TO THE FLOORBOARD. THE FAILURE RECURRED ON MULTIPLE OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE HYDRAULICS CODE WAS PRESENT AS A RESULT THE MASTER CYLINDER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 105,000. THE VIN WAS NOT AVAILABLE.

AT APPROXIMATELY 1:30PM, I WAS DRIVING IN SACRAMENTO MAKING A RIGHT TURN MERGING INTO TRAFFIC WITH MY FOOT ON THE BRAKE PEDAL WHEN ALL OF A SUDDEN THE PETAL DROPPED TO THE FLOOR WITH NO HYDRAULIC PRESSURE IN IT. THE ABS LIGHT CAME ON, THE BRAKE LIGHT CAME ON, AND THE PANEL SAID "SERVICE BRAKE SYSTEM." I HAD MY SON IN THE CAR WITH ME AND I PULLED OVER TO THE SIDE OF THE ROAD PRESSING EXTREMELY HARD ON THE BRAKE PEDAL TO GET IT TO STOP. I IMMEDIATELY WENT TO PEP BOYS AROUND THE CORNER WITHOUT BRAKES (EXCEPT WHEN I PRESSED HARD ON THE BRAKE PEDAL ALL THE WAY TO THE FLOOR). PEP BOYS LOOKED AT IT AND SAID IT MIGHT BE THE MASTER CYLINDER BUT THEY WERE NOT WILLING TO SELL ME ONE UNTIL I HAD A FORD DEALER LOOK AT THE VEHICLE. WHEN I TURNED THE CAR BACK ON, THE ABS LIGHT WAS OFF, THE BRAKE WARNING LIGHT WAS OFF, AND THE SERVICE WARNING WAS OFF. FORD DEALER LOOKED AT THE VEHICLE, DROVE IT AROUND FOR 22 MILES AND NOTHING OUT OF THE ORDINARY HAPPENED. I ADVISED FORD THAT PEP BOYS HAD ADVISED ME THERE WAS A TECHNICAL SERVICE BULLETIN (TSB) ON INTERMITTENT BRAKE LOSS FOR 2006 FORD ESCAPE HYBRID. THE FORD REPRESENTATIVE IMMEDIATELY SNAPPED BACK AT ME "THAT DOESN'T MEAN ITS COVERED UNDER WARRANTY?" I THEN SAID, I CARE ABOUT MY SAFETY AND WANT TO KNOW WHY OUT OF THE BLUE MY BRAKES FAILED. WHEN I WENT BACK TO SEE IF THEY FOUND A PROBLEM, THEY STATED EVERYTHING WAS IN NORMAL WORKING ORDER AND THERE WERE NO CODES IN THE SYSTEM TO INDICATE BRAKE FAILURE. *TR

I HAVE THE HYBRID VERSION OF ESCAPE. I WAS EXITING A FREEWAY WHEN THE ABS YELLOW LIGHT AND BRAKE RED LIGHT CAME ON MY DASHBOARD. I THEN PUSHED THE BRAKE PEDAL AND NOTICED THE CAR WASN'T SLOWING DOWN AS IT SHOULD THAT'S WHEN I SLAMMED ON THE BRAKES TO MAKE THE CAR SLOW DOWN. I IMMEDIATELY PULLED OVER TO THE SIDE OF THE ROAD. THE DASHBOARD READ REGEN BRAKES DISABLE. I TURNED OFF THE CAR AND RESTARTED IT. THE CAR WORKED LIKE IT DID BEFORE BUT WHEN I RAN A DIAGNOSTIC ON THE CAR IT STILL READ THE REGEN BRAKES DISABLED. THE CAR WORKED FINE WITH THE WARNING BUT EVENTUALLY AFTER DRIVING FOR ABOUT 15 MINUTES THE WARNING WENT AWAY. *TR

THE VEHICLE WAS AND HAS BEEN DRIVING NORMALLY UNTIL STANDARD BRAKING SITUATION OF COMING TO A STOPLIGHT. AS THE BRAKES WERE APPLIED THE ABS AND BRAKE LIGHT CAME ON AND ALL POWER ASSIST TO THE BRAKES WAS GONE. I HAD TO CRUSH THE BRAKE PEDAL TO GET ANY BRAKING AT ALL. LUCKILY I'M STRONG ENOUGH TO MANUALLY BRING THE VEHICLE TO A STOP. THIS WAS THE FIRST TIME (DECEMBER 2013) SINCE I'VE HAD THE VEHICLE THAT THIS HAPPENED. IT'S NOW APRIL 2014 AND THE SAME ISSUE HAS RETURNED (TWICE IN A WEEK). A VERY DANGEROUS POTENTIAL SITUATION. HOWEVER, AFTER BRAKING TO A STOP THE VEHICLE CAN BE TURNED OFF AND BACK ON TO CORRECT THE SITUATION (ABS AND BRAKE LIGHT TURN OFF) AND THE BRAKES RETURN TO NORMAL. I PURCHASED THIS VEHICLE AT AUCTION FROM A FLEET OF VEHICLES. THE STICKER DID SAY BRAKE PROBLEMS, HOWEVER, AFTER DRIVING IT I FOUND ONLY NORMAL BRAKING AND ATTRIBUTED THE "BRAKE PROBLEM" TO WORN BRAKE PADS ETC. I CAN ONLY SAY THAT THE "BRAKE PROBLEM" THEY MENTIONED ON THE STICKER MUST HAVE BEEN THE SAME SITUATION I'VE RUN INTO - SO THE FLEET PERSONNEL MUST HAVE BEEN EXPERIENCING THE SAME THING. THIS SITUATION SEEMS TO ME TO BE A MUCH DEEPER DESIGN FLAW AND AFTER RESEARCHING ONLINE AND SEEING SO MANY OTHER SIMILAR COMPLAINTS - THIS OBVIOUS FLAW SHOULD BE EXPOSED AND CORRECTED ON A VEHICLE RECALL BASIS BEFORE THERE ARE FATALITIES. IT SEEMS TO ME ONLY A MATTER OF TIME...... *TR

I WAS DRIVING THE VEHICLE AND THE RED BRAKE LIGHT CAME ON WITH A MESSAGE TO CHECK BRAKE SYSTEM. FOR THE REST OF THE TRIP THE BRAKES WORKED OK. I REACHED MY DESTINATION AND TURNED THE CAR OFF. WHEN I CAME BACK OUT AND STARTED THE VEHICLE BOTH THE RED BRAKE LIGHT AND THE YELLOW ABS LIGHT WERE ON. WHEN I WAS PULLING OUT OF THE PARKING LOT I PRESSED THE BRAKE PEDAL BUT THE CAR DID NOT STOP. I HAD TO USE THE HAND BRAKE TO STOP THE CAR FROM GOING INTO THE ONCOMING TRAFFIC. I BACKED UP AND PARKED THE CAR AND CALLED A TOW TRUCK. WHEN THE CAR WAS LOADED ONTO THE TOW, ABOUT AN HOUR LATER, THE BRAKES WORKED AGAIN. *TR

COMING TO A STOP TO LEAVE PARKING LOT, I FELT THE BRAKES SHUTTER AS IF WAS SLIDING. THE SKIING LIGHT CAME ON FOR ABOUT 2 SECONDS, VEHICLE MOTION STOPPED, THEN THE ABS LIGHT CAME ON AND GOT A MESSAGE ON DASH THE GET BAKE SYSTEM SERVICED. ABS LIGHT IN ON ALL THE TIME AND THE ABS SYSTEM DOES NOT WORK. WILL BE TAKING TO REPAIR SHOP TODAY FOR EVALUATION AND REPAIR. THIS SEEMS TO BE A KNOWN ISSUE WITH THIS VEHICLE MODEL. RECALL???? *TR

MY 2006 ESCAPE HYBRID SUDDENLY LOST BRAKING POWER, OCCURRING AS I ATTEMPTED TO SLOW TO EXIT OFF OF I-95 TO MY HOME. THE ABS AND WARNING LIGHT CAME ON, AT THE SAME TIME,THE BRAKE PEDAL WENT TO THE FLOOR BOARD BUT THERE WAS JUST ENOUGH TO GET SLOWED DOWN PUSHING AS HARD AS I COULD AND LUCKILY THE OFF RAMP WAS UP HILL. I WAS GOING TO PULL OFF AND GET TOWED BUT DECIDED BEING ON THE SIDE OF I-95 WAS TOO SCARY AND INSTEAD DROVE ,DESPITE THE FAILURE. I WENT 5MPH AND MADE IT HOME . THE NEXT MORNING THE BRAKES WERE MIRACULOUSLY WORKING FINE. NOW I AM TOO SCARED TO DRIVE THE CAR AND HAVE READ OF OTHERS THAT SPENT TONS OF MONEY WITHOUT THE CAR BEING FIXED. *TR

VEHICLE GAS PEDAL HAD TO BE DEPRESSED FULLY TO THE FLOOR WITH ASSISTANCE OF EMERGENCY BREAK TO BRING VEHICLE TO COMPLETE STOP IN LIGHT TRAFFIC AT AROUND 9:30 PM. PULLED VEHICLE INTO EMPTY PARKING LOT AND HAD VEHICLE TOWED TO SERVICE CENTER (LAKE ZURICH TIRE & AUTO, INC.) WHERE IT WAS LEFT OVERNIGHT. FOLLOWING MORNING MECHANIC LOOKED AT VEHICLE AND IT WAS DETERMINED THAT FRONT RIGHT BRAKE HOSE FAILED AND LEFT FRONT BRAKE HOSE WAS LEAKING. THERE WAS VERY LITTLE BRAKE FLUID LEFT. MECHANIC STATED THAT BOTH HOSES SHOWED DETERIORATION WHICH WAS UNUSUAL FOR A VEHICLE WITH THIS MILEAGE. HE ALSO STATED THAT THIS WAS THE 5TH ESCAPE AROUND THIS MODEL YEAR THAT HE HAS SEEN WITH THIS ISSUE WITHIN THE LAST COUPLE OF WEEKS. I SENT A LETTER TO FORD CUSTOMER RELATIONS TODAY REQUESTING REIMBURSEMENT OF $282.32 FOR THE NECESSARY REPAIRS. *TR

BRAKE FAILURE. IN ONE SHORT DISTANCE, BOTH FRONT FLEXIBLE HOSES CARRYING BRAKE FLUID RUPTURED TOTALLY LOSING BRAKE RESPONSE. CAR WAS BROUGHT UNDER CONTROL BY OTHER MEANS. WE COULD HAVE BEEN KILLED IN A VARIED CIRCUMSTANCE. IT WAS NECESSARY TO HAVE THE CAR TOWED FOR REPAIRS.

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 MPH AND ATTEMPTING TO DECELERATE, THE BRAKE PEDAL BECAME STUCK TO THE FLOOR BOARD. THE CONTACT WAS ABLE TO STOP THE VEHICLE BY ENGAGING THE EMERGENCY BRAKE. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC, WHO PERFORMED A BRAKE INSPECTION WHICH LOCATED THE FRONT PASSENGER'S SIDE BRAKE LINE WAS FRACTURED PREMATURELY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 35,000. *TR

WIFE AND I WERE ENROUTE HOME FROM VERO BEACH, FL TRAVELING WEST ON FL HIWAY 60 ABOUT 10 MILES EAST OF THE FL TURNPIKE AROUND 8:30 AM. TRAVELED OVER SHORT STRETCH OF REPAVED ROAD. AT THAT TIME HEARD BEEP, NOTICED RED BRAKE LIGHT AND AMBER ABS LIGHT ON. CRUISE CONTROL ON MOVING 60 MPH. TRIED BRAKES, NOTICED EXCESSIVE BRAKE TRAVEL, BUT STILL HAD SOME BRAKES. CONTINUED ON UNTIL TURNPIKE JUNCTION. PULLED OFF ROAD, STOPPED, SHUT OFF IGNITION. UPON RESTARTING (AFTER 5 SECONDS), WARNING LIGHTS STAYED OFF, HAD GOOD BRAKES. PROCEEDED 130 MILES TO HOME W/O INCIDENT. THIS HAS OCCURRED 3 TIMES BEFORE AND HAVE HAD IT TO THE DEALER'S SERVICE DEPT. ON JULY 5TH. I AM DETAILING THIS INCIDENT BECAUSE I HAVE THE MOST INFORMATION ABOUT IT. WHEN IT OCCURRED ALL 4 TIMES, IT WAS EITHER AFTER CROSSING RAILROAD TRACKS, HITTING A POT HOLE OR IN THIS CASE AFTER A CHANGE IN ROAD SURFACE. AND IT DOESN'T HAPPEN ALL THE TIME WHEN CROSSING ROUGH SURFACES. THE DEALER (NICK NICHOLAS FORD IN INVERNESS, FL) CANNOT SEEM TO FIND AND FIX THIS. I HAVE TO GROUND THIS VEHICLE BECAUSE I CANNOT TRUST IT WITH MY WIFE DRIVING BY HERSELF. IT COULD COST UP TO 7K FOR FORD TO SWAP OUT COMPONETS TO TRY TO FIX IT - MY COST. THIS IS A SAFETY ISSUE! NOT A WEAR AND TEAR ISSUE.

BOUGHT THE CAR FROM NOVATO FORD, NOW JOURNEY FORD IN 2008. A FEW DAYS AGO I HAD TO BRAKE HARD, BUT AS FAR AS I COULD TELL THE ANTILOCK BRAKING SYSTEM (ABS) DID NOT ENGAGE. THE BRAKES WORKED AND THE CAR STOPPED/. THE NEXT DAY I NOTICED THAT AS SOON AS I STARTED THE CAR THE ABS AND BRAKE LIGHT WERE ON. I TOOK IT TO A LOCAL REPAIR SHOP WHERE THEY RAN A DIAGNOSTIC SCAN, WHICH RETURNED CODE C1475. THE NON-FORD REPAIR SHOP SAID THEY WOULD NEED TO FOLLOW FORD'S TECHNICAL SERVICE BULLETIN AND THE REPAIR WOULD COST 3500 IN PARTS AND ANOTHER $700 IN LABOR. I AM WRITING BECAUSE IT SEEMS HIGHLY UNUSUAL TO ME AND THE SERVICE PERSONNEL WHO HAVE REVIEWED THIS MATTER FOR THIS TO OCCUR. THIS IS FORD'S SERVICE BULLETIN HTTP://WW.W.AUTOELECTRICPRO.COM/PURCHASED/IMAGES/076000/074720.PDF. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE WARNING INDICATOR ILLUMINATED INTERMITTENTLY. THE FAILURE RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO THE DEALER FOUR TIMES. THE TECHNICIAN INFORMED THE CONTACT THAT THE ELECTRONIC HYDRAULIC BRAKE SYSTEM WOULD NEED TO BE REPLACED. THE VEHICLE WAS SCHEDULED FOR REPAIRS. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 86,000. UPDATED 11/19/13*LJ

FEEL FOR A MOMENT LIKE YOU ARE DRIVING IN ICE(SLIPPERY). THEN SERVICE BRAKE SYSTEM APPEAR WITH THE TRIANGLE WITH THE ADMIRATION SIGN INSIDE. *TR

WIFE AND I WERE ENROUTE HOME FROM VERO BEACH, FL TRAVELING WEST ON FL HIWAY 60 ABOUT 10 MILES EAST OF THE FL TURNPIKE AROUND 8:30 AM. TRAVELED OVER SHORT STRETCH OF REPAVED ROAD. AT THAT TIME HEARD BEEP, NOTICED RED BRAKE LIGHT AND AMBER ABS LIGHT ON. CRUISE CONTROL ON MOVING 60 MPH. TRIED BRAKES, NOTICED EXCESSIVE BRAKE TRAVEL, BUT STILL HAD SOME BRAKES. CONTINUED ON UNTIL TURNPIKE JUNCTION. PULLED OFF ROAD, STOPPED, SHUT OFF IGNITION. UPON RESTARTING (AFTER 5 SECONDS), WARNING LIGHTS STAYED OFF, HAD GOOD BRAKES. PROCEEDED 130 MILES TO HOME W/O INCIDENT. THIS HAS OCCURRED 3 TIMES BEFORE AND HAVE HAD IT TO THE DEALER'S SERVICE DEPT. ON JULY 5TH. I AM DETAILING THIS INCIDENT BECAUSE I HAVE THE MOST INFORMATION ABOUT IT. WHEN IT OCCURRED ALL 4 TIMES, IT WAS EITHER AFTER CROSSING RAILROAD TRACKS, HITTING A POT HOLE OR IN THIS CASE AFTER A CHANGE IN ROAD SURFACE. AND IT DOESN'T HAPPEN ALL THE TIME WHEN CROSSING ROUGH SURFACES. THE DEALER (NICK NICHOLAS FORD IN INVERNESS, FL) CANNOT SEEM TO FIND AND FIX THIS. I HAVE TO GROUND THIS VEHICLE BECAUSE I CANNOT TRUST IT WITH MY WIFE DRIVING BY HERSELF. IT COULD COST UP TO 7K FOR FORD TO SWAP OUT COMPONENTS TO TRY TO FIX IT - MY COST. THIS IS A SAFETY ISSUE! NOT A WEAR AND TEAR ISSUE. *LN UPDATED 1/6/2014 *JS

PART 1: I PURCHASED THIS USED VEHICLE FROM WHAT IS A WELL KNOWN DEALERSHIP IN MY AREA OF LIVING ON 3/21/13. AS YOU CAN SEE FROM THE DATE THE FIRST BRAKE FAILURE HAPPENED, IT WAS 4 DAYS AFTER I DROVE THE VEHICLE OFF THE LOT. THE BRAKE AND ABS LIGHTS ILLUMINATED ON THE DASH ON MY WAY HOME FROM WORK. THANKFULLY, BESIDES BEING SCARED TO DEATH, I WAS OK. THE DEALERSHIP TOWED MY VEHICLE AND STATED THEY "MIRACULOUSLY" (MY SARCASM) HAD BRAKES WHEN DRIVING IT FROM THE TOW TRUCK INTO THE SHOP. THEY HAD GREAT DIFFICULTIES FIGURING OUT WHAT WAS WRONG AND HAD EVEN TALKED WITH THE FORD COMPANY AND CAME UP WITH THE HYDRAULICS SYSTEM BEING THE ISSUE WHICH WAS THEN REPLACED BY THE DEALERSHIP. AT A LATER TIME WITH FURTHER OCCURRENCE, I WAS INFORMED THE MODULAR HAD ALSO AT THE FIRST BRAKE FAILURE BEEN REPLACED, ALTHOUGH THERE IS NO PROOF OF THAT ON MY SERVICE RECORD (ANOTHER ISSUE). AFTER REPLACING THESE ITEMS, THE DEALERSHIP CONTINUED TO HAVE DIFFICULTIES TRYING TO GET THE BRAKE AND ABS LIGHTS FROM ILLUMINATING ON THE DASH AND APPARENTLY HAD TO UNHOOK SOME VACUUM PUMP TO CORRECT ISSUE. FOLLOWING THIS I WAS ASSURED EVERYTHING WAS FIXED. SECOND BRAKE FAILURE WAS ON 5/26/13. THANKFULLY,I WAS JUST COMING TO A STOP AT MY RESIDENCE WHEN THIS OCCURRED! AGAIN VEHICLE WAS TOWED. AN ERROR CODE WAS FOUND AND RESET AND ASSURED EVERYTHING WAS OK. THIS IS ALSO WHEN I DID SOME DIGGING AND REQUESTED THE PREVIOUS OWNERS NAME. TO MY AMAZEMENT, THIS HAD HAPPENED ONCE TO THE PREVIOUS OWNER.....FUNNY, THE DEALERSHIP AND FORD WERE INVOLVED AND STATED IT COULD HAVE BEEN A MODULAR OR A "FLUKE" AND NOTHING WAS DONE AT THAT TIME AND THE VEHICLE WAS TRADED SHORTLY AFTER. HMMM..I INHERITED A PROBLEM. *TR

DRIVING ALONG IN TRAFFIC WHEN ALL OF A SUDDEN THE BRAKES WOULDN'T FUNCTION AT ALL, EVEN WITH TWO FEET PRESSING ON THE BRAKE PEDAL WITH ALL OF MY STRENGTH. THE BRAKE LOSS SEEMS TO OCCUR ABOUT ONCE A MONTH, AND NOW OCCURRED TWICE IN AUGUST. AFTER SHUTTING THE VEHICLE OFF AND RESTARTING IT, THE BRAKES WORK AGAIN. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 25 MPH AND DEPRESSING THE BRAKE PEDAL THE ABS WARNING LIGHT ILLUMINATED AND THE WARNING CHIME WAS ALSO ACTIVATED. THE BRAKES ALSO FAILED TO RESPOND WHEN THEY WERE APPLIED. THE CONTACT CONTINUED TO DEPRESS THE BRAKE PEDAL UNTIL THEY ENGAGED. THE FAILURE OCCURRED TWICE. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS WHERE THE TECHNICIAN STATED THE MASTER CYLINDER BOOSTER ASSEMBLY WAS LEAKING BRAKE FLUID AND NOT ENGAGING. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 78,000. *TR

DRIVING ABOUT 35 AND THE ABS LIGHT AND ANTI SKID LIGHT CAME ON, WHEN AT SLOW SPEED THE CAR STARTED DOING A CHUGGING AND THEN IT WENT ON BATTERY. IT DID THIS ALL THE WAY HOME. I AM LUCKIER THAN MOST MY MAN IS A MECHANIC AN PUT IT ON THE COMPUTER AND IT STATED WHERE THE PROBLEM WAS. I ALSO LOOKED ONLINE AND SEE HUNDREDS OF PEOPLE COMPLAINING ABOUT THE TONE RING. IN 5 MONTHS MY 16 YEAR OLD WILL BE DRIVING THIS CAR FULL TIME AND NOW I AM REAL CONCERNED FOR HER SAFETY. SOME ONE RECALL THIS TONE RING, PEOPLE ARE LOOSING BRAKES!!!! *TR

DRIVING ABOUT 35 AND THE ABS LIGHT AND ANTI SKID LIGHT CAME ON, WHEN AT SLOW SPEED THE CAR STARTED DOING A CHUGGING AND THEN IT WENT ON BATTERY. IT DID THIS ALL THE WAY HOME. I AM LUCKIER THAN MOST MY MAN IS A MECHANIC AN PUT IT ON THE COMPUTER AND IT STATED WHERE THE PROBLEM WAS. I ALSO LOOKED ONLINE AND SEE HUNDREDS OF PEOPLE COMPLAINING ABOUT THE TONE RING. IN 5 MONTHS MY 16 YEAR OLD WILL BE DRIVING THIS CAR FULL TIME AND NOW I AM REAL CONCERNED FOR HER SAFETY. SOME ONE RECALL THIS TONE RING, PEOPLE ARE LOOSING BRAKES!!!! *TR

ABS LIGHT CAME ON AT 59408 MILES. VEHICLE WAS TAKEN DICK MASHETER FORD IN COLUMBUS, OH AND REPAIRED ON 12/1/11 BY REPLACING LEFT FRONT ABS TONE RING. AT 68005 MILES, THE ABS LIGHT CAME ON ONCE AGAIN. VEHICLE WAS ONCE AGAIN TAKEN TO DICK MASHETER FORD IN COLUMBUS, OH WHERE THE VEHICLE WAS AGAIN REPAIRED. THIS TIME BOTH LEFT AND RIGHT ABD TONE RINGS WERE REPLACED. FAILURE OF THE ABS TONE RING AFTER LESS THAN 8600 MILES OF OPERATION MAY INDICATE A SYSTEMIC ISSUE FOR THE PARTICULAR VEHICLE. *TR

1/25/13 PULLED OUT OF DRIVEWAY TAKING DAUGHTER TO SCHOOL ~ AS I APPROACHED STOP SIGN I HAD NO BRAKES. PEDAL TO FLOOR ... THANKFULLY NO CARS WERE COMING ~ YANKED WHEEL TO THE RIGHT AND PULLED UP EMERGENCY BRAKE TO STOP. DROPPED CAR OFF AT 5 STAR FORD NRH, TX AND NOW HAVE BEEN QUOTED OVER 4600.00 TO REPLACE HCU ABS MODULE ON A CAR WITH LESS THAN 60K MILES?! THE PART ALONE IS 4100.00 .... ARE YOU SERIOUS?! I AM DISGUSTED THAT I HAVE NOW SEEN AND READ SO MANY INSTANCES OF OTHER CONSUMERS WITH EXACT SAME ISSUE AND WITH NO RECALLS OR LIABILITY ON FORD'S BEHALF! THIS SHOULD NOT BE TOLERATED AND IS A HUGE SAFETY ISSUE, TO SAY THE VERY LEAST. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 65 MPH, SHE HEARD A LOUD NOISE COMING FROM THE VEHICLE FOLLOWED BY THE ILLUMINATION OF THE ABS WARNING LIGHT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY ADVISED THAT THE O-RINGS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED TWICE WITHIN A WEEK. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS UNKNOWN. THE CURRENT MILEAGE WAS APPROXIMATELY 84,500.

I WAS DRIVING ABOUT 35 MPH WHEN THE RED "BRAKE" WORD APPEARED, AND THE RED "SERVICE BRAKE SYSTEM" MESSAGE CAME ON. BRAKES SEEMED FINE, SO I CONTINUED DRIVING ABOUT 3 MILES. STOPPED AT A STORE. WHEN I CAME OUT ABOUT 30 MINUTES LATER AND STARTED THE CAR THOSE LIGHT MESSAGES DID NOT COME ON, SO I DROVE TOWARD HOME ABOUT 3 MILES AWAY. AS I WAS ABOUT 3 BLOCKS FROM HOME I DROVE OVER A RECESSED MANHOLE COVER IN THE STREET AND THE RED BRAKE WORD, THE "SERVICE BRAKE SYSTEM" MESSAGE CAME ON AGAIN WHEN I HIT THAT BUMP, AND ALSO A WHITE "ABS" WORD. THE BRAKES IMMEDIATELY FELT LIKE THEY WERE GOING OUT AS I SLOWED DOWN TO TURN A CORNER AHEAD. I DIDN'T ACCELERATE ANY MORE BECAUSE THE BRAKES FELT UNRESPONSIVE, SO I COASTED THE REST OF THE WAY THROUGH THE TURN AND TRIED TO PULL OVER AND STOP IN A SPACE WHERE THERE WERE NO PARKED CARS, BUT BRAKES WERE NOT WORKING AND I REALIZED I WASN'T GOING SLOW ENOUGH TOWARD A PARKED CAR AHEAD. I WAS ABOUT TO SWERVE BACK OUT INTO THE STREET BUT PRESSED THE BRAKE DOWN HARD ALL THE WAY AND FELT IT STOP LIKE A MANUAL BRAKE, AND I STOPPED BEFORE HITTING THE PARKED CAR. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 45 MPH THE BRAKES WERE ENGAGED AND THE ANTI LOCK BRAKES FAILED. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE TONE RING WOULD HAVE TO BE REPLACED. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 33,219 AND THE CURRENT FAILURE MILEAGE WAS 70,000.

ABS AND 4X4 SENSOR LIGHTS ACTIVATE AND FLASH ON DASHBOARD ABS BRAKING FAILS , SENSOR REP[LACED AND WENT OUT AGAIN AFTER A YEAR. SEEMS TO BE A PROBLEM WITH NUMEROUS ESCAPES AS FOUND IN ONLINE SEARCH. *TR

TOTAL BRAKE FAILURE WHILE DRIVING. *TR

SIX DAYS AFTER PURCHASING THIS VEHICLE USED FROM A DEALER, MY FATHER LOST BRAKES WHILE DRIVING IN TOWN. THE ABS LIGHT CAME ON AND THE BRAKES HAD TO BE PUSHED TO THE FLOOR. THE REPAIR INVOLVED REPLACING THE ENTIRE HYBRID SYSTEM. THE NEXT TIMES THE ABS LIGHT WENT OFF WHILE EITHER HE OR MYSELF WAS DRIVING WE WOULD APPLY THE BRAKES TO MAKE SURE WE HAD PROPER USE OF THEM. WE DECIDED NOT TO BRING THE VEHICLE BACK IN TO BE LOOKED AT BECAUSE THE ABS LIGHT WOULD NEVER STAY ON AND THE BRAKES SEEMED TO BE IN WORKING ORDER. ALSO, WE DID NOT WANT BE WITHOUT THE VEHICLE FOR THE LENGTHY PERIOD OF TIME WE EXPERIENCED IN JANUARY. THE NEXT TIME THE VEHICLE COMPLETELY LOST BRAKES WAS SEPTEMBER 5, 2012 WHEN MY FATHER WAS DRIVING. THIS TIME THE TRACTION CONTROL AND ABS LIGHTS WENT ON. OUR DEALER SENT US TO THE LOCAL FORD DEALER AND THEY WANTED NOTHING TO DO WITH HELPING US OUT ON THE REPAIR TO HAVE A SAFE VEHICLE TO DRIVE. WE TOOK THE FORD BACK TO OUR DEALER WHO ENDED UP PUTTING A NEW AXLE ON THE VEHICLE AND CLEARING THE REST OF THE CODES. I WAS SHOCKED THAT I HAD TO BUY AN AXLE. IT WAS SOMETHING TO DO WITH A THE AXLE'S TONE RING BEING BROKEN AND NOT GIVING A READING TO THE SPEED SENSOR. THE NEXT TIME MY FATHER LOST BRAKES WAS ON SEPTEMBER 26, 2012. THIS TIME THE BRAKES WENT TO THE FLOOR AND HE HAD NO BRAKES AT ALL. WE HAD THE DEALER TOW THE VEHICLE THIS TIME. THE SERVICE SHOP SAID THEY CLEARED THE CODES AND COULD NOT GET THE PROBLEM TO REPRODUCE. BY THIS TIME WE ARE BOTH DONE WITH THIS CAR. I TOLD THEM I WANTED SOMETHING IN WRITING THAT THE VEHICLE WAS SAFE TO DRIVE IN CASE SOMEONE GOT INTO A ACCIDENT. THEY GAVE ME THE PAPERWORK STATING THEY COULD NOT GET THE PROBLEM TO DUPLICATE AND THE VEHICLE WAS OPERATING AS INTENDED AT THIS TIME . THE VERY NEXT DAY, MY FATHER LOST BRAKES WHILE DRIVING TO WORK. AGAIN, WE HAD THE DEALER TOW IN THE VEHICLE. *TR

MULTIPLE CONTINUED INSTANCES OF COMPLETE BRAKE FAILURE. SINCE THE INITIAL OCCURRENCE, ALREADY DOCUMENTED ON THIS SITE (ODI ID NUMBER : 10349431), IT RANDOMLY RECURRED AT LEAST 10 TIMES OVER THE PAST 2 YEARS, INCLUDING 3 TIMES IN A SINGLE TRIP IN JUNE 2012 AND TWO ADDITIONAL TIMES IN JULY 2012. THE BRAKE FAILURES TYPICALLY OCCURRED DURING HOT WEATHER WHEN RUNNING THE AIR CONDITIONER, BUT NOT ALWAYS. EVERY TIME WE THOUGHT WE'D "FIGURED OUT" A PATTERN TO THE FAILURES, THE BRAKES WOULD GO OUT AT A DIFFERENT TIME THAN THEY EVER HAD BEFORE -- AT A HIGHER SPEED, OR WHILE SLOWING FOR A STOP LIGHT GOING UPHILL VERSUS WHEN WE WERE TRYING TO SLOW TO A STOP AT THE BASE OF A STEEP HILL WITH A MARINA IN FRONT OF US. WE FINALLY SOLD THE CAR FEARING FOR THE SAFETY OF OUR FAMILY, OTHERS ON THE ROADWAYS, AND OUR FINANCES. NO WONDER FORD QUIT MAKING THESE VEHICLES... *TR

I WAS ABOUT TO EXIT THE PARKING LOT OF A GROCERY STORE WHEN THE BRAKES WENT INTO A NON-POWER BRAKE MODE. I WAS ROLLING TO THE STOP SIGN. I PROBABLY WASN'T EVEN GOING 15 MPH. AS NOTHING HAPPENED WHEN I TOUCHED THE BRAKES, I HAMMERED THEM AND CAME TO A SHARP JERKING HALT. IT WAS A LITTLE FRIGHTENING AS ONCOMING TRAFFIC WAS GOING 45-50 MPH. THEN THE ABS AND BRAKE SYSTEM LIGHTING CAME ON. IF I HAD NOT KNOWN HOW NON-POWER BRAKES FELT, I PROBABLY WOULD HAVE SLID INTO ONCOMING TRAFFIC. THIS COULD HAVE BEEN FATAL. I SEE ONLINE A LOT OF COMPLAINTS WITH THIS SAME ISSUE WITH THE BRAKING SYSTEMS OF THE ESCAPE HYBRIDS. I AM NOT SURE WHY IT IS NOT COVERED ON THE 100,000 MILE/ 8 YR WARRANTY AND ALSO, WHY THERE HAS BEEN NO RECALL. I SEE THERE IS A RECALL FOR WINDSHIELD WIPERS. I SERIOUSLY THINK THIS IS A LITTLE MORE OF A SAFETY ISSUE. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE ABS WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT TRIED TO APPLY THE BRAKES BUT TO NO AVAIL. THE CONTACT HAD TO USE THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. THE VEHICLE WAS SHUT OFF AND RESTARTED HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR INSPECTION OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 80,000. THE VIN WAS UNAVAILABLE.

WHILE DRIVING, THE ABS COMES ON AND THE BRAKES BASICALLY ARE UNRESPONSIVE. I HAD TO SLAM ON THE BRAKES JUST TO GET THE CAR TO SLOW DOWN. LUCKILY I WASN'T GOING ANY FASTER OR THERE MIGHT HAVE BEEN A VERY SERIOUS ACCIDENT. I TOOK THE CAR TO MIDAS, AND THEY FIXED A FEW THINGS RELATED TO BRAKING AND SAID THAT THE CAR WOULD BE FINE NOW, BUT JUST A FEW DAYS LATER THE SAME ISSUE HAPPENED AGAIN. *TR

THE CHECK BRAKE SYSTEM MESSAGE APPEARS IN MESSAGE SYSTEM ON 2006 FORD ESCAPE HYBRID, WITH THE ACCOMPANYING BRAKE WARNING SYMBOL LIGHT COMING ON. THE BRAKE PEDAL SEEMS TO LOSE SOME PRESSURE IN THE PEDAL AND GOES FURTHER TO THE FLOOR. THE BRAKE FLUID RESERVOIR IS FULL, SO THE BRAKE FLUID IS NOT LOW. THIS HAS HAPPENED ON AND OFF NOW FOR THE LAST FEW DAYS. I HAD A BRAKE JOB DONE ON THE REAR BRAKES 2 MONTHS AGO, AND THE DEALERSHIP SAYS THE FRONT BRAKES ARE FINE. THEY RECOMMEND REPLACING THE MASTER CYLINDER FOR 1300 DOLLARS, AND THEN STATE THAT IT MIGHT NOT SOLVE THE PROBLEM AND THEY WOULD THEN HAVE TO REPLACE A CONTROL MODULE FOR ABOUT 4500 TO 5000 DOLLARS. I NOTICED ONLINE THAT A LOT OF PEOPLE SEEM TO BE HAVING THIS SAME PROBLEM WITH THE FORD ESCAPE HYBRID FROM 2005 TO 2006, AND THEY ARE INCURRING THE SAME COSTLY REPAIR. SOME OF THEM COMPLAINED ABOUT LOSING POWER TO THE BRAKING SYSTEM. *TR

ABS CONSTANT ACTIVATION, THEN ABS SYSTEM OFF. FOUND A CRACKED TONE RING ON DRIVER SIDE FR WHEEL. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT WAS DRIVING 30 MPH AND DEPRESSED THE BRAKE PEDAL BUT THE VEHICLE WOULD NOT RESPOND. THE CONTACT STATED THAT THE BRAKE PEDAL WAS DEPRESSED INTO THE FLOORBOARD ABNORMALLY AND THE VEHICLE WOULD NOT SLOW DOWN COMPLETELY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY INFORMED THE CONTACT THAT ABS TONE RING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED SEVERAL TIMES. THE MANUFACTURER WAS NOTIFIED AND STATED THAT THEY WOULD FILE A REPORT. THE FAILURE MILEAGE WAS 20,000.

TONE RING FAILURE ON ABS SYSTEM. BRAKE FADE UNTIL COMPUTER NOTED SENSOR FAILURE AND INDICATES ABS FAILURE LIGHT. TONE RING WAS BROKEN $12.45 PART LABOR $226.00 I AM TOLD IT IS A VERY COMMON PROBLEM WITH THE ESCAPES WHERE A PLASTIC RING COMES UNGLUED AND CAUSES THE ABS TO ENGAGE WHEN IT IS NOT NECESSARY. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING AT AN UNKNOWN SPEED, THE SRS BRAKE WARNING LIGHT ILLUMINATED WHILE THE CONTACT WAS APPLYING THE BRAKES. IN ADDITION, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD ABNORMALLY AND THE VEHICLE FAILED TO STOP. THE CONTACT APPLIED EXTREME PRESSURE TO THE BRAKES IN ORDER TO STOP THE VEHICLE AS THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED AND RESUMED NORMAL OPERATION. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSIS AND THE CONTACT WAS ADVISED THAT THE ANTI-LOCK BRAKE HYDRAULIC UNIT AND MASTER CYLINDER WOULD NEED REPLACING, AND TWO GALLONS OF BRAKE FLUID WAS NEEDED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 95,000.

ABS LIGHT AND BRAKE LIGHT CAME ON WHEN I GOT INTO THE CAR TO GO TO WORK AFTER DRIVING IT THE PREVIOUS DAY WITH NO PROBLEMS. BRAKE PEDAL BECAME SOFT AND BRAKING WAS NOT SMOOTH AND WHEN BRAKE PEDAL WAS PRESSED IT MADE A SQUEALING NOISE. DEALER DIAGNOSED IT AS A FAULTY ABS MODULE REPLACEMENT COST OF $3000. *TR

MY VEHICLE'S EMERGENCY BRAKE HAS NEVER PREVENTED MY VEHICLE FROM MOVING FORWARD UNDER POWER. IT DOESN'T HOLD ON A HILL. IF YOU TAKE YOUR FOOT OFF THE BRAKE PEDAL AFTER APPLYING THE EMERGENCY BRAKE, THE VEHICLE WILL LURCH FORWARD MAKING A GRATING SOUND. HAVING THE VEHICLE IN PARK POSITION ON THE GEAR SHIFT IS WHAT HOLDS THE VEHICLE ON A HILL. I HAVE HAD BRAKES CHECKED AT THE DEALER A NUMBER OF TIMES AND THEY TELL ME THAT THIS THE NATURE OF THE BEAST. I RECENTLY HAD MY DIFFERENTIAL REPLACED TO REMOVE A HOWLING SOUND IN THE REAR OF MY VEHICLE AFTER HAVING THE PARKING BRAKE ADJUSTED.(COST 3000 DOLLARS) SOUND HAS DIMINISHED BUT NOT DISAPPEARED ALTOGETHER. NOW I WONDER IF THE DIFFERENTIAL NEEDED REPLACEMENT. ALSO WHEN THE DEALER DID THIS REPAIR, THEY TOLD ME THAT I HAD MY RIGHT REAR EMERGENCY BRAKE PAD MISSING AND THAT THEY COULD REPLACE IT FOR AN ADDITIONAL $300. I HAVE NOT REPLACED IT YET. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE REAR WINDSHIELD DETACHED FROM THE VEHICLE. THE VEHICLE WAS STOPPED AND THE CONTACT NOTICED THAT THE HINGES FOR THE WINDSHIELD WERE BROKEN. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED. THE CONTACT REPAIRED THE VEHICLE HIMSELF. THE CONTACT ALSO STATED THAT WHILE DRIVING 40 MPH IN SNOWY CONDITIONS, HE APPLIED TO BRAKES AND THE ANTI LOCK BRAKE WARNING LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 45,000.

THE BRAKES FAIL ON A REGULAR BASIS WHILE SLOWING DOWN FROM SPEEDS BETWEEN 10 AND 35 MPH. IT OCCURS AS A SUDDEN RELEASE OF BRAKING PRESSURE WHILE STEPPING ON THE BRAKE PEDAL TO SLOW DOWN. AT THAT TIME A MOMENTARY WARNING LIGHT COMES ON FOR SEVERAL SECONDS AND THE SYSTEM APPEARS TO GO INTO A FAIL-SAFE MODE THAT ALLOWS MANUAL OPERATION OF THE BRAKES. THIS CAUSES A LARGE INCREASE IN BRAKING DISTANCE AND I CONSIDER IT VERY DANGEROUS. THIS FAILURE SEEMS TO BE RELATED TO THE HYBRID BRAKING SYSTEM AND MAY BE COMMON TO OTHER HYBRID VEHICLES. AFTER STOPPING THE WARNING LIGHT GOES AWAY AND THE BRAKES WILL AGAIN FUNCTION NORMALLY. THE FAILURE DOES NOT OCCUR CONTINUOUSLY BUT IT DOES OCCUR ALMOST EVERY DAY THAT IT IS DRIVEN. THE CAR HAS BEEN IN A REPAIR SHOP NUMEROUS TIMES WITH MANY PART REPLACED BUT THE PROBLEM CONTINUES TO EVADE OUR FLEET MECHANICS. THIS IS AN INHERENT PROBLEM WITH THIS VEHICLE AND COMMONLY KNOWN WHERE THERE ARE LARGE FLEETS OF HYBRID VEHICLES. MY CO-WORKER DRIVES THE SAME TYPE OF ESCAPE HYBRID AND HE HAS THE SAME FAILURE. PLEASE INVESTIGATE WITH FORD AND/OR TOYOTA. A SIMILAR PROBLEM HAS BEEN SEEN WITH TOYOTA PRIUS IN OUT FLEET. *TR CONSUMER STATED AT SOME PERIOD AROUND 2014-15 THE CAR WAS SENT TO THE FLEET DEPT AGAIN FOR BRAKING PROBLEMS AND THERE WAS SOME BREAKTHROUGH WITH REPAIRS. VEHICLE WAS TRANSFERRED TO DIFFERENT NYCDEP DRIVER FOR A COUPLE OF YEARS. VIN NUMBER NOT AVAILABLE BUT COULD INQUIRE WITH CONSUMER'S TRANSPORTATION SECTION. UPDATED 6/11/18*JB

"ABS" WARNING LIGHT ILLUMINATED AND "SERVICE BRAKE SYSTEM" APPEARED ON DISPLAY. APPLIED BRAKE PEDAL AND ANTI-LOCK ENGAGED CAUSING A "CHATTERING" SOUND FROM BRAKES AND SEVERE VIBRATION. EXTRA PRESSURE ON BRAKE PEDAL NEEDED TO BRING VEHICLE TO A SAFE STOP. *TR

TONE RING FAILURE ON ABS BRAKE SYSTEM ON 2006 FORD ESCAPE. BRAKE FADE UNTIL COMPUTER SYSTEM NOTES SENSOR FAILURE AND INDICATES ABS FAILURE LIGHT. THE SYSTEM DOES THIS FOR EACH ENGINE STARTUP--BRAKE FADE UNTIL ERROR CODED OUT. A CHEAPLY MADE PIECE, LOW PARTS REPLACEMENT BUT EXPENSIVE MECH REPAIR REQUIRING REMOVAL OF CALIPER AND AXLE HUB....ALL ITEMS THAT ARE WELL RUSTED INTO PLACE. AN EXTREMELY POOR DESIGN FOR SUCH AN IMPORTANT SAFETY FEATURE. *TR

BRAKE LIGHT COMES ON, SERVICE BRAKE SYSTEM MESSAGE ON DASH DISPLAYS, AND ABS LIGHT DISPLAYS. VEHICLES BRAKES FAIL AND EVEN WHEN APPLYING BRAKE PEDAL COMPLETELY VEHICLE DOES NOT STOP COMPLETELY WITHOUT PUMPING BRAKES SEVERAL TIMES OR USING EMERGENCY BRAKE. THIS HAPPENED A COUPLE TIMES LAST WEEK (WITHOUT WARNING LIGHTS) AND TOOK IT TO A LOCAL MECHANIC WHO INSPECTED BRAKES AND ADVISED EVERYTHING LOOKS FINE. OCCURRED AGAIN THIS EVENING WITH WARNING LIGHTS. TURNED OFF VEHICLE & RESTARTED AND NO LIGHTS AND NO PROBLEM BRAKING. RESEARCHED ONLINE AND THERE ARE NUMEROUS COMPLAINTS OF THIS IN BLOGS, COMMENTS, ETC. *TT

WHILE TRAVELING HOME ON AN INTERSTATE AT 70 MPH THE RED BRAKE LIGHT CAME ON AFTER A LIGHT BREAKING SITUATION. I DID THE SYSTEM CHECK AVAILABLE ON THE VEHICLE AND THE BRAKE FLUID WAS SHOWN AS OK. THE BRAKE PADS WERE REPLACED NOT LONG AGO SO I WAS CONFUSED. A SHORT TIME LATER THE YELLOW ABS LIGHT CAME ON. WHEN I WENT TO BRAKE MY FOOT WENT TO THE FLOORBOARD AND THE VEHICLE WAS NOT STOPPING. I SWERVED ONTO THE SHOULDER OF THE INTERSTATE TO AVOID AN ACCIDENT. IT TOOK A GREAT DISTANCE ( I WOULD SAY MORE THAN 100 YARDS ) FOR THE VEHICLE TO STOP. I WAS NEVER SO SCARED IN MY LIFE. I DROVE HOME ON SIDE STREETS AT 25 MPH WITH MY WARNING LIGHTS FLASHING AND VIRTUALLY NO BRAKES. AFTER TAKING THE VEHICLE TO A FORD DEALERSHIP I RESEARCHED THE BREAK FAILURE ISSUE AND TO MY AMAZEMENT FOUND NUMEROUS OTHER SUCH INCIDENTS. AFTER FIVE DAYS IN THE REPAIR SHOP AND THREE FAILED ATTEMPTS BY THE TECHNICIAN TO BLEED THE BREAK LINES I WAS TOLD THAT I NEEDED A $4200 COMPUTER CONTROL UNIT. I BELIEVE THIS IS A SERIOUS DESIGN FLAW IN THE ELECTRICALLY CONTROLLED BREAK SYSTEM OF THE HYBRID VEHICLE AND NO PERSON SHOULD HAVE TO GO THROUGH THE TERROR OF ATTEMPTING TO STOP FROM 70 MPH WITH THE BREAKING SYSTEM SHUT DOWN. THIS IS A TIMEBOMB WAITING TO GO OFF IN THE FORM OF A FATAL ACCIDENT.

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT SPEEDS GREATER THAN 5 MPH, THERE WAS A LOUD GRINDING NOISE FROM THE VEHICLE. THE ABS AND 4-WHEEL DRIVE WARNING LIGHTS WERE ILLUMINATED ON THE INSTRUMENTAL PANEL. THE DEALER WAS CONTACTED AND THEY ADVISED HIM THAT THE FAILURE WAS COMMON IN THAT PARTICULAR YEAR, MAKE AND MODEL VEHICLE. THE FAILURE AND CURRENT MILEAGE WAS APPROXIMATELY 53,900.

*THIS IS THE SECOND TIME THAT I HAVE HAD A COMPLETE "BRAKE FAILURE" WHILE DRIVING MY 2006 FORD ESCAPE HYBRID IN TRAFFIC. THIS LAST TIME, I WAS DRIVING ON A FREEWAY IN BEDFORD, TEXAS AND OBSERVED THAT TRAFFIC IN THE DISTANCE WAS STOPPING FOR CONSTRUCTION. I APPLIED MY BRAKES BUT THE PEDDLE WENT TO THE FLOOR. I HAD TO EXIT THE ROADWAY ONTO THE SHOULDER TO AVOID OTHER VEHICLES. I PUT MY VEHICLE IN LOW GEAR FROM DRIVE AND APPLIED MY EMERENGY BRAKE TO STOP MY CAR. THIS IS THE "SECOND" TIME I HAVE HAD TO TAKE EVASIVE ACTION TO AVOID A COLLISION WITH THIS BAKE PROBLEM. THE "ABS" LIGHT CAME ON, THE RED BRAKE LIGHT CAME ON, AND THERE WAS A COMPUTER MESSAGE ON THE DASH THAT READ "SERVICE BRAKE SYSTEM". THE FIRST TIME THAT I EXPERIENCED THIS SAME PROBLEM, I TOOK MY CAR INTO THE DEALERSHIP IN FOR WARRANTY REPAIR. THEY ADVISED THAT SINCE THE "CODE LIGHTS" WERE NOT ON AT THIS VERY MOMENT, THEY WERE NOT ABLE TO DIAGNOSIS THE PROBLEM. I WAS INSTRUCTED TO DRIVE THE ESCAPE UNTIL THE "CODE LIGHTS" CAME BACK ON AND THEN BRING IT BACK FOR SERVICE!!! I COMPLIED TO THIS REQUEST AND BOUGHT THE TRUCK BACK IN WITH THE "CODE LIGHTS" ON AND THE MESSAGE READING. DEALERSHIP WORKED ON THE VEHICLE FOR SEVERAL DAYS AND THE ASSIST SERVICE MANAGER DROVE IT FOR A COUPLE OF DAYS TO CHECK IT OUT. THE TRUCK WAS RETURNED TO ME WITH ASSURANCE THAT THE "BRAKE PROBLEM" WAS FIXED. ON JULY 9, 2011, I AGAIN HAD A "COMPLETE BRAKE FAILURE" WITH MY TRUCK(SEE ABOVE) ON JULY 11, 2011, I TOOK MY ESCAPE HYBRID BACK TO THE DEALERSHIP AND ADVISED THE ASSISTANT SERVICE MANAGER, ABOUT THE PROBLEM AND WHAT ALMOST HAPPENED TO ME IN TRAFFIC. I ALSO SHOWED HIM SOME OF THE OTHER COMPLAINTS ABOUT THIS SAME TYPE OF "BRAKE FAILURE" THAT HAS OCCURRED ON OTHER FORD ESCAPE HYBRIDS. I HAVE ALSO CALLED FORD CORPORATE TO START A COMPLAINT! "DOES IT TAKE SOMEONE GETTING KILLED OR INJURIED BEFORE SOMETHING IS DONE?" INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT *CN

BRAKE FAILURE RESULTING IN THE BRAKE PEDAL GOING TO THE FLOOR AND A LOSS OF HYDRAULIC OR POWER BRAKING. VEHICLE DOES STOP AFTER A HARD PRESSING OF BRAKE PEDAL. THIS IS SOMETIMES FOLLOWED BY A YELLOW ABS LIGHT AND RED BRAKE LIGHT WARNING. THE PROBLEM IS FIXED BY TURNING THE CAR OFF AND BACK ON. I AM NOT KIDDING. ITS LIKE REBOOTING THE COMPUTER. THIS STARTED ABOUT 2 YEARS AGO. I REPORTED IT TO FORD WHO SAID THEY DO NOT KNOW ANYTHING ABOUT IT AT THE DEALER AND NATIONAL LEVEL. I TOOK THE CAR IN FOR AN OIL CHANGE AT THE DEALERSHIP AND MENTIONED THE INTERMITTENT BRAKE FAILURE. AFTER THE OIL SERVICE, THE PROBLEM WENT AWAY FOR A YEAR. I THOUGHT FORD HAD SECRETLY FIXED IT WHILE THEY WERE CHANGING THE OIL. THEN ABOUT A WEEK AGO THE PROBLEM HAS RETURNED AND HAS HAPPENED 10 TIMES. I THINK IT IS RELATED TO THE CAR NOT HAVING ENOUGH POWER BECAUSE THIS HAPPENS WHILE THE ICE (INTERNAL COMBUSTION ENGINE) IS OFF. PERHAPS IT IS RELATED TO RUNNING THE AIR CONDITIONING SINCE IT STOPPED AFTER THE SUMMER AND RETURNED AGAIN. THE ICE TURNS OFF WHILE BRAKING AT SPEEDS BELOW 40MPH SO THAT IS PROBABLY RELATED. *TR

THE ABS RING (TONE RING ACCORDING TO FORD) ON THE FRONT RIGHT AXLE FRACTURED DURING DRIVING. THIS SENT A FALSE SIGNAL TO THE PROCESSOR AND APPLIED THE ABS WHILE THE VEHICLE WAS TRAVELLING AT HIGHWAY SPEEDS. THIS EXTENDED THE BRAKING DISTANCE TO AN UNSAFE AND UNPREDICTABLE LENGTH ON DRY PAVEMENT. TWO MONTHS AFTER THE FIRST INCIDENT AND REPLACEMENT OF THE FRONT RIGHT RING THE FRONT LEFT RING BROKE AGAIN SETTING OFF THE ABS AT AN UNPREDICTABLE TIME.

STANDARD DAY DRIVING. GET IN THE VEHICLE START AS NORMAL. DRIVE 25 FEET DOWN THE ROAD, SMALL HESITATION, RESISTANCE TO GO FORWARD FOR A MOMENT. ABS LIGHT ILLUMINATES, WARNING BEEP OCCURS. VEHICLE DRIVES ODD, BRAKES ARE WEAKER THAN NORMAL. SERVICE ABS SYSTEM ILLUMINATES ON CENTER PANEL. MOMENTS LATER, SERVICE 4X4 SYSTEM ILLUMINATES AS ANOTHER SMALL HESITATION RESISTANCE TO ROLL OCCURS. VEHICLE DRIVES 'OK' BUT DIFFERENT. DROVE IT HOME SAFELY FROM THAT MOMENT. *TR

TL*THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH, THE BRAKE PEDAL BEGAN TO PULSATE EXCESSIVELY WHEN PRESSURE WAS APPLIED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR DIAGNOSTIC TESTING. THE ABS SENDING UNIT WAS REPLACED; HOWEVER THE FAILURE CONTINUED TO OCCUR AFTER THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 46,200. UPDATED 07/08/11 *BF UPDATED 3/16/12 *CN

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE BRAKE SYSTEM FAILED WITH THE ILLUMINATION OF THE ABS WARNING LAMP. THE CONTACT ALSO MENTIONED THAT HE WAS ABLE TO STOP THE VEHICLE BY USING THE EMERGENCY BRAKE. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS NOT INCLUDED IN RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 07V156000 (SERVICE BRAKES, HYDRAULIC:ANTILOCK:CONTROL UNIT/MODULE). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 64,000.

I JUST BOUGHT A 2006 FORD ESCAPE HYBRID. THE SERVICE BREAK SYSTEM LIGHT AND MESSAGE CAME ON MONDAY, THE 2ND TIME I DROVE IT, ON THE WAY TO WORK. I STOPPED AT A GAS STATION BUT IT TURNED OFF. NEXT MORNING, SAME THING SO I CHECKED FLUIDS. IT WAS OFF AGAIN THE REST OF THAT DAY. LIT UP AGAIN WEDNESDAY. I MADE IT THAT EVENING TO A SERVICE STATION BEFORE THEY CLOSED (VERY RURAL AREA). THE WARNINGS WERE NOT ON AND HE COULD NOT SEE ANYTHING OBVIOUS ON PRELIMINARY INSPECTION BUT SAID TO BRING IN IN THE MORNING IF THE WARNING WAS BACK. THURSDAY IT ACTED FUNNY ON MY DRIVEWAY. THE NEXT CURVE I FOUND OUT WHY, NO BREAKING POWER EVEN WITH THE EXTREMELY STIFF AND DIFFICULT PEDAL TO THE FLOOR. I FINALLY GOT IT TO A STOP WAY PAST THE CRAZY RIDE AROUND THE CURVE. I STOPPED TO CALM MYSELF AND DECIDE IF IT WAS POSSIBLE TO GET TO TOWN. I DECIDED THE E-BRAKE SEEMED TO STOP IT IF I KEPT IT VERY SLOW. SO I PROCEEDED TO TOWN-NOT TO A FORD DEALER BECAUSE OF SOME VERY SCARY BIG HILLS, BUT INSTEAD TO THE SERVICE STATION WHO I TRUST. HE WAS BOOKED A WEEK AND A HALF AND HE DIDN'T KNOW IF HIS COMPUTER HAD THE HYBRID PROGRAMMING TO CHECK IT. SO I HAD TO TOW IT 63M TO THE DEALER I GOT IT FROM, THINKING THEY WOULD STAND BY IT OR IT WOULD BE COVERED BY THE "DRIVETRAIN PLUS" SERVICE AGREEMENT I PURCHASED TO COVER ANY SCARY PRICED REPAIRS THAT CROP UP ON OLDER CARS. IT WAS SOLD AS-IS, AND IOWA HAS NO LEMON LAW APPARENTLY, THE PLAN I PURCHASED SOUNDS LIKE IT WON'T COVER IT, AND THEY OFFERED ME A MEASLY 10% OFF THE BILL THAT IS ABOUT HALF AGAIN WHAT I PAID FOR THE CAR. I GOT TO DRIVE MY NEW USED CAR 4 1/2 TIMES. ALL I CAN DO IS THANK MY LUCKY STARS MY KIDS WEREN'T IN THE CAR, THERE WASN'T A CAR NEAR ME, I WASN'T COMING DOWN ONE OF THE STEEP AND CURVY RIVER BLUFFS ON MY WAY TO OR FROM WORK, OR ANY NUMBER OF OTHER SCARY SCENARIOS THAT COULD HAVE BEEN. FALIURE OF THE BRAKE SYSTEM'S HYDRAULIC CONTROL UNIT HCU AND MASTER CYLINDER IS EXTREMELY DANGEROUS AND A DESIGN FLAW MANY HAVE EXPERIENCED.

IN 12/2006, MY FORD ESCAPE HYBRID BEGAN MALFUNCTIONING. I WOULD GET A "SERVICE BRAKE SYSTEM" MESSAGE AND THE EMERGENCY BRAKE LIGHT WOULD APPEAR. I BROUGHT IT IN TO CHAMPION FORD IN BOULDER, CO 3 TIMES. THE FIRST 2 TIMES THEY REFUSED TO ACKNOWLEDGE THE PROBLEM. THE 3RD TIME THEY ACKNOWLEDGED THE PROBLEM AFTER I GAVE THEM INFORMATION FROM THE INTERNET AND THE TSB. WITH COOPERATION FROM FORD SERVICE THEY PERFORMED A GROUND/HARNESS REPLACEMENT. CHAMPION FORD THEN WENT OUT OF BUSINESS. OVER THE NEXT 4 YEARS, I BROUGHT MY CAR TO SILL-TERHAR FORD IN BROOMFIELD, CO FOR THE SAME ISSUE AND ADDITIONAL 6 TIMES, WHERE THEY PERFORMED THE SAME SERVICE (REPLACE GROUND/HARNESS). NOW, THEY ARE SAYING THE FIX REQUIRES A NEW ABS MODULE ($4,000). THROUGH MY OWN RESEARCH, I HAVE DISCOVERED THAT THIS PROBLEM IS RAMPANT WITH OTHER OWNERS LOSING THEIR BRAKES. I NEVER LOST MY BRAKES, BUT AFTER DISCUSSING THIS WITH MY CURRENT FORD SERVICE REP, HE SUGGESTS THAT MY PROBLEM COULD RESULT IN "IMPROPER" BRAKING BEHAVIOR, WHICH MEANS I'VE BEEN DRIVING AN UNSAFE VEHICLE FOR 4 YEARS BASED ON FORD'S SERVICE RECOMMENDATION FOR MY PROBLEM. FORD IS REFUSING TO ACCEPT RESPONSIBILITY FOR MY PROBLEM, EVEN THOUGH WHEN MY PROBLEM STARTED, I WAS UNDER WARRANTY. *TR

2006 FORD ESCAPE XLT, C/O LEFT FRONT ABS (ANTI LOCK BRAKING SYSTEM) TONE RING FAILURE... AT 94,782 MILES ON MY ODO MY LEFT FRONT ABS TONE RING BROKE COMPLETELY IN-HALF CAUSING A ABS SENSOR FAILURE AND THE BRAKES BECAME TEMPORARILY SEMI-UNRESPONSIVE FOR A FEW SECONDS ( 3-5 SECONDS ) WHEN I PRESSED ON THE BRAKES TO STOP THE CAR. BRAKING WAS GREATLY REDUCED AS IF THE CAR THOUGHT I WAS SLIDING ON ICE OR SNOW. AFTER THE SYSTEM DETECTED FAILURE ( 3-5 SECONDS) THE ABS LIGHT CAME ON IN MY DASHBOARD AND THE ABS SYSTEM SEEMED TO BE DEACTIVATED BY THE CAR. WHEN I GOT HOME AND TOOK THE LEFT FRONT WHEEL OFF AND INSPECTED MY BRAKES AND ABS SENSOR, I NOTICED THE LEFT FRONT ABS TONE RING WAS COMPLETELY RUSTED, FREE SPINNING LOOSELY AROUND THE AXLE AND WAS BROKEN COMPLETELY ON ONE END. I WENT ONTO GOOGLE AND RESEARCHED THIS PROBLEM AND FOUND THAT MANY OTHER PEOPLE HAVE ENCOUNTERED THE SAME PROBLEMS ON THEIR FORD ESCAPES. I WOULD LIKE THIS TO BE INVESTIGATED AS I THINK THAT PERHAPS THE ABS TONE RINGS FORD USED ARE FAULTY AND COULD POSE A DANGER TO MOTORIST BY CAUSING SIGNIFICANT LOSS OF BRAKING ABILITY OVER A FEW SECONDS AS DIRECT RESULT OF THE ABS TONE RING FAILURE. THE ABS TONE RING IS REPLACEABLE BY FORD OR YOU CAN BUY THE PART AT A PARTS STORE. REPAIR DOES INVOLVE REMOVING PART OF THE AXLE, SO IT IS BEST DONE BY A MECHANIC OR TRAINED PROFESSIONAL. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT WAS TRAVELING 50 MPH WHEN THE ABS WARNING LIGHT ILLUMINATED. THE CONTACT APPLIED THE BRAKES AND THERE WAS A REDUCTION OF 80% BRAKING POWER. THE CONTACT REFERENCED TECHNICAL SERVICE BULLETIN 10024326 (SERVICE BRAKE: CONTROL UNIT MODULE) AND BELIEVED THE FAILURE TO BE THE SAME. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 81,000. UPDATED 4/4/11 *CN THE REPAIR SHOP INSTALLED A MASTER CYLINDER. UPDATED 05/23/11

I WAS DRIVING HOME FROM WORK, GOING ABOUT 35 MPH WHEN I FELT MY CAR START TO SLID LIKE IT WAS ON ICE EVEN THOUGH THE PAVEMENT WAS DRY. MY ABS LIGHT AND MY SERVICE 4WD LIGHT CAME ON. I HAD A VERY HARD TIME GETTING HOME BECAUSE THE BRAKES WERE FAILING. I CAME HOME GOOGLED IT AND REALIZED THAT IT WAS MY TONE RING AND THAT IT WAS A COMMON PROBLEM. SURE ENOUGH NEXT DAY TOOK IT TO A FORD DEALERSHIP AND THAT'S WHAT IT WAS. THE PROBLEM DATES BACK TO 2000 FORD ESCAPES AND AS RECENT AS 2010 FORD ESCAPES. THE MECHANIC AT THE DEALERSHIP ADVISED ME THAT THE RING COULD SNAP JUST FROM TURNING A CORNER. I DON'T KNOW WHY FORD ISN'T BEING REQUIRED TO FIX THIS ISSUE. WHY ARE THE BEING ALLOWED TO PUT THIS SAME PRODUCT IN THE VEHICLE YEAR AFTER YEAR KNOWING ITS INFERIOR. WHEN THE RING BREAKS IT MAKES IT VERY HARD TO STOP THE CAR WHICH IS A HUGE SAFETY HAZARD.

FORD ESCAPE HYBRID 2006 ABS AND BRAKE FAILURE LIGHT COME ON, LOSE POWER BRAKING. MUST PUSH VERY HARD ON BRAKE PETAL TO STOP CAR, HAS HAPPENED APPROX. 8 TIMES. AFTER STOPPING CAR, I CAN USUALLY TURN KEY OFF AND THEN RESTART CAR AND PROBLEM IS GONE. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT WHILE DRIVING 20 MPH, THE ABS WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY THE DEALER WHO INFORMED THE CONTACT THAT THEY WERE UNABLE TO PERFORM A FULL DIAGNOSIS AND WAS UNABLE TO DUPLICATE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 54,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 59,000.

LETTER FROM SENATOR DENT ON BEHALF OF CONSTITUENT REGARDING A 2006 FORD ESCAPE HYBRID (DOT/I # 2010-2203) *TGW THE CONSUMER STATED A WARNING LIGHT ILLUMINATED TO SERVICE THE BRAKE SYSTEM. THE CONSUMER STATED IT COST $120 TO DIAGNOSE THE PROBLEM AS A FAULTY HYDRAULIC COMPUTER MODULE AND THE COST TO REPLACE IT WOULD BE $ 5,000. *JB

BRAKES ON MY 2006 FORD ESCAPE HYBRID FAILED AT HIGHWAY SPEED AND THE ABS AND BRAKE LIGHT CAME SIMULTANEOUSLY. BY PINNING THE BRAKE TO THE FLOOR I WAS ABLE TO SLOW THE VEHICLE IN THE SHOULDER. TURNING THE CAR OFF AND BACK ON "RESOLVED" THE ISSUE AND I WAS ABLE TO DRIVE HOME. THE PROBLEM HAPPENS RANDOMLY AND WITHOUT WARNING. I HAVE PLACED A CALL TO THE DEALER BUT HAVE NOT HEARD BACK YET. LOOKING ON LINE IT SEEMS TO BE A COMMON PROBLEM, YET NO RECALL HAS BEEN ISSUED FOR THIS VERY DANGEROUS SITUATION. *TR

2006 FORD ESCAPE HYBRID - INTERMITTENT POWER BRAKE BOOST FAILURE. WHEN BEGINNING TO PRESS ON BRAKES FOR AN INSTANT THEY FEEL NORMAL AND POWER ASSISTED, THEN THE PEDAL FALLS AND ALL POWER ASSIST IS GONE. THE VEHICLE STOPS WITH GREAT PRESSURE IN THE LAST FEW INCHES OF PEDAL TRAVEL. 3 OCCURRENCES: AS OF OCTOBER 4, 2010 1. MAY 2010 AT THE END OF A FREEWAY OFF RAMP AT APPROXIMATELY 160,000 MILES ON THE VEHICLE 2. 24 SEPTEMBER , 2010 ( APPROXIMATELY 180,000 MILES ON THE VEHICLE) SAME BRAKE PROBLEM OCCURRED AFTER A STOP OF OVER 30 MINUTES, AND WHEN THE VEHICLE WAS BACKED UP, FIRST BRAKE PRESSING RESULTED IN AN INSTANT OF PEDAL , THEN PEDAL SNAPPING TO THE FLOOR AND CAR STOPPING AFTER APPLICATION OF MANUAL PRESSURE. DASH INDICATOR LIGHTS CAME ON A FEW SECONDS LATER. 3. ONE WEEK TO THE DAY LATER, 1 OCTOBER, 2010 AT APPROXIMATELY 188,500 MILES. FIRST BRAKE APPLICATION AFTER A START OF THE VEHICLE AND BACKING UP. PRESSING BRAKES RESULTED IN THE FAILURE DESCRIBED. APPROXIMATELY 30 OR 40 SECONDS AFTER THE LOSS OF BRAKE BOOST THE DASHBOARD LIT UP WITH "BRAKES" RED LIGHT AND OTHERSLIKE THE 'SERVICE SOON' WRENCH. I AM THE PURCHASER OF THE CAR NEW IN THE LOS ANGELES, CALIFORNIA AREA, AND THE PRIMARY ( OVER 90% OF THE TIME) DRIVER, COVERING OVER 110 MILES 4 DAYS A WEEK. *TR

TL* THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 50 MPH, THE ABS LIGHT AND FOUR WHEEL DRIVE LIGHT SUDDENLY ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS DRIVEN TO THE CONTACT'S RESIDENCE AND PARKED. UPON RESTARTING THE VEHICLE, THE CONTACT NOTICED THAT NONE OF THE LIGHTS WERE ILLUMINATED; HOWEVER, AFTER DRIVING APPROXIMATELY 4 MILES, THE LIGHTS ILLUMINATED AGAIN. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE FAILURE CONTINUED TO OCCUR. THE FAILURE MILEAGE WAS 70,683 AND THE CURRENT MILEAGE WAS 70,890.

I OWN A 2006 FORD ESCAPE. IT HAS 70,683 MILES ON IT. I WAS DRIVING ON THE HIGHWAY (50 MPH) AND NOTICED THE ABS LIGHT ON AND THE 4WD LIGHT WAS FLASHING. THIS HAS OCCURRED TWICE IN THE LAST TWO DAYS. THE FIRST OCCURRENCE, I ADDED BRAKE FLUID AND THE LIGHTS WENT OUT. THIS HAPPENED AGAIN TWO DAYS LATER ON THE HIGHWAY AND AROUND THE SAME RATE OF SPEED.. *TR

I HAVE A 2006 FORD ESCAPE WITH ONLY 46,708 MILES AND MY ABS/AWD LIGHTS AND HAVE BEEN GOING ON AND OFF JUST OUT OF NOWHERE. ALSO, RELATED TO THIS WHEN I PRESS DOWN ON MY BRAKES THERE IS A LOUD SCRAPING NOISE THAT IT MAKES. I HAVE DONE SOME RESEARCH AND IT LOOKS LIKE IT COULD BE A BAD TONE RING (ABS RING) AND SEEMS VERY COMMON WITH THIS TYPE OF VEHICLE. I HAVE LOOKED AROUND AND MOST SERVICE REPAIR PLACES WANT TO REPLACE THE ENTIRE AXLE FOR AROUND $600 DOLLARS. I SHOULD NOT BE HAVING THIS TYPE OF PROBLEM WITH A VEHICLE THAT I HAVE HAD FOR ONLY ABOUT A YEAR OR SO. PLEASE INVESTIGATE THIS ISSUE WITH THIS TYPE OF VEHICLE. THANK YOU!!! *TR

A COUPLE MONTHS AGO, I TOOK MY ESCAPE HYBRID TO HAVE THE BRAKES CHECKED OUT. NEEDLESS TO SAY, THEY CHECKED IT OUT AND SAID EVERYTHING WAS FINE AND I WAS ON MY WAY A COUPLE OF HOURS LATER. THEN YESTERDAY, MY ABS AND BRAKE LIGHTS ILLUMINATED AND THEN CHECK BRAKE SYSTEM CAME ON. AFTER THIS OCCURRED, MY BRAKES GO OUT AND THEN I MUST COME TO A ROLLING STOP ON THE SIDE OF THE ROAD WHILE TRYING TO AVOID HITTING ANYONE. IT OCCURRED 6 TIMES AT DIFFERENT SPEEDS (20MPH & 70MPH) I THEN RETURNED IT TO THE DEALERSHIP YESTERDAY AND ASKED THEM TO LOOK OVER IT. TODAY, I AM TOLD THAT I NEED A NEW ABS SYSTEM INSTALLED WITH THE HYDRAULIC/ELECTRIC CONTROL UNITS TOTALLY $7,400. OF COURSE, THERE IS NO WARRANTY FOR THIS. I HAVE BEEN RESEARCHING THIS ISSUE ONLINE AND HAVE NOTICED SEVERAL POSTING REGARDING A SIMILAR ISSUE HOWEVER STILL NO RECALL. I WOULD ASSUME A FACTORY DEFECT REGARDING THE BRAKES WOULD BE SIGNIFICANT ENOUGH FOR A RECALL BEFORE SOMEONE GETS KILLED. *TR

I WAS DRIVING APPROXIMATELY 40 MILES PER HOUR, APPROACHING A RED LIGHT AND BUSY INTERSECTION. I APPLIED BRAKES (VIA PEDAL) AS USUAL, BUT HAD NO BRAKING POWER / CORRESPONDING SLOWDOWN. I HAD TO JAM MY FOOT TO THE FLOOR AND COVER THE EMERGENCY BRAKE IN CASE I NEEDED IT, AND THANKFULLY I WAS THE FIRST CAR AT THE LIGHT SO THERE WAS NO ACCIDENT. THE REST OF THE DRIVE, IT TOOK AT LEAST 5 TIMES LONGER/MORE DISTANCE TO SLOW THE VEHICLE TO A STOP THAN NORMAL AND AT THE SAME MOMENT I LOST BRAKING POWER, A CHIME SOUNDED & BOTH THE ABS AND BRAKE(S) LIGHT ON THE DASH LIT UP; MESSAGE CENTER READ "SERVICE BRAKES SOON". I JUST HAD THE VEH IN FOR ITS 40K MILE SERVICE 2 DAYS AGO & IT HAD NOTHING WRONG WITH IT--BRAKES WERE ALL LISTED AS TOP CONDITION. NOW I'M ABSOLUTELY TERRIFIED TO DRIVE THE VEHICLE, UNSURE WHEN THIS CONDITION WILL RECUR (THE LIGHTS RESET & AND I CHECKED TODAY--THE BRAKES ARE WORKING AGAIN, FOR NOW.) WHEN THE CONDITION OCCURS, BRAKING IS AN ODD SLOW PULSING, LIKE A SLOWED DOWN VERSION OF AN EMERGENCY ABS STOP ("PUMPING THE BRAKES" FEELING.) I'VE NEVER HAD BRAKE PROBLEMS UNTIL THIS INCIDENT. WHEN I TURNED THE CAR OFF AND RESTARTED IT, THE ABS & BRAKE LIGHTS CLEARED AND, FOR NOW AT LEAST, THE BRAKES *SEEM* TO BE WORKING BUT I CAN'T CHANCE IT. GETTING IT TOWED FOR SERVICE. *TR

RED BRAKE LIGHT AND SERVICE BRAKE SYSTEM LIGHT A CONSTANT PROBLEM THAT HAS NOT BEEN FIXED. I HAVE HAD THIS PROBLEM SINCE MAY 2010 AND IT IS NOW AUGUST 2010 AND IT IS STILL NOT FIXED. WE OWN A 2006 FORD ESCAPE HYBRID. WE HAVE HAD NEW BRAKES, A NEW WIRE HARNESS, SOME OTHER TIP REPLACED, AND A SENSOR REPLACED. WE HAVE EVEN HAD A FORD ENGINEER LOOK AT IT. I HAVE BEEN CONCERNED ABOUT HAVING AN ACCIDENT BECAUSE I HAVE TWO SMALL CHILDREN. THE VEHICLENLY HAS 58,000 MILES AND I BELIEVE THAT THE PROBLEM IS THE ABS MODULE. BUT THE ABS MODULE SHOULD NOT BE GOING OUT AT 58,000 MILES. THIS PROBLEM HAS BEEN VERY FRUSTRATING. *TR

I WAS DRIVING IN TOWN, DOING NOTHING OUT OF THE ORDINARY WHEN THE VEHICLE SUFFERED COMPLETE ABS BRAKE SYSTEM FAILURE. I AM NOW AFRAID TO DRIVE IT. *TR

BRAKING SYSTEM DEFECTS IN FORD ESCAPE HYBRID 2006. THE BRAKES FAIL, MULTIPLE TRIPS TO THE DEALERSHIP HAVE NOT RESOLVED THE PROBLEM. THE PROBLEM HAS GOTTEN WORSE. *TR

CATASTROPHIC BRAKE FAILURE CAUSING PROPERTY DAMAGE AND DAMAGE TO CAR. WE HAVE TAKEN OUR VEHICLE TO A FORD DEALERSHIP TWICE IN PAST YEAR TO FIND OUT WHY OUR BRAKES "CATCH" CAUSING A MOMENTARY LOSS OF BRAKING. THEY TOLD US BOTH TIMES THAT THEY COULDN'T FIND ANY PROBLEM AND SENT US OUT WITHOUT AN ANSWER OR FIX. THEN YESTERDAY WHAT WE FEARED FINALLY HAPPENED; DURING BRAKING THE BRAKE PEDAL SUDDENLY WENT TO THE FLOOR AND THE BRAKES FAILED CAUSING THE VEHICLE TO PLOW INTO A GARAGE DOOR. THE CAR IS BACK AT THE DEALERSHIP NOW AND EVEN DURING DROP-OFF THEY TOLD US THAT THIS COULDN'T HAPPEN AND THAT WE WERE MISTAKEN. *TR

I AM THE OWNER OF A 2006 FORD ESCAPE HYBRID AND HAVE HAD AT LEAST FOUR EXPERIENCES OF MALFUNCTIONING SPEED SENSORS. THEY HAVE GIVEN ME CONCERN ABOUT THE SAFETY OF THE VEHICLE AND CAUSED ME INCONVENIENCE AND EXPENSES FOR REPAIR. THE TYPICAL INCIDENT INVOLVES A MALFUNCTIONING OF THE ABS AND 4X4 SYSTEMS, WITH WARNING LAMPS LIGHTING UP INDICATING THAT THERE IS A DANGER OF SKIDDING AND LOSS OF VEHICLE CONTROL. IN THREE INSTANCES I HAD THE PROBLEM DIAGNOSED AND REPAIRED BY FORD DEALERS, WHO REPORTED: "FOUND REAR WHEEL SPEED SENSOR TO BE FAULTY" (JAN. 08); "REPLACED THE FAILED RIGHT REAR WHEEL SPEED SENSOR" (SEPT. 08); "INSPECTED THE SENSOR AT THE RIGHT FRONT WHEEL AND FOUND THE TONE RING ON THE AXLE CRACKED. NEEDS NEW AXLE" (AUG. 09). TWO OF THESE WERE DONE ON WARRANTY; THE THIRD COST $344.95. ALL DEALERS HAVE GIVEN ASSURANCES THAT EVEN WITH WARNING LIGHTS INDICATING PROBLEMS AS DESCRIBED IT WAS "SAFE" TO CONTINUE DRIVING THE CAR UNTIL REPAIRS CAN BE MADE. ON MARCH 7 AND 8, 2010, WHILE ON A TRIP AWAY FROM HOME, THE SAME SYMPTOMS OCCURRED AGAIN. GIVEN EARLIER ASSURANCES BY DEALERS, I CONTINUED ON MY TRIP IGNORING AS BEST AS POSSIBLE THE WARNING LIGHTS, POPPING SOUNDS OF THE 4X4, AND OCCASIONAL SHUDDERING OF THE ABS SYSTEM. SURPRISINGLY, AFTER SOME HIGHWAY DRIVING (PERHAPS 50 MILES) THE WARNING SIGNALS STOPPED LIGHTING UP AND THE CAR SEEMED TO HANDLE FAIRLY NORMALLY. NOW, A FEW DAYS LATER, THE CAR CONTINUES TO OPERATE WITHOUT SIGNS OF MALFUNCTION, BUT IT REMAINS UNCLEAR WHETHER THE PROBLEM "FIXED ITSELF" OR THE COMPUTER-CONTROLLED READ-OUTS HAVE CEASED FUNCTIONING, THEREBY DISGUISING THE POSSIBLE PERSISTENCE OF THE UNDERLYING PROBLEM. I HAVE NOT HAD ANY ACCIDENTS AS A RESULT OF THESE PROBLEMS, BUT IT IS EXTREMELY DISCONCERTING TO HAVE TO WORRY ABOUT WHAT MAY BE AN INHERENTLY FAULTY DESIGN THAT MAY COMPROMISE THE SAFETY OF THIS VEHICLE DESPITE ASSURANCES TO THE CONTRARY GIVEN BY DEALERS. *TR

I HAVE A 2006 FORD ESCAPE V6 2WD. BOTH ABS TONE RINGS CRACKED WITH ONLY 58K MILES. THIS IS THE SAME DEFECT THAT FORD RECALLED ON THE 2001-2004 MODELS. THIS DEFECT CAUSES THE ABS SYSTEM TO FAIL AND TURN OFF. I HAVE READ THAT THE 2005,2007, 2008, AND 2009 HAVE THE SAME FAILURES. THAT MEANS EVERY MODEL FROM 2001-2008 HAVE HAD THE SAME DEFECT WITHOUT BEING ADDRESSED. *TR

THE ANTI-LOCK BRAKES ENGAGE WHEN COMING TO A NORMAL STOP. HAPPENS EVERY DAY AND I AM TOLD IT IS A VERY COMMON PROBLEM WITH THE ESCAPES WHERE A PLASTIC RING COMES UNGLUED AND CAUSES THE ABS TO ENGAGE WHEN IT IS NOT NECESSARY. HAVE ALMOST HIT MULTIPLE VEHICLES AND NEARLY ENDED UP IN A FEW INTERSECTIONS BECAUSE THE ABS PREVENTS ME FROM STOPPING NORMALLY ON DRY SURFACES. *TR

WE OWN A 2006 FORD ESCAPE HYBRID 4WD. IT HAS APPROX. 56,000 MILES ON IT. THE ABS SYSTEM FAILED ON IT IN DEC. THE FORD DEALERSHIP IN OUR AREA CAME BACK WITH AN ESTIMATE OF $6000 FOR REPAIR SECONDARY TO A FAILURE IN THE HYDRAULIC CONTROL UNIT COMPUTER WHICH CONTROLS THE ABS SYSTEM. THE PART ITSELF IS $4300. WE CONTACTED FORD WHOSE RESPONSE WAS THAT WE SHOULD HAVE BOUGHT THE EXTENDED WARRANTY. THE DEALER THEN CONTACTED FORD DIRECTLY AND FORD AGREED TO TAKE $1000 OFF THE PART COST WHICH BROUGHT OUR REPAIR DOWN TO $5000. OUR NON-FORD MECHANIC WAS ABLE TO PURCHASE A USED PART FOR $350, INSTALL IT THEN TAKE IT TO FORD TO REFLASH THE COMPUTER COMPONENTS. FORD CAME BACK TO US AFTER ABOUT A WEEK AND SAID THEY COULD NOT REFLASH THE SYSTEM BECAUSE THOSE COMPONENTS COULD ONLY BE PROGRAMMED ONCE ON THE INITIAL BUILD. WE WOULD BE FORCED TO PURCHASE A NEW PART FROM FORD WHO THEN ARE ALSO THE ONLY ONES WHO POSSESS THE SOFTWARE TO GET THE VEHICLES WORKING AGAIN. I LOOKED ONLINE AND WOULD BE ABLE TO PURCHASE THE PART FOR $2300 BUT COULD ONLY HAVE A FORD DEALER DO THE REMAINDER OF THE WORK TO GET THE COMPUTER SYSTEM TO WORK. NOT SURE IF ANY FORD DEALERSHIP WOULD ALLOW US TO BRING IN OUR OWN PART WE PURCHASED OFF THE INTERNET IF WE WERE TO PURCHASE THE CHEAPER PART. IN ADDITION, IT TURNS OUT FORD IS REQUIRING PARTS DEALERS TO RETURN THE USED PART TO FORD AFTER PURCHASING THE NEW PART. FORD THEN REMANUFACTURES THE PART (WHICH THEY GOT FOR FREE FROM THE CONSUMER) AND RESELLS IT AS A NEW PART FOR $4300 TO SOME OTHER UNSUSPECTING HYBRID OWNER. SINCE OUR CAR IS UNDRIVEABLE WITHOUT THE REPAIR, IT FEELS LIKE FORD IS GROSSLY TAKING ADVANTAGE OF THE CIRCUMSTANCES IN SITUATIONS SUCH AS THESE TO UNFAIRLY GOUGE THEIR CUSTOMERS. PART # 7M6Z2C286B. *TR

BRAKE SYSTEM ON 2006 FORD HYBRID ESCAPE. REPLACED BRAKES AT REPUTABLE SHOP NEAR HOME 11/17/09 AS ABS LIGHT WAS ON AND 55,000 MILES ON CAR. SHOP INFORMED ME ABS LIGHT STILL ON SO THEY PUT CAR ON COMPUTER AND FOUND IT TO BE THE SENSOR ON THE BRAKE AXLE. THEY UNFORTUNATELY COULD NOT HELP ME AS FORD DOES NOT ALLOW ACCESS TO NECESSARY COMPONENTS TO FIX SYSTEM UNTIL CAR IS 5 YRS.OLD AND WAS TOLD THEY TRIED TO PUT A NEW STATIC RING ON AND IT MIGHT WORK. IF LIGHT COMES ON AGAIN TAKE TO DEALER. 2 WKS LATER ABS LIGHT ON AS WELL AS RED BRAKE LIGHT SO TOOK CAR TO WILLOWBROOK FORD DEALER. THEY INFORMED ME THE PART TO REPLACE IS $4300 WITHOUT LABOR. THIS SEEMS CRIMINAL FOR A PART TO COST THAT MUCH AS THE CAR IS ONLY A 2006. I HAVEN'T EVEN FINISHED PAYING FOR THE CAR. THEY TOLD ME I SHOULD OF GOTTEN THE EXTENDED WARRANTY AND I TOLD THEM THEY SHOULD MAKE A BETTER PRODUCT. I EXPECT A NEW CAR TO LAST LONGER THAN 3 YRS. AS IT STANDS TODAY THEY ARE TRYING TO DISCONNECT THE ABS SYSTEM BUT I AM NOT SURE OF THE SAFETY OF THE CAR. IF THEY CANNOT DO THAT I WILL BE FORCED TO PAY THE PRICE FOR THIS OUTRAGEOUS PART. ARE THERE ANY OTHER COMPLAINTS ABOUT THE SAFETY OF THE 2006 FORD ESCAPE HYBRID? *TR

CATASTROPIC FAILURE OF THE BRAKES. *TR

THE 05-06 FORD ESCAPES HAVE A MAJOR FAILURE IN THEIR BRAKING AND AXLE SYSTEM. I BOUGHT A NEW ESCAPE IN 2006 IN LESS THEN TWO YEARS THE ABS LIGHT CAME AFTER REPLACING THE FRONT BRAKE PADS. I TOOK THE CAR TO A MECHANIC AND HE STATED THAT THE FRONT AXLE HAS "TEETH" ON IT THAT EASILY BREAK OFF AND THEREFORE DISENGAGING THE ABS SYSTEM. ON A DAILY BASIS THE BREAKS "THUMP" LIKE THEY ARE NOT ABLE TO STOP THE VEHICLE, THIS HAPPENS AT ANY SPEED, EVEN WHILE TRYING TO PULL INTO A PARKING SPOT. THIS HAS NOT CAUSED ANY ACCIDENTS BUT WE NEVER KNOW IF THE BRAKES ARE GOING TO WORK THEY ARE SUPPOSE TO. MY VEHICLE WAS PAST ITS WARRANTY WHEN THIS PROBLEM FIRST OCCURRED, AND NOW I HAVE TO PAY FOR THE REPLACEMENT OF THE ENTIRE FRONT AXLE BECAUSE A ENGINEERING MALFUNCTION. THE MECHANIC STATED THAT FORD IS AWARE OF THE PROBLEM BUT THEY REFUSE TO PLACE A RECALL ON THE PARTS. I INQUIRED ABOUT FIXING THE PROBLEM, HE STATED THAT THE PARTS, WHICH AGAIN IS THE ENTIRE FRONT AXLE, IS ON BACK ORDER FOR AROUND 5 MONTHS AND THE COST IS AROUND $1500.00.I HAVE ALSO TALKED TO SEVERAL PEOPLE WHO OWN FORD ESCAPES AND THEY HAVE THE SAME ISSUE. IF FORD IS AWARE OF THE PROBLEM AND THEY KNOW THERE IS A PROBLEM BECAUSE OF THE LACK OF FRONT AXLES WHY HASN'T THIS CONSTITUTED A RECALL OR AT LEAST A SAFETY INVESTIGATION. *TR

TL*THE CONTACT OWNS A 2006 FORD ESCAPE. WHILE DRIVING APPROXIMATELY BETWEEN 25-35 MPH ON NORMAL CONDITIONS; THE BRAKE WARNING LIGHT INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. IN AN ATTEMPT TO APPLY PRESSURE TO THE BRAKE PEDAL THERE WAS A GRINDING NOISE FOLLOWED BY A LOW POWER RESPONSE. THE WARNING INDICATOR LIGHT REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF AND THE FOUR WHEEL DRIVE LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT WAS ABLE TO DRIVE WITH CAUTION. THE VEHICLE HAS NOT BEEN REPAIRED. THE CONTACT IS AWARE OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 104,000. THE VIN NUMBER WAS UNAVAILABLE.

SERVICE ABS AND 4WD ON FORD ESCAPE. SEEMS TOO COMMON! HTTP://WWW.TOPIX.COM/FORUM/AUTOS/FORD-ESCAPE/T6TEJMPRNVN7F47O5/P2. *TR

ABS DASH LIGHT FLASHES INTERMITTENTLY WHEN BRAKING , NOISE AND CLUNKING FROM FRONT OF VEHICLE AS WELL AS JERKING . ABS TONE RING FAILURE AFTER ORIGINAL PART FAILURE WAS CORRECTED (REPLACED AXLES) ON BOTH FRONT AXLES. PARTS FAILED AGAIN ON ONE AXLE. *TR

TL*THE CONTACT OWNS A 2006 FORD ESCAPE HEV. WHILE DRIVING 60 MPH, THE CONTACT ATTEMPTED TO STOP THE VEHICLE; HOWEVER, THE BRAKES FAILED. THE BRAKE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL AND READ "SERVICE BRAKE SYSTEM". THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. HE HAS NOT TAKEN THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE OCCURRED WITHOUT WARNING. THE CURRENT AND FAILURE MILEAGES WERE 80,592. UPDATED 06/08/09 *BF THE CONSUMER WAS INFORMED THE HYDRAULIC CONTROL UNIT WAS DEFECTIVE. UPDATED 06/09/09.*JB UPDATED 6/9/09 *CN CONSUMER STATED CAR WAS TAKEN TO DREW FORD WHERE IT WAS ORIGINALLY PURCHASED, THEY TOOK A LOOK AT IT AND STATED NOTHING WAS WRONG WITH THE CAR AND THAT CONSUMER SHOULD PICK IT UP. CONSUMER EXPLAINED HE HAD FILED 20 COMPLAINTS ONLINE WITH NHTSA. FOLLOWING DAY, DEALER TESTED THE VEHICLE AGAIN AND THE BRAKES ONCE AGAIN FAILED AT THE DEALERS PARKING LOT. UPDATED 6/8/18*JB UPDATED 06/10/09.*JB

NO SPECIAL CIRCUMSTANCES. UNDER DAILY DRIVING THE TONE RING A PART THE ABS BRAKING SYSTEM RELIES ON FREQUENTLY FAILS. PREVIOUSLY THIS REQUIRED THE REPLACEMENT OF THE FRONT AXLE. CURRENTLY JUST THE TONE RING IS REPLACED. *TR

I STARTED THE CAR, AND THE ABS AND BRAKE WARNING LIGHTS CAME ON. HOWEVER, THE BRAKES SEEMED TO FUNCTION NORMALLY. AFTER I DROVE 1/4 MILE, I APPROACHED A TRAFFIC LIGHT, AND THE BRAKES DID NOT WORK. I WAS ABLE TO STOP BY GETTING ONTO THE SHOULDER AND PRESSING THE BRAKE TO THE FLOOR. IT TOOK ABOUT 100 YARDS TO STOP STARTING AT 35 MPH. WHEN I RESTARTED THE CAR, THE BRAKES APPEARED TO WORK, AND I DROVE SLOWLY TO MY DESTINATION. WHEN LEAVING THE DESTINATION, I HAD THE SAME PROBLEM, BUT I REALIZED THAT THE BRAKES DID NOT WORK WHILE IN THE PARKING LOT. AFTER RESTARTING THE CAR TWICE, THE BRAKES WORKED, AND I WAS ABLE TO DRIVE IT TO THE DEALER. THE BRAKE WARNING LIGHT CAME ON WHILE DRIVING, BUT THE BRAKES SEEMED TO WORK. *TR

WHILE DRIVING ON THE HIGHWAY, BRAKE AND ABS WARNING LIGHTS CAME ON DASH AND BRAKES FAILED. COULD ONLY GET MINOR STOPPING POWER WHEN BRAKES DEPRESSED ALL THE WAY TO THE FLOOR. MANAGED TO STOP WITHOUT CRASH. WHEN CAR WAS TURNED OFF AND RESTARTED, THE LIGHTS WERE OFF AND THE BRAKES FUNCTIONED OKAY. DEALER CLAIMED THEY COULD FIND NO EVIDENCE OF A PROBLEM BECAUSE THE RESTART OF THE CAR CLEARED THE ERROR LOG. EXACT PROBLEM REAPPEARED 2 WEEKS LATER. BRAKE AND ABS LIGHT CAME ON DASH, BRAKES WOULD NOT STOP VEHICLE EXCEPT VERY MINOR BRAKING POWER WHEN DEPRESSED ALL THE WAY TO THE FLOOR. THIS TIME, DROVE CAR TO NEARBY DEALER WITHOUT TURNING OFF AND DEMANDED THAT THEY DRIVE IT TO WITNESS PROBLEM. AGAIN, THEY INSISTED THERE WAS NO PROBLEM UNTIL THEY ACTUALLY DROVE THE VEHICLE. REPLACED MASTER BRAKE CYLINDER AND BLED BRAKES 3 TIMES BEFORE BRAKES PASSED TEST. *TR CONSUMER STATED COMPLAINT WAS REPORTED MORE THAN 8 YEARS AGO FOR A CAR THAT CONSUMER HASN'T OWNED FOR MORE THAN 7 YEARS. UPDATED 6/8/18*JB

TL*THE CONTACT OWNS A 2006 FORD ESCAPE HEV. WHILE DRIVING 25 MPH, THE CONTACT ATTEMPTED TO STOP THE VEHICLE; HOWEVER, THE BRAKES DID NOT FUNCTION AND THE BRAKE WARNING INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT HAD TO APPLY THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE IS CURRENTLY BEING DIAGNOSED BY THE DEALER. THE CONTACT DID NOT NOTICE ANY DIFFERENCES BEFOREHAND. THE CURRENT AND FAILURE MILEAGES WERE 3,100. UPDATED 11/17/08 *CN UPDATED 11/21/08. *JB

UPON PURCHASE RUMBLING WAS FELT WHILE BRAKING. THE FUCCILLO CAR DEALER MECHANIC SAID THAT IT WAS THE 4WD KICKING IN. THIS PROBLEM CONTINUED AND ONCE THE 90 DAY WARRANTY WAS UP THEIR STORY CHANGED. THE ABS LIGHT CAME ON AND THE TONE RING NEEDED TO BE REPLACED. HE SAID THEY HAVE HAD MANY OF THESE AND BE LOOKING FOR A RECALL. THIS IS DEFINITELY A SAFETY ISSUE AS THE BRAKES BEGIN TO CLANG AND BANG WITHOUT WARNING. *TR

TL*THE CONTACT OWNS A 2006 FORD ESCAPE. THE CONTACT STATED THAT THE ABS LIGHT ILLUMINATES AND THE BRAKES FAIL. HE MUST APPLY THE EMERGENCY BRAKE IN ORDER TO STOP THE VEHICLE. THE DEALER REPLACED THE ENTIRE ABS, BUT THE FAILURE CONTINUED. THE MOST RECENT FAILURE OCCURRED ON MARCH 1, 2008. THE MANUFACTURER INFORMED THE CONTACT THAT HE WOULD RECEIVE A CALL BACK. THE CURRENT MILEAGE WAS 32,000 AND FAILURE MILEAGE WAS 31,723. UPDATED 04/29/08. *LJ

TL*THE CONTACT OWNS A 2006 FORD ESCAPE HYBRID. THE CONTACT STATED THAT THE BRAKE WARNING LIGHT INTERMITTENTLY ILLUMINATES AND DISPLAYS "SERVICE BRAKE SYSTEM". THE VEHICLE WAS TAKEN TO THE DEALER ON SEVERAL OCCASIONS, BUT THEY HAVE BEEN UNABLE TO REPAIR THE FAILURE. THE CURRENT MILEAGE WAS 22,000 AND FAILURE MILEAGE WAS 160. UPDATED 04/11/08 *BF UPDATED 04/11/08 *TR

VEHICLE'S FRONT WHEEL CONSTANTLY PULLS TO THE LEFT WHEN APPLYING BRAKES HAS JERKED STEERING WHEEL OUT OF HAND 3 TIMES. *TR

BRAKE WARNING LIGHT AND SERVICE BRAKE SYSTEM MESSAGE FREQUENTLY DISPLAYED ON INSTRUMENT PANEL (MORE THAN A DOZEN OCCURRENCES OVER 12 MONTHS). OWNERS MANUAL DESCRIBES THIS AS A DANGEROUS CONDITION. FOUR ATTEMPTS BY FORD SERVICE TO CORRECT AND ARE UNABLE TO DETERMINE CAUSE BECAUSE CODES ARE ERASED WHEN VEHICLE IS TURNED OFF(?). *TR

APPROXIMATELY EVERY 8,000 MILES THE PARKING BRAKE ON THE MANUAL TRANSMISSION, INLINE-4, FWD LOOSENS AND MUST BE TAKEN TO THE DEALER TO BE TIGHTENED. THUS FAR, THIS HAS OCCURRED TWICE. WHILE PARKING ON A HILL THIS IS A SAFETY CONCERN, ESPECIALLY SINCE THE CLUTCH NO LONGER HOLDS THE VEHICLE IN PLACE AFTER 17,000 MILES. *JB

BRAKES FAILED FOR THE SECOND TIME. THE VEHICLE WAS TAKEN IN FOR THE BRAKE REPAIR AFTER THE FIRST TIME ABOUT 4 WEEKS AGO BUT WAS TOLD BY THE FORD DEALERSHIP THAT THERE WASN'T ANYTHING WRONG WITH THE BRAKES. AFTER THE SECOND TIME THEY NOW HAVE TO ORDER PARTS WHICH ARE ON BACK ORDER IN ORDER TO MAKE THE REPAIR. *NM

NORMAL CITY DRIVING INITIATED FAILURE OF BRAKES TO HAVE PRESSURE. IMMEDIATELY BRAKE AND ABS LIGHTS ILLUMINATED. BRAKES MAY BE APPLIED, BUT RELEASE AFTER APPLICATION. INITIALLY, WHEN BROUGHT INTO FORD DEALERSHIP 11 DAYS AGO, PROBLEM WAS DIAGNOSED TO BE ELECTRONIC, BUT AFTER REPLACEMENT OF ELECTRONIC CONTROL SYSTEM FOR BRAKES, THE PRESSURE FAILS TO RESUME. *JB

I PURCHASED A 2006 ESCAPE HYBRID ON APRIL 9TH & IMMEDIATELY IT HAD BRAKE FAILURE PROBLEMS - ESSENTIALLY NO BRAKES. IT HAS BEEN AT DEALERSHIP SINCE APRIL 10TH. THEY CLAIMED IT WAS FIXED ON APRIL 22 & WHEN I WENT TO GET IT, SAME PROBLEM HAPPENED IN TEST DRIVE. THEY HAVE NO IDEA WHAT ELSE IS WRONG. THEY REPLACED THE BRAKE SENSOR, BUT OBVIOUSLY THAT DIDN'T RESOLVE THE PROBLEM. THIS IS A MAJOR SAFETY ISSUE ESPECIALLY IN SOUTH FLORIDA, WHERE THE ABILITY TO PROPERLY BRAKE IS HIGHLY ESSENTIAL. *NM