2003 Bmw X5 Electrical Problems

Your vehicle's dashboard wiring caught fire, producing heavy smoke and flames that engulfed the entire vehicle within about a minute. This is an extreme fire hazard that could cause serious injury or property damage. The electrical wiring in the dashboard needs to be completely inspected and replaced to identify and fix the source of the fire.

Your vehicle caught fire while parked, causing the dashboard to melt and making the car undrivable. You have video evidence of the fire starting on its own. The dealer was notified but the vehicle was not diagnosed or repaired to determine the root cause of the electrical fire.

Your 2003 BMW X5 caught fire while parked and turned off outside your house, destroying the dashboard. The fire department determined the fire was caused by an electrical problem in the vehicle. This is a serious safety hazard that requires immediate investigation of the electrical system and any damaged wiring or components.

Your car lost power while driving, gradually slowing down until it stopped completely and had to be towed home. The engine starts, but the transmission won't engage any gears. This could involve issues with the fuel system, electrical connections, or transmission, and will likely require professional diagnosis and repair to identify which system failed.

Your parked and turned-off BMW X5 caught fire unexpectedly in the early morning hours, causing total loss of the vehicle. The fire department and police responded to the scene. Investigation into the root cause of the electrical or structural failure that led to the fire would be needed to determine what repairs or replacements are required.

After having your 2003 BMW X5 repaired at a dealership for an airbag recall, your battery warning light came on and the engine stalled while driving home at 55 mph. The dealer indicated diagnostic testing was needed but never completed the repair, and BMW's manufacturer support didn't help resolve the issue. The problem may have resulted from the dealer not properly disconnecting the battery during the recall service work. Fixing this will likely require proper battery diagnostics and reconnection procedures by a qualified technician.

TL* THE CONTACT OWNS A 2003 BMW X5. WHILE DRIVING APPROXIMATELY 65 MPH, THERE WAS THE SMELL OF PLASTIC BURNING AND THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT STATED THAT THERE WAS SMOKE COMING FROM THE FRONT OF THE VEHICLE. THE ENGINE STALLED WITHOUT WARNING. MOMENTS LATER, THE VEHICLE WAS ENGULFED IN FLAMES. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND FILED A REPORT. THE VEHICLE WAS BURNED DOWN TO THE FRAME. THE VEHICLE WAS DESTROYED AND TOWED TO A BODY SHOP. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2003 BMW X5. THE CONTACT STATED THAT THE FRONT PASSENGER SIDE CAUGHT FIRE WHILE PARKED IN A RESIDENTIAL GARAGE. THE MANUFACTURER INVESTIGATED THE FAILURE AND CONCLUDED THAT CAUSE OF THE FIRE WAS NOT DUE A MANUFACTURING DEFECT. A POLICE REPORT WAS FILED OF THE INCIDENT. THE CONTACT STATED THAT THE BATTERY WAS REPLACED TWICE AND THE COMPUTER SYSTEM WAS REPLACED THREE TIMES PRIOR TO THE FIRE. THE VEHICLE WAS DESTROYED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 150,000. UPDATED 2/15/13 *CN THE CONSUMER BELIEVED THE FIRE WAS DUE TO AN ELECTRICAL FAILURE. UPDATED 02/02/513

THE PIXELS ON THE INSTRUMENT CLUSTER AND THE RADIO DISPLAY ARE FADED OUT WHICH MAKES THE VISIBILITY ON THESE ITEMS EXTREMELY DIFFICULT. THIS IS A KNOWN ISSUE THAT HAS BEEN BROUGHT TO BMWUSA'S ATTENTION AND DISCUSSED ON MANY BMW FORUMS, YET THE MANUFACTURER AND ITS SUPPLIER (SIEMANS VDO) REFUSE TO FIX. *TR

I WAS DRIVING THE VEHICLE IN STOP AND GO TRAFFIC, THE VEHICLE LOST ALL POWER FORCING ME TO COME TO COMPLETE STOP IN THE MIDDLE OF THE HIGHWAY. THIS OCCURRED 3 OTHER TIMES IN THE PAST 4 MONTHS , THE OTHER INCIDENTS WERE IN THE PARKING LOT. THE CAR STARTS UP AND RUNS PERFECTLY BEFORE AND AFTER. I AM CONCERNED ABOUT MY SAFETY. SEARCHING FOR A SOLUTION, I FOUND THAT BMW HAS SERVICE BULLETIN TO ADDRESS THIS ISSUE. I AM SURPRISED THAT THERE IS NO RECALL ON THIS SINCE IT IS A HUGE SAFETY CONCERN. *TR

CAR SHUT DOWN WHILE DRIVING APPX 35MPH WITHOUT WARNING, NEARLY CRASH DUE TO LOSS OF STEERING ASSIST AND INSTRUMENT. DEALER REPLACED BOTH DME AND BATTERY WHICH WAS SUSPICIOUS SINCE TWO UNRELATED COMPONENT FAILED AT SAME TIME? EXTREMELY DANGEROUS WHEN IT HAPPENED IN TRAFFIC, ENDANGERING BOTH MY PASSENGERS AND OTHER DRIVERS NEARBY. RECALL TO THE DME AND BATTERY SHOULD BE ISSUED. REPAIR COST $2500. *TR

MY 2003 BMW 530I SEDAN CAUGHT FIRE DUE TO AN ELECTRICAL FAULT WHILE PARKED IN NEW HAVEN, CONNECTICUT. THE FIRE DEPARTMENT AND POLICE WERE CALLED. CASE #[XXX] WAS ASSIGNED BY OFFICER [XXX] OF THE NEW HAVEN PD. THE CAR, TOO BADLY DAMAGED TO REPAIR, WAS HAULED AWAY FOR EVENTUAL SCRAPPING. I WAS CLOSE TO THE CAR WHEN THE FIRE STARTED. FLAMES WERE ERUPTING FROM THE DASH, WHERE THE CLIMATE CONTROL SWITCHES ARE LOCATED. I TRIED SMOTHERING THE FLAMES WITH A SWEATER. THIS DID NOT INTERRUPT THE PROGRESS OF THE FIRE. THERE WAS NO PERSONAL INJURY OR PROPERTY DAMAGE OTHER THAN TO THE CAR AND ITS CONTENTS. ITEMS SITUATED IN THE FRONT SEAT AREA WERE NOT RECOVERED, DUE TO THE INTENSITY OF THE FIRE. THE APPARENT CAUSE OF THE FIRE WAS AN ELECTRICAL FAULT. IN 2010 NEW COUNTRY BMW IN HARTFORD TWICE REPLACED THE CLIMATE CONTROL FAN FINAL STAGE RESISTOR, ONCE IN APRIL AND AGAIN IN OCTOBER, AT NO CHARGE FOR THE SECOND REPLACEMENT. IN THE DAYS BEFORE THE FIRE THE CLIMATE CONTROL WAS AGAIN ACTING ERRATICALLY, AND THE EVIDENCE INDICATES THE FINAL STAGE RESISTOR WAS FAILING ONCE AGAIN. BMW NORTH AMERICA INSPECTED THE CAR AND CONFIRMED THAT THE FIRE WAS CAUSED BY AN ELECTRICAL FAULT IN THE AREA BEHIND THE DASH WHERE THE FINAL STAGE RESISTOR IS LOCATED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).*TR

WHILE DRIVING, THE CAR SUDDENLY SHUT DOWN AND LOST ALL POWER. HAD TO PULL OVER TO THE SIDE OF THE ROAD QUICKLY TO AVOID AN ACCIDENT; HAD THIS BEEN AT HIGH SPEED, THE SITUATION MIGHT HAVE BEEN WORSE. SUBSEQUENTLY WHEN TRYING TO START, THE CAR SHOWS A MYRIAD OF WARNING LIGHTS AND FAULTS. A FUSE FOR THE MAIN COMPUTER (DME) HAD BLOWN, DUE TO A WIRING SHORT BETWEEN THE ELECTRONIC THERMOSTAT AND THE MAIN COMPUTER. REPLACING THE FUSE IS NOT A PERMANENT FIX, AS IT BLOWS SHORTLY AFTER EACH TIME THE CAR IS STARTED, RENDERING THE CAR UNDRIVEABLE. THIS FIX TO REPLACE SHORTED WIRING IS IN THE THOUSANDS OF DOLLARS. THE CAR HAD BEEN METICULOUSLY MAINTAINED AND HAD NEVER SUFFERED ANY RELATED ISSUE BEFORE. THERE IS A POOR CONNECTION, FAULTY WIRING, DESIGN FLAW, OR THE LIKE IN THIS SYSTEM. *TR

THE LEFT REAR TAIL LIGHT CONTINUES TO WORK INTERMITTENTLY. THE 'CHECK BRAKE, CHECK REAR LIGHT' WARNING ILLUMINATES EVEN AFTER BULBS HAVE BEEN REPLACED. I HAVE REPLACED THE BULBS NUMEROUS TIMES, WITH THE MOST RECENT BEING A FEW DAYS AGO. YET, THE WARNING MESSAGE REAPPEARED THIS EVENING. THE PROBLEM IS SIMILAR TO THOSE RECENTLY INVESTIGATED BY NHTSA ON OTHER BMW MODELS SUCH AS THE 3 SERIES AND IS A COMMON COMPLAINT IN BMW FORUMS AND OTHER FORUMS ON THE INTERNET.

TL*THE CONTACT OWNS A 2003 BMW X5. WHILE PULLING INTO THE DRIVEWAY AT 5 MPH, THE DRIVER NOTICED THAT THE INSTRUMENT PANELS LIGHT BEGAN TO DIM AND THE VEHICLE STALLED. APPROXIMATELY TWO HOURS LATER, THE VEHICLE WAS ABLE TO BE RESTARTED AND WAS DRIVEN TO THE DEALER. THE MECHANIC INFORMED HER THAT THE INSTRUMENT CLUSTER WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE CURRENT MILEAGE WAS 100,200 AND FAILURE MILEAGE WAS 95,000. UPDATED 03/09/09. *LJ AFTER SHUTTING THE VEHICLE OFF, THE FRONT AND REAR LIGHTS STAYED ON AND THE DOOR LOCKS WERE INOPERATIVE. THE CONSUMER ATTEMPTED TO RESTART THE VEHICLE, BUT IT WOULD NOT START. THE DEALER FOUND COMMUNICATIONS FAULTS IN THE INSTRUMENT CLUSTER. UPDATED 03/12/09. *JB

BMW X-5 HAS CAUSED TWO ACCIDENTS BY SPONTANOUS ACCELLERATION - AFTER FIRST ACCIDENT BMW WAS CONTACTED AND ENGINEERS KEPT VEHICLE AND DETERMINED THAT CAUSE OF ACCIDENT DRIVER ERROR-WE PAID FOR REPAIR OF VEHICLE. SAME "ACCELERATION" HAPPENED ABOUT SIX MONTHS LATER ON JANUARY 7 SENDING CAR CRASHING THROUGH FRONT OF BUILDING - ONLY BY MIRACLE PEOPLE WEREN'T INGURED IN THESE ACCIDENTS (THE BUILDING WAS A A RETAIL STORE). THIS IS A LEASED VEHICLE AND WE DON'T KNOW WHAT TO DO. LSO, THESE INCIDENTS HAVE CAUSED OUR INSURANCE TO SKYROCKET.*AK

OCTOBER 2002 I PURCHASED A NEW BMW X5 - SHORTLY THERE AFTER I STARTED TO EXPERIENCE INTERMITTENT ELECTRICAL PROBLEMS - HEADLIGHTS WOULD NOT SHUT OFF WITHOUT RE-STARTING THE CAR, INTERIOR LIGHTS WOULD NOT TURN OFF, THE FLASHERS WOULD COME ON, THE REAR LATCH WOULD DISCONNECT, THE KEYLESS ENTRY INTO THE CAR WOULD NOT WORK, BATTERY WAS BEING DRAINED AND ULTIMATELY THE BATTER WOULDN'T EVEN HOLD A CHARGE. AFTER 3-4 MONTHS OF EXPERIENCING THESE INTERMITTENT PROBLEMS, I INSISTED THE DEALER TAKE THE CAR BACK AND LET ME PURCHASE A 2003 BMW X5. I RECEIVED THE NEWEST BMW X5 ON FEBRUARY 26, 2003 AND ON MARCH 10, 2003, I STARTED EXPERIENCING PROBLEMS AGAIN! THIS TIME, WHEN THE IGNITION WAS TURNED ON, THE FLASHERS CAME ON AND THE INTERIOR LIGHTS WOULD NOT SHUT OFF WITHOUT ME OPENING THE DOOR AND CLOSING IT AGAIN - I HAD TO MANUALLY SHUT OFF THE FLASHERS. MINUTES LATER AFTER DRIVING THE CAR, I SHUT OFF THE IGNITION, GOT OUT OF THE CAR AND USED THE KEYLESS ENTRY SYSTEM TO LOCK THE CAR AND ARM THE ALARM. I WASN'T ABLE TO LOCK THE CAR DOORS BUT THE ALARM WAS ACTIVATED. I HAD TO TURN THE ALARM OFF AND OPEN THE DOOR AND CLOSE IT AGAIN. THEN I WAS ABLE TO LOCK IT. THE CAR HAS BEEN AT THE DEALER SINCE AND THEY DO NOT KNOW WHAT IS CAUSING THIS PROBLEM. *JB