2004 Ford Escape Body & Structure Problems

Your son lost control of your 2004 Ford Escape while driving at 45 mph, causing the vehicle to roll into a ditch. When the vehicle rolled back onto its wheels, none of the airbags deployed despite the serious crash, and your son suffered a head injury requiring stitches. The vehicle was not inspected or repaired after the accident. This issue may involve structural integrity or airbag system failures that require professional inspection by a Ford dealer.

Your vehicle's subframe has developed rust. This is a structural component that supports your car's weight and suspension, and rust can weaken it over time. While you may not see warning lights, significant rust on the subframe could eventually affect your vehicle's safety and stability. A repair would likely involve cleaning the rusted areas and applying protective coating, or in severe cases, replacing the affected subframe components.

CPSC:ABOUT A MONTH AGO I NOTICED A LOUD NOISE COMING FROM THE REAR PASSENGER SIDE OF MY VEHICLE WHEN GOING OVER BUMPS IN THE ROAD. UPON INSPECTION, I FOUND THE SHOCK CASING ON THE REAR PASSENGER SIDE IS COMPLETELY RUSTED OUT AND MY SHOCK MOUNT IS NO LONGER ATTATCHED TO MY VEHICLE. *DT *JS

PASSENGER SIDE REAR WHEEL WELL RUSTING AWAY. SHOCK TOWER MOUNT IS IN TREMENDOUS JEOPARDY. I HAVE LOOKED AT DOZENS OF SIMILAR MODEL YEAR ESCAPES THIS WEEKEND, INCLUDING ONE I OWN, AND THEY ARE ALL FINE. A REVIEW OF THE INTERNET SHOWS I AM NOT ALONE THOUGH. THOUSANDS OF REPORTS OF THE SAME ISSUE. WHAT TO DO?

THE TWO HINGES HOLDING THE REAR WINDOW TO THE TAILGATE ARE BADLY CORRODED TO THE POINT THAT THE METAL BOLTS HAVE FAILED AND THE REAR WINDOW IS NOW A SAFETY HAZARD AND COULD FALL OFF DURING NORMAL DRIVING.

CATASTROPHIC FAILURE OF THE FRONT SUB-FRAME ENGINE CRADLE ASSEMBLY. IT COMPLETELY RUSTED APART ON THE PASSENGER SIDE CAUSING THE LOWER CONTROL ARM TO COME LOOSE. MY DAUGHTER WAS DRIVING WHEN IT CAME LOOSE CAUSING THE ESCAPE TO RUN OFF THE ROAD. THANKFULLY THERE WAS PLENTY OF SHOULDER ON THE RURAL ROAD AND NO ONE WAS HURT. HAD THIS BEEN IN TRAFFIC, AN ACCIDENT WOULD HAVE BEEN INEVITABLE. CALLED FORD CUSTOMER SERVICE - NO HELP, THERE IS NOTHING THEY CAN DO. THE CAR HAS BEEN GARAGE KEPT, WELL MAINTAINED WITH ON 70K MILES. NOTHING ELSE IS RUSTED. THIS IS CLEARLY A DEFECTIVE PART. MORE DISTURBING IS THAT THERE WAS A RECALL 14S04 BACK IN 2014. ALL THAT WAS DONE WAS TO ADD REINFORCEMENT CROSS BRACE IF RUST WAS PRESENT. THIS DID NOT ADDRESS THE DEFECTIVE PART, NOR, DID THE FORD DEALER NOTIFY US OF THE RUSTING PART WHICH WAS DESTINE TO FAIL. BASED ON THIS TYPE OF PRODUCT SUPPORT AND CONCERN FOR CUSTOMER SAFETY, WE WILL BE LOOKING ELSEWHERE FOR VEHICLES IN THE FUTURE.

2004 FORD ESCAPE. CONSUMER WRITES IN REGARDS TO VEHICLE FRONT SUB-FRAME CROSSBRACE CORROSION SEPARATION OF LOWER CONTROL ARM RECALL NOTICE REPAIRS. *M UPDATED 07/20/2017*JS

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING 35 MPH, THE VEHICLE BEGAN TO SHAKE VIOLENTLY WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUBFRAME WAS CRACKED AND NEEDED TO BE REPLACED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRAME FRACTURED AND NEEDED TO BE REPLACED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE CONTACT WAS INFORMED THAT THE DAMAGE WAS TOO EXTENSIVE TO BE REMEDIED PER THE RECALL. THE MANUFACTURER STATED THAT DUE TO THE AGE AND MILEAGE OF THE VEHICLE, ASSISTANCE WOULD BE DENIED. THE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE SWERVED INDEPENDENTLY INTO A DITCH. THERE WERE NO INJURIES AND A POLICE REPORT WAS NOT FILED. THE CONTACT NOTICED THAT THE SUBFRAME WAS RUSTED AND DETACHED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT TOOK THE VEHICLE TO A LOCAL DEALER WHERE IT WAS DIAGNOSED THAT THE SUBFRAME NEEDED TO BE REPLACED. THE MANUFACTURER DID NOT WANT TO REPLACE THE SUBFRAME FOR FREE. THE CONTACT STATED THAT THE VEHICLE COULD NOT BE DRIVEN LONG DISTANCES. THERE WERE NO RECALLS FOR THE VEHICLE. THE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE FRONT SUBFRAME WAS RUSTED AND AFFECTED THE CONTROL ARM. THERE WAS A RECALL FOR THE FRONT SUBFRAME RUST; HOWEVER, THE VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT REQUESTED THAT THE VIN BE INCLUDED IN THE RECALL. THE NHTSA CAMPAIGN NUMBER WAS UNKNOWN. THE FAILURE MILEAGE WAS 111,255.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT 70 MPH, THE FRONT PASSENGER SIDE TIRE AND FRAME FRACTURED AND CAUSED SPARKS TO EMIT FROM THE VEHICLE. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROAD. THE VEHICLE WAS TOWED TO THE DEALER BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT HAD RECEIVED NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS NOT AVAILABLE.

I HEARD RATTLING FROM THE BACK OF MY CAR LIKE A TIN THERMOS ROLLING AROUND. I LOOKED AT THE BACK AND WAS INSPECTING MY VEHICHLE. ONCE I TOOK OUT THE SPARE TIRE COVER I DISCOVERED A HUGE HOLE IN THE RIGHT REAR WHEEL WELL. I CALLED MY DEALER ABOUT THE ISSUE AND BROUGHT THE CAR IN AS SOON AS POSSIBLE TO BE SERVICED. I HAVE LOOKED THIS UP ONLINE TO SEE IF THERE IS A RECALL FOR AN ISSUE LIKE THIS AND I AM FINDING THAT MANY FORD ESCAPE OWNERS FROM 2005-2006 ARE HAVING THE SAME ISSUE. THIS ISSUE IS A SAFETY HAZARD. I AM CURRENTLY UNABLE TO DRIVE MY CAR AS MY DEALER IS NOT COMFORTABLE LETTING USE DRIVE IT, AND THEIR BODY SHOP WAS UNABLE TO REPAIR IT SAYING THAT IT WAS TO COMPROMISED AND WOULD BE LIABILITY

PASSENGER SIDE REAR INNER WHEEL WELL AND STRUT MOUNT RUSTED OUT. HOLE THE SIZE OF A GRAPEFRUIT. APPARENTLY THIS IS A KNOWN ISSUE WITH THIS MAKE, MODEL, AND YEAR OF VEHICLE. COMPLAINTS REGARDING THIS EXACT ISSUE ALL OVER THE INTERNET YET NO SAFETY RECALL REGARDING THE PROBLEM. MY STRUT HAS NOT YET PROTRUDED AND BROKEN THROUGH THE MOUNT BUT WILL SHORTLY IF NOT ADDRESSED.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHEN THE VEHICLE WAS MOVED FROM A PARKING SPOT, THERE WAS EVIDENCE OF FRAGMENTS OF CORRODED METAL UNDERNEATH THE VEHICLE. THE CONTACT STATED THAT THE PASSENGER AND DRIVER SIDE REAR WHEEL WELLS WERE CORRODED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE INSPECTED. THE CONTACT WAS INFORMED THAT THERE WAS EXTREME CORROSION TO THE FUEL TANK, THE FUEL TANK STRAPS, AND THE ENTIRE REAR SUBFRAME OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

PASSENGER SIDE REAR WHEEL WELL RUSTED. SHOCK MOUNT IS NOW COMPLETELY DISCONNECTED.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 25 MPH, THE STEERING WHEEL SEIZED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 84,000.

OUR 2004 FORD ESCAPE IS MAKING METALLIC CREAKING, SQUEAKING AND GROANING SOUNDS FROM THE PASSENGER SIDE REAR. THE SOUND IS TRIGGERED BY JUST SITTING IN THE STATIONARY CAR AND ROCKING BACK AND FORTH. IT BECOMES CONSTANT AS SOON AS THE VEHICLE STARTS MOVING. THERE ARE ALSO OCCASIONAL HEAVY METALLIC THUMPS OR KNOCKS ON THE PASSENGER SIDE OR UNDERSIDE OF THE CAR, AND THE RIDE IS ROUGH. THE PASSENGER SIDE REAR INNER METAL WHEELHOUSE IS EXTREMELY RUSTY. A FEW HOLES ARE SEVERAL INCHES SQUARE & GO ALL THE WAY THROUGH INTO THE INTERIOR OF THE CAR. PART OF THE RUST IS VERY NEAR WHERE THE TOP OF THE SHOCK ABSORBER BOLTS INTO THE WHEELHOUSE. THE WHEELHOUSE METAL IS SO RUSTY THAT I CAN FLEX IT WITH MY HAND AND CAUSE THE CREAKING SOUNDS. I BELIEVE THE HEAVY METALLIC THUMPS ARE CAUSED WHEN THE CONICAL BUMPER INSIDE THE TOP OF THE SPRING BOTTOMS OUT AND HITS THE SUSPENSION MOUNTED TO THE BOTTOM OF THE SPRING. THIS LIKELY HAPPENS BECAUSE THE SHOCK ABSORBER CANNOT STOP IT, SINCE THE RUSTY WHEELHOUSE BENDS SO MUCH. THIS SERIOUS SAFETY PROBLEM IS HEAVILY DOCUMENTED ON THE INTERNET BY A VERY LARGE NUMBER OF PEOPLE. THE TOP OF THE SHOCK ABSORBER COULD CRASH THROUGH THE WHEELHOUSE AND PROTRUDE INTO THE CAR INTERIOR, INJURING OCCUPANTS OF THE CAR. THIS WOULD MAKE LOSS OF CONTROL MORE LIKELY. IT WOULD BE EXTREMELY DANGEROUS IF THE SHOCK ABSORBER BREAKS FREE AND BECOMES TANGLED UP WITH THE REAR WHEEL OR PUNCTURES THE TIRE. THIS CAR IS A UNIBODY CONSTRUCTION, SO THIS WHEELHOUSE IS SUPPOSED TO PROVIDE STRUCTURAL STRENGTH FOR THAT PART OF THE CAR. IN THE EVENT OF A CRASH THIS RUSTY WHEELHOUSE WILL DISINTEGRATE AND NOT PROPERLY ABSORB THE CRASH ENERGY LIKE IT IS SUPPOSED TO. THIS MAKES IT MORE LIKELY THAT THE OCCUPANTS WILL GET INJURED. PLEASE FORCE A VEHICLE RECALL ASAP WHICH MAKES FORD MOTOR CO. REPLACE THIS DANGEROUS WHEELHOUSE WITH ONE THAT HAS A SAFER, NON-RUSTING DESIGN.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING 45 MPH, A LOUD BANGING NOISE WAS HEARD. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR PASSENGER WHEEL WELL, AND THE SHOCK ABSORBER TOWER WERE SEVERELY CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS INVALID. THE APPROXIMATE FAILURE MILEAGE WAS 144,000.

2004 FORD ESCAPE. REAR RIGHT WHEEL HUB RUST/CORROSION AROUND STRUT ASSEMBLY. SAFETY ISSUE WITH REAR SHOCK. KNOWN PROBLEM WITH 2004 TO 2006 FORD ESCAPE DESPITE RUST PROOFING. RUSTS AROUND AREA FOR STRUT LEADING TO STRUCTURAL COMPROMISE OF THIS ASSEMBLY. UNSAFE TO DRIVE.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING AT APPROXIMATELY 40 MPH, THE VEHICLE VIOLENTLY VEERED TO THE RIGHT WITHOUT WARNING. THE FAILURE RECURRED THREE TIMES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SUBFRAME FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE) BUT THE REMEDY FAILED TO PREVENT THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 59,000.

RIGHT REAR INNER FENDER WELL RUSTED OUT. CAUSING SHOCK NOT TO BE ATTACHED. UNSAFE TO DRIVE AS IS. FORD SHOULD DO SOMETHING ABOUT THIS.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO A DEALER FOR NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). WHILE HAVING THE REPAIRS PERFORMED, THE FAILURE LISTED IN THE NOTICED OCCURRED. DUE TO CORROSION, THE CROSS BRACE THAT WAS INSTALLED FAILED TO SUPPORT THE WEIGHT AND FRACTURED, RENDERING THE PART UNUSABLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE MANUFACTURER WOULD ONLY PROVIDE RECALL REPAIRS ONCE. THE FAILURE MILEAGE WAS APPROXIMATELY 145,000.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE REAR PASSENGER SIDE INNER FENDER WELL WAS RUSTED DUE TO EXCESSIVE CORROSION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 109,000.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING AT 15 MPH, THE VEHICLE INDEPENDENTLY VEERED TO THE RIGHT. UPON FURTHER INSPECTION, THE CONTACT NOTICED THAT THE FRONT PASSENGER TIRE LEANED OUTWARDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE SUBFRAME FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 101,000.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V165000 (STRUCTURE). THE CONTACT BROUGHT THE VEHICLE TO DEALER FOR THE RECALL REMEDY. THE MECHANIC STATED THAT THE VEHICLE WAS UNSAFE TO OPERATE BECAUSE THE SUBFRAME WAS EXTREMELY CORRODED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 143,000.

I WAS DRIVING AND THE REAR END OF THE TRUCK SOUNDED LIKE IT WAS FALLING APART. WHEN I STOPPED AND LOOKED THE PASSENGER SIDE REAR WHEEL WELL WAS COMPLETELY ROTTED OUT AND THE METAL PLATE THAT HOLDS THE SHOCK IN PLACE WAS HANGING AND BANGING AROUND. THE LEFT SIDE IS COMPLETELY INTACT. I TOOK IT TO CAUSEWAY COLLISION TO LOOK AT IT AND THEY SAID ITS A DEFECT AND PROBABLY NOT FIXABLE. THE TRUCK HAS HIGH MILEAGE BUT RUNS GREAT. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING AT APPROXIMATELY 40 MPH, THERE WAS A LOUD NOISE EMERGING FROM THE REAR PASSENGER SIDE OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE REAR PASSENGER STRAP MOUNT WAS RUSTED AND THE REAR PASSENGER WHEEL WELL NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 121,000. UPDATED 6/8/15*CN THE CONSUMER STATED THE REAR PASSENGER SIDE WHEEL WELL RUSTED AND CREATED A BIG HOLE, WHICH CAUSED THE TOP STRESS MOUNT TO FALL DOWN. UPDATED 06/11/15*JB

HAD BEEN NOTICING NOISES WHEN I DROVE OVER BUMPS AND ROUGH SURFACES COMING FROM THE BACK RIGHT SIDE OF THE VEHICLE. I HIT AN UNAVOIDABLE HOLE IN THE ROAD TODAY AND HEARD A LOUD THUMP FROM THE REAR RIGHT SIDE OF THE VEHICLE. I PROCEEDED TO MY SISTER'S HOUSE WHERE MY BROTHER IN-LAW CHECKED THE VEHICLE AND FOUND THAT THE STRUT/SHOCK HAD BROKE THROUGH THE HORRIBLY RUSTED WHEEL WELL AND WAS HITTING THE UNDERSIDE OF THE PLASTIC WHEEL WELL COVER. THIS COULD HAVE BEEN A DISASTER HAD IT HAPPENED A FEW DAYS AGO WHILE I WAS ON THE FREEWAY. I HAVE AN APPOINTMENT TO TAKE THE VEHICLE IN TO SEE IF IT CAN BE FIXED. IN THE MEAN TIME I HAVE NO VEHICLE TO DRIVE AS IT IS NOT DRIVABLE. I SEE FROM NUMEROUS COMPLAINTS THAT THIS IS A CONTINUING PROBLEM WITH THIS VEHICLE. WHY IS FORD NOT BEING HELD ACCOUNTABLE FOR THIS ISSUE? I MAY HAVE TO GET ANOTHER VEHICLE THAT I AM NOT PREPARED TO DO. THIS IS A SAFETY ISSUE THAT I FEEL SHOULD BE ADDRESSED. *TR

PASSENGER (RIGHT) REAR WHEEL WELL RUSTED THROUGH, CAUSING THE STRUT TO DETACH. *TR

EXCESSIVE CORROSION IN REAR WHEEL WELLS, STRAPS HOLDING GAS TANK AND UNDERSIDE OF RUNNING BOARDS. BOTH RUNNING BOARDS COMPLETELY FELL OFF, THE STRAPS HOLDING THE TANK HAD TO BE REPLACED BECAUSE THE TANK WAS IN DANGER OF FALLING OFF. THIS CAR IS IN A COVERED GARAGE 90% OF THE TIME. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING APPROXIMATELY 45 MPH, THE CONTACT HEARD A CLUNKING SOUND NEAR THE REAR PASSENGER SIDE OF THE VEHICLE. THE DEALER STATED THAT THE WHEEL WELL WAS CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 140,000.

RUNNING BOARD RUSTED AND FELL OFF. *TR

THE RIGHTSIDE OF MY WHEELWELL WAS ROTTED OUT ALONG WITH THE FLOOR AROUND IT THAT HELD THE WHEEL WELL THE SHOCK NEEDED TO BE REPLACED AS WELL. WHEN I WENT TO THE DEALERSHIP TO GET THE WHEEL WELL THEY TOLD ME THIS WAS A WELL KNOWN PART TO BE REPLACED. SO I ASKED WHY WAS IT NOT A RECALL ON IT NO ANSWER COULD HE GIVE ME. I WAS GETTING A BURNING SMELL FROM MY EXHAUST (MUFFLER FUMES) AS I DROVE HOME MANY TIMES I FELT MYSELF GETTING SLEEPY AS I DROVE ON TO GET TO MY DESTINATION I PRAYED TOGET SAFELY THERE LITTLE DID I KNOW I WAS GETTING FUMES IN MY CAR THAT CAUSED THIS. I HAVE DRIVEN WITH MY YOUNG GRANDCHILDREN IN THIS DANGEROUS CONDITION IN THIS CAR MY QUESTION IS IF THE FORD DEALERSHIP KNEW OF THIS TO BE A WELL KNOWN PROBLEM WHY DID THEY NOT RECALL IT I ONLY THANK THE LORD THAT IT DID NOT KILL ME OR MY GRANDCHILDREN. ALSO IT PAST INSPECTION A YEAR AGO HOW COULD THEY HAVE NOT SEEN WHAT WAS HAPPENING IN THIS AREA. I DO HAVE PICTURES OF IT AND IT WAS EVEN WORST THEN THE PICTURES I HAVE SEEN ONLINE PROOF ONE MORE TIME THAT GOD IS ALWAYS ON YOURSIDE IF YOU BELIEVE EVERYONE ELSE PLEASE CHECK YOUR WHEEL WELL GOD BLESS! *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT HEARD A LOUD ABNORMAL NOISE NEAR THE REAR OF THE VEHICLE. THE CONTACT DISCOVERED THAT THE REAR PASSENGER SIDE WHEEL SHOCK AND TOWER WERE SEVERELY CORRODED AND PENETRATED THE SUBFRAME AND FLOOR INTERIOR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.

THE SHOCK TOWER IN THE PASSENGER SIDE REAR WHEEL HAS BROKEN, DUE TO RUST AND CORROSION, AND PUNCTURED THROUGH THE INTERIOR OF THE TRUNK AND THE BACK SEAT. THE INTERIOR OF THE CAR BODY HAS SEPARATED FROM THE EXTERIOR BODY SO THAT THE WHEEL AND ROAD CAN BE SEEN FROM INSIDE THE BACK SEAT THROUGH A LARGE (INCH OR MORE WIDE) GAP. THERE IS NO CORROSION OR DAMAGE IN ANY OTHER WHEEL WELL. THERE IS A CORROSION RELATED RECALL ON THIS CAR WHICH THE DEALERSHIP SAYS IS UNRELATED TO THIS PARTICULAR AREA OF THE CAR (SAFETY RECALL 14S02). FORD'S CUSTOMER "CARE" CENTER ACKNOWLEDGED MULTIPLE COMPLAINTS YET HAS NO INVESTIGATION OR ACTIVITY AIMED AT A REMEDY FOR THIS COMMON PROBLEM. DUE TO FORD'S APPARENT NEGLIGENCE WHICH HAS CAUSED HUNDREDS OF FORD OWNERS IDENTICAL DAMAGE, MY CAR IS UNSAFE AND FORD IS UNWILLING TO ACT. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH, THE REAR PASSENGER SIDE STARTED TO RATTLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSE THAT THE REAR PASSENGER SIDE WHEEL WELL WAS CORRODED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 143,000.

MY DAUGHTER COMPLAINED ABOUT A LOUD CLANGING NOISE FROM THE RIGHT REAR OF HER CAR. I BOUGHT IT USED FROM A DEALER AND IT HAS BEEN KEPT IN A GARAGE AND USED SPARINGLY. UPON INSPECTION I NOTED THAT THE RIGHT REAR STRUT HAD COMPLETELY BROKEN FREE DUE TO EXTENSIVE RUST OF THE WHEEL WELL. I CANNOT ALLOW HER TO DRIVE IT IN THIS CONDITION. NOT SURE IF IT CAN BE REPAIRED YET OR WHETHER IT WILL COST MORE THAN THE CAR IS WORTH. I NOW RECOGNIZE THAT THERE ARE MANY OTHER OWNERS WITH THE EXACT SAME PROBLEM. WITH SO MANY OWNERS HAVING THE SAME EXPERIENCE SOMETHING SHOULD BE DONE. *JS

THE REAR PASSENGER FENDER WELL HAS RUSTED OUT. WE CAN SEE INTO OUR TRUCK. THE RUST IS SO BAD THE TOP SHOCK MOUNT IS NO LONGER CONNECT AND THE FRAME IS CRACKED. I WENT TO TWO DIFFERENT BODY SHOPS BECAUSE FORD IS UNWILLING TO DO ANYTHING. BOTH BODY SHOPS SAID A 10 YEAR OLD VEHICLE SHOULD NOT RUST LIKE THIS AND IT WOULD COST MORE THAN WHAT THE VEHICLE IS WORTH TO FIX. WE CAN NOT LONGER DRIVE OUR VEHICLE AND WILL HAVE TO CONSIDER IT AS TOTAL UNLESS FORD STANDS BEHIND THEIR VEHICLES AND CREATES A RECALL. FORD CREATED A RECALL FOR THE FRONT OF THEIR FORD ESCAPES RUSTING OUT BUT HAVE NOT DONE THE SAME FOR THE REARS. I HAVE READ ONLINE SEVERAL HUNDRED OTHER PEOPLE HAVING THE SAME ISSUE WITH THEIR FORD ESCAPE. *JS

WE JUST PURCHASED THIS VEHICLE . W E KNEW ABOUT A PAINT ISSUE BENEATH THE HATCH WINDOW. TOOK THE VEHICLE TO A VERY REPUTABLE GLASS AND BODY SHOP . THE SHOP OWNER IMMEDIATELY WENT TO THE RIGHT REAR WHEEL WELL AND TOLD US TO LOOK AT IT . THE AREA BEHIND THE TIRE IS VERY EATEN WITH RUST. A GOOD SIZED HOLE EXISTS EXTENDING TO THE SHOCK AND STRUT. THE SHOP OWNER SAID THAT HE HAS SEEN MANY OF THEM. ALWAYS THE SAME WHEEL WELL AND NOWHERE ELSE. ASSUREDLY THE STRUT AND SHOCK ARE COMPROMISED. HE SAID THAT HE ALMOST ALWAYS SEES THIS ON THE ESCAPES. THE PREVIOUS OWNER WAS EXTREMELY METICULOUS ABOUT SERVICING AND UPKEEP WITH THE VEHICLE. *TR

RIGHT FRONT WHEEL SEPARATED FROM METAL ATTACHMENT, PRESUMABLY A RUST-THROUGH FAILURE. *JS

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT UPON INSPECTION, SHE WAS ADVISED THAT THE SUB FRAME WAS COMPLETELY COVERED WITH RUST AND HAD BECOME DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE ENTIRE REAR SUB FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE CURRENT AND FAILURE MILEAGE WAS 180,000.

MY HUSBAND WAS DRIVING HOME WITH OUR SON AND STARTED TO HEAR A LOUD NOISE. TOOK IT TO OUR REPAIR GUY WHO STATED THE FRAME WAS COMPLETELY RUSTED THROUGH AND WAS NO LONGER SAFE TO DRIVE. WE THEN TOOK IT FOR A 2ND LOOK AND WAS TOLD THE SAME THING AND THAT ITS NOT FIXABLESO WE'LL HAVE TO BUY A NEW CAR. WE'VE ONLY HAD THIS CAR FOR 6 YEARS AND I BOUGHT IT FROM OUR LOCAL FORD DEALERSHIP WHO WHEN CONTACTED SAID THEY COULDN'T DO ANYTHING TO HELP BECAUSE THERE ARE NO RECALLS ON THE VEHICLE FOR THIS PROBLEM. WE HAVE 2 SMALL CHILDREN AND I'M VERY LUCKY THAT SOMETHING DIDN'T HAPPEN TO THEM. WHAT IS A RECALL GOING TO TAKE? SOMEONE GETTING HURT OR WORSE?? THIS IS A MAJOR SAFETY ISSUE AND FORD NEEDS TO BE RESPONSIBLE CLEARLY ITS A MANUFACTURING PROBLEM WHEN THERE'S 1000'S OF CUSTOMERS WITH THE SAME PROBLEM!!!! *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE FRAME WAS RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 138,000.

WELL, MY FORD ESCAPE 2004 LTD EDITION HAD ISSUES SLOWING DOWN. I HAD USED THE CRUISE CONTROL INTERMITTENTLY AND NOTICED THAT THE VEHICLE CONTINUED AS IF CRUISE CONTROL WAS ON EVEN AFTER I BRAKED HARD AND CANCELLED THE CRUISE CONTROL. I SHUT THE VEHICLE OFF AND TRIED TURNING IT BACK ON. WHEN IT STARTED BACK UP, THE VEHICLE REVVED TO 5,000 RPM IN UNDER 5 SECONDS. I DID THIS TWICE WITH THE SAME EFFECT. I BROUGHT IT IN TO MY FORD DEALERSHIP. THEY SAID THERE WAS NO RECALL (ALTHOUGH NOW I SEE THEM ALL OVER THE INTERNET). I GOT A CALL BACK AFTER THIS WHOLE ORDEAL THAT THE RIGHT REAR WHEEL WELL HAD COMPLETELY RUSTED THROUGH AND THAT THE SHOCK WAS NOT ATTACHED TO ANYTHING. THIS SEEMS TO BE A COMMON TREND WITH THESE VEHICLES, BUT THERE ARE NO RECALLS. MY DEALERSHIP IS BRINGING IT TO AN AUTO BODY SHOP TODAY. I AM EXPECTING A $3,000 REPAIR NOW. *TR

TL* THE CONTACTS OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 35 MPH, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR END OF THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS ADVISED THAT THERE WAS A HOLE ABOVE THE PASSENGER'S SIDE REAR BODY PANEL AND AS A RESULT, THE REAR PASSENGER'S SIDE STRUCTURE OF THE UNIBODY NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 112,000.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE SUB FRAME WAS COMPLETELY RUSTED AND HAD BECOME DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENTIRE FRONT SUB FRAME NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 40,000. UPDATED 11/19/13*LJ UPDATED 11/29/2013 *JS

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, SHE HEARD AN ABNORMAL NOISE AND UPON FURTHER INVESTIGATION, SHE FOUND THAT THE REAR WHEEL WELL SUFFERED FROM SEVERE CORROSION. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT UPON INSPECTION, IT WAS FOUND THAT THE SUB FRAME WAS COMPLETELY RUSTED AND HAD BECOME DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE THE FAILURE WAS CONFIRMED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 143,000.

THE RIGHT REAR WHEEL WELL THAT SUPPORTS THE SHOCK TOWER HAS COMPLETELY RUST OUT,THIS IS COMMON IN THE 2004-2006 ESCAPES. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THERE WAS AN ABNORMAL KNOCKING NOISE COMING FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE THEY STATED THAT THE FRAME WAS RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND ADVISED THAT THEY COULD NOT PROVIDE ANY ASSISTANCE TO THE CONTACT. THE FAILURE MILEAGE WAS 98,000.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT WAS TRYING TO OPEN THE TRUNK BY ENGAGING THE KEY ALARM BUT THE TRUNK WOULD NOT OPEN. THE TRUNK ALSO COULD NOT BE OPENED MANUALLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THEY STATED THAT THEY NEEDED TO REPLACE THE TRUNK LATCH. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURE WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 40,100 AND THE CURRENT MILEAGE WAS 43,000. . UPDATED 07/27/12 *BF THE CONSUMER STATED THAT DEALER WANTED TO CHARGER 24,500 TO REPAIR THE MOTOR AND 125.00 TO EVALUATE. THE CONSUMER FEELS THIS IS TOO EXPENSIVE. UPDATED 08/02/2012 *JS

FOR OVER A YEAR I HAVE BEEN HEARING A RATTLING SOUND BUT THOUGHT NOTHING OF IT, FIGURED A SCREW WAS LOOSE IN THE PANELLING CAUSING A VIBRATION. I HAVE TAKEN IT TO A FORD SERVICE CENTER NUMEROUS TIMES COMPLAINING OF NOISE, THEY SAID THEY WOULD BALANCE THE TIRES AND CHECK THE BRAKES, BUT NEVER SAID ANYTHING ABOUT WHEEL WELL RUSTING THROUGH. THE REAR PASSENGER SIDE WHEEL WELL IS RUSTED COMPLETELY THROUGH AND THE STRUT IS LOOSE DUE TO THE RUST DAMAGE THAT IS CONTINUING TO GROW. I HAVE RECENTLY BEEN INVESTIGATING THE ENTIRE VEHICLE TRYING TO LOCATE THE SOURCE OF THE SOUND, I FINALLY FIGURED IT OUT AND DECIDED TO TAKE IT TO AUTO BODY SHOP ON 5/22/2012 AT 11:33 AM AND THEY WERE STUNNED TO SEE THE INSIDE OF THE WHEEL WELL ON THE PASSENGER SIDE. THE APPRAISER CAME OUT AND TOOK PICTURES AND LOOKED AT IT. AFTER LOOKING IT OVER HE TURNED TO ME AND ASKED ME HOW OLD THE VEHICLE IS, I SAID IT IS A 2004. HE SAID, "I HAVE NEVER SEEN THIS HAPPEN BEFORE." HE CAME TO THE CONCLUSION THAT IT MUST BE A FACTORY DEFECT. HE SAID WHEN FORD WAS PUTTING THE COATING ON THE INSIDE OF THE WHEEL WELL, THEY MUST NOT HAVE COATED IT ENOUGH AND MOISTURE GOT INSIDE CAUSING IT TO RUST. HE WENT BACK INSIDE AND ONE OF THE GUYS FROM THE SHOP HAPPENED TO BE INSIDE, SO HE CAME AND LOOKED AT IT AND SAID HE HAS NEVER SEEN THAT HAPPEN BEFORE EITHER AND HE HAS BEEN DOING BODY WORK FOR 25 YEARS! HE ALSO SAID IT IS POSSIBLY BECOMING A SAFETY ISSUE, BECAUSE THE STRUT IS COMING LOOSE, DUE TO THE RUSTING OUT FROM AROUND THE STRUT. THIS MOVEMENT OF THE STRUT COULD POTENTIALLY CAUSE PROBLEMS WITH HANDLING, ESPECIALLY WHEN TURNING AROUND CORNERS. HE GRABBED THE STRUT AND IT SHOOK EASILY BY HAND. I HAVE NOTICED THE CAR PULLS TO THE LEFT WHENEVER I HIT A BUMP IN THE ROAD, AT FIRST I THOUGHT IT WAS WIND PULLING ME, BUT IT IS HAPPENING MORE OFTEN. I CALLED FORD, BUT THEY SAID WARANTY RAN OUT, CANT HELP YOU. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *TT

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE REAR PASSENGER SIDE WHEEL WELL ACCUMULATED WATER ABNORMALLY. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER LOCATED CORROSION IN THE PASSENGER SIDE REAR WHEEL WELL THAT CAUSED THE SUSPENSION AND BOLTS TO CORRODE. THE DRIVER SIDE WHEEL WELL WAS ALSO SHOWING SIGNS OF CORROSION. THE MANUFACTURER DENIED ASSISTANCE WITH THE REPAIR, STATING THAT THE WARRANTY WAS EXPIRED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 115,000 AND THE CURRENT MILEAGE WAS 140,000.

LIFT GATE GLASS HINGE BOLT CORRODED AND FELL APART LEAVING REAR GLASS HANGING. *TR

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE TAILGATE DOOR WOULD NOT OPEN . THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE POWER DOOR LIFT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT PROVIDED NO ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 208,000.

TL* THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT WAS DRIVING 70 MPH WHEN HE HEARD A LOUD NOISE IN THE REAR OF THE VEHICLE AS IT STARTED SWAYING ABNORMALLY. THE PASSENGER SIDE REAR FENDER WELL WAS CORRODED AROUND THE STRUT MOUNT AND THE STRUT HAD COME THROUGH. THE VEHICLE WAS TAKEN TO THE DEALER WHO CONFIRMED THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE SINCE THE VEHICLE WAS OUT OF WARRANTY. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 125,000.

TL*THE CONTACT OWNS A 2004 FORD ESCAPE. THE CONTACT STATED THAT THE GAP UNDERNEATH THE VEHICLE WHERE THE TOW HOOK IS LOCATED IS DAMAGED. HE IS ATTEMPTING TO TRADE IN THE VEHICLE AND GOT IT INSPECTED. THE INSPECTOR DISCOVERED THE DAMAGE AND STATED THAT THE TOW HOLE HOOK IS TOO LARGE FOR THE VEHICLE. THE ENGINE SIZE WAS UNKNOWN. THE CURRENT MILEAGE IS 84,000 AND FAILURE MILEAGE WAS 83,000.

WHILE DRIVING HOME FROM HAVING A FEW DRINKS WITH MY FRIENDS, A DEER RAN OUT IN FRONT OF ME AND ALTHOUGH I SLAMMED ON THE BRAKES, I COULDN'T STOP QUICK ENOUGH TO AVOID HITTING THE DEER AND SMASHING IN THE GRILL OF MY NEW CAR. WHEN THE STATE PATROL ARRIVED, THEY GAVE ME A TICKET FOR SPEEDING AND AFTER I TOLD THEM THAT I WAS NOT SPEEDING WHEN I HIT THE DEER, (I HAD GOTTEN THE SPEED DOWN TO ABOUT 60MPH AT IMPACT) THEY THEN WANTED ME TO TAKE A ALCOHOL IMPAIRED TEST WHICH I NATURALLY DECLINED BECAUSE I WASN'T IMPAIRED. I ONLY HAD JUST A FEW DRINKS AND MAYBE SOME BEER & WINE AT DINNER AND MAYBE 2 DRINKS BEFORE I LEFT TO GO HOME. THEY THEN PROCEEDED TO ARREST ME LIKE A COMMON CROOK AND TOOK ME TO JAIL, WHERE I HAD TO SPEND THE NIGHT. ANYWAYS, MY INSURANCE COMPANY REFUSES TO FIX MY NEW CAR AND NOW THE CAR COMPANY REFUSES TO FIX IT ALSO. THIS CAR IS A PIECE OF JUNK. IF IT HAD BEEN MADE GOOD, IT WOULDN'T HAVE SUSTAINED ALL THAT DAMAGE FROM HITTING A LOUSY DEER. WHILE TRYING TO FIX THE DAMAGE MYSELF, MY FRIEND [XXX] PUT SOME GAS ON THE GRILL AND LIT IT TO SOFTEN UP THE PLASTIC JUNK THEY MADE THE GRILL OUT OF, SO WE COULD BEND IT BACK TOGETHER AND J.B. WELD IT. WELL, [XXX] GOT SOME OF THE HOT MELTED PLASTIC ON HIM AND IT BURNED LIKE [XXX] AND HE JUMPED UP AND KNOCKED OVER THE JAR WITH GAS IN IT AND THE WHOLE PLACE WENT UP IN FLAMES. MY CAR NOT ONLY BURNED, BUT MY GARAGE WENT UP IN SMOKE TOO. NOW THE INSURANCE COMPANY IS TELLING ME THAT THEY WON'T PAY THE CLAIM FOR THE GARAGE OR THE CAR CAUSE IT LOOKS LIKE ARSON FOR PROFIT. HOW IN THE [XXX] CAN I PROFIT FROM LOSING MY CAR AND GARAGE. [XXX] PISSED, AND HAS THREATENED TO SUE ME CAUSE HE GOT BURNED AND THINKS HE SHOULD GET SOME OF THE INSURANCE MONEY I THOUGHT I WAS GOING TO GET SINCE HE'S THE ONE THAT STARTED THE FIRE. SHOULDN'T I BE SUING HIM? ANYWAY, IF THE [XXX] CAR HAD BEEN MADE GOOD, I WOULDN'T BE IN THIS FIX. NOW I HAVEN'T GOT ANYTHING TO DRIVE AND NO PLACE TO PARK IT IF I DID. THIS REALLY SUCKS. IS THERE ANYONE I CAN SUE? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR