2005 Dodge Grand Caravan Brakes Problems

Your ABS, brake, and traction control warning lights came on in early 2020. Your vehicle has lost both ABS and traction control, which is particularly concerning in winter driving conditions. A mechanic diagnosed a communication problem with the ABS module itself—not a power or ground issue. The vehicle is still being driven without these safety features while awaiting repair.

LEFT REAR BRAKE LINE HAS BROKEN IN THE SAME PLACE AS THE PREVIOUS 2 LINES BROKE. I AM LOOKING AT A FOURTH BRAKE LINE IN TWO YEARS! THESE BRAKE LINES ARE FACTORY PARTS WITH IDENTICAL DEFECTS IN THE WELDED STEEL LINE. *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE VEHICLE WAS PARKED WHEN SHE NOTICED THAT SHE COULD NOT LOCK OR UNLOCK THE DOORS USING THE KEY FOB. THE CONTACT HAD TO USE THE KEY TO MANUALLY ENTER THE VEHICLE. THE CONTACT ALSO STATED THAT THE LIGHTING ON THE INSTRUMENT PANEL AND THE BRAKE LIGHTS STOPPED ILLUMINATING. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE FAILURE MILEAGE WAS 128,000. THE VIN WAS UNAVAILABLE.

FRONT BRAKE FAILURE EXCESSIVE WEAR BRAKE PADS- ABOUT TWO WEEKS FROM ACCEPTABLE PADS TO NOTHING METAL ON METAL CAUSED BY HUB BEARING FAILURE - ALLOWS THE WHEEL TO MOVE HORIZONTALLY ON THE AXLE SHAFT. THERE WAS NO INDICATION OF BEARING FAILURE PRIOR TO BRAKE PAD WEAR FAILURE OF THE HUB BEARINGS COULD BE THE REASON FOR MANY OF THE BRAKE PAD WEAR PROBLEMS ON THESE VEHICLES HAD TO REPLACE THE REAR BEARING HUBS 6 MONTHS AFTER PURCHASING THE VEHICLE IN 2005- REPLACED LEFT AND RIGHT FRONT BEARING HUB ASSEMBLIES, ROTORS, AND BRAKE PADS ALSO ABS FAILURE - SENSORS ARE CONTROLLED BY THE COMPUTER MODULE WHICH IS PRONE TO FAILURE - CONTROLS ALL THE ELECTRICAL SYSTEMS OF THE VEHICLE. SO REPLACING INDIVIDUAL WHEEL SENSORS DOES NOT FIX THE PROBLEM - ONLY REPLACING THE FAULTY COMPUTER CONTROL MODULE WILL ELIMINATE THE PROBLEM UNTIL IT FAILS AGAIN. *TR

ABS LIGHT CAME ON AND THE SCAN SHOWED THAT THE LEFT FRONT SENSOR WAS BAD BUT AFTER REPLACING THE SENSOR THE LIGHT STAYED ON. THE BRAKE WARNING LIGHT ALSO COMES ON AFTER DRIVING A SHORT DISTANCE.

ABS LIGHT ON -- DEALER REPLACED LEFT REAR WHEEL SPEED SENSOR (SECOND OCCURRENCE). *TR

ABS LIGHT ON -- DEALER REPLACED LEFT REAR WHEEL SPEED SENSOR. *TR

ABS LIGHT ON -- DEALER REPLACED LEFT REAR WHEEL SPEED SENSOR (THIRD OCCURRENCE). *TR

TL* THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE BRAKES HAVE BEEN REPAIRED FIVE TIMES. THE ROTORS HAVE BEEN TURNED ONCE AND REPLACED TWICE TWO MONTHS AGO. WHEN THE COMPLAINT WAS FILED, THE ROTORS NEEDED TO BE REPLACED AGAIN. THE DEALER STATED THAT THE FAILURES ARE CAUSED BY "FAULTY" DRIVING. CHRYSLER HAS NOT BEEN CONTACTED. THE AIR CONDITIONER MALFUNCTIONED THREE TIMES AND WAS REPAIRED. EVERY SEASON THE AIR CONDITIONER MALFUNCTIONS. THE REAR HOSES WERE REPLACED TWICE ALONG WITH THE COMPRESSOR. THE POWER LOCKS ON ALL OF THE DOORS WERE DEFECTIVE. THE PASSENGERS WERE UNABLE TO OPEN THE DOOR ALTHOUGH THE DOOR LOCKS WERE IN THE UNLOCKED POSITION. THE PASSENGER FRONT WINDOWS STARTED MAKING A CLANGING NOISE WHEN IT WAS OPENED AND THAT WAS REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 9,000. THE CURRENT MILEAGE WAS APPROXIMATELY 83,000.

FOUR CARS IN FRONT OF ME AT AN INTERSECTION WITH TRAFFIC LIGHT WHEN I LOST ALL BRAKES. THE PEDAL WENT RIGHT TO THE FLOOR. I HAD TO PULL OVER TO THE RIGHT AND ALMOST RIGHT ONTO A PERSONS LAWN TO KEEP FROM REAR ENDING THE VEHICLE IN FRONT OF ME. IF MY DAUGHTER HAD BEEN DRIVING THERE WOULD HAVE BEEN AN ACCIDENT REPORT WITH THIS. THANK GOODNESS NO ONE WAS HURT. MY HUSBAND HAD JUST BEEN DRIVING AND HE SAID THE PEDAL WAS FEELING SOFT. IT WOULD GRIP AND THEN GIVE. I HAVE HAD THIS 2005 DODGE CARAVAN FOR A LITTLE OVER A YEAR. I BOUGHT IT AT A USED CAR DEALER, BUT I HAVE HAD NO RECALLS ON ANYTHING BY THE DEALERSHIP. WHEN CONTACTED THEY CAN NOT HELP ME. I DO NOT KNOW IF THIS HAS HAPPENED BEFORE WITH THE VEHICLE, BUT THE DEALERSHIP WEBSITE HAS PROBLEMS WITH THE BRAKES AND THE 2005 IS THE WORST. THERE WAS REALLY NO WARNING AND THERE IS STILL NO SENSORY LIGHTS ON EITHER. *TR

THE PARKING BRAKE CABLE ROUTING ON DODGE G CARAVAN, 2005, SXT. THE CABLE IS RUBBING THE REAR VERTICAL SWAY BAR LINK CAUSING THE RUBBER ON THE LINE TO DETERIORATE AND POSSIBLY CAUSE BREAKAGE OF THE CABLE THUS LEADING TO PARKING BRAKE FAILURE. THE PARKING BRAKE CABLE WAS RE-ROUTED TO AVOID CONTACT WITH THE SWAY BAR LINK. *TR

2005 DODGE GRAND CARAVAN THE ANTI-LOCK BRAKE LIGHT CAME ON. THE DEALER HAD TO REPLACE BRAKE MODULE AND THE RIGHT FRONT WHEEL SENSOR. *DT

I WAS DRIVING TO GET LUNCH BEFORE PICKING UP MY SON FROM SCHOOL. I PULLED INTO A BURGERKING PARKING LOT AS I WENT TO STOP AT A STOP SIGN THE BRAKE PEDAL WENT TO THE FLOOR. WHEN I FINALLY STOPPED THE MINI VAN I NOTICED THAT THERE WAS A TRAIL OF BRAKE FLUID ON THE GROUND. UPON FURTHER INSPECTION THE LEFT FRONT BRAKE LINE HAD EXPLODED. *TR

I WAS BRAKING AS I WAS DESCENDING A HILL ON THE HIGHWAY WHEN THE FRONT BRAKES GOT SO HOT THAT MY AUTOMOBILE STARTED TO SHIMMY. I STOPPED AND DISCOVERED THAT MY RIGHT FRONT BRAKES WERE ON FIRE. I HAD MY FRONT BRAKES PADS AND ROTORS REPLACED ABOUT 7,000 MILES AGO WITH MOPAR VALUE LINE BRAKES AT THE DODGE DEALERSHIP. MY VEHICLE IS A 2005 DODGE GRAND CARAVAN WITH 56,380 MILES ON IT. *TR

BOUGHT DODGE GRAND CARAVAN 2005 IN AUG. 2006 WITH 29K MILES, NOW HAS 50K MILES. I'VE REPLACED THE BRAKES FIVE TIMES AND THE ROTOR ONCE AND THEY NEED TO BE REPLACED AGAIN. I HAVE DRIVEN IN CO FOR 43 YRS AND HAVE NEVER HAD THIS PROBLEM WITH ANY OTHER CAR. *TR

TL*THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE BRAKE LINE ON HER VEHICLE HAS RUPTURED AT LEAST THREE TIMES WITHIN THE PAST EIGHT MONTHS. WHILE DRIVING AT AN UNKNOWN SPEED, THE BRAKES FAILED. THE VEHICLE WAS REPAIRED BY A MECHANIC WITH PARTS PURCHASED FROM THE DODGE DEALER. THE VEHICLE HAS BEEN REPAIRED THREE TIMES FOR THIS FAILURE AND THE CONTACT IS CURRENTLY TOO AFRAID TO DRIVE THE VEHICLE. THE FAILURES OCCUR WITHOUT WARNING. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 51,500.

BRAKES FAIL COMPLETELY EVERY 20K MILES, REQUIRE FULL ROTOR / PAD REPLACEMENT. OBVIOUS DESIGN FLAW, IF THEY FAIL THAT QUICKLY THEN CERTAINLY SOMETHING MORE DANGEROUS COULD OCCUR. *TR

BRAKE SYSTEM FAILURE WHILE DRIVING. NOTHING PREVIOUSLY NOTED PRIOR TO FAILURE. BRAKE PEDAL WENT ALL THE WAY TO FLOOR, COULD NOT RESTORE BRAKING BY PUMPING THE BRAKE PEDDLE. RESORTED TO EMERGENCY BRAKE AND DOWN SHIFT. STOP ACHIEVED WITHOUT ACCIDENT. UNKNOWN CORRECTION AT THIS POINT. *CN

CRACKS IN ROOF UNDER PLASTIC MOLDING IN BODY ASSEMBLY , WHICH WAS NOT COVERED AFTER 36,000 MILES,DENIED BY DODGE BUT SOME ASSISTANCE FROM DEALER AFTER YELLING, CAUSED WATER LEAKAGE INTO RIGHT PILLAR ASSEMBLY , FLOOR COMPARTMENT AND UNKNOWING TO US SUB CARPETING. OUR WORRIES ARE STRUCTURAL SAFETY , MOLD AND ODOR POSSIBLY ELECTRICAL WIRING AND IF THERE ARE MORE IN ROOF THAT WE DON'T KNOW ABOUT ,AND ON ADDED NOTE PREMATURE DISC BRAKE WEAR ROTORS AND PADS DATE IS APPROXIMATE HAVE TO LOOK UP SERVICE RECORD ,DEALER GREENFIELD DODGE LAWRENCEVILLE NJ *TR

CATHEDRAL CITY DODGE REFUSED TO WORK ON THE RECALL BECAUSE THE VEHICLE WAS MODIFIED. THE RECALL PROBLEM HAD NOTHING TO DO WITH THE MODIFICATIONS BUT CATHEDRAL CITY DODGE REFUSED TO WORK ON IT.. AFTER SEVERAL HEATED CONVERSATIONS WITH MANAGEMENT CATHEDRAL CITY DODGE RETURNED MY VEHICLE WITH A DEAD BATTERY, AND A LEAK IN MY ENGINE AND DID NOT FIX THE RECALLED ITEM. AFTER I RECEIVED MY VEHICLE I NOTICED THAT THE NEW PROBLEMS WITH MY VEHICLE HAD NOTHING TO DO WITH THE MODIFICATIONS BUT WERE INDEPENDENT FROM ANY MODIFICATIONS PREVIOUSLY MADE TO MY VEHICLE. AFTER COMPLAINING TO THE DODGE CORPORATION I WAS REFERRED TO THE DODGE SERVICE CENTER IN LAQUINTA. THERE MY CAR WAS EQUIPPED WITH A NEW BATTERY AND THE RECALL ITEM WAS NOT FIXED BECAUSE THE MANAGER REFUSED TO WORK ON THE VEHICLE BECAUSE OF THE MODIFICATIONS. I CALLED LAQUINTA DODGE TO COMPLAIN AND MY VEHICLE WAS RETURNED TO ME WITH THE ENGINE LEAK, THE UNSERVICED RECALL ITEM AND NOW IN DOESN'T SHIFT INTO GEAR. THE CATHEDRAL CITY SERVICE CENTER AND THE LAQUINTA SERVICE CENTER DIDN'T EVEN CHECK TO SEE IF THE PROBLEMS WERE IN ANYWAY WAY CONNECTED TO THE MODIFICATIONS. THEY JUST REFUSED TO EVEN LOOK AT IT. NOW THERE IS ANOTHER RECALL ON MY DODGE GRAND CARAVAN THAT HAS TO DO WITH THE AIRBAGS AND LAQUINTA IS REFUSING TO WORK ON IT. IN SUMMARY MY VEHICLE ARRIVED IN PALM SPRINGS FULLY OPERATIONAL IN JUNE 2006 AND EVER SINCE THE FIRST CONTACT WITH CATHEDRAL CITY SERVICE CENTER MY VEHICLE HAS BEEN INOPERABLE. BETWEEN THE CATHEDRAL CITY AND LAQUINTA DODGE SERVICE CENTERS MY CAR NOW HAS AN ENGINE LEAK, A BAD HEATING COIL, DEFECTED AIRBAGS PROBLEMS SHIFTING INTO GEAR AND DOES NOT START. MY VEHICLE WAS FULLY OPERATIONAL AND HAD 80 MILES ON IT WHEN IT ARRIVED AT CATHEDRAL CITY DODGE IN 2006 AND NOW HAS 87 MILES ON IT AND IS IN OPERABLE. THAT?S 87 MILES NOT 8,700 OR 87,000 MILES. IT HAS ONLY 87 MILES BECAUSE IT HASN'T BEEN RUNNING SINCE CATHEDRAL CITY AND LAQUINTA DODGE HAVE DAMAGED MY VEHICLE. *JB

TL*THE CONTACT OWNS A 2005 DODGE GRAND CARAVAN. WHILE DRIVING 35 MPH, THE CONTACT HEARD A LOUD GRINDING NOISE AND THE BRAKE PEDAL WENT DOWN TO THE FLOORBOARD. THE DEALER STATED THAT THE FRONT BRAKE PADS WERE WORN. THE DEALER REPLACED THE BRAKE PADS AND TURNED THE ROTORS. APPROXIMATELY THREE MONTHS LATER, THE ABS WARNING LIGHT ILLUMINATED. THE DEALER STATED THAT THE VEHICLE NEEDED FRONT BRAKE PADS AND PERFORMED THE REPAIR. WHILE DRIVING 25 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND IT WENT DOWN TO THE FLOORBOARD, MAKING THE VEHICLE DIFFICULT TO STOP. HE HAD TO APPLY THE EMERGENCY BRAKE TO STOP THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER WHO STATED THAT THE BRAKE LINE FAILED. THE DEALER REPLACED THE BRAKE LINE. APPROXIMATELY TWO MONTHS LATER, THE VEHICLE EXPERIENCED THE SAME FAILURE. THE DEALER HAS NOT DIAGNOSED THE CAUSE OF FAILURE. THE CURRENT MILEAGE IS 55,000 AND FAILURE MILEAGE WAS 23,000.

PREMATURE FRONT BRAKE FAILURE-- WE PURCHASED OUR 2005 DODGE GRAND CARAVAN NEW, IN LATE SPRING 2004. SINCE THEN, WE HAVE HAD TO REPLACE THE FRONT BRAKES TWICE, ONCE AT 18,000 MILES, AND NOW AT 35,000 MILES. OUR DRIVING HABITS HAVE NOT CHANGED AND PREVIOUSLY (FOR THE LAST 25 YEARS, WITH 5 DIFFERENT CARS) WE HAVE GONE 30,000 - 40,000 MILES BETWEEN BRAKE JOBS. THIS VEHICLE REPLACED A 10-YEAR OLD PLYMOUTH GRAND VOYAGER WHICH HAD NO PROBLEMS WITH BRAKE WEAR. THE DEALER SERVICE MANAGER SAYS HE HAS SEEN 2005 GRAND CARAVANS COMING IN NEEDING BRAKE JOBS AT ABOUT 25,000 MILES, BUT NOT 18,000 MILES. YET, NEITHER THE DEALER NOR CHRYSLER ADMITS THAT THERE IS A SYSTEM OR COMPONENT PROBLEM. I SPOKE WITH CHRYSLER CUSTOMER SERVICE AND THEY WERE, AT BEST, RELUCTANTLY HELPFUL. THEY HAVE AGREED TO PAY FOR THE PARTS, BUT NOT THE LABOR. SO, I HAVE NOW HAD TO PAY, IN PART, FOR FRONT BRAKE JOBS TWICE IN LESS THAN 3 YEARS, AVERAGING LESS THAN 18,000 MILES BETWEEN THE REPAIRS. THIS IS TOTALLY UNACCEPTABLE. NEEDLESS TO SAY, IF CHRYSLER DOESN'T DO SOMETHING ELSE TO REMEDY THIS SITUATION, THIS WILL BE THE LAST CHRYSLER PRODUCT I WILL OWN...AND I WILL NOT BE KEEPING THIS MINIVAN MUCH LONGER. *NM

DT*: THE CONTACT STATED WITHOUT WARNING, THERE WAS A LOUD CRUNCH NOISE THAT CAME FROM THE BRAKES WHILE STOPPING. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND THE BRAKE PADS AND ROTORS WERE REPLACED. UPDATED 3/17/2006 - *NM

MY DODGE GRAND CARAVAN 2005 WAS BOUGHT USED AT BONIFACE-HIERS AT MERRITT ISLAND FLORIDA IN MARCH 2005. I'VE HAD BRAKE PROBLEMS SINCE. THE DEALERS REPAIR SHOP FOREMAN HAD SOMEONE LOOK AT IT IN APRIL 2005: SAID HE DID ME A FAVOR; THERE IS NO WARRANTY. BRAKES SHAKE AND ABS DOESN'T WORK. BRAKES ALSO LOCK. DANGEROUS. I TRAVELED TO MAINE FOR THE SUMMER. MANY CLOSE CALLS. ON 11-20-05, AFTER BEING TOLD VERBALLY THAT BRAKES ARE NOT WARRANTY ITEM, I SENT A COMPLAINT CARD. TODAY, I'M GOING TO BONIFACE-HIERS[MONDAY] AND A DAIMLER-CHRYSLER REP IS SUPPOSED TO LOOK INTO THE DEFECTS. *JB

DT: THE CONTACT STATED THERE HAVE BEEN PROBLEMS WITH THE BRAKES SINCE HE PURCHASED THE VEHICLE. HE FELT A JERK WHILE DRIVING THE VEHICLE. HE PULLED OFF THE ROAD AND FOUND THE BACK WHEELS LOCKED. THERE WAS SMOKE COMING FROM THE REAR PASSENGER SIDE WHEEL. THE DEALER MADE SEVERAL ATTEMPTS TO REPAIR THE VEHICLE. THE REPAIRS CONSISTED OF: BLEEDING OF THE BRAKES, REPLACEMENT OF THE MASTER CYLINDER, AND REPLACEMENT OF THE AIR BAG WIRING. NONE OF THE REPAIRS HAVE CORRECTED THE PROBLEM. *AK

THE PARKING RELEASE BRAKE ON MY 2005 DODGE GRAND CARAVAN IS VERY CLOSE TO THE LEVER ONE STEPS ON TO ENGAGE THE BRAKE. WHEN RELEASING THE PARKING BREAK THE LEVER HAS HIT MY HAND SEVERAL TIMES. THE LAST TIME MAY HAVE BROKEN MY MIDDLE FINGER. *NM

DT: CONTACT STATES WHEN THE BRAKE PEDAL IS PUSHED IT GOES TO THE FLOOR, BRAKING QUICKLY COULD NOT BE DONE IF NEEDED. EVENTUALLY, THE PRESSURE RECONSTITUTES, AND THE BRAKING SYSTEM IS NORMAL. THE SERVICE DEALER REPLACED THE MASTER CYLINDER, BUT THIS DID NOT FIX THE PROBLEM. *AK

WHILE DRIVING 20 MP APPLIED THE BRAKES TO SLOW DOWN AND ABS LOCKED THE WHEELS, CAUSING CONSUMER'S VEHICLE TO REAR END ANOTHER VEHICLE.*AK